← New search

2008 Toyota Prius

Owner reports · Recalls · Investigations

More warning signs than most Prius years

Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.

About this comparison →

When problems were reported

Mileage at the reported incident

1,248 reports with mileage · 249 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

152 crash reports6 fire reports50 injury reports

Exterior Lighting complaints

579 reports
Clear category filter
55,781 miles · Jun 22, 2015
Exterior Lighting

ALMOST WEEKLY MY PASSENGER SIDE HEADLIGHT GOES VERY DIM OR OUT COMPLETELY. I KNOW IT WHEN I TURN RIGHT AS IT IS DARK AS I ENTER A SIDE STREET UNTIL DRIVER'S HEADLIGHT ILLUMINATES AREA. BULBS ARE $ 279 AND NEW ONES DON'T CORRECT IT. I KEEP GETTING DEFECTIVE EQUIPMENT TICKETS AS WELL. THANK YOU *TR

NHTSA ODI #10726476

60,000 miles · Jun 9, 2015
Exterior Lighting

I WAS DRIVING MY TOYOTA 2008 PRIUS IN THE PITCH BLACK AT 70-75 MPH IN THE BADLANDS STATE PARK. THE HEADLIGHTS TURNED OFF SPONTANEOUSLY. I HAD TO MAKE AN EMERGENCY STOP. NO HEADLIGHTS!! THEY EVENTUALLY TURNED BACK ON.

NHTSA ODI #10724442

26,000 miles · Jun 2, 2015
Exterior Lighting

THE LEFT HEADLIGHT GOES ON AND OFF. THIS IS A RECURRING PROBLEM WITH 2008 PRIUS ACCORDING TO OTHER INTERNET SITES I HAVE VISITED. THERE SHOULD HAVE BEEN A RECALL.

NHTSA ODI #10722862

150,777 miles · Apr 23, 2015
Exterior Lighting

I BOUGHT A USED TOYOTA PRIUS 2008 .RIGHT SIDE HEADLIGHT KEEPS TURNING OFF AT NIGHT. *TR

NHTSA ODI #10712335

78,700 miles · Apr 3, 2015
Exterior Lighting

I WAS TRAVELING ON A MAJOR HIGHWAY AND ALL MY LIGHTS WENT OUT. PITCH BLACK. LUCKILY, THERE WERE VERY FEW CARS ON THE ROAD. I WAS ABLE TO PULL TO THE SIDE AND PUT MY FLASHERS ON AND USE THEIR INTERMITTENT FLASHING TO SLOWLY FIND MY WAY HOME (ABOUT 8 MORE MILES). THIS COULD HAVE CAUSED FATALITIES - MY OWN AND OTHERS WHO MAY HAVE…

Read full complaint

I WAS TRAVELING ON A MAJOR HIGHWAY AND ALL MY LIGHTS WENT OUT. PITCH BLACK. LUCKILY, THERE WERE VERY FEW CARS ON THE ROAD. I WAS ABLE TO PULL TO THE SIDE AND PUT MY FLASHERS ON AND USE THEIR INTERMITTENT FLASHING TO SLOWLY FIND MY WAY HOME (ABOUT 8 MORE MILES). THIS COULD HAVE CAUSED FATALITIES - MY OWN AND OTHERS WHO MAY HAVE CRASHED INTO ME. THIS WAS A TERRIBLE SITUATION AND FROM WHAT I HAVE JUST RESEARCHED, IT HAPPENS WITH THE PRIUS. NOW I HAVE THE INCONVENIENCE (AND EXPENSE?) OD FIGURING OUT HOW TO GET THIS FIXED SO IT WILL NEVER HAPPEN AGAIN!!!! *TR

NHTSA ODI #10703644

94,000 miles · Mar 31, 2015
Electrical SystemExterior Lighting

THE LEFT HEADLIGHT KEEPS TURNING ITSELF OFF WHEN DRIVING OR NOT. WHEN BUMPED NEXT TO THE HEADLIGHT COVER IT COMES BACK ON. THE BULB AND CONNECTOR ARE FINE. THIS IS A SAFETY HAZARD, THAT IF THE RIGHT ONE STARTS DOING THE SAME THIN AT NIGHT, IT WOULD PUT ME INTO A DANGEROUS AND LIFE THREATENING SITUATION. I THINK TOYOTA SHOULD…

Read full complaint

THE LEFT HEADLIGHT KEEPS TURNING ITSELF OFF WHEN DRIVING OR NOT. WHEN BUMPED NEXT TO THE HEADLIGHT COVER IT COMES BACK ON. THE BULB AND CONNECTOR ARE FINE. THIS IS A SAFETY HAZARD, THAT IF THE RIGHT ONE STARTS DOING THE SAME THIN AT NIGHT, IT WOULD PUT ME INTO A DANGEROUS AND LIFE THREATENING SITUATION. I THINK TOYOTA SHOULD HAVE A RECALL ON THIS PROBLEM. *TR

NHTSA ODI #10702986

Mileage unknown · Feb 15, 2015
Electrical SystemExterior Lighting

INTERMITTENT HEADLAMP FAILURE. FLICKING LIGHTS ON AND OFF WILL TEMPORARILY REMEDY ONLY TO FAIL AGAIN DURING THE SAME DRIVE. NEAR ACCIDENT ON PITCH BLACK MOUNTAIN ROAD WHEN BOTH LIGHTS FAILED. BULBS HAVE BEEN REPLACED MULTIPLE TIMES BY DEALER AND PROBLEM CONTINUES. I'VE BEEN PULLED OVER BY LAW ENFORCEMENT AND GIVEN WARNINGS. WE H…

Read full complaint

INTERMITTENT HEADLAMP FAILURE. FLICKING LIGHTS ON AND OFF WILL TEMPORARILY REMEDY ONLY TO FAIL AGAIN DURING THE SAME DRIVE. NEAR ACCIDENT ON PITCH BLACK MOUNTAIN ROAD WHEN BOTH LIGHTS FAILED. BULBS HAVE BEEN REPLACED MULTIPLE TIMES BY DEALER AND PROBLEM CONTINUES. I'VE BEEN PULLED OVER BY LAW ENFORCEMENT AND GIVEN WARNINGS. WE HAVE TWO YOUNG CHILDREN AND CANNOT SAFELY DRIVE OUR CAR DURING THE NIGHT OR FOR TRAVEL. THERE IS CLEARLY A PROBLEM...WHY IS THERE NO ACCOUNTABILITY? MUST THERE BE DEATHS OR INJURIES TO GET THIS RESOLVED? *TR

NHTSA ODI #10683538

50,000 miles · Jan 22, 2015
Exterior Lighting

RIGHT HEADLIGHT STARTED WORKING INTERMITTENTLY AROUND 50,000 MILES, THEN FINALLY FAILED. REPLACING THE BULB DID NOT FIX THE PROBLEM. THEN LEFT HEADLIGHT COMPLETELY FAILED AROUND 63,000 MILES. IT WAS DEFINITELY ANNOYING TO HAVE ONE FUNCTIONING HEADLIGHT, AND NOW IT'S JUST PLAIN UNSAFE NOT TO HAVE ANY AT ALL. *TR

NHTSA ODI #10678434

112,011 miles · Jan 18, 2015
Exterior Lighting

THE HEADLIGHTS INTERMITTENTLY FAIL - TURN OFF - DURING DRIVING (WITHOUT WARNING). FORTUNATELY, SO FAR ONLY ONE HEADLIGHT HAS FAILED AT ONCE. TOYOTA IS AWARE OF THIS ISSUE, BUT SO FAR THERE HAVEN'T BEEN ENOUGH PROBLEMS, APPARENTLY, TO JUSTIFY A SAFETY RECALL. SEEMS LIKE A VERY SERIOUS THING - AND IT IS JUST A MATTER OF GOOD FO…

Read full complaint

THE HEADLIGHTS INTERMITTENTLY FAIL - TURN OFF - DURING DRIVING (WITHOUT WARNING). FORTUNATELY, SO FAR ONLY ONE HEADLIGHT HAS FAILED AT ONCE. TOYOTA IS AWARE OF THIS ISSUE, BUT SO FAR THERE HAVEN'T BEEN ENOUGH PROBLEMS, APPARENTLY, TO JUSTIFY A SAFETY RECALL. SEEMS LIKE A VERY SERIOUS THING - AND IT IS JUST A MATTER OF GOOD FORTUNE ON TOYOTA'S PART THAT THERE HAVE NOT BEEN FATALITIES (TO MY KNOWLEDGE). *TR

NHTSA ODI #10676340

Mileage unknown · Jan 4, 2015
Electrical SystemExterior LightingVisibility/wiper

THE DRIVER HEADLAMP TURNS OFF AFTER APPROX 5 MINUTES OF USE. CAN TURN LIGHTS OFF THEN ON AGAIN TO RESTART HEADLAMP. I FIRST TOOK TO DEALER AFTER PURCHASING USED BECAUSE OF THIS PROBLEM AND THEY DID NOT MENTION WHAT I HAVE RECENTLY LEARNED IS A KNOWN DEFECT. THIS HAS BEEN OCCURRING FOR THE LAST TWO YEARS. CHANGING BULB FIXES PROB…

Read full complaint

THE DRIVER HEADLAMP TURNS OFF AFTER APPROX 5 MINUTES OF USE. CAN TURN LIGHTS OFF THEN ON AGAIN TO RESTART HEADLAMP. I FIRST TOOK TO DEALER AFTER PURCHASING USED BECAUSE OF THIS PROBLEM AND THEY DID NOT MENTION WHAT I HAVE RECENTLY LEARNED IS A KNOWN DEFECT. THIS HAS BEEN OCCURRING FOR THE LAST TWO YEARS. CHANGING BULB FIXES PROBLEM FOR A WHILE BUT PROBLEM RE-OCCURS. THIS ISSUE IS A MAJOR SAFETY ISSUE, AND TOYOTA IS CHARGING EXORBITANT RATES TO REPLACE THE HEADLAMPS. I AM AFRAID TO DRIVE MY CAR AT NIGHT OR FOR LONG DISTANCES. THIS PROBLEM NEEDS A PERMANENT FIX! *TR

NHTSA ODI #10669928

Official recalls

4

12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence & remedy

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Hybrid Propulsion System: Inverter

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Engine And Engine Cooling

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

12V537000 · Steering; Steering:gear Box:shaft Sector

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence & remedy

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Steering:gear Box:shaft Sector

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Steering

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP13001 · Intermediate Steering Shaft Separation

Opened Feb 21, 2013 · Closed Apr 8, 2020

Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Additional source detail variants (3)

Steering:column

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606