IllustrationTHE RUBBER ON THE REAR LIFTGATE HAS DETERIORATED. MY FINGERS GET COVERED IN A STICKY GOO EVERY TIME I OPEN IT.
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
Structure complaints
68 reportsTHE REAR LATCH ASSEMBLY IS HELD IN PLACE BY PLASTIC BOLTS. OVER TIME, THE PLASTIC DISTINGRATES. WHEN ATTEMPTING TO OPEN THE REAR LATCH OF THE PARKED CAR, THE PLASTIC CRACKED AND THE ASSEMBLY CAME LOOSE.
THE HATCHBACK LATCH HAS A RUBBER COVER WHICH HAS BEEN DETERIORATING FOR SEVERAL YEARS. THERE ARE 100S OF COMPLAINTS ON THE INTERNET ABOUT IT. NOW, THE LATCH PRESSURE PLATE FAILS TO ALLOW ME TO OPEN HATCH AND THE NEARBY (PLASTIC?) PART IS BROKEN--SIMILAR TO MANY OTHERS ON WEB. DEALER QUOTES A $540 COST TO REPAIR THE LATCH AND …
Read full complaint
THE HATCHBACK LATCH HAS A RUBBER COVER WHICH HAS BEEN DETERIORATING FOR SEVERAL YEARS. THERE ARE 100S OF COMPLAINTS ON THE INTERNET ABOUT IT. NOW, THE LATCH PRESSURE PLATE FAILS TO ALLOW ME TO OPEN HATCH AND THE NEARBY (PLASTIC?) PART IS BROKEN--SIMILAR TO MANY OTHERS ON WEB. DEALER QUOTES A $540 COST TO REPAIR THE LATCH AND PLATE.
THE LATCH HANDLE ON THE HATCHBACK HAS "MELTED" FOR LACK OF A BETTER WORD. THE HANDLE HAS BECOME GOOEY AND LEAVES A BLACK RESIDUE ON MY FINGERS EVERY TIME I OPEN THE HATCHBACK. BECAUSE OF THIS PROBLEM, THE HANDLE IS HARDER TO USE, MAKING IT MORE TRYING TO OPEN THE TRUNK.
REAR SWITCH THAT ALLOWS LIFT GATE TO BE OPEN, FAILS. RUBBER BREAKS DOWN AND BECOMES LIKE GLUE, MAKING IT HARD FOR INDIVIDUAL OPENING LIFT GATE TO REMOVE HAND AS NORMALLY EXPECTED, INDUCING STRAIN ON INDIVIDUAL BACK AND CREATING UNEXPECTED TWISTING MOTION CAUSING INJURY AND DAMAGING TRIM ON CAR. TOYOTA HAS ISSUED RECALL IN JA…
Read full complaint
REAR SWITCH THAT ALLOWS LIFT GATE TO BE OPEN, FAILS. RUBBER BREAKS DOWN AND BECOMES LIKE GLUE, MAKING IT HARD FOR INDIVIDUAL OPENING LIFT GATE TO REMOVE HAND AS NORMALLY EXPECTED, INDUCING STRAIN ON INDIVIDUAL BACK AND CREATING UNEXPECTED TWISTING MOTION CAUSING INJURY AND DAMAGING TRIM ON CAR. TOYOTA HAS ISSUED RECALL IN JAPAN BUT NOT US [HTTPS://TOYOTA.JP/RECALL/KAISYU/121107.HTML] [NOT SURE OF EXACT DATE, THIS IS SECOND REPORT TOYOTA CLAIM 1512-2317-10]
I PURCHASED MY PRIUS IN 2008. APPROXIMATELY 3 YEARS AFTER PURCHASE, I NOTICED THAT THE HANDLE ON THE BACK HATCH HAD STARTED TO GET REALLY SOFT IN HOT WEATHER AND FREEZE UP A LITTLE IN COLD WEATHER. AT FIRST IT WAS JUST A NUISANCE AS IT SOMETIMES LEFT A BLACK STICKY SUBSTANCE ON MY HANDS; HOWEVER, OVER TIME IT BECAME PROGRESSIVEL…
Read full complaint
I PURCHASED MY PRIUS IN 2008. APPROXIMATELY 3 YEARS AFTER PURCHASE, I NOTICED THAT THE HANDLE ON THE BACK HATCH HAD STARTED TO GET REALLY SOFT IN HOT WEATHER AND FREEZE UP A LITTLE IN COLD WEATHER. AT FIRST IT WAS JUST A NUISANCE AS IT SOMETIMES LEFT A BLACK STICKY SUBSTANCE ON MY HANDS; HOWEVER, OVER TIME IT BECAME PROGRESSIVELY WORSE AND THE HATCH BECAME HARDER TO OPEN. I CANNOT OPEN IT AT ALL NOW (SEPT. 2015), LEAVING ME WITHOUT ACCESS TO THE SPARE TIRE, THE BATTERY, SNOW SHOVEL, OR MY ACCIDENT KIT (FLARES, BLANKET, ETC). MY BACK LIGHT ALSO KEEPS GOING OFF THEN COMING BACK (I GOT A TICKET FOR IT) BUT I CANNOT GET TO THE LIGHT FIXTURE BECAUSE I CANNOT OPEN THE TRUNK. THIS IS THEREFORE A SAFETY HAZARD AND TOYOTA SHOULD FIX IT. I AM TOLD THAT THEY HAVE ADMITTED LIABILITY AND FIXED THIS PROBLEM FOR FREE IN JAPAN. IF THAT IS TRUE, IT SHOULD BE EXTENDED TO THE US! LACK OF ACCESS TO BATTERY AND SPARE TIRE AND THE PROBLEM WITH THE REAR LIGHT POSE A SERIOUS SAFETY ISSUE.
THE LATCH HANDLE ON THE HATCHBACK HAS DISINTEGRATED. THE HANDLE HAS BECOME GOOEY AND LEAVES A BLACK RESIDUE ON MY FINGERS EVERY TIME I OPEN THE HATCHBACK. BECAUSE OF THIS PROBLEM, THE HANDLE IS HARDER TO USE, MAKING IT DIFFICULT TO OPEN THE TRUNK. REPLACEMENT PART NUMBER IS 84905-47010.
WE PURCHASED OUR PRIUS IN 2008. APPROXIMATELY 3 YEARS AFTER PURCHASE, WE NOTICED THAT THE HANDLE ON THE BACK HATCH STARTED TO MELT. AT FIRST IT WAS JUST A NUISANCE AS IT LEFT A BLACK GOO ON YOUR HANDS. AS TIME PASSED IT BECAME PROGRESSIVELY WORSE AND THE HATCH BECAME HARDER TO OPEN DUE TO THE MELTED HANDLE. LAST WEEK (AUG. …
Read full complaint
WE PURCHASED OUR PRIUS IN 2008. APPROXIMATELY 3 YEARS AFTER PURCHASE, WE NOTICED THAT THE HANDLE ON THE BACK HATCH STARTED TO MELT. AT FIRST IT WAS JUST A NUISANCE AS IT LEFT A BLACK GOO ON YOUR HANDS. AS TIME PASSED IT BECAME PROGRESSIVELY WORSE AND THE HATCH BECAME HARDER TO OPEN DUE TO THE MELTED HANDLE. LAST WEEK (AUG. 2015) OUR 12 VOLT BATTERY DIED OVER NIGHT AND WE COULDN'T START THE CAR OR GET ANYTHING TO WORK. OF COURSE, WE COULD NOT OPEN THE BACK HATCH AT ALL TO ACCESS THE BATTERY. WE CALLED A TOW SERVICE TO TOW OUR CAR TO THE LOCAL DEALER. WE WERE ABLE TO JUMP THE CAR AND DRIVE TO THE DEALER. THE SERVICE TECHNICIAN SAID THAT HE HAD NEVER HERD OF THIS HAPPENING. IT WAS DETERMINED THAT THE MELTED HANDLE SHORTED OUT THE WIRING FOR THE REAR LIGHT AND DRAINED THE BATTERY OVERNIGHT. AFTER A LITTLE RESEARCH< WE FOUND THAT THIS IS NOT A LOCALIZED PROBLEM BUT IS PRETTY COMMON ON 2007 AND 2008 PRIUS'. TOYOTA IS NOT WILLING TO FIX TS OWN DESIGN FLAW AND WE ARE OUT $250. THIS POSES A SERIOUS SAFETY ISSUE IF THERE IS A FLAT TIRE OR DEAD BATTERY AND WE ARE UNABLE TO OPEN THE BACK HATCH.
I WAS HIT IN THE REAR END WHICH SHOVED ME INTO THE VEHICLE IN FRONT OF ME 7/31/2015. AIR BAGS DID NOT DEPLOY.
THE BLACK RUBBER IS DISINTEGRATING AND FALLING OFF THE OUTSIDE TRUNK LATCH, MAKING IT DIFFICULT TO OPEN THE HATCHBACK TO GET TO THE SPARE TIRE OR BATTERY. THIS IS ALSO HAPPENING TO MY NEIGHBOR, WHO PARKS RIGHT NEXT TO ME AND ALSO HAS A 2008 PRIUS.
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606