IllustrationTHERE WAS A POPPING NOISE IN MY STEERING WHEEL AND THEN I HAD NO MOVEMENT IN MY TIRES. MY STEERING WHEEL JUST SPINS ROUND AND ROUND BUT MY TIRES WILL NOT MOVE I WAS DRIVING DOWN THE STREET AND I HAD NO CONTROL OF MY CAR. SO I BELIEVE IT HAS SOMETHING TO DO WITH THE STEERING SHAFT OR SUSPENSION.*DT*JB
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
Suspension complaints
6 reportsCPCS:I1410421A. 2008 TOYOTA PRIUS. CONSUMER STATED THE CAR WAS TAKEN IN FOR A WHEEL ALIGNMENT. APPARENTLY, TOYOTA HAS NOT ALLOWED ANY WAY TO ADJUST THE REAR TOE OR CAMBER ON THE PRIUS, WHICH CAN RESULT IN STEERING ISSUES AND PROBLEMS ASSOCIATED WITH EXCESSIVE OR UNEVEN TIRE WEAR. *LN
I WAS LEAVING THE AIRPORT AND BEGINNING TO PICK UP SPEED (APPROXIMATELY 30-35 MPH) WHEN I HAD A VERY SCARY INCIDENT WITH MY 2008 PRIUS. IT SUDDENLY FISHTAILED TO THE LEFT, SEVERAL SECONDS LATER FISHTAILED TO THE RIGHT, AND AS IT YET AGAIN BEGAN TO FISHTAIL TO THE LEFT, I JAMMED ON THE BRAKES VERY HARD AND IT CORRECTED. IT WAS…
Read full complaint
I WAS LEAVING THE AIRPORT AND BEGINNING TO PICK UP SPEED (APPROXIMATELY 30-35 MPH) WHEN I HAD A VERY SCARY INCIDENT WITH MY 2008 PRIUS. IT SUDDENLY FISHTAILED TO THE LEFT, SEVERAL SECONDS LATER FISHTAILED TO THE RIGHT, AND AS IT YET AGAIN BEGAN TO FISHTAIL TO THE LEFT, I JAMMED ON THE BRAKES VERY HARD AND IT CORRECTED. IT WAS TERRIFYING AND FORTUNATELY THERE WAS NO ONE TO MY RIGHT OR BEHIND ME AND THE TAXI ON MY LEFT MANAGED TO AVOID ME. I KNEW THAT I WOULD NEVER FEEL SAFE IN MY PRIUS AGAIN. I IMMEDIATELY REPORTED THE PROBLEM TO THE TOYOTA REGIONAL MANAGER WHO SAID TO TAKE IT INTO THE DEALERSHIP. I THEN SPENT THE NEXT TWO DAYS READING COMPLAINTS POSTED ON THE INTERNET ABOUT THE PRIUS. IT IS CHILLING TO READ HOW MANY COMPLAINTS HAVE BEEN FILED AND THE PATTERNS THAT EMERGE IN THE REPORTING. I TOOK MY CAR INTO THE DEALERSHIP WHERE THE SERVICE MANAGER LOOKED OVER THE COMPLAINT THAT HAD BEEN WRITTEN UP AND SAID, "I NEVER HEARD OF THIS BEFORE." I TOLD HIM HE ONLY HAD TO GO TO THE INTERNET TO SEE HOW SIMILAR CASES WITH THE PRIUS HAVE BEEN DOCUMENTED. HE TOLD ME THAT I SHOULDN'T BELIEVE WHAT I FIND THERE. I TRIED MY BEST TO GIVE HIM A THOROUGH EXPLANATION OF THE PROBLEM BUT HE DIDN'T SEEM MUCH INTERESTED IN GETTING A FIX ON WHAT I WAS TALKING ABOUT. HE ASKED IF I HAD GONE OVER A BUMP. "NO," I REPLIED, "BUT WHY DO YOU ASK?" HE SAID THAT GOING OVER A BUMP CAN TRIGGER A SENSOR IN THE WHEEL THAT SETS IN MOTION A SERIES OF RESPONSES. "AND GOING OVER A BUMP ISN'T A PROBLEM FOR TOYOTA?", I ASKED. HE DIDN'T RESPOND AND ONLY SAID THAT THEY WILL LOOK THE CAR OVER. FROM READING THE DOCUMENTED REPORTS ON THE INTERNET, I KNEW EXACTLY WHAT THE FINDINGS WOULD BE. "WE DON'T FIND ANYTHING WRONG WITH YOUR CAR," HE TOLD ME. "BUT YOU DO AGREE THAT THERE IS SOMETHING SERIOUSLY WRONG, DON'T YOU?", I ASKED. HE IMMEDIATELY HUSTLED ME OUT OF THE AREA. I KNEW THAT I COULD NEVER SELL MY CAR TO ANOTHER PERSON IN GOOD FAITH, BUT I SOLD IT BACK TO THE DEALERSHIP AT A BIG LOSS. *TR
I BOUGHT A 2008 TOYOTA PRIUS IN THE SUMMER OF 2008 AND ALMOST IMMEDIATELY GOT INTO AN ACCIDENT. I WAS TURNING A CORNER AND THE CAR DIDN'T HANDLE AS I EXPECTED - I GOT A "HYDROPLANING" WARNING LIGHT EVEN THOUGHT IT WAS NOT RAINING AND TRIED TO BRAKE, BUT THE BRAKES DID NOT REACT AND I ENDED UP CRASHING INTO A CURB, CAUSING $3,000…
Read full complaint
I BOUGHT A 2008 TOYOTA PRIUS IN THE SUMMER OF 2008 AND ALMOST IMMEDIATELY GOT INTO AN ACCIDENT. I WAS TURNING A CORNER AND THE CAR DIDN'T HANDLE AS I EXPECTED - I GOT A "HYDROPLANING" WARNING LIGHT EVEN THOUGHT IT WAS NOT RAINING AND TRIED TO BRAKE, BUT THE BRAKES DID NOT REACT AND I ENDED UP CRASHING INTO A CURB, CAUSING $3,000 IN DAMAGE TO THE WHEEL, AXEL, AND BUMPER. NO ONE WAS HURT AND THERE WAS NO PROPERTY DAMAGE OTHER THAN TO MY OWN CAR. AT THE TIME I CHALKED IT UP TO NOT YET BEING USED TO THE CAR, I HAD PREVIOUSLY HAD A JETTA THAT HANDLED WONDERFULLY AND I WAS USED TO THAT CAR BEING COMPLETELY RESPONSIVE. I MADE THE NECESSARY REPAIRS TO MY CAR AND JUST TRIED TO BE MORE CAUTIOUS WHEN I WAS DRIVING IN THE FUTURE. I HAVE ALWAYS NOTICED CERTAIN THINGS ABOUT THE HANDLING AND BRAKING OF THIS CAR, AND THE CURRENT RECALL ON THE 2010 VERSION MADE ME REALIZE I WASN'T IMAGINING THESE PROBLEMS. I CONSTANTLY GET THE HYDROPLANING TYPE WARNING ON MY DASHBOARD WHEN I GO OVER BUMPS OR IN BAD WEATHER, TO THE POINT WHERE I FEEL UNSAFE DRIVING MY PRIUS IN INCLEMENT WEATHER AND OFTEN BORROW A RELATIVE'S CAR. I HAVE BEEN LUCKY TO HAVE NO MORE ACCIDENTS OTHER THAN THAT FIRST ONE, BUT THERE HAVE BEEN MOST DEFINITELY BEEN TIMES WHEN I FELT THE CAR WAS NOT HANDLING THE WAY IT OUGHT TO. EVEN WHEN I HAD THAT ACCIDENT I HAD MAINTAINED TO FAMILY AND FRIENDS THAT I JUST COULDN'T FATHOM HOW I GOT INTO THAT ACCIDENT AND I FELT LIKE IT WAS "THE CAR'S FAULT." I DIDN'T SPREAD THIS OPINION TOO WIDELY THOUGH BECAUSE IT SOUNDED LIKE I WAS JUST MAKING AN EXCUSE FOR MY ACCIDENT. THAT'S REALLY HOW I FELT THOUGH; AS IF SOMETHING WENT WRONG WITH THE BRAKES THAT DAY. I FELT IF I HAD BEEN IN ANY OTHER CAR I'VE EVER DRIVEN THAT ACCIDENT COULD HAVE BEEN AVOIDED. I DIDN'T EVEN KNOW THERE WAS AN OPTION TO FILE A COMPLAINT WITH THE NHTSA UNTIL THIS RECALL HIT THE NEWS, SO I FIGURED FILING A COMPLAINT NOW IS BETTER THAN NEVER FILING AT ALL. THANKS FOR YOUR TIME. *TR
2008 TOYOTA PRIUS LEANS TO LEFT 3/4 ". IT IS VISIBLY NOTICEABLE AND SITS EVEN LOWER WITH DRIVER OCCUPANT. TOYOTA DEALER SAYS WITHIN SPECS AND IS SAFE. THEY WON'T REPLACE SPRINGS ON LEFT SIDE OR COILS. MANY OTHER PRIUS OWNERS HAVE SAME PROBLEMS. I HAVE EXTENDED WARRANTY WHICH WE PAID A LOT FOR AND THEY STILL WON'T FIX VEHICLE. TH…
Read full complaint
2008 TOYOTA PRIUS LEANS TO LEFT 3/4 ". IT IS VISIBLY NOTICEABLE AND SITS EVEN LOWER WITH DRIVER OCCUPANT. TOYOTA DEALER SAYS WITHIN SPECS AND IS SAFE. THEY WON'T REPLACE SPRINGS ON LEFT SIDE OR COILS. MANY OTHER PRIUS OWNERS HAVE SAME PROBLEMS. I HAVE EXTENDED WARRANTY WHICH WE PAID A LOT FOR AND THEY STILL WON'T FIX VEHICLE. THIS CAN'T BE SAFE CAN IT? *TR
TL* THE CONTACT OWNS A 2008 SATURN VUE. DURING ROUTINE SERVICE, A TECHNICIAN NOTICED THAT BOTH REAR TIRES EXHIBITED UNEVEN TIRE WEAR. THE REAR TIRES WERE REPLACED. HOWEVER HE SPECULATED THAT THE REAR SUSPENSION SYSTEM CAUSED THE TREAD TO ABNORMALLY WEAR. THE FAILURE MILEAGE WAS 15,325. THE CURRENT MILEAGE WAS 15,400. …
Read full complaint
TL* THE CONTACT OWNS A 2008 SATURN VUE. DURING ROUTINE SERVICE, A TECHNICIAN NOTICED THAT BOTH REAR TIRES EXHIBITED UNEVEN TIRE WEAR. THE REAR TIRES WERE REPLACED. HOWEVER HE SPECULATED THAT THE REAR SUSPENSION SYSTEM CAUSED THE TREAD TO ABNORMALLY WEAR. THE FAILURE MILEAGE WAS 15,325. THE CURRENT MILEAGE WAS 15,400. UPDATED 3/8/10 *CN UPDATED 06/11/10. *JB
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606