← New search

2008 Toyota Prius

Owner reports · Recalls · Investigations

More warning signs than most Prius years

Owner complaints for the 2008 Toyota Prius are substantially higher than the model-year median of 164.

About this comparison →

When problems were reported

Mileage at the reported incident

1,248 reports with mileage · 249 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Exterior Lighting. Review the 579 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 235 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Service Brakes, Hydraulic. Review the 171 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

152 crash reports6 fire reports50 injury reports

Electrical System complaints

235 reports
Clear category filter
Mileage unknown · Jan 4, 2015
Electrical SystemExterior LightingVisibility/wiper

THE DRIVER HEADLAMP TURNS OFF AFTER APPROX 5 MINUTES OF USE. CAN TURN LIGHTS OFF THEN ON AGAIN TO RESTART HEADLAMP. I FIRST TOOK TO DEALER AFTER PURCHASING USED BECAUSE OF THIS PROBLEM AND THEY DID NOT MENTION WHAT I HAVE RECENTLY LEARNED IS A KNOWN DEFECT. THIS HAS BEEN OCCURRING FOR THE LAST TWO YEARS. CHANGING BULB FIXES PROB…

Read full complaint

THE DRIVER HEADLAMP TURNS OFF AFTER APPROX 5 MINUTES OF USE. CAN TURN LIGHTS OFF THEN ON AGAIN TO RESTART HEADLAMP. I FIRST TOOK TO DEALER AFTER PURCHASING USED BECAUSE OF THIS PROBLEM AND THEY DID NOT MENTION WHAT I HAVE RECENTLY LEARNED IS A KNOWN DEFECT. THIS HAS BEEN OCCURRING FOR THE LAST TWO YEARS. CHANGING BULB FIXES PROBLEM FOR A WHILE BUT PROBLEM RE-OCCURS. THIS ISSUE IS A MAJOR SAFETY ISSUE, AND TOYOTA IS CHARGING EXORBITANT RATES TO REPLACE THE HEADLAMPS. I AM AFRAID TO DRIVE MY CAR AT NIGHT OR FOR LONG DISTANCES. THIS PROBLEM NEEDS A PERMANENT FIX! *TR

NHTSA ODI #10669928

149,922 miles · Dec 20, 2014
Electrical System

THE SPIRAL CABLE THAT CONTROLS THE ELECTRICAL SUPPLY TO THE STEERING WHEEL (RADIO, HEATING,AIR CONDITIONING, ETC. FAILED). IN SOME VEHICLES THE AIR BAG POWER SUPPLY IS ROUTED THROUGH THIS CABLE AND THE AIR BAG POWER SUPPLY FAILS WHEN THE SPIRAL CABLE FAILS. IN MY PARTICULAR CASE THE AIR BAG WARNING LIGHT DID NOT COME ON BUT MO…

Read full complaint

THE SPIRAL CABLE THAT CONTROLS THE ELECTRICAL SUPPLY TO THE STEERING WHEEL (RADIO, HEATING,AIR CONDITIONING, ETC. FAILED). IN SOME VEHICLES THE AIR BAG POWER SUPPLY IS ROUTED THROUGH THIS CABLE AND THE AIR BAG POWER SUPPLY FAILS WHEN THE SPIRAL CABLE FAILS. IN MY PARTICULAR CASE THE AIR BAG WARNING LIGHT DID NOT COME ON BUT MOST OF THE OTHER SWITCHES CEASED WORKING).

NHTSA ODI #10667405

Mileage unknown · Dec 19, 2014
Electrical SystemExterior Lighting

PURCHASED USED IN OCT 2013, FIRST HAD TO REPLACE HEADLIGHT IN DEC 2013. HAVE REPLACED RIGHT HEADLIGHT 6 TIMES AND BALLAST ONCE. PROBLEM ONLY TEMPORARILY RESOLVED. THIS MONTH HEADLIGHT WENT OUT AGAIN. HAVE REPLACED BALLAST AND BULB WITH NO SUCCESS. HEADLIGHT WILL NOT STAY ON LONGER THAN 30 SEC BEFORE GOING BACK OUT. *TR

NHTSA ODI #10667246

53,341 miles · Dec 9, 2014
Electrical SystemStructure

THE HATCHBACK LIFT HAS DETERIORATED AND NO LONGER WORKS. THE TOYOTA SERVICE REPRESENTATIVE QUOTED ME $570 TO REPLACE IT, STATING IT COULD POSE AN ELECTRICAL SYSTEM SAFETY ISSUE. NO DAMAGE HAS OCCURRED AND SINCE IT IS KEYLESS ... HOW DOES THIS HAPPEN? THE CLEAR COAT HAS DEGRADED ONLY ON THE PIECE OF METAL THAT ENCLOSES THE …

Read full complaint

THE HATCHBACK LIFT HAS DETERIORATED AND NO LONGER WORKS. THE TOYOTA SERVICE REPRESENTATIVE QUOTED ME $570 TO REPLACE IT, STATING IT COULD POSE AN ELECTRICAL SYSTEM SAFETY ISSUE. NO DAMAGE HAS OCCURRED AND SINCE IT IS KEYLESS ... HOW DOES THIS HAPPEN? THE CLEAR COAT HAS DEGRADED ONLY ON THE PIECE OF METAL THAT ENCLOSES THE HATCHBACK'S LIFT MECHANISM AND STARTED FLAKING ABOUT THE SAME TIME THAT I NOTICED IT WAS GETTING HARDER AND HARDER TO LIFT THE HATCHBACK. COULD THESE TWO FAILURES BE RELATED? WHEN THESE PROBLEMS STARTED SEVERAL MONTHS AGO IT DIDN'T OCCUR TO ME THAT THERE MIGHT BE A CONNECTION. THE SERVICE REP IGNORED MY QUESTION ABOUT A POSSIBLE RELATIONSHIP. *TR

NHTSA ODI #10663239

90,000 miles · Nov 12, 2014
Electrical SystemStructure

REAR HATCH BUTTON RUBBER HAS MELTED. CAUSES ELECTRICAL HATCH OPENING MECHANISM TO FAIL COMPLETELY. RUBBER REMAINS STICKY IN HOT WEATHER, TRANSFERS TARRY RESIDUE TO FINGERS. IN COLD WEATHER BUTTON WILL NOT FUNCTION AT ALL. SAFETY ISSUE BECAUSE REAR HATCH IS NOT ACCESSIBLE. CAN NOT ACCESS SPARE TIRE. THERE IS NO HATCH RELEASE AVAI…

Read full complaint

REAR HATCH BUTTON RUBBER HAS MELTED. CAUSES ELECTRICAL HATCH OPENING MECHANISM TO FAIL COMPLETELY. RUBBER REMAINS STICKY IN HOT WEATHER, TRANSFERS TARRY RESIDUE TO FINGERS. IN COLD WEATHER BUTTON WILL NOT FUNCTION AT ALL. SAFETY ISSUE BECAUSE REAR HATCH IS NOT ACCESSIBLE. CAN NOT ACCESS SPARE TIRE. THERE IS NO HATCH RELEASE AVAILABLE AT DRIVER'S SEAT IN FRONT. THERE IS NO MECHANICAL ONLY ALTERNATIVE. CHILD TRAPPED IN TRUNK WOULD HAVE NO WAY OUT. DESPITE NUMEROUS AND WELL DOCUMENTED CASES REPORTED ONLINE TOYOTA WILL NOT FIX PROBLEM VOLUNTARILY. *TR

NHTSA ODI #10654331

70,000 miles · Nov 10, 2014
Electrical SystemExterior Lighting

THE HEADLIGHT ON THE RIGHT SIDE OF THE CAR GOES OUT WHILE DRIVING. IT COMES BACK ON WHEN I TURN THE HEADLIGHT OFF AND TURN THEM BACK ON AGAIN. THE HEADLIGHT WILL GO OFF AGAIN AT DIFFERENT SPEEDS. THE HEADLIGHT MAY GO OFF MULTIPLE TIMES WHEN DRIVING. THIS IS A VERY LARGE SAFETY CONCERN. *TR

NHTSA ODI #10654052

161,000 miles · Oct 26, 2014
Electrical SystemExterior Lighting

THE FIRST TIME BOTH LIGHTS WENT OUT, WE WERE TRAVELING SOUTH ON I-95 NEAR RICHMOND, VA. PRIOR TO THIS, WE THOUGHT THE LIGHTS HAD DIMMED A COUPLE TIMES, BUT WHEN WE CHECKED THEM, THEY WERE FINE. THERE IS NO MISTAKE WHEN YOU LOOSE BOTH HEADLIGHTS WHILE ON HIGH BEAM, THERE ARE NO FOG LIGHTS, SO IT GETS VERY DARK. I THINK GOING TO…

Read full complaint

THE FIRST TIME BOTH LIGHTS WENT OUT, WE WERE TRAVELING SOUTH ON I-95 NEAR RICHMOND, VA. PRIOR TO THIS, WE THOUGHT THE LIGHTS HAD DIMMED A COUPLE TIMES, BUT WHEN WE CHECKED THEM, THEY WERE FINE. THERE IS NO MISTAKE WHEN YOU LOOSE BOTH HEADLIGHTS WHILE ON HIGH BEAM, THERE ARE NO FOG LIGHTS, SO IT GETS VERY DARK. I THINK GOING TO LOW BEAM GAVE US SOME LIGHT (THE FOG LIGHTS) BUT DO NOT REMEMBER, I THEN TURNED THE LIGHT SWITCH OFF AND BACK ON IMMEDIATELY, WHICH TURNED THE LIGHTS BACK ON. SINCE THAT FIRST INCIDENT OF THEM BOTH GOING OUT, WE HAVE SEEN BOTH THE DRIVER'S SIDE HEADLIGHT ALONE, THE PASSENGER SIDE HEADLIGHT ALONE, AND AT LEAST HALF A DOZEN TIMES BOTH LIGHTS GO OUT AT THE SAME TIME. ALL BUT ONCE, TURNING THE LIGHT SWITCH OFF AND THEN ON TURNED THE LIGHTS BACK ON. THE LAST TIME BOTH WENT OUT, I HAD TO TURN THE SWITCH OFF AND BACK ON SEVERAL TIMES TO GET THE LIGHTS BACK ON. WITH A COST OF OVER $200 PER LIGHT, I DECIDED TO CHANGE THE PASSENGER SIDE LIGHT AND SEE IF THAT LIGHT WOULD STAY ON. IT MADE NO DIFFERENCE. I FOUND IN THE USER'S MANUAL THAT LOW VOLTAGE COULD CAUSE THE HIGH INTENSITY DISCHARGE (HID) LIGHTS TO GO OUT, SO I HAD AAA CHECK THE ENGINE BATTERY. THE TEST SHOWED THE BATTERY WAS GOOD, BUT IT ONLY HAD 364 COLD CRANKING AMPS SO I HAD A NEW BATTERY PUT IN. WE WERE TOLD BY TWO OTHER SOURCES THAT THE RIGHT BATTERY HAD 450 COLD CRANK AMPS SO I THOUGHT THAT MIGHT ACCOUNT FOR THE HID LIGHT PROBLEM. THAT WAS JUST A FEW DAYS AGO, AND THE PASSENGER SIDE HEADLIGHT HAS STILL GONE OUT SEVERAL TIMES SINCE THE BULB AND BATTERY WERE REPLACED. SO FAR, WE HAVE NOT HAD BOTH LIGHTS GO OUT AGAIN. *TR

NHTSA ODI #10650009

77,000 miles · Oct 22, 2014
Electrical SystemEngine

DRIVING ON SB HWY 35 AT 74MPH, MASTER WARNING LIGHT CAME ON AND VEHICLE SHUT DOWN, NO ELECTRICAL OR ENGINE CONTROL. PULLED SAFELY TO SHOULDER OF ROAD. CAR WOULD NOT RESTART. GOT OUT OF CAR, LOCKED CAR, UNLOCKED CAR (TOYOTA TECHNICIAN INSTRUCTIONS), THEN CAR RESTARTED. GOT CAR OFF THE ROAD, CONTACTED STATE FARM FOR TOW TO AUT…

Read full complaint

DRIVING ON SB HWY 35 AT 74MPH, MASTER WARNING LIGHT CAME ON AND VEHICLE SHUT DOWN, NO ELECTRICAL OR ENGINE CONTROL. PULLED SAFELY TO SHOULDER OF ROAD. CAR WOULD NOT RESTART. GOT OUT OF CAR, LOCKED CAR, UNLOCKED CAR (TOYOTA TECHNICIAN INSTRUCTIONS), THEN CAR RESTARTED. GOT CAR OFF THE ROAD, CONTACTED STATE FARM FOR TOW TO AUTONATION TOYOTA SOUTH AUSTIN. TOYOTA TECHNICIAN REMOVED A THIRD PARTY TELEMATIC DEVICE (IN-DRIVE) FROM OBD PORT. VEHICLE DIAGNOSTIC SCAN SHOWED TWO COMMUNICATION ERRORS U0100 AND U0111. THIRD PARTY TELEMATIC DEVICE WAS NOT REINSTALLED. VEHICLE WAS TEST DRIVEN, HELD OVERNIGHT, TEST DRIVEN AGAIN AND THE ERRORS OR SHUTDOWN DID NOT REPEAT. TOYOTA SERVICE MANAGER SAID THEY HAVE SEEN THIRD PARTY DEVICES CONNECTED TO ODB PORT CAUSE ERRORS AND HAVE TO BE REMOVED OR REPLACED. WE HAVE THREE HYBRID VEHICLES IN OUR HOUSEHOLD EACH WITH A THIRD PARTY TELEMATIC DEVICE FROM IN-DRIVE. ALL THREE HAVE BEEN REMOVED AND RETURNED TO IN-DRIVE WITH SUPPLIED PACKAGING AND RETURN INSTRUCTIONS. *TR

NHTSA ODI #10649235

81,000 miles · Aug 24, 2014
Electrical SystemLatches/locks/linkages

TRUNK HATCH RELEASE RUBBER PIECE STARTED GOING SOFT; IT IS NOW MELTED AND COMPLETELY DISINTEGRATED INTO THE LATCH LOCKING MECHANISM. *TR

NHTSA ODI #10627814

104,000 miles · Aug 23, 2014
Electrical SystemExterior Lighting

RIGHT HEAD LIGHT WOULD GO OFF ON IT'S OWN. LIGHT WAS REPLACED BY DEALER ABOUT A YEAR AGO. NOW BOTH HEADLIGHTS GO OUT!!!!!! *TR

NHTSA ODI #10627786

Official recalls

4

12V536000 · Engine And Engine Cooling; Hybrid Propulsion System: Inverter

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence & remedy

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Hybrid Propulsion System: Inverter

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Engine And Engine Cooling

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 6, 2003, through March 30, 2009 and FCHV-adv vehicles manufactured December 12, 2008, through September 13, 2011. During manufacturing, a scratch may have occurred inside of the electrically driven water pump at the coil wire. The coil wire may corrode at the scratched portion.

Consequence: The corroded coil wire may break and the water pump could stop. The corroded coil wire could cause a short circuit between coil wires and a possible open fuse, creating a stall-like condition of the hybrid system while the vehicle is being driven. This may increase the risk of a vehicle crash.

Remedy: Toyota will notify its owners, and dealers will replace the electric water pump, free of charge. The recall began on January 17, 2013. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

12V537000 · Steering; Steering:gear Box:shaft Sector

Nov 14, 2012

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence & remedy

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Additional source detail variants (2)

Steering:gear Box:shaft Sector

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

Steering

Toyota is recalling certain model year 2004-2009 Prius vehicles manufactured August 5, 2003, through March 30, 2009. The affected vehicles have a steering intermediate extension shaft assembly built with metal splines that complete the connection from the steering wheel to the steering gear. These splines may have been manufactured with an insufficient hardness.

Consequence: Over time, the splines may wear and eventually fail resulting in a loss of steering ability, increasing the risk of a vehicle crash.

Remedy: Toyota will notify owners, and dealers will inspect the extension shaft and replace it if it is one with insufficient hardness, free of charge. The recall began during December 2012. Owners may contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

DP13001 · Intermediate Steering Shaft Separation

Opened Feb 21, 2013 · Closed Apr 8, 2020

Status: closed (inferred from source dates) · Steering; Steering:column; Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Additional source detail variants (3)

Steering:column

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering:linkages

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606

Steering

The Office of Defects Investigation (ODI) received a January 2013 defect petition requesting that it open an investigation on Model Year (MY) 2004-2009 Toyota Prius vehicles to address a possible manufacturing safety defect related to the steering column intermediate shaft.During the defect petition evaluation, ODI: 1.Reviewed the petition and its enclosures; 2.Reviewed the subject steering system layout; 3.Examined the Petition Vehicle?s history, including its repair history; 4.Reviewed and followed-up potentially related consumer complaints; 5.Assessed Safety Recalls 06V-188 and 12V-537; and, 6.Requested and examined complaint, claim, field report, service history, and warranty information from Toyota.ODI's review revealed that the petition vehicle had been recalled (Recall 06V188) to remedy a defect in the system identified in the petition with the remedy taking place prior to the failure that prompted the petition. Circumstances point to incorrect reassembly of the petitioner's vehicle by those who performed the recall remedy.ODI examined the issues raised by this petition to identify any related safety defect trend in the general subject vehicle population.That review identified a low rate of related consumer complaints (twenty-five over a eight year period from a population of over 600,000 vehicles) and no pattern that would identify either a safety defect not already covered by the two existing steering safety recalls by Toyota or a systematic problem with either recall remedy.Based on this evaluation, ODI does not believe that additional investigation will lead to a finding that a defect related to motor vehicle safety exists in the subject vehicles. Therefore, in view of the need to allocate and prioritize NHTSA?s limited resources to best accomplish the agency's safety mission, the petition is denied. The denial of this petition does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency reserves the right to take further action if warranted by the circumstances.For more information, see the Federal Register notice in the public file for this action (https://www.nhtsa.gov/recalls#vehicle, select NHTSA ID, enter: DP13001)The ODI reports cited above can be reviewed on-line (https://www.nhtsa.gov/recalls#vehicle) under the following NHTSA ID numbers:10407520, 10418710, 10429551, 10473654, 10478195, 10478053, 10437229, 10489425, 10510722, 10639984, 10648277, 10499778, 10712626, 10723196, 10787530, 10808124, 10838803, 11071646, 11098144, 11099507, 11102659, 11160767, 11192607, 11287550, 11287606