I BURN MY HEADLIGHTS IN THE DAYTIME. A FRIEND SAW ME DRIVING, PHONED ME AND SAID THAT I HAD A HEADLIGHT OUT (LEFT). AFTER I ARRIVED AT MY DESTINATION, I TURNED OFF THE LIGHTS, THEN BACK ON, AND THE HEADLIGHT WORKED AGAIN. IF THIS WERE TO HAPPEN AT NIGHT, IT WOULD OF COURSE, BE MORE OF A HAZARD. *TR
2008 Toyota Prius
Owner reports · Recalls · Investigations
More warning signs than most Prius years
Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.
About this comparison →How this year compares
Owner complaints by model year
Compare all Prius years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1,248 reports with mileage · 249 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
Exterior Lighting complaints
579 reportsI HAVE A 2007 PRIUS HEADLIGHTS GO OFF 1 AT A TIME THEN BOTH SOMETIMES,THEY COME ON WHEN I FLIP ON OFF SWITCH; THIS HAS BEEN HAPPENING AT LEAST 10 TIMES PER WEEK DEALER TELLS ME BULBS FOR $509 PLUS TAX DOES NOT MAKE SENSE SINCE BULBS WORK FINE MOST OF THE TIME OTHER PEOPLE INDICATE THAT CHANGING BULBS DOES NOT SOLVE PROBLEM. …
Read full complaint
I HAVE A 2007 PRIUS HEADLIGHTS GO OFF 1 AT A TIME THEN BOTH SOMETIMES,THEY COME ON WHEN I FLIP ON OFF SWITCH; THIS HAS BEEN HAPPENING AT LEAST 10 TIMES PER WEEK DEALER TELLS ME BULBS FOR $509 PLUS TAX DOES NOT MAKE SENSE SINCE BULBS WORK FINE MOST OF THE TIME OTHER PEOPLE INDICATE THAT CHANGING BULBS DOES NOT SOLVE PROBLEM. *TR
PREMATURE HID HEADLAMP FAILURE. MY CAR IS BARELY 40K MILES. HEADLAMPS INTERMITTENTLY GOES OUT. IT WOULD COME BACK ON IF I TURN THE HEADLAMPS OFF AND THEN ON. *TR
THE HEADLIGHT OF MY 2008 TOYOTA PRIUS STOPPED WORKING SO I WHEN I HAD IT REPLACED THE DEALERSHIP CHARGED ME $350.00 FOR THE BULB. AFTER I PAID FOR THE REPLACEMENT OF THE BULB, THE SERVICE MANAGER GAME ME A CUSTOMER SERVICE NUMBER TO CALL AND COMPLAIN ABOUT THE PRICE OF THE BULB. NO ONE ANSWERED. I WENT HOME AND CHECKED THE VAR…
Read full complaint
THE HEADLIGHT OF MY 2008 TOYOTA PRIUS STOPPED WORKING SO I WHEN I HAD IT REPLACED THE DEALERSHIP CHARGED ME $350.00 FOR THE BULB. AFTER I PAID FOR THE REPLACEMENT OF THE BULB, THE SERVICE MANAGER GAME ME A CUSTOMER SERVICE NUMBER TO CALL AND COMPLAIN ABOUT THE PRICE OF THE BULB. NO ONE ANSWERED. I WENT HOME AND CHECKED THE VARIOUS BLOGS ON THE INTERNET AND FOUND THAT THIS HAS BEEN AN ON GOING PROBLEM WITH THE TOYOTA PRIUS. THE HEADLIGHTS SEEM TO BE DEFECTIVE. EXCLUDING THE INFLATED COST OF A LIGHT BULB, THIS HAS TO BE A SAFETY CONCERN FOR TOYOTA. THE BOTTOM LINE IS I PAID JUST OVER $401.00 TO REPLACE A $10.00 LIGHT BULB. THAT IS JUST PLAIN WRONG AND SOMEONE SHOULD HOLD TOYOTA RESPONSIBLE. THANK YOU FOR YOUR TIME IN THIS MATTER. DENNIS BENNETT *TR
I HAVE A 2008 PRIUS AND THE HID HEADLIGHTS GO OUT IN THE FIRST 5 MILES AFTER STARTING UP, BOTH SIDES WILL GO OUT, BUT IF I CLICK THE SWITCH THEY COME BACK ONE. I' M A LINE HAUL COURIER AND DRIVE 423 MILES A NIGHT SO I HAVE THE PATTERN OF THE LIGHTS GOING OUT ONE SIDE THEN THE OTHER FOR ABOUT 5 TO 10 MINS. HITTING THE SWITCH TO P…
Read full complaint
I HAVE A 2008 PRIUS AND THE HID HEADLIGHTS GO OUT IN THE FIRST 5 MILES AFTER STARTING UP, BOTH SIDES WILL GO OUT, BUT IF I CLICK THE SWITCH THEY COME BACK ONE. I' M A LINE HAUL COURIER AND DRIVE 423 MILES A NIGHT SO I HAVE THE PATTERN OF THE LIGHTS GOING OUT ONE SIDE THEN THE OTHER FOR ABOUT 5 TO 10 MINS. HITTING THE SWITCH TO PRIME THEM BACK ON THEN THEY STAY ONE FOR AN HOUR OR EVEN TWO. IF I STOP AT 7-11 OR GAS, THEY'LL ACT UP FOR ABOUT ANOTHER 10 MINS, THEN THEY STAY ON. ONCE IN A GREAT WHILE ONE OF THEM WILL GO OFF, BUT I DRIVE WITH MY RUNNING LIGHTS ON SO I'LL HAVE LIGHT TO CATCH WHEN THEY GO OFF. I STARTED TO COMPLAIN AFTER A MONTH OR SO, BUT THE GAL SAID THAT IT WOULD COST $800.00 OR MORE, (I'VE HEARD IT'S HIGHER. I 'VE ASKED A COUPLE OF TIMES AND WAS TOLD 'IT'S ELECTRICAL! I CAN'T AFFORD THAT KIND OF SCRATCH FOR SOMETHING THAT'S SHOULD BE ALL WORKING, FOR $26,000! I JUST FIGURE THAT IT SHOULD WORK AND IF IT DON'T, WHY SHOULD I PAY FOR SOMETHING THAT SHOULD COME WITH THIS HIGH TECH VEHICLE!! ANY WAY I LOVE IT EXCEPT FROM THE INTERMITTENT HIGH LIGHT FAILURE...I HOPE MY CHP DOESN'T BLOW A FUSE IF SOMETHING HAPPENS AND THEY TEST IT AND TOYOTA WAS AT FAULT AS IT SHOULD PROVIDE A SAFE CAR FOR CALIFORNIA HIGHWAYS... *TR
THE HEADLIGHTS ON MY 2008 TOYOTA PRIUS WORK INTERMITTENTLY WHICH CAUSE REAL SAFETY ISSUES WHEN DRIVING. THE HEADLIGHTS ARE HID (HIGH INTENSITY DISCHARGE) AND THE TOYOTA DEALER HAS TRIED REPAIRING THE PROBLEM BUT THE PROBLEM RETURNS. THIS RECURRING PROBLEM HAS BEEN NOTED BY MANY OWNERS BUT TOYOTA DOES NOT COVER THE PROBLEM IF I…
Read full complaint
THE HEADLIGHTS ON MY 2008 TOYOTA PRIUS WORK INTERMITTENTLY WHICH CAUSE REAL SAFETY ISSUES WHEN DRIVING. THE HEADLIGHTS ARE HID (HIGH INTENSITY DISCHARGE) AND THE TOYOTA DEALER HAS TRIED REPAIRING THE PROBLEM BUT THE PROBLEM RETURNS. THIS RECURRING PROBLEM HAS BEEN NOTED BY MANY OWNERS BUT TOYOTA DOES NOT COVER THE PROBLEM IF IT IS OUT OF THEIR 3YR / 36KMILE WARRANTY. THIS IS A SAFETY ISSUE THAT SHOULD BE COVERED UNDER WARRANTY BY TOYOTA REGARDLESS OF MILEAGE. THEY PROBABLY DON'T WANT TO COVER THIS UNDER WARRANTY AS THE BULB COSTS ~$300 (~$400 INSTALLED). *TR
HEADLIGHT FAILURE ON THE PRIUS SEEMS TO BE AN ON GOING ISSUE FROM YEAR TO YEAR FOR THE MODELS THAT HAVE THE HID TYPE. I LOST THE DRIVERS SIDE LIGHT ABOUT THE FIRST OF SEPT. 08 AND THE PASSENGER SIDE THIS MORNING. DOING A SEARCH AND READING OF THE PROBLEM IS WHY I AM FILING A COMPLAINT. *TR
TL*THE CONTACT OWNS A 2008 TOYOTA PRIUS. THE CONTACT STATED THAT THE HEADLIGHTS FAIL TO PROJECT FAR ENOUGH DOWN THE ROAD. THE FAILURE IS EVIDENT WHILE DRIVING AT ANY SPEED. THE CURRENT MILEAGE WAS 450 AND FAILURE MILEAGE WAS 83. UPDATED 05/19/08. *LJ UPDATED 05/19/08
WHEN I TURN MY HEAD LIGHTS ON AFTER A FEW MINUTES LEFT LIGHT GOES OFF I TURN OFF THE LIGHTS AND TURN BACK ON AGAIN THE BOTH LIGHTS ARE ON FOR FEW MINUTES AND THEN AGAIN LEFT LIGHT GOES OFF. *TR
Official recalls
412V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence & remedy
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Hybrid Propulsion System: Inverter
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Engine And Engine Cooling
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.
Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.
Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
12V537000 · Steering; Steering:gear Box:shaft Sector
Nov 14, 2012
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence & remedy
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Additional source detail variants (2)
Steering:gear Box:shaft Sector
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
Steering
Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.
Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.
Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.
10V036000 · Equipment:other:labels
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
DP13001 · Intermediate Steering Shaft Separation
Opened Feb 21, 2013 · Closed Apr 8, 2020
Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Additional source detail variants (3)
Steering:column
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering:linkages
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Steering
The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606
Illustration