Visibility/wiper. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Service Brakes. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

8 crash reports0 fire reports4 injury reports

Wheels complaints

4 reports

Clear category filter

25,202 miles · Mar 7, 2020

Wheels

Read full complaint

MY 2016 PRIUS FOUR TOURING WITH 25,202 MILES IS CHEWING UP ITS TIRES. SPECIFICALLY, IT IS CHEWING THEM UP ON THE "INSIDE" OF THE REAR TIRES (THAT IS, THE TREAD OF THE REAR TIRES CLOSEST TO THE CENTER OF THE CAR IS BEING WORN OFF FASTER THAN THE TREAD ON THE "OUTSIDE" OF THE TIRES). THE REAR WHEELS ARE OUT OF ALIGNMENT IN THE CAMBER BY A NEGATIVE 1.7 DEGREES "OUT" OF WHERE IT SHOULD BE (THE TOP OF THE TIRE IS "TILTED IN" TOWARD THE MIDDLE OF THE CAR 1.7 DEGREES FROM WHERE IT SHOULD BE). THE TOYOTA DEALER SERVICE WRITER REFUSES TO TAKE OWNERSHIP AND IS SAYING THAT THERE IS NO KIT/REPAIR TO MAKE A CAMBER ADJUSTMENT ON THE REAR TIRES OF THE 2016 PRIUS CARS. I JUST ROTATED MY TIRES WITH 25,202 MILES ON 3.7.2020 AND THE TIRE DEPTH ON THE REAR TIRES IS A 2/32 WITH THE FRONT 4/32 AS O 3.7.2022. ON 12.19.2019, WITH A MILEAGE READING OF 23,361THE TIRE DEPTH WAS 6/32 ON THE REAR TIRES AND 7/32 ON THE FRONT.

NHTSA ODI #11316777

21 miles · Aug 31, 2018

Wheels

VEHICLE WAS SOLD WITHOUT A SPARE TIRE OR JACK. WHY DOES THE GOVERNMENT ALLOW A CAR COMPANY TO SELL A VEHICLE WITHOUT A SPARE TIRE AND JACK?

NHTSA ODI #11123885

30,000 miles · Jun 11, 2018

Wheels

I HAD A BLOW OUT ON THE DRIVER REAR TIRE GOING DOWN THE INTERSTATE GOING APPROXIMATELY 70 MPH. THE TREAD COMPLETELY SEPARATED FROM THE SIDEWALL. THE TIRES WERE TOYO NANOENERGY A29.

NHTSA ODI #11101280

3,000 miles · Jan 9, 2017

TiresWheels

IF THE TIRE PRESSURE IS DECREASED BY THE SLIGHTEST AMOUNT THE LIGHT WILL GO ON AND STAY ON. IF THE TEMPERATURE IS COOL THE LIGHT WILL GO ON AND STAY ON. I'VE BROUGHT IT BACK TO SERVICE 4 TIMES DURING NOVEMBER AND DECEMBER OF 2016. THEIR SCAN SHOWS NO FAULT. I PURCHASED THE PRIUS IN FEBRUARY 2016 AND DIDN'T HAVE THIS PROBLEM UNTI…

Read full complaint

NHTSA ODI #10943978

Official recalls

18V579000 · Electrical System:wiring

Sep 5, 2018

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016-2018 Toyota Prius vehicles. A portion of the engine wire harness connected to the hybrid Power Control Unit (PCU), could contact the cover at this connection and wear, causing an electrical short circuit.

Consequence & remedy

Consequence: An electrical short can increase the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect the engine wire harness assembly and replace it if damage is found. A protective sleeve or protective tape will be included to prevent any future damage. These repairs will be performed free of charge. The recall began October 30, 2018. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0T.

18V085000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Air Bags:side/window

Jan 31, 2018

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016 Toyota Prius and Lexus RX 350, RX 350 F Sport, RX 450h F Sport and RX 450h vehicles and 2015-2016 Lexus NX 200T, NX Turbo and NX 300h vehicles. The air bag pressure sensors and/or the acceleration sensors may fail causing the side/curtain shield air bags and/or the front air bags to not deploy in the event of a crash.

Consequence & remedy

Consequence: If the air bags fail to deploy in a crash, it can increase the risk of injury.

Remedy: Toyota will notify owners, and dealers will replace the sensors as necessary based on their serial numbers, free of charge. The recall is expected to begin March 12, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are JLA, J0F.

Additional source detail variants (3)

Air Bags:side/window

Consequence: If the air bags fail to deploy in a crash, it can increase the risk of injury.

Remedy: Toyota will notify owners, and dealers will replace the sensors as necessary based on their serial numbers, free of charge. The recall is expected to begin March 12, 2018. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for this recall are JLA, J0F.

Air Bags:frontal:sensor/control MODULE-INACTIVE

Consequence: If the air bags fail to deploy in a crash, it can increase the risk of injury.

Air Bags:frontal

Consequence: If the air bags fail to deploy in a crash, it can increase the risk of injury.

17V658000 · Hybrid Propulsion System: Inverter

Oct 18, 2017

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2016 Prius vehicles. A capacitor within the hybrid system may not have been properly bolted to the inverter housing.

Consequence & remedy

Consequence: If the capacitor was not properly secured, vibrations from driving the vehicle may damage the capacitor, shutting down the hybrid system, causing a loss of motive power and increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will replace the inverter, free of charge. The recall is expected to begin by early December 2017. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is H0U.

16V741000 · Parking Brake

Oct 14, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2016-2017 Prius vehicles manufactured August 6, 2015, to October 3, 2016. The affected vehicles are equipped with a foot-operated parking brake system that has a parking brake cable that may disengage.

Consequence & remedy

Consequence: If the parking brake cable disengages from the mechanism and the transmission is left in a gear other than 'Park' while the ignition is on and the driver leaves the vehicle, the vehicle may roll unexpectedly, increasing the risk of a crash.

Remedy: Toyota will notify owners, and dealers will install a clip at the parking brake cable end to prevent the cable from disengaging, free of charge. The recall began November 10, 2016. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is G01.

16V672000 · Air Bags:frontal:passenger Side:inflator Module

Sep 16, 2016

Toyota Motor Engineering and Manufacturing (Toyota) is recalling certain model year 2016 Toyota Prius vehicles manufactured November 30, 2015, to June 14, 2016. An air bag inflator manufacturing error may result in the inadvertent partial inflation of the front passenger air bag.

Consequence & remedy

Consequence: A front passenger air bag that unintentionally inflates can increase the risk of a crash or injury.

Remedy: Toyota will notify owners, and dealers will replace the front passenger air bag assembly, free of charge. The recall began November 10, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is G0W.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.