The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated that while the vehicle was turned off on several occasions, the liftgate button was depressed and the liftgate was partially raised before freezing. The vehicle was taken to a dealer where it was diagnosed that the driver’s side liftgate hinge had cracked and snapped…
Read full complaint
The contact owns a 2020 Toyota Rav4 Hybrid. The contact stated that while the vehicle was turned off on several occasions, the liftgate button was depressed and the liftgate was partially raised before freezing. The vehicle was taken to a dealer where it was diagnosed that the driver’s side liftgate hinge had cracked and snapped, causing the liftgate to become inoperable. The vehicle was repaired. On another occasion, the liftgate failed to close fully and failed to operate as intended. The vehicle was taken back to the same dealer where it was diagnosed that the passenger’s side liftgate hinge had cracked and snapped. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Avalon, Avalon Hybrid, Corolla, Highlander, Highlander Hybrid, RAV4, RAV4 Hybrid, Lexus ES350, Lexus RX350, Lexus RX450H, 2021 Sienna Hybrid, Lexus ES250, 2020-2022 Camry, Camry Hybrid, and ES300H vehicles. A short circuit may develop in the Occupant Classification System (OCS) sensor, preventing the front passenger air bag from deploying.
Consequence & remedy
Consequence: An air bag that does not deploy during a crash increases the risk of injury.
Remedy: Dealers will inspect and replace the sensor as necessary, free of charge. Interim letters notifying owners of the safety risk were mailed in February 2024. Some final remedy owner letters were mailed October 31, 2024. Letters will continue to be mailed in phases through January 2026. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 23TB15/23TA15 Lexus 23LB03/23LA03.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.
Additional source detail variants (2)
Steering:column
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.
Air Bags:frontal
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020-2021 Toyota Avalon and 2020 Avalon Hybrid, RAV4, and RAV4 Hybrid vehicles. Breakaway pins within the steering column, designed to absorb energy and reduce injury during a crash, could have been damaged during production, possibly affecting the performance of the driver's air bag in the event of a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence: In the event of a crash, an air bag that does not perform as designed can increase the risk of injury.
Remedy: Toyota will notify owners, and dealers will replace the steering column, free of charge. The recall began December 18, 2020. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is 20TB17/20TA17.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and 2020 RAV4 Hybrid vehicles equipped with electric power steering (EPS). Water may enter through the steering gear box cover and cause a loss of electric power steering assist.
Consequence & remedy
Consequence: A loss of power steering assist could increase steering effort at low vehicle speeds, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace the power steering gear box, free of charge. The recall began August 17, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB11 / 20TA11.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2019-2020 RAV4 and RAV4 Hybrid vehicles. The front lower suspension arms may have cracks, which may result in the suspension arm separating from the front wheel assembly.
Consequence & remedy
Consequence: If a suspension control arm breaks, it can result in a loss of vehicle control, increasing the risk of a crash.
Remedy: Toyota will notify owners, and dealers will replace both front lower suspension arms, free of charge. This recall began August 10, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's interim numbers for this recall are 20TB08 / 20TA08.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2020 Toyota Avalon Hybrid, Camry, Camry Hybrid and Lexus ES300h and 2019-2020 RAV4 and RAV4 Hybrid vehicles equipped with 2.5L 4-Cylinder engines. Porosity in the engine castings may result in cracks than can allow coolant to leak internally and/or externally.
Consequence & remedy
Consequence: A coolant leak can cause the engine to overheat and cause a vehicle stall in conventional gasoline vehicles, increasing the risk of a crash. Additionally, for all involved vehicles, the engine may get damaged mechanically, possibly resulting in an engine oil leak, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect and replace the engine including the engine block, as necessary, free of charge. The recall began April 3, 2020. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus at 1-800-255-3987. Toyota's number for this recall is 20TA04. Lexus' number for this recall is 20LA02.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2020 Toyota RAV4 Hybrid Problems, Complaints & Recalls | Skip That Year
Illustration