IllustrationSPEEDOMETER RANDOMLY TURNS OFF SO YOU CAN NOT SEE HOW FAST YOU ARE GOING. DEALER SAYS IT IS A KNOWN WARRANTY ISSUE, BUT I AM NO LONGER COVERED.
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
Unknown Or Other complaints
50 reportsABS ACTUATOR, VCS FAILURE. UNSAFE BRAKING ISSUES. TOYOTA DEALER IS QUOTING $2500 TO FIX. FOUND THAT A WARRANT EXTENSION WAS ADDED BY TOYOTA AS THIS IS A KNOWN ISSUE, ALTHOUGH TOYOTA CORP IS SAYING THAT THE WARRANTY EXTENSION EXPIRED JANUARY 1ST, 2018. A FRIEND WITH A 2006 PRIUS HAS THE SAME WARRANTY EXTENSION EXPIRATION (L…
Read full complaint
ABS ACTUATOR, VCS FAILURE. UNSAFE BRAKING ISSUES. TOYOTA DEALER IS QUOTING $2500 TO FIX. FOUND THAT A WARRANT EXTENSION WAS ADDED BY TOYOTA AS THIS IS A KNOWN ISSUE, ALTHOUGH TOYOTA CORP IS SAYING THAT THE WARRANTY EXTENSION EXPIRED JANUARY 1ST, 2018. A FRIEND WITH A 2006 PRIUS HAS THE SAME WARRANTY EXTENSION EXPIRATION (LETTER ATTACHED) AND WHERE MY CAR IS A 2008 MODEL, TOYOTA CORP ADVISES THAT THE EXTENSION EXPIRES AT THE SAME TIME AND THAT THERE IS NO OTHER OPTIONS, THAT THEY WILL NOT ASSIST WITH THIS SAFETY PROBLEM.
THE BACK LATCH ON MY 2008 TOYOTA PRIUS TRUNK HAS BEEN MADE WITH FAULTY MATERIALS. THE POOR CHOICE IN MATERIALS USED TO CONSTRUCT THE LATCH ARE A SAFETY CONCERN. IN EXTREME TEMPERATURES, THE LATCH DOES NOT FUNCTION PROPERLY. IN EXTREME HEAT, THE LATCH MELTS AND BURNS AND STICKS TO MY HAND AND ANYTHING ELSE IT COMES IN CONTACT …
Read full complaint
THE BACK LATCH ON MY 2008 TOYOTA PRIUS TRUNK HAS BEEN MADE WITH FAULTY MATERIALS. THE POOR CHOICE IN MATERIALS USED TO CONSTRUCT THE LATCH ARE A SAFETY CONCERN. IN EXTREME TEMPERATURES, THE LATCH DOES NOT FUNCTION PROPERLY. IN EXTREME HEAT, THE LATCH MELTS AND BURNS AND STICKS TO MY HAND AND ANYTHING ELSE IT COMES IN CONTACT WITH. IN EXTREME COLD TEMPERATURES I AM UNABLE TO GET MY TRUNK OPEN. THIS WAS A DESIGN FLAW THAT COULD AFFECT MY SAFETY IF I WAS EVER IN NEED OF GETTING INTO MY TRUNK, OR OUT OF IT IN A LIFE OR DEATH SITUATION. IF I WAS STUCK IN MY CAR AND THE ONLY WAY OUT WAS THROUGH MY TRUNK BECAUSE OF A CRASH OR AVALANCHE OR OTHER DISASTER, I BETTER HOPE THAT IT'S ON A NICE WARM DAY, BECAUSE IF IT'S ON A COLD DAY I'M SCREWED AS IT WILL BE NEARLY IMPOSSIBLE TO GET ME OUT. THIS IS A DESIGN FLAW ON THE PART OF TOYOTA, AND I WOULD APPRECIATE THEM TAKING INTO ACCOUNT THEIR CUSTOMERS SAFETY AND REMEDYING AN ISSUE THAT WAS CAUSED BY THEM USING A MATERIAL THAT DOES NOT WORK IN EXTREME TEMPERATURES. I LOVE A LOT ABOUT MY PRIUS, BUT A LATCH THAT MELTS AND FREEZES AND ONLY WORKS PROPERLY WHEN THE TEMPERATURE IS BETWEEN 45 AND 75 ISN'T ACCEPTABLE TO ME.
MY CAR IS CONSUMING OIL. TOLD TOYOTA DEALER ABOUT IT 2-3 YEARS AGO SEVERAL TIMES AND THEY KEPT SAYING JUST ADD OIL. NOW IT IS WORSE. I NEED TO ADD OIL EVERY GAS FILL UP. NOT LEAKING OR BURNING, BUT USING OIL! I HAVE ADDED 4 QUARTS SINCE LAST OIL CHANGE AND ONLY GONE OVER APPROX 2200 MILES.
VEHICLE REPEATEDLY SHIFTED INTO OTHER GEARS WHILE DRIVING AT FULL SPEED (NEUTRAL OCCURRED MOST OFTEN, BUT ALSO EXPERIENCED IT SHIFTING INTO PARK). THIS ALSO OCCURRED AFTER CAR HAD BEEN IDLING. THE SHIFTER DID NOT APPEAR TO MOVE ON IT'S OWN, YET CAR WOULD SHIFT OUT OF DRIVE ON IT'S OWN. THIS OCCURRED ON THE HIGHWAY, IDLING, AND O…
Read full complaint
VEHICLE REPEATEDLY SHIFTED INTO OTHER GEARS WHILE DRIVING AT FULL SPEED (NEUTRAL OCCURRED MOST OFTEN, BUT ALSO EXPERIENCED IT SHIFTING INTO PARK). THIS ALSO OCCURRED AFTER CAR HAD BEEN IDLING. THE SHIFTER DID NOT APPEAR TO MOVE ON IT'S OWN, YET CAR WOULD SHIFT OUT OF DRIVE ON IT'S OWN. THIS OCCURRED ON THE HIGHWAY, IDLING, AND ON REGULAR SURFACE STREETS. ANYWHERE IN BETWEEN 5-75 MPH. TSB 0142-11
TRUNK/HATCH RELEASE--RUBBER PIECE, HAS GUMMED UP FOR THE SECOND TIM. IT WAS REPLACED ONCE BY A RECALL--NOW WHAT?
THE RUBBER REAR HATCH DOOR RELEASE BUTTON ON MY 2008 TOYOTA PRIUS STARTED TO DEGRADE AND BECOME STICKY IN HOT SUMMER WEATHER. I ORIGINALLY THOUGHT THAT THE LATCH WAS STICKY AND GREASY BECAUSE DEALERSHIP SERVICE PEOPLE HAD OPENED THE CAR WITH GREASY HANDS, BUT THEN THE LATCH BUTTON COVER BECAME STIFF AND DIFFICULT TO PRESS A FEW …
Read full complaint
THE RUBBER REAR HATCH DOOR RELEASE BUTTON ON MY 2008 TOYOTA PRIUS STARTED TO DEGRADE AND BECOME STICKY IN HOT SUMMER WEATHER. I ORIGINALLY THOUGHT THAT THE LATCH WAS STICKY AND GREASY BECAUSE DEALERSHIP SERVICE PEOPLE HAD OPENED THE CAR WITH GREASY HANDS, BUT THEN THE LATCH BUTTON COVER BECAME STIFF AND DIFFICULT TO PRESS A FEW MONTHS LATER, WHEN THE WEATHER TURNED COLD. THIS BECAME A REAL SAFETY HAZARD WHEN I LOADED THE CAR COMPLETELY FULL OF MY BELONGINGS ON A COLD NIGHT TO MOVE CROSS-COUNTRY THE NEXT MORNING, AND THE DOOR LATCH WAS SO STIFF AND BRITTLE FROM THE COLD THAT IT CRACKED AND BROKE, BUT THE HATCH WOULDN'T OPEN. MY CHAINS, SPARE TIRE, TOOLS, JUMPER CABLES, ETC. WERE ALL STUFFED BACK THERE, COMPLETELY UNREACHABLE FROM THE FRONT BECAUSE THE CAR WAS FULL (ONE OF THE ITEMS WAS A BED FRAME, WHICH PROBABLY COULD NOT BE REMOVED WITHOUT OPENING THE REAR HATCH). NEEDLESS TO SAY, I DIDN'T FEEL VERY COMFORTABLE STARTING A 2-DAY CROSS-COUNTRY DRIVE ON WINTER ROADS THE NEXT MORNING, WITHOUT ACCESS TO MY EMERGENCY EQUIPMENT. EVENTUALLY, THE LATCH BUTTON STARTED WORKING AGAIN, BUT IT REMAINS CRACKED, HARD IN THE COLD, AND GOOEY IN THE SUMMER. I AM HOPING TO REPLACE THIS PART AS SOON AS I AM ABLE TO SPEND THE $300'500 THAT THE DEALERSHIP CHARGES FOR THIS REPAIR. THIS LATCH BUTTON IS CLEARLY DEFECTIVE AND WAS TESTED FOR NEITHER COLD (<40F) NOR WARM (>80F) WEATHER.
THE LATCH HANDLE ON THE HATCHBACK HAS DISINTEGRATED. IT IS GETTING HARDER TO OPEN HATCHBACK.
TRUNK LATCH HANDLE IS A STICKY MESS. LEAVES BLACK MARKS ON FINGERS. FIX THIS PROBLEM TOYOTA!
WHEN DRIVING VEHICLE IN WARM WEATHER IT SLIPS ON ITS OWN FROM DRIVE TO NEUTRAL. THIS HAPPENS WHILE DRIVING DOWN THE ROAD. IN ORDER TO CONTINUE YOU HAVE TO HOLD THE GEAR LEVER IN D OR ELSE IT SLIPS BACK INTO N WHICH OF COURSE CAUSES YOU TO LOSE SPEED. THIS HAPPENS IF YOU STOP AT A STOP LIGHT AND THEN TRY TO GO. ALSO HAPPENS W…
Read full complaint
WHEN DRIVING VEHICLE IN WARM WEATHER IT SLIPS ON ITS OWN FROM DRIVE TO NEUTRAL. THIS HAPPENS WHILE DRIVING DOWN THE ROAD. IN ORDER TO CONTINUE YOU HAVE TO HOLD THE GEAR LEVER IN D OR ELSE IT SLIPS BACK INTO N WHICH OF COURSE CAUSES YOU TO LOSE SPEED. THIS HAPPENS IF YOU STOP AT A STOP LIGHT AND THEN TRY TO GO. ALSO HAPPENS WHILE YOU ARE DRIVING DOWN THE ROAD. THERE HAVE BEEN COMPLAINTS ON A TOYOTA FORUM (CUSTOMERS) AND NUMEROUS PEOPLE ARE HAVING THIS PROBLEM. NOTHING SHOWS UP IN DIAGNOSTIC TESTS. WE HAD OUR 12V BATTERY REPLACED BECAUSE A LOW CHARGE MESSAGE CAME UP. STILL HAVING SAME PROBLEM. OTHER POSTS SAY IT'S THE SHIFT LEVER AND IT IS A MANUFACTURER FLAW. THIS FIX IS ANOTHER $500.THIS IS CLEARLY A SAFETY ISSUE AND A MANUFACTURER ISSUE.
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606