MY 2001 TOYOTA PRIUS CONSISTENTLY WORE OUT THE FRONT TIRES ON THE INSIDE PART OF THE TREAD, NOT EASILY VISIBLE FROM THE STREET. THE TIRES WORE DOWN TO THE CORDS IN LESS THAN 10,000 MILES. MY WIFE HAD AN ACCIDENT WHERE SHE COULD NOT STOP THE CAR IN TIME TO AVOID IT. MY YOUNG DAUGHTER WAS IN THE CAR AT THE TIME. THESE CARS ARE…
Read full complaint
MY 2001 TOYOTA PRIUS CONSISTENTLY WORE OUT THE FRONT TIRES ON THE INSIDE PART OF THE TREAD, NOT EASILY VISIBLE FROM THE STREET. THE TIRES WORE DOWN TO THE CORDS IN LESS THAN 10,000 MILES. MY WIFE HAD AN ACCIDENT WHERE SHE COULD NOT STOP THE CAR IN TIME TO AVOID IT. MY YOUNG DAUGHTER WAS IN THE CAR AT THE TIME. THESE CARS ARE STILL ON THE ROAD. I COMPLAINED TO TOYOTA BUT THE COMPLAINT FELL ON DEAF EARS. *TR
NHTSA ODI #10319401
Mileage unknown · Feb 4, 2006
SuspensionTiresCrash
TIRES ON VEHICLE ARE COMING APART ON THE INSIDE TREAD LINE AFTER APPROXIMATELY 5,000 MILES OF USE. WE HAD ONE CRASH WHERE CAR COULD NOT BE STOPPED IN TIME. DID NOT PUT THE CRASH TOGETHER WITH THE TIRE PROBLEM UNTIL RECENTLY. *NM
NHTSA ODI #10149453
60,000 miles · May 16, 2005
SuspensionTires
I HAVE SERIOUS AND REPEATING PROBLEMS WITH SUSPENSION/ TIRES ON MY TOYOTA PRIUS 2001 CAR (MANUFACTURED 06/01). THREE TIMES THE FRONT TIRES WHERE ABNORMALLY AND SIGNIFICANTLY WORN (DURING APPROX 7,500 MILES) WITH, WITH SIDE AND TOP SCARS ETC. TOYOTA ALREADY CHANGED THE TIRES FOUR TIMES BUT THEY ARE UNABLE TO SOLVE PROBLEM. …
Read full complaint
I HAVE SERIOUS AND REPEATING PROBLEMS WITH SUSPENSION/ TIRES ON MY TOYOTA PRIUS 2001 CAR (MANUFACTURED 06/01). THREE TIMES THE FRONT TIRES WHERE ABNORMALLY AND SIGNIFICANTLY WORN (DURING APPROX 7,500 MILES) WITH, WITH SIDE AND TOP SCARS ETC. TOYOTA ALREADY CHANGED THE TIRES FOUR TIMES BUT THEY ARE UNABLE TO SOLVE PROBLEM. HOWEVER, THE SAME PROBLEM IS LIKELY REPEAT ITSELF AGAIN AND AGAIN, AND CHANGING THE TIRES IS NOT A SOLUTION. I DO NOT LIKE DRIVING ON SUCH DANGEROUSLY WORN TIRES; MOREOVER, IT IS AGAINST THE LAW TO DRIVE ON TIRES IN SUCH CONDITION). CAR WAS REGULARLY IN SCHEDULED TOYOTA SERVICE (INCLUDING TIRES ROTATION, PRESSURE CHECK ETC.).
NHTSA ODI #10121100
68,362 miles · Sep 14, 2004
Tires
CONSUMER INSPECTED THE TIRES AND THE BELTS WORE INTO THE STEEL. TIRES WERE REPLACED ON THE FRONT FOUR TIMES. VEHICLE WAS ALIGNED SEVERAL TIMES BUT THE TIRES CONTINUED TO WEAR. THEY WERE REPLACED WITH THE SAME MAKE/MODEL TIRE.*AK
NHTSA ODI #10087883
26,000 miles · Jan 15, 2004
Tires
THIS IS THE 3RD SET OF TIRES I HAVE HAD TO PUT ON THE CAR DUE TO UNEVEN WEAR. I ONLY HAVE 48000 MILES ON THE CAR. THE TIRES WEAR AS THOUGH THEY ARE UNDER INFLATED, BUT I AM CAREFUL TO BE SURE THAT I AM FOLLOWING THE MANUFACTURERS RECOMMENDATION FOR TIRE INFLATION. SINCE THIS IS THE ONLY TIRE USEABLE ON THIS CAR, I AM VERY DIS…
Read full complaint
THIS IS THE 3RD SET OF TIRES I HAVE HAD TO PUT ON THE CAR DUE TO UNEVEN WEAR. I ONLY HAVE 48000 MILES ON THE CAR. THE TIRES WEAR AS THOUGH THEY ARE UNDER INFLATED, BUT I AM CAREFUL TO BE SURE THAT I AM FOLLOWING THE MANUFACTURERS RECOMMENDATION FOR TIRE INFLATION. SINCE THIS IS THE ONLY TIRE USEABLE ON THIS CAR, I AM VERY DISAPPOINTED IN TOYOTA'S RESPONSE TO THE PROBLEM. SINCE TOYOTA PROBABLY GAVE THE SPECS TO BRIDGESTONE TO MANUFACTURE THE TIRE, IT IS TOYOTA'S RESPONSIBILITY TO ASSURE THAT THE TIRE WAS DESIGNED TO BE TO HAVE A NORMAL TREAD LIFE AS WELL AS HELP THE CAR FUNCTION EFFICIENTLY. IT IS REALLY TOUGH TO HAVE TO PAY $80.00 A TIRE AND HAVE IT ONLY LAST 25000 MILES. YES I HAVE HAD THE DEALER SERVICING THE CAR AND ROTATING THE TIRES AND THE ALIGNMENT IS FINE. THE PROBLEM IS THE TIRE THAT TOYOTA REQUIRES TO BE USED ON THE PRIUS.
NHTSA ODI #10070475
33,987 miles · Dec 10, 2003
Tires
WHILE DRIVING THE VEHICLE AT 35MPH, THE FRONT PASSENGER TIRE BLEW OUT. (SIZE # P175/65R14) (DOT # UNKNOWN.) THE MANUFACTURER HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER INFORMATION. *PH TIRES WERE ROTATED WHEN THE OIL WAS CHANGED. DEALER STATED TIRES FAILED DUE TO LACK OF ROTATION. ON ONE OCCASION, CONS…
Read full complaint
WHILE DRIVING THE VEHICLE AT 35MPH, THE FRONT PASSENGER TIRE BLEW OUT. (SIZE # P175/65R14) (DOT # UNKNOWN.) THE MANUFACTURER HAS BEEN CONTACTED. PLEASE PROVIDE FURTHER INFORMATION. *PH TIRES WERE ROTATED WHEN THE OIL WAS CHANGED. DEALER STATED TIRES FAILED DUE TO LACK OF ROTATION. ON ONE OCCASION, CONSUMER THOROUGHLY CHECKED THE TIRE BEFORE DRIVING. TOOK VEHICLE TO THE DEALER AND THEY FOUND A WORM NAIL AFTER LOOKING FOR OVER AN HOUR. CONSUMER HAS THE TIRES. AFTER THE FIRST FAILURE, THE CONSUMER CONTACTED WENT TO FIRESTONE FOR REPLACEMENT TIRES. FIRESTONE STATED THEY COULD ANOTHER TIRE AND GET THE SAME EFFECT SINCE THEY DIDN'T HAVE IT IN STOCK. TOYOTA STATED DIFFERENTLY AND NOR DID THEY HAVE THE TIRE IN STOCK. AFTER DAYS OF THREATS, TOYOTA HAD THE SAME EXACT TIRE AVAILABLE FOR THE CONSUMER. *PH
NHTSA ODI #10047749
Mileage unknown · Oct 28, 2003
SteeringTires
SUSPECTED QUALITY ISSUE RESULTING IN PREMATURE WEAR OF FRONT DRIVER'S SIDE TIRE, LEADING TO POTENTIALLY UNSAFE DRIVING/HANDLING SITUATIONS.*AK
NHTSA ODI #10043788
32,000 miles · Sep 1, 2003
Tires
BRIDGESTONE POTENZA TIRES, P175/65R14- ON JULY 28, 2003 HAD TO REPLACE TIRES ON THE 2001 TOYOTA PRIUS. ONE TIRE WAS FLAT. I NOTICED THAT THE TIRE HAD A BIG CRACK AND THE CORDS WERE VISIBLE. I LOOKED AT IT CLOSER AND NOTICED THAT THERE WERE CRACKS HALFWAY AROUND THE TIRE. I LOOKED AT THE OTHER 3 TIRES AND NOTICED THAT THEY HAD C…
Read full complaint
BRIDGESTONE POTENZA TIRES, P175/65R14- ON JULY 28, 2003 HAD TO REPLACE TIRES ON THE 2001 TOYOTA PRIUS. ONE TIRE WAS FLAT. I NOTICED THAT THE TIRE HAD A BIG CRACK AND THE CORDS WERE VISIBLE. I LOOKED AT IT CLOSER AND NOTICED THAT THERE WERE CRACKS HALFWAY AROUND THE TIRE. I LOOKED AT THE OTHER 3 TIRES AND NOTICED THAT THEY HAD CRACKS ALSO. THE TIRES LOOKED LIKED THEY WERE VERY OLD. *AK
NHTSA ODI #10036983
Mileage unknown · Aug 25, 2003
Tires
WITHIN 9 MONTHS OF VEHICLE PURCHASE I HAD THREE FLAT TIRES AND REPLACED THE BRIDGESTONE POTENZA TIRES WITH A DIFFERENT BRAND RATHER THAN RIST ADDITIONAL FAILURES. *AK
NHTSA ODI #10033437
35,974 miles · Aug 5, 2003
EquipmentFuel System, GasolineTiresCrashInjury
EXTREME TIRE BLOW OUT(ONLY SHREDS LEFT)HESITATION RESULTING IN LOSS OF POWER IN TRAFFIC/GAS PEDAL SENSOR?*AK
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2001 THROUGH 2003 PRIUS PASSENGER CARS MANUFACTURED FROM JANUARY 28, 2000, THROUGH MAY 30, 2003. THE STEERING LINKAGE MAY LOOSEN, RESULTING IN REDUCED ELECTRIC STEERING ASSISTANCE WHEN MAKING A LEFT TURN.
Consequence & remedy
Consequence: LOSS OF POWER STEERING, PARTICULARLY WHEN AN OPERATOR IS ACTIVELY INTENDING TO STEER THE VEHICLE, MAY INCREASE THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND DEALERS WILL REPLACE THE NUTS IN THE STEERING LINKAGE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JULY 8, 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
ON CERTAIN PASSENGER VEHICLES, DUE TO IMPROPER MOLDING OF THE RESIN BODY OF THE CRANKSHAFT POSITION SENOR INSTALLED ON THE ENGINE BLOCK, ENGINE OIL MAY PENETRATE THE SEAL AND ENTER THE SENSOR WIRING CONNECTOR. THE WIRE HARNESS CONNECTOR MAY NOT BE SUFFICIENTLY ATTACHED TO THE LOCKING TAB OF THE SENSOR WIRING CONNECTOR.
Consequence & remedy
Consequence: ENGINE OIL INSIDE THE SENSOR WIRING CONNECTOR COULD CAUSE EXPANSION DUE TO THE HEAT OF THE ENGINE AND COULD DEFORM THE SENSOR WIRING CONNECTOR. THE CONNECTOR MAY BECOME DISCONNECTED, WHICH COULD CAUSE THE ENGINE TO STALL WHILE DRIVING AND NOT BE ABLE TO BE RESTARTED INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE CRANKSHAFT POSITION SENSOR FREE OF CHARGE. THE RECALL BEGAN ON JULY 26, 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INSUFFICIENT ELECTRICAL CONTACT CAN OCCUR IN THE TORQUE SENSOR THAT CONTROLS THE POWER ASSIST OPERATION OF THE ELECTRIC POWER STEERING GEAR BOX. THE TORQUE SENSOR COULD SEND IMPROPER ELECTRICAL SIGNALS.
Consequence & remedy
Consequence: IF THIS OCCURS, THE POWER STEERING WARNING ICON WILL BE DISPLAYED ON THE CENTER PANEL, AND THE DRIVER COULD EXPERIENCE HIGHER THAN NORMAL STEERING EFFORT DEPENDING UPON VEHICLE SPEED.
Remedy: DEALERS WILL REPAIR THE ELECTRIC STEERING GEAR BOX.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
2001 Toyota Prius Problems, Complaints & Recalls | Skip That Year
Illustration