IllustrationOUR 2008 TOYOTA PRIUS HAS A BRAKE HESITATION. THIS HESITATION OCCURS WHEN GOING OVER A ROUGH ROAD SURFACE WHILE BRAKING OR SLOWING. THIS PROBLEM HAPPENS OFTEN. I HAVE LEARNED THAT IF I KEEP PRESSING ON THE BRAKE WHEN THIS HAPPENS I AM ABLE TO STOP AND/OR SLOW DOWN. *TR
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
2880–25K
31125–50K
22150–75K
13675–100K
169100–150K
123150K+
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
152 crash reports6 fire reports50 injury reports
Service Brakes, Hydraulic complaints
171 reportsI HAVE A 2008 TOYOTA PRIUS. FROM DAY ONE, I HAVE HAD A PROBLEM WITH BRAKING OVER UNEVEN TERRAIN. WHEN THE VEHICLE GOES OVER THE UNEVEN TERRAIN, AND YOU ARE BRAKING, THE STABILITY CONTROL LIGHT GOES ON THE DASH AND THE BRAKES STOP WORKING UNTIL THE VEHICLE IS PAST THE UNEVEN ROAD. THIS ALSO HAPPENS ON ICY ROADS WHEN THE VEHICL…
Read full complaint
I HAVE A 2008 TOYOTA PRIUS. FROM DAY ONE, I HAVE HAD A PROBLEM WITH BRAKING OVER UNEVEN TERRAIN. WHEN THE VEHICLE GOES OVER THE UNEVEN TERRAIN, AND YOU ARE BRAKING, THE STABILITY CONTROL LIGHT GOES ON THE DASH AND THE BRAKES STOP WORKING UNTIL THE VEHICLE IS PAST THE UNEVEN ROAD. THIS ALSO HAPPENS ON ICY ROADS WHEN THE VEHICLE STARTS TO SLIP, THE BRAKES FAIL. I DID NOT THINK THERE WAS ANYTHING WRONG UNTIL I HEARD OF SIMILAR COMPLAINTS. I AM TAKING THE VEHICLE IN TO THE DEALER THIS WEEK FOR IT'S SERVICE AND WILL BE REPORTING THE PROBLEM TO THEM AT THAT TIME. *TR
2008 TOYOTA PRIUS WITH ANTI-SLIP REAR-WIGGLE UPON HITTING SMALL BUMPS IN ROAD. THE ANTI-SLIP ELECTRONIC SYSTEM IS WAY TOO SENSITIVE AS IT IS RESPONDING TO SMALL BUMPS IN THE ROAD. I CAN UNDERSTAND HOW THIS MAY BE HELPFUL AT HIGH SPEEDS OR ICY CONDITIONS, BUT AT SLOW SPEEDS THE BLINKING YELLOW SKID-CONTROL DASHBOARD LIGHT AND R…
Read full complaint
2008 TOYOTA PRIUS WITH ANTI-SLIP REAR-WIGGLE UPON HITTING SMALL BUMPS IN ROAD. THE ANTI-SLIP ELECTRONIC SYSTEM IS WAY TOO SENSITIVE AS IT IS RESPONDING TO SMALL BUMPS IN THE ROAD. I CAN UNDERSTAND HOW THIS MAY BE HELPFUL AT HIGH SPEEDS OR ICY CONDITIONS, BUT AT SLOW SPEEDS THE BLINKING YELLOW SKID-CONTROL DASHBOARD LIGHT AND REAREND WIGGLE AS THE SYSTEM TRIES TO RECOVER DOES SEEM ANNOYING. THE SYSTEM IS OVERLY SENSITIVE. *TR
I OWN A TOY.PRI.2008,ON 02/03/10 I WAS LEAVING DRIVEWAY APPLIED GAS,CAR TOOK OFF ACROSS ST. INTO TIDALFLOW OF AT. OCEAN AT HIGH TIDE,THE CAR WOULD NOT SHIFT. BRAKE OR TURN OFF. THE POLICE PIC'S NOTEDED GAS PEDAL WAS NOT VISIBLE, FLOOR MAT WAS OVER IT, THE SALT WATER WAS IN CAR AND UPON LEAVING CAR IT WAS WAIST DEEP. THE CAR WAS…
Read full complaint
I OWN A TOY.PRI.2008,ON 02/03/10 I WAS LEAVING DRIVEWAY APPLIED GAS,CAR TOOK OFF ACROSS ST. INTO TIDALFLOW OF AT. OCEAN AT HIGH TIDE,THE CAR WOULD NOT SHIFT. BRAKE OR TURN OFF. THE POLICE PIC'S NOTEDED GAS PEDAL WAS NOT VISIBLE, FLOOR MAT WAS OVER IT, THE SALT WATER WAS IN CAR AND UPON LEAVING CAR IT WAS WAIST DEEP. THE CAR WAS SERVICED 1/4/10 AT TOYOTA DEALER FOR STATE INSPETION AND USUAL MT. NEVER MENTIONED RECALL OF MATS WHICH I NOW FIND WAS A WELL KNOWN FACT IN SEPT.09. THEY ARE INSISTING IT WILL DRY OUT AND BE FINE,SALT WATER ON ANY CAR IS DEADLY BUTI HYBRID. THE HOUR IT SAT IN WATER PRIOR TO TOW,THE CAR STILL WOULD NOT SHUT OFF. I CALLED TOYOTA THAT DAY AS TOW TOOK CAR TO IT,THEY INSISTED THAT THERE WAS NO ISSUES WITH 2008 PRIUS. THE CAR WAS MOVING MUCH FASTER THAN MY 10MPH OF ORIGIN AND WOULD NOT BRAKE,SHIFT OR SHUT OFF. WATER WAS POURING OUT STEREO SPEAKERS AND UP UNDER HOOD ON/OR UNDER ENGINE BLOCK,THE ENGINE RAN FOR THE HOUR THE CAR SAT IN SALT WATER. TOYOTA HSA BEEN ABSOLUTELY NO HELP AND STILL INSISTS DESPITE AN OFFICAL RECALL THAT THERE WERE TROUBLES WITH 2008 PRIUS. THE POLICE PHOTOS SAY IT ALL. *TR
MY 2008 TOYOTA PRIUS HAS THE SAME PROBLEM AS REPORTED IN THE 2010 RECALL. WHEN APPROACHING AN INTERSECTION (OR DOING ANYTHING), IF MY CAR HITS A BUMP OR POTHOLE, THE SKID CONTROL TAKES OVER AND I CAN NOT MANUALLY BRAKE. WHY IS THIS NOT BEING ADDRESSED? THE DATE IN QUESTION I WAS APPROACHING AN INTERSECTION AND HIT A POTHOLE A…
Read full complaint
MY 2008 TOYOTA PRIUS HAS THE SAME PROBLEM AS REPORTED IN THE 2010 RECALL. WHEN APPROACHING AN INTERSECTION (OR DOING ANYTHING), IF MY CAR HITS A BUMP OR POTHOLE, THE SKID CONTROL TAKES OVER AND I CAN NOT MANUALLY BRAKE. WHY IS THIS NOT BEING ADDRESSED? THE DATE IN QUESTION I WAS APPROACHING AN INTERSECTION AND HIT A POTHOLE AND EVEN THOUGH I WAS HITTING THE BRAKES, NOT UNTIL THE SKID CONTROL WAS FINISHED COULD THE BRAKES ACTUALLY FIRE, AND THAT DIDN'T HAPPEN UNTIL MY CAR WAS HALFWAY IN THE INTERSECTION! *TR
HELLO, I LIVE IN ISRAEL, SOFTWARE EXPERT, M.SC. IN MECHANICAL ENGINEERING. ON FEB 5TH 2010 MY PRIUS 2008 CRASHED INTO THE CAR DRIVING AHEAD DUE TO THE BRAKES PROBLEM. CRASH PRE-CONDITIONS: LOW SPEED - 28KM/HOUR (17.4MPH), SLIPPERY ROAD DURING THE RAIN, MORE THAN SUFFICIENT DISTANCE TO THE CAR AHEAD. THE CAR AHEAD STARTED BRA…
Read full complaint
HELLO, I LIVE IN ISRAEL, SOFTWARE EXPERT, M.SC. IN MECHANICAL ENGINEERING. ON FEB 5TH 2010 MY PRIUS 2008 CRASHED INTO THE CAR DRIVING AHEAD DUE TO THE BRAKES PROBLEM. CRASH PRE-CONDITIONS: LOW SPEED - 28KM/HOUR (17.4MPH), SLIPPERY ROAD DURING THE RAIN, MORE THAN SUFFICIENT DISTANCE TO THE CAR AHEAD. THE CAR AHEAD STARTED BRAKING SHARPLY, INSTANTLY STRONG BRAKING HAS BEEN APPLIED TO PRIUS WITH NO RESPONSE FOR A FEW TENTHS OF SEC, THERE WAS A FEELING OF SLIDING WHICH RESULTED IN CRASH. DURING TWO YEARS DISPROPORTIONALLY LOW BRAKES RESPONSE HAPPENED TO ME TWICE IN SIMILAR LOW SPEED CONDITIONS; WHEN COMING TO ROUNDABOUTS AT 15-20KM/HOUR WHILE APPLYING SIGNIFICANT PRESSURE ON BRAKES I CAME 2-3M FURTHER THAN EXPECTED WITH THE FEELING OF VERY WEAK BRAKES RESPONSE. ATTEMPTS TO REPRODUCE THIS CONDITION DIDN'T SUCCEED, IT HAPPENS IN VERY SPECIFIC CIRCUMSTANCES. THE CRASH RESULTED IN NO INJURIES, BUT SIGNIFICANT DAMAGE TO BOTH CARS (ABOUT $4000). *TR
TL*THE CONTACT OWNS A 2008 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 6 MPH ON AN ICY ROAD SURFACE; PROCEEDING TO MAKE A RIGHT TURN WITH PRESSURE APPLIED TO BRAKE PEDAL, THERE WAS A THREE SECOND DELAY POWER RESPONSE. THE DRIVER EXERTED EXCESSIVE FORCE TO THE BRAKE PEDAL AND SUDDENLY, THE VEHICLE SLOWED DOWN. THE VEHICLE WAS ABL…
Read full complaint
TL*THE CONTACT OWNS A 2008 TOYOTA PRIUS. WHILE DRIVING APPROXIMATELY 6 MPH ON AN ICY ROAD SURFACE; PROCEEDING TO MAKE A RIGHT TURN WITH PRESSURE APPLIED TO BRAKE PEDAL, THERE WAS A THREE SECOND DELAY POWER RESPONSE. THE DRIVER EXERTED EXCESSIVE FORCE TO THE BRAKE PEDAL AND SUDDENLY, THE VEHICLE SLOWED DOWN. THE VEHICLE WAS ABLE TO RESUME NORMAL OPERATION. THE FAILURE OCCURRED WHENEVER MAKING A RIGHT TURN ON ANY TYPE OF ROAD SURFACE CONDITIONS. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER AND THE TECHNICIAN REFUSED TO INSPECT THE VEHICLE. THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE MILEAGE WAS 14,000. THE VIN WAS UNAVAILABLE.
TRACTION CONTROL ISSUES WITH 2008 TOYOTA PRIUS. THE TRACTION CONTROL MAKES THE CAR ALMOST UNDRIVEABLE ON SNOW COVERED ROADS DUE TO POWER BEING REMOVED FROM DRIVING WHEELS. SUGGEST ADDING A SWITCH TO DISABLE THE TRACTION CONTROL. *TR
ON MY 2008 PRIUS I APPLIED THE BRAKES OVER ANYTHING OTHER THAN PERFECTLY SMOOTH DRY PAVEMENT AND THE "TRACTION CONTROL" LIGHT COMES ON AND THE CAR STOPS ALL BRAKING FORCE MOMENTARILY FOR APPROXIMATELY A SECOND OR SO. WHILE THIS IS USUALLY JUST AN ANNOYANCE I WAS DRIVING ON THE WASHINGTON CAPITAL BELTWAY I-495 EAST NEAR THE…
Read full complaint
ON MY 2008 PRIUS I APPLIED THE BRAKES OVER ANYTHING OTHER THAN PERFECTLY SMOOTH DRY PAVEMENT AND THE "TRACTION CONTROL" LIGHT COMES ON AND THE CAR STOPS ALL BRAKING FORCE MOMENTARILY FOR APPROXIMATELY A SECOND OR SO. WHILE THIS IS USUALLY JUST AN ANNOYANCE I WAS DRIVING ON THE WASHINGTON CAPITAL BELTWAY I-495 EAST NEAR THE ROUTE 50 THE CAR AHEAD OF ME SLAMMED ON THE BRAKES, I LOOKED AWAY BRIEFLY THEN HIT THE BRAKES AND THE BRAKES DID NOT APPLY PRESSURE CONSISTENTLY CAUSING MY CAR TO RUN INTO THE BACK OF A LARGER TRUCK WHICH SHOULD HAVE A FAR GREATER BRAKING DISTANCE THAN MY PRIUS. I SHOULD HAVE BEEN ABLE TO BRAKE IN TIME. *TR
I HAVE A 2008 TOYOTA PRIUS AND HAVE HAD BRAKE PROBLEMS WITH THIS CAR SINCE IT WAS NEW BEEN BACK TO DEALERS AT LEAST 6 TIMES ONLY TO BE TOLD "WE CANNOT DUPLICATE THE PROBLEM". WHEN IT IS RAINING AND I FIRST START OUT WITH THE CAR THE BRAKES WILL SLAM ON AND THE TIRES WILL SKID. MY WIFE HAD THE CAR OUT ONE TIME WHILE I WAS IN THE …
Read full complaint
I HAVE A 2008 TOYOTA PRIUS AND HAVE HAD BRAKE PROBLEMS WITH THIS CAR SINCE IT WAS NEW BEEN BACK TO DEALERS AT LEAST 6 TIMES ONLY TO BE TOLD "WE CANNOT DUPLICATE THE PROBLEM". WHEN IT IS RAINING AND I FIRST START OUT WITH THE CAR THE BRAKES WILL SLAM ON AND THE TIRES WILL SKID. MY WIFE HAD THE CAR OUT ONE TIME WHILE I WAS IN THE HOSPITAL AND SHE HURT HER BREAST WITH THE SEATBELT WHEN THIS HAPPENED TO HER. ALSO WHEN I AM STEPPING ON THE BRAKES WHEN GOING OVER SOME BUMPS THE RIGHT FRONT WHEEL WILL LOCK UP AND THE ANTI SKID LIGHT COMES ON. THIS CAR IS DANGEROUS TO DRIVE AND THE LAST TIME I SPOKE TO TOYOTA TUES OF THIS WEEK THE PERSON I SPOKE TO SAID WHAT WOULD I LIKE FOR TOYOTA TO DO FOR ME AND I TOLD HIM TOYOTA SHOULD BUY THIS CAR BACK FROM ME AND ALL HE SAID WAS THAT IS NOT GOING TO HAPPEN. JUST WANT TO BE HEARD AT THIS POINT THAT IS WHY I AM MAKING A COMPLAINT WITH NHTSA. WE NEED TO BE HEARD. *TR
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606