NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
171 reportsClear category filter102 miles · Feb 8, 2010
Service Brakes, HydraulicCrash
I HAVE A 2008 TOYOTA PRIUS. WHEN I DRIVE OVER BUMPY SURFACES SUCH AS ROAD COVERS OR POT HOLES WHILE BREAKING, I CAN FEEL MY CAR ACCELERATING MID-BRAKE AND THEN HAVE TO PRESS DOUBLY HARD ON MY BRAKES TO SLOW THE VEHICLE. I WAS IN AN ACCIDENT DRIVING BECAUSE DRIVING OVER SOME BUMPY RAILROAD TRACK CROSSINGS, I HAD TO BREAK BECAUSE …
Read full complaint
I HAVE A 2008 TOYOTA PRIUS. WHEN I DRIVE OVER BUMPY SURFACES SUCH AS ROAD COVERS OR POT HOLES WHILE BREAKING, I CAN FEEL MY CAR ACCELERATING MID-BRAKE AND THEN HAVE TO PRESS DOUBLY HARD ON MY BRAKES TO SLOW THE VEHICLE. I WAS IN AN ACCIDENT DRIVING BECAUSE DRIVING OVER SOME BUMPY RAILROAD TRACK CROSSINGS, I HAD TO BREAK BECAUSE THE CAR IN FRONT OF ME STOPPED SUDDENLY. I FLOORED THE BRAKES AND MY CAR CONTINUED TO ROLL RIGHT INTO THE CAR IN FRONT OF ME. I HAVE ALSO CONSIDERED THAT PERHAPS THERE WAS ELECTRICAL INTERFERENCE WITH MY BRAKES CAUSED BY THE RAILROAD CROSSING. *CN
NHTSA ODI #10307627
12,800 miles · Feb 8, 2010
Service Brakes, HydraulicTraction Control System
BRAKES RELEASE AT STOPS WHERE ONLY SLIGHT ROAD CONDITIONS EXIST AND HERE THERE SHOULD BE COMPLETE BRAKING. I HAVE FOUND THIS HAPPENS AT NUMEROUS TIMES DURING THE PERIOD I HAVE OWNED MY 2008 PRIUS. I BELIEVE THERE ARE VALID CONCERNS WITH THIS VEHICLES BRAKE SYSTEM THAT NEED TO BE ACKNOWLEDGED AND ADDRESSED BY THE MANUFACTURER…
Read full complaint
BRAKES RELEASE AT STOPS WHERE ONLY SLIGHT ROAD CONDITIONS EXIST AND HERE THERE SHOULD BE COMPLETE BRAKING. I HAVE FOUND THIS HAPPENS AT NUMEROUS TIMES DURING THE PERIOD I HAVE OWNED MY 2008 PRIUS. I BELIEVE THERE ARE VALID CONCERNS WITH THIS VEHICLES BRAKE SYSTEM THAT NEED TO BE ACKNOWLEDGED AND ADDRESSED BY THE MANUFACTURER. *CN
NHTSA ODI #10307589
15 miles · Feb 8, 2010
Service Brakes, ElectricService Brakes, HydraulicTraction Control System
1) THE EVEN HAPPENS DURING NORMAL BRAKING FROM 40 MPH OVER A ROAD WITH POTHOLES. THE LOCATION IS HERE: HTTP://MAPS.GOOGLE.COM/?IE=UTF8&HQ=&HNEAR=CLEVELAND,+CASS,+MISSOURI&LL=38.67887,-94.675729&SPN=0.00139,0.00284&Z=19 2) THE CAR LOSES ALL BRAKING FOR 1-2 SECONDS AFTER RUNNING OVER THE POTHOLE. IF SOMEBODY WAS IN FRONT OF M…
Read full complaint
1) THE EVEN HAPPENS DURING NORMAL BRAKING FROM 40 MPH OVER A ROAD WITH POTHOLES. THE LOCATION IS HERE: HTTP://MAPS.GOOGLE.COM/?IE=UTF8&HQ=&HNEAR=CLEVELAND,+CASS,+MISSOURI&LL=38.67887,-94.675729&SPN=0.00139,0.00284&Z=19 2) THE CAR LOSES ALL BRAKING FOR 1-2 SECONDS AFTER RUNNING OVER THE POTHOLE. IF SOMEBODY WAS IN FRONT OF ME, IT WOULD RESULT IN A ACCIDENT. IT HAPPENS 5 DAYS A WEEK AS PART OF MY DAILY COMMUTE. 3) TOYOTA SAYS IT IS NORMAL FOR THE PRIUS TO DO THIS.
NHTSA ODI #10307381
53,300 miles · Feb 8, 2010
Service Brakes, Hydraulic
SUMMARY: BRAKES HESITATE IF I HAVE THE BRAKES ON BEFORE DRIVING OVER BUMPY ROAD TRANSITION: DRIVING ~25 TO 30MPH GOING UP HILL, ON BRIDGE THAT IS A FREEWAY OVERPASS, WHERE I TURN INTO THE LEFT TURN LANE THAT HAS A STOPLIGHT THAT LEADS TO THE FREEWAY ON RAMP. IF THE LIGHT IS RED OR I NEED TO SLOWDOWN FOR THE TURN, WHEN MY WHEE…
Read full complaint
SUMMARY: BRAKES HESITATE IF I HAVE THE BRAKES ON BEFORE DRIVING OVER BUMPY ROAD TRANSITION: DRIVING ~25 TO 30MPH GOING UP HILL, ON BRIDGE THAT IS A FREEWAY OVERPASS, WHERE I TURN INTO THE LEFT TURN LANE THAT HAS A STOPLIGHT THAT LEADS TO THE FREEWAY ON RAMP. IF THE LIGHT IS RED OR I NEED TO SLOWDOWN FOR THE TURN, WHEN MY WHEELS GO OVER THE METAL TRANSITION PLATE BETWEEN THE ASPHALT ROAD AND THE CONCRETE BRIDGE, IF I HAVE MY BRAKES ON PRIOR TO THE TRANSITION, THE OUT OF CONTROL LIGHT FLASHES , ABS ENGAGES AND AFTER THE TRANSITION, I LOSE BRAKES FOR A SECOND OR TWO OR MAYBE THREE. IF THE LIGHT IS RED IT CAN BE A LITTLE TRICKY AS I NEED TO STOP FOR THE LIGHT SHORTLY AFTER THE TRANSITION. THERE ARE TWO LANES THAT TURN ONTO THE FREEWAY AND IF SOMEONE SHIFTS FROM ONE LANE TO THE OTHER FOR A BETTER LIGHT POSITION, IT GETS EVEN TRICKIER TO STOP ON TIME. FOR THOSE IN SAN DIEGO, THIS IS THE LIGHT AT LA COSTA IN CARLSBAD, GOING WEST ON LA COSTA AND ENTERING THE I-5 SOUTH ON RAMP.
NHTSA ODI #10307344
54,950 miles · Feb 7, 2010
Service Brakes, Hydraulic
WHILE DRIVING OVER A BUMPY ROAD TODAY, I APPLIED BRAKES TO MY PRIUS (2008). THE VEHICLE JUMPED INTO ANTI-LOCK POSITION AND WOULD NOT STOP EVEN AFTER APPLYING MORE PRESSURE. FINALLY, JUST BEFORE REAR ENDING THE VEHICLE IN FRONT OF ME, I WAS ABLE TO STOP. I NOTIFIED TOYOTA ABOUT THIS TODAY ON THEIR WEB SITE. IS THERE ANYTHING …
Read full complaint
WHILE DRIVING OVER A BUMPY ROAD TODAY, I APPLIED BRAKES TO MY PRIUS (2008). THE VEHICLE JUMPED INTO ANTI-LOCK POSITION AND WOULD NOT STOP EVEN AFTER APPLYING MORE PRESSURE. FINALLY, JUST BEFORE REAR ENDING THE VEHICLE IN FRONT OF ME, I WAS ABLE TO STOP. I NOTIFIED TOYOTA ABOUT THIS TODAY ON THEIR WEB SITE. IS THERE ANYTHING ELSE I SHOULD DO? *TW
NHTSA ODI #10307305
30,000 miles · Feb 7, 2010
Electronic Stability Control (esc)Service Brakes, AirService Brakes, ElectricCrash
MY CAR IS A 2008 PRIUS. THE INCIDENT IS THAT MY CAR DIDN'T STOP AND SKIDDED INTO A CONCRETE CURB, DAMAGING THE RIGHT FRONT POWER STEERING RACK. IT WAS SNOWING, ABOUT 1-2" ACCUMULATED. DRIVING INTO MY OFFICE PARKING LOT, THERE IS A STREET WITH A STEEP BUT SHORT HILL - MAYBE 50FEET OR LESS - (IT WAS NOT PLOWED OR SANDED). AT THE…
Read full complaint
MY CAR IS A 2008 PRIUS. THE INCIDENT IS THAT MY CAR DIDN'T STOP AND SKIDDED INTO A CONCRETE CURB, DAMAGING THE RIGHT FRONT POWER STEERING RACK. IT WAS SNOWING, ABOUT 1-2" ACCUMULATED. DRIVING INTO MY OFFICE PARKING LOT, THERE IS A STREET WITH A STEEP BUT SHORT HILL - MAYBE 50FEET OR LESS - (IT WAS NOT PLOWED OR SANDED). AT THE FOOT OF THE HILL, THERE IS A LEFT TURN INTO A LEVEL PARKING LOT OR A RIGHT TURN UNDER A HIGHWAY OVERPASS, OR STRAIGHT AHEAD INTO SHRUBS AND THE RIVER. I SLOWED DOWN BEFORE GOING DOWN THE HILL AND AS I WENT DOWN THE HILL I LIGHTLY PUMPED BRAKES. TRIED TO COME TO A COMPLETE STOP AT FOOT OF THE HILL BUT CAR DIDN'T STOP COMPLETELY, BUT WAS GOING SLOW. SO, I MADE THE LEFT TURN INTO THE PARKING LOT. THE BODY OF THE CAR TURNED INTO THE LOT, BUT WAS NOT IN CONTROL. WITH THE BRAKES ON, AND THE WHEEL TURNED TO THE LEFT, THE CAR WENT INTO A SLIDE SIDEWAYS TO THE RIGHT. THE RIGHT FRONT WHEEL SLAMMED INTO A CONCRETE CURB AND THE CAR STOPPED. IT FELT AS IF I HAD NO BRAKES - COMING DOWN THE HILL THEY COULDN'T STOP ME AND THERE WAS NO SKID CONTROL COMING ON AT ANY TIME. THE FAILURE: GIVEN THE WEATHER CONDITIONS I DON'T KNOW HOW TO PROVE A FAILURE BUT I SUSPECT SOMETHING WITH THE BRAKES. I HAVE OWNED THIS CAR FOR ONE YEAR (PURCHASED IT USED) AND DURING THAT TIME THE ONE THING THAT BUGS ME IN THE CAR IS THE BRAKES AND THE SKID CONTROL. THEY JUST FEEL STRANGE, I GO OVER A DEPRESSED MANHOLE IN THE ROAD AND THE DSC COMES ON AND IT FEELS LIKE I SKID - IT SHOULD JUST FEEL LIKE A BUMP. REPAIRS: THIS IS THE LIST -ENTIRE POWER STEERING RACK ON RIGHT FRONT TO BE REPLACED- TIE ROD, LOWER CONTROL ARM, WHEEL, RIM-ALL BENT. FRONT COVER AND LOWER BALL JOINT DAMAGED-TO BE REPLACED. OVER $3000 IN REPAIRS; THEY WILL BE DONE THIS WEEK (8 FEB). IF YOU WANT THE OLD PARTS I CAN ASK FOR DEALER TO SAVE THEM. CAR IS @ TOYOTA DEALER. MILEAGE & SPEED ARE MY BEST GUESS; COMPONENTS I GUESSED - YOUR TERMS WERE NOT FAMILIAR TO ME. *TW
NHTSA ODI #10307159
20,000 miles · Feb 6, 2010
Service Brakes, Hydraulic
PROCEEDING TO GET ON HIGHWAY AND IN GRAVEL DRIVEWAY VEHICLE LOST TRACTION AND BRAKES FAILED.(AT LEAST 5 OR 6 TIMES IN 2009 AND MOST RESCENT 2/03/10)\HEADLIGHT AND RELAY SWITCH FAILED\FRONT RUNNING LIGHT NOT WORKING ALL THE TIME\RADIO SWITCHING FROM FM,FM2AND AM RANDOMLY\CAR FOR NO REASON GOING DEAD AT A STORE ORBEING PARKED FOR…
Read full complaint
PROCEEDING TO GET ON HIGHWAY AND IN GRAVEL DRIVEWAY VEHICLE LOST TRACTION AND BRAKES FAILED.(AT LEAST 5 OR 6 TIMES IN 2009 AND MOST RESCENT 2/03/10)\HEADLIGHT AND RELAY SWITCH FAILED\FRONT RUNNING LIGHT NOT WORKING ALL THE TIME\RADIO SWITCHING FROM FM,FM2AND AM RANDOMLY\CAR FOR NO REASON GOING DEAD AT A STORE ORBEING PARKED FOR AN HOUR OR 2AND HAVING TO BE JUMPED\MAIN BATTERIES LOSING CHARGE(MOST OF THESE ISSUES HAVE ALREADY BEEN DOCUMENTED AT TOYOTA WITH THE RESPONSE THAT THERE IS NOTHING WRONG WITH THE CAR AS FAR BACK AS AUGUST AND MOST RECENT IN DECEMBER '09) ALSO THE TIRES WENT BALD AFTER 20,000 MILES\CAN'T PUT MORE THAN 8 GALLONS OF FUEL IN TANK'EVER *CN
NHTSA ODI #10307072
40,000 miles · Feb 6, 2010
Service Brakes, HydraulicCrash
DRIVING ON A DIRT ROAD WHICH TURNS INTO A PAVED ROAD. STARTED SLIDING AS SOON AS I HIT THE PAVED ROAD. PUMPED ON THE BRAKES, THE ABS DIDNT WORK. THE CAR KEPT SLIDING OFF THE ROAD INTO A FENCE. $4000.00 IN DAMAGE. *CN
NHTSA ODI #10306929
15,000 miles · Feb 5, 2010
Service Brakes, Hydraulic
2008 PRIUS, 2006 LEXUS 400H MOMENTARY BRAKE LOSS. I BELIEVE THE 2010 PRIUS BRAKE ISSUE GOES WELL BEYOND 2010 PRIUS MODELS. I THINK THE MOMENTARY (SPLIT SECOND) DELAY IN BRAKING HAPPENS AT LOW SPEEDS, INFREQUENTLY, PERHAPS IN THE B SHIFT POSITION EXCLUSIVELY (NOT CERTAIN ON THIS IN THE LEXUS) AND USUALLY ON SLIPPERY SURFACES AN…
Read full complaint
2008 PRIUS, 2006 LEXUS 400H MOMENTARY BRAKE LOSS. I BELIEVE THE 2010 PRIUS BRAKE ISSUE GOES WELL BEYOND 2010 PRIUS MODELS. I THINK THE MOMENTARY (SPLIT SECOND) DELAY IN BRAKING HAPPENS AT LOW SPEEDS, INFREQUENTLY, PERHAPS IN THE B SHIFT POSITION EXCLUSIVELY (NOT CERTAIN ON THIS IN THE LEXUS) AND USUALLY ON SLIPPERY SURFACES AND/OR COLD WEATHER AND USUALLY WHEN GOING DOWN AN INCLINE. THE FEELING I GOT IN MY PRIUS AND MY WIFE IN HER LEXUS WAS NOT AN ACCELERATION FEELING BUT A GOING INTO NEUTRAL FEELING. IT KIND OF FELT LIKE THE CAR PICKED UP SPEED BUT MORE FROM THE COASTING EFFECT THAN ANYTHING TO DUE WITH AN ACCELERATOR. I WOULD LOOK AT THE ANTI-LOCK BRAKING AS IT RELATES TO REGENERATIVE BRAKING WITH A DASH OF SPEED THROWN IN. GOOD LUCK. I STILL FEEL THE CARS ARE SAFE. DATE BELOW NOT REAL-JUST PLACEHOLDER -TODAY'S DATE. *TR
NHTSA ODI #10306814
Mileage unknown · Feb 5, 2010
Service Brakes, Hydraulic
I OWN A 2008 PRIUS AND I HAVE THE SAME BRAKE PROBLEM AS MANY OWNERS HAVE REPORTED. THE BRAKE SOMETIMES DOES NOT WORK ON A BUMPY ROAD EDGE AND WHEN IT OCCURS THE ORANGE LIGHT THAT INDICATES UNSTABLE CONDITION TURNS ON. IT ALSO OCCURS WHEN IT IS RAINING. FOURSOME REASON, IT WORKS WELL IN A HEAVY RAIN BUT DOESN'T WORK ON A ROAD UN…
Read full complaint
I OWN A 2008 PRIUS AND I HAVE THE SAME BRAKE PROBLEM AS MANY OWNERS HAVE REPORTED. THE BRAKE SOMETIMES DOES NOT WORK ON A BUMPY ROAD EDGE AND WHEN IT OCCURS THE ORANGE LIGHT THAT INDICATES UNSTABLE CONDITION TURNS ON. IT ALSO OCCURS WHEN IT IS RAINING. FOURSOME REASON, IT WORKS WELL IN A HEAVY RAIN BUT DOESN'T WORK ON A ROAD UNDER "LIGHT" RAINING CONDITION. WHENEVER IT HAPPENS, THE CAR SLOWS DOWN BUT DOESN'T STOP AND I FEEL IT'S SLIDING ON THE ROAD SURFACE. I HAVEN'T CONTACTED THE DEALER REGARDING THIS PROBLEM. *TR
NHTSA ODI #10306812
Official recalls
4Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Illustration