While driving straight on smooth paved road, car began to shake and right rear passenger wheel came completely separated from car. After skidding off the road and being able to visually inspect, it was clear the sub-frame had broken and the wheel had come off in its entirety. The rotor, the lugs, and calipers were all still at…
Read full complaint
While driving straight on smooth paved road, car began to shake and right rear passenger wheel came completely separated from car. After skidding off the road and being able to visually inspect, it was clear the sub-frame had broken and the wheel had come off in its entirety. The rotor, the lugs, and calipers were all still attached to the wheel.
NHTSA ODI #11753091
Mileage unknown · Feb 14, 2025
Wheels
purchased tires at walmart auto care center in 2019 at 2770 E. Carson St. Lakewood, 90712, +15624298137. the warranty shows they should last at least 40000 miles. the tires worned out (by walmart auto care center staff on 11/2024) at 27000 miles. Walmart has not worked with me to replace these defective low quality tires (viva3 …
Read full complaint
purchased tires at walmart auto care center in 2019 at 2770 E. Carson St. Lakewood, 90712, +15624298137. the warranty shows they should last at least 40000 miles. the tires worned out (by walmart auto care center staff on 11/2024) at 27000 miles. Walmart has not worked with me to replace these defective low quality tires (viva3 brand) and i am in a dilemma as i am unable to replace them now. I am [XXX] and [XXX] and i use my vehicle for doctors, pharmacy and errands for my daily survival. thanks INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11642777
Mileage unknown · Jan 15, 2024
Back Over PreventionSuspensionWheelsCrash
THIS VEHICLE NEEDS TO TAKE OFF FROM THE CONSUMERS DUE DOESN'T DRIVES PROPERLY HAS REAR MAJOR DAMAGE ALSO LEFT SIDE REAR DOOR THEY DIDN'T DID GOOD JOB ALSO THE HYBRID BATTERY SHOWS AT THE DASHBOARD IN N OUT ENGINE CHECK LIGHT. THE REAR FRAME BOUNCE BY THE SIDE IT'S UNSAFE. CAR TIME DEALERSHIP AT ONTARIO, CA DON'T CARE BE CAREFUL …
Read full complaint
THIS VEHICLE NEEDS TO TAKE OFF FROM THE CONSUMERS DUE DOESN'T DRIVES PROPERLY HAS REAR MAJOR DAMAGE ALSO LEFT SIDE REAR DOOR THEY DIDN'T DID GOOD JOB ALSO THE HYBRID BATTERY SHOWS AT THE DASHBOARD IN N OUT ENGINE CHECK LIGHT. THE REAR FRAME BOUNCE BY THE SIDE IT'S UNSAFE. CAR TIME DEALERSHIP AT ONTARIO, CA DON'T CARE BE CAREFUL ALSO SOLD ME WITH STOLEN CA LICENSE PLATES THIS DEALERSHIP, IT'S SCAM. I DIDN'T KNOW LIKE TO SCAM CONSUMERS SINCE [XXX] GOT IT AND RETURN IT DUE REFUSE TO FIX IT RIGHT AND; THE BANK CANCEL THE TRANSACTION GLOBAL LENDING SERVICES BY ROSE BROWN GENERAL MANAGER EXT 51033 AT THE TELEPHONE THE BANK 877-538-2071 INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11565590
Mileage unknown · Jan 15, 2024
StructureWheels
The rear right wheel broke off when going in reverse, leaving driveway (low speed). Towed to a garage. Was told that the rear frame member had rusted through. Had no warning of this -- car is used regularly and had been inspected several months ago. EXACT SAME THING HAPPENED TO ANOTHER COUPLE WE KNOW WHO ALSO OWN A 2013 PRI…
Read full complaint
The rear right wheel broke off when going in reverse, leaving driveway (low speed). Towed to a garage. Was told that the rear frame member had rusted through. Had no warning of this -- car is used regularly and had been inspected several months ago. EXACT SAME THING HAPPENED TO ANOTHER COUPLE WE KNOW WHO ALSO OWN A 2013 PRIUS -- rear wheel came off because the frame member rusted through. Happened about a month before ours. They too were going in reverse, slowly, coming out of a parking spot, after driving 40+ miles to Boston. Car needed to be towed and rear frame member replaced. Repair for us cost $1300
NHTSA ODI #11565553
88,000 miles · Mar 4, 2017
Wheels
A WARNING LIGHT CAME ON INDICATING LOW TIRE PRESSURE. I STOPPED IMMEDIATLY IN THE CLOSEST PARKING LOT. THE SIDEWALL ON MY GOODYEAR WEATHERHANDLER FUEL MAXX TIRES HAD SPLIT APART, ABOUT 12 INCHES TOTAL IN 3 SPOTS. THE CORDS OF THE SIDEWALL WERE SHOWING. THESE WERE 65,000 MILE TIRES PURCHASED JANUARY 2016. THEY HAD ABOUT 28,000 M…
Read full complaint
A WARNING LIGHT CAME ON INDICATING LOW TIRE PRESSURE. I STOPPED IMMEDIATLY IN THE CLOSEST PARKING LOT. THE SIDEWALL ON MY GOODYEAR WEATHERHANDLER FUEL MAXX TIRES HAD SPLIT APART, ABOUT 12 INCHES TOTAL IN 3 SPOTS. THE CORDS OF THE SIDEWALL WERE SHOWING. THESE WERE 65,000 MILE TIRES PURCHASED JANUARY 2016. THEY HAD ABOUT 28,000 MILES ON THEM AT THE TIME THEY FAILED. I JUST FINISHED A 2500 MILE TRIP USING THE INTERSTATES. IF THEY FAILED THERE, IT WOULD HAVE KILLED US. GOD WAS WATCHING OVER US. THE TIRE WAS TOTALLY FLAT IN 5 MINUTES. THESE WERE PURCHASED FROM TIRE KINGDOM. AFTER GETTING THE SPARE ON, I DROVE THE 2 MILES TO THE STORE I PURCHASED THEM FROM. THEY EXPLAINED THEY NO LONGER HAD ANY STOCK, AS IT WAS A PURCHASE THEIR CHAIN MADE FROM SEARS WHEN THEY WENT OUT OF BUSINESS. I WAS UPSET THEY SOLD ME LEFT OVER TIRES. THEY OFFERED TO REPLACE THE FAILED TIRE, BUT I NEED SOMEONE TO REPLACE ALL OF THEM. THEY ARE A HAZARD. I AM AFRAID TO DRIVE THE CAR. I WILL CONTACT THE MANUFACTURER AND SEE WHAT THEY WILL DO FOR ME.THE DATE CODE ON THE TIRES SHOW THEY WERE 2 1/2 YEARS OLD WHEN I PURCHASED THEM.
NHTSA ODI #10958606
20,000 miles · May 28, 2016
SteeringUnknown Or OtherWheels
IN HEAVY RAINS BREAKING DOES NOT WORK WELL. EVEN AT 10 MPH IF YOU HIT A PUDDLE OF WATER. CAN CAUSE A CRASH. IT HAS HAPPENED ON A DIRT ROAD GOING AT LOW SPEED. BACK ROAD WHERE WATER RISES AND IN SOME HEAVY RAIN ON THE HIGHWAY
NHTSA ODI #10871323
3,100 miles · Mar 27, 2014
TiresWheels
I HAD A REAR TIRE BLOW OUT FOR NO APPARENT REASON. I DID NOT HIT ANYTHING. AND IT APPEARS TO BE A DEFECT. I DID HAVE TO DRIVE OFF ROAD TO SAFELY AVOID RISKY SITUATION. THE TOYOTA DEALER REFUSED TO TAKE UP WITH YOKOHAMA. I BOUGHT THE CAR ONLY IN FEBRUARY THIS YEAR AND BARLEY HAS ANY MILES ON IT. THE DEALERSHIP COMPLETELY UNHELPFU…
Read full complaint
I HAD A REAR TIRE BLOW OUT FOR NO APPARENT REASON. I DID NOT HIT ANYTHING. AND IT APPEARS TO BE A DEFECT. I DID HAVE TO DRIVE OFF ROAD TO SAFELY AVOID RISKY SITUATION. THE TOYOTA DEALER REFUSED TO TAKE UP WITH YOKOHAMA. I BOUGHT THE CAR ONLY IN FEBRUARY THIS YEAR AND BARLEY HAS ANY MILES ON IT. THE DEALERSHIP COMPLETELY UNHELPFUL. THIS IS CLEARLY A DEFECT AND SAFETY HAZARD! *TR
NHTSA ODI #10575245
5,500 miles · Mar 19, 2014
Service BrakesStructureWheelsCrash
WHILE THE CAR WAS GOING DOWN THE RAMP TO THE PARKING BASEMENT, THE BRAKE IN OUR PRIUS DIDN'T FUNCTION EVEN THOUGH THE DRIVER SLAMMED ON IT AND THE CAR CONTINUED TO PICKED UP ACCELERATION. NONE OF THE AIRBAGS DEPLOYED EITHER, AMAZINGLY. THE DRIVER WAS ABLE TO MAKE A RIGHT TURN AND MISSED THE WALL/CONCRETE PILLAR, BUT THE DRIVER …
Read full complaint
WHILE THE CAR WAS GOING DOWN THE RAMP TO THE PARKING BASEMENT, THE BRAKE IN OUR PRIUS DIDN'T FUNCTION EVEN THOUGH THE DRIVER SLAMMED ON IT AND THE CAR CONTINUED TO PICKED UP ACCELERATION. NONE OF THE AIRBAGS DEPLOYED EITHER, AMAZINGLY. THE DRIVER WAS ABLE TO MAKE A RIGHT TURN AND MISSED THE WALL/CONCRETE PILLAR, BUT THE DRIVER HIT A PARKED CAR AND THAT'S WHAT STOPPED THE PRIUS FROM MOVING FURTHER. *TR
NHTSA ODI #10573591
480 miles · Dec 23, 2013
Wheels
I BOUGHT THIS CAR IN NOVEMBER SINCE THE CAR IS NEW . I WANTED TO INSTALL MUD GUARDS SO I HAD TO REMOVE EACH WHEEL. AS I WAS TORQUING THE WHEEL NUTS, ONE STUD CAME OFF. I USED A TORQUE WRENCH 65 FTLB. I WENT TO THE DEALER THEY TOLD ME THAT I BROKE THE STUD THAT THIS IS NOT COVER BY THE WARRANTY. I TOLD THEM THAT THIS STUDS MUST …
Read full complaint
I BOUGHT THIS CAR IN NOVEMBER SINCE THE CAR IS NEW . I WANTED TO INSTALL MUD GUARDS SO I HAD TO REMOVE EACH WHEEL. AS I WAS TORQUING THE WHEEL NUTS, ONE STUD CAME OFF. I USED A TORQUE WRENCH 65 FTLB. I WENT TO THE DEALER THEY TOLD ME THAT I BROKE THE STUD THAT THIS IS NOT COVER BY THE WARRANTY. I TOLD THEM THAT THIS STUDS MUST HAVE A DEFECT FROM MANUFACTURING. I HOPE THEY DON'T FAIL WHILE I'M DRIVING. *TR
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013-2015 Prius and 2014-2017 Prius V vehicles not included in recall 18V-684. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: An unexpected hybrid power system shut down may increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will perform a software update for the hybrid system. If the vehicle has experienced an inverter failure with certain hybrid system faults related to this condition, the inverter assembly will be repaired or replaced, prior to software update. All repairs will be performed free of charge. This recall began July 24, 2020. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is 20TB10 / 20TA10.
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2014 Toyota Prius and 2012-2014 Toyota Prius V vehicles. Excessive voltage in the Intelligent Power Module (IPM) within the inverter may cause the hybrid system to shut down, causing the vehicle to stall while being driven.
Consequence & remedy
Consequence: If the hybrid system shuts down unexpectedly, it can increase the risk of a crash.
Remedy: Toyota will notify owners, and dealers will update the software for the motor/generator control electronic control unit (ECU) and the hybrid control ECU as necessary, free of charge. The recall began January 22, 2019. Owners may contact Toyota customer service at 1-888-270-9371. Toyota's number for this recall is J0V. Note: The software updates in this recall are needed even if the vehicle had the software previously updated under recalls 14V-053 or 15V-449.
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence & remedy
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Electrical System:software
Toyota is recalling certain model year 2010 through 2014 Prius vehicles. In the affected vehicles, the Intelligent Power Module (IPM) inside the inverter module (a component of the hybrid system) contains transistors that may become damaged from high operating temperatures. If this occurs, various warning lamps will be illuminated on the instrument panel and the vehicle will have reduced power allowing it to only drive a short distance.
Consequence: The vehicle may enter a fail-safe/limp-home mode that limits the drivability of the vehicle. The hybrid system could also shut down completely resulting in a vehicle stall, increasing the risk of a crash.
Remedy: Toyota will notify owners and dealers will update the software for both the motor/generator control electronic control unit (ECU) and the hybrid control ECU, free of charge. If an owner experiences a failure of the inverter before the vehicle receives updated software, the dealer will repair or replace the inverter assembly with a new one at no charge. The recall began on March 21, 2014. Owners may contact Toyota at 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
DP23005 · Brake Actuator Valve Wear
Opened Nov 22, 2023 · No close date supplied
Status: open (inferred from source dates) · Service Brakes, Hydraulic:foundation Components; Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Additional source detail variants (2)
Service Brakes, Hydraulic:foundation Components
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
Service Brakes, Hydraulic:power Assist
The Office of Defects Investigation (ODI) has received a petition dated September 19, 2023 from the owner of a 2012 Toyota Prius V requesting that ODI reevaluate its decision to deny DP19-004. In the letter, the petitioner reported experiencing an unexpected and complete loss of brake power while driving, accompanied by multiple dashboard warning lights. This petition is based on the petitioner's direct experience and assessment that ODI closed DP19-004 because its prompting petition was withdrawn by that petitioner. ODI will review the work conducted during DP19-004 and a review of any additional related complaints and crashes via a new defect petition The petition and related materials can be reviewed at NHTSA.gov under the following ODI number:11553736.
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP19004 · Brake Actuator Valve Wear
Opened Sep 30, 2019 · Closed Jan 21, 2021
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:power Assist
On September 19, 2019, the Office of Defects Investigation (ODI) received a defect petition from Mr. Roger Hogan requesting that the Agency investigate and recall certain Toyota Prius, Prius PHV, Camry Hybrid and Avalon Hybrid vehicles for a brake actuator valve wear condition covered under Toyota Customer Support Programs ZJB and ZKK (subject CSP?s). In support of his request, the petitioner identified 117 NHTSA complaints allegedly related to the subject CSP condition, including 60 reporting crashes. On September 30, 2019, ODI opened Defect Petition DP19-004 to evaluate the petitioner?s request for an investigation. In August 2020, the petitioner notified the Agency that he was withdrawing his petition. Because the petitioner has withdrawn the petition, we are denying the petition as moot and no further analysis of this petition is necessary.NHTSA is authorized to issue an order requiring notification and remedy of a defect if the Agency?s investigation shows a defect in the design, construction, or performance of a motor vehicle that presents an unreasonable risk to safety. 49 U.S.C. ?? 30102(a)(9), 30118. Because the petitioner has with withdrawn the petition, the petition is denied as moot. This action does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency notes that it is not required to receive a defect petition prior to opening a defect investigation and will take further action if warranted by future circumstances.
2013 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration