NHTSA owner reports · September 18, 2026 snapshot.
Steering complaints
40 reportsClear category filter24,200 miles · Feb 2, 2015
Steering
TURNING LEFT OR RIGHT THERE IS A CLICKING NOISE AND A CLICK IN THE STEERING WHEEL MAINLY AT SLOW SPEED & IF JUST BEARING MOVING - VERY LOW SPEED. NUMEROUS REPORTS HAVE BEEN TURNED INTO TOYOTA - YET THEY WILL NOT DO A RECALL - APPEARS THAT THE STEERING SHAFT IS THE PROBLEM. HAVE BEEN TOLD HUNDREDS HAVE HAD TO BE REPLACED IN PH…
Read full complaint
TURNING LEFT OR RIGHT THERE IS A CLICKING NOISE AND A CLICK IN THE STEERING WHEEL MAINLY AT SLOW SPEED & IF JUST BEARING MOVING - VERY LOW SPEED. NUMEROUS REPORTS HAVE BEEN TURNED INTO TOYOTA - YET THEY WILL NOT DO A RECALL - APPEARS THAT THE STEERING SHAFT IS THE PROBLEM. HAVE BEEN TOLD HUNDREDS HAVE HAD TO BE REPLACED IN PHOENIX ALONE. CAN YOU REQUEST FROM TOYOTA HOW MANY OF THESE SHAFTS THE DEALERS HAVE PURCHASED? TOYOTA WILL NOT TELL ME WHEN I REQUESTED THIS INFORMATION. OUR VEHICLE HAS LESS THAN 25K MILES ON IT & IT IS 7 YEARS OLD SO IT ISN'T AN ABUSED VEHICLE. THIS PROBLEM IS ALSO ON OTHER TOYOTA MODELS / YEARS I'VE BEEN TOLD. *TR
NHTSA ODI #10680705
125,000 miles · Dec 29, 2014
Steering
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE INTERMEDIATE DRIVESHAFT DETACHED FROM THE MOUNT DUE TO A FAILED SPIRAL CABLE ASSEMBLY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTI…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE ATTEMPTING TO PARK, THE STEERING WHEEL SEIZED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE INTERMEDIATE DRIVESHAFT DETACHED FROM THE MOUNT DUE TO A FAILED SPIRAL CABLE ASSEMBLY. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 125,000.
NHTSA ODI #10668821
141,451 miles · Jun 17, 2014
Electrical SystemEngineSteering
WE WERE STARTING OFF TO GO ON VACATION WHEN WARNING LIGHTS CAME ON THE DASHBOARD AND INFORMATION PANEL WITH HYBRID SYSTEM WARNINGS AND BRAKE WARNINGS THEN THE CAR COMPLETELY STOPPED IN THE MIDDLE OF THE ROAD AND STEERING WAS LOST. WE WERE ABLE TO GET OFF TO THE SIDE ENOUGH TO PREVENT CAUSING AN ACCIDENT HOWEVER WE WERE ON A BUS…
Read full complaint
WE WERE STARTING OFF TO GO ON VACATION WHEN WARNING LIGHTS CAME ON THE DASHBOARD AND INFORMATION PANEL WITH HYBRID SYSTEM WARNINGS AND BRAKE WARNINGS THEN THE CAR COMPLETELY STOPPED IN THE MIDDLE OF THE ROAD AND STEERING WAS LOST. WE WERE ABLE TO GET OFF TO THE SIDE ENOUGH TO PREVENT CAUSING AN ACCIDENT HOWEVER WE WERE ON A BUSY STREET. HAD IT TOWED TO THE LOCAL TOYOTA DEALER AND THE DIAGNOSIS WAS A FAILED COIL. THEY REPLACED ALL 3 COILS SAYING THAT IT WOULD BE PRUDENT AS THE ENGINE WAS ALREADY APART (I AGREE). THEY ALSO SAID THAT THIS IS A RELATIVELY COMMON OCCURRENCE WITH SOME OF THE HIGHLANDER HYBRIDS. I HAVE THE PART AND IT LOOKS LIKE THE TOP OF THE COIL BECAME OVER HEATED AND BLEW OUT THE TOP PLASTIC COMPOUND. I CONSIDER MYSELF VERY LUCKY THAT THIS DID NOT HAPPEN WHILE ON A HIGHWAY ON A RAINY DAY WHERE THE VEHICLE ABRUPTLY STOPPING WOULD CERTAINLY HAVE CAUSED ME TO BE IN AN ACCIDENT. THIS IS CERTAINLY A FLAW THAT TOYOTA SHOULD ADDRESS FOR SAFETY REASONS AND IT MAKES ME HESITANT TO WANT TO PURCHASE ANOTHER TOYOTA PRODUCT AGAIN. *TR
NHTSA ODI #10598817
Mileage unknown · Mar 16, 2013
Steering
I HAD TO REPLACE THE STEERING SHAFT ON THIS CAR. I WAS TOLD THAT ON THE 2008 AND 2013 MODELS THERE WAS AN ISSUE. TOYOTA WOULD NOT WORK WITH ME ON THIS EXPENSE. I FEEL THIS IS A MAJOR PART OF THE CAR AND I COULD HAVE BEEN IN DANGER IF NOT FIXED. THEM KNOWING THIS IS AN ISSUE AND NOT DOING A RECALL IS WRONG! I FELT THEY SHOULD…
Read full complaint
I HAD TO REPLACE THE STEERING SHAFT ON THIS CAR. I WAS TOLD THAT ON THE 2008 AND 2013 MODELS THERE WAS AN ISSUE. TOYOTA WOULD NOT WORK WITH ME ON THIS EXPENSE. I FEEL THIS IS A MAJOR PART OF THE CAR AND I COULD HAVE BEEN IN DANGER IF NOT FIXED. THEM KNOWING THIS IS AN ISSUE AND NOT DOING A RECALL IS WRONG! I FELT THEY SHOULD HAVE TAKEN CARE OF THIS AND NOT AT MY EXPENSE. I HAVE HAD ABOUT 3 DIFFERENT RECALLS ON THE CAR AND THIS JUST ADDED TO MY WORRIES. I AM NOT SURE WHAT CONSTITUTES A RECALL BUT FELT THIS WAS ONE ON TOYOTA. THANK YOU *TR
NHTSA ODI #10503276
61,000 miles · Dec 15, 2012
Electrical SystemSteering
MY STEERING LOCKS WHEN I WAS DRIVING. I REPORTED THIS ISSUE BEFORE TO THE DEALER, BUT THEY FIGURE OUT THAT THE COMPUTER HAS A PROBLEM AFTER THE BIG ISSUE. *TR
NHTSA ODI #10488862
82,600 miles · Nov 20, 2012
Seat BeltsSteering
TL* THE CONTACT OWNS 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE PARKED THE REAR PASSENGER DOOR SIDE SEAT BELT WOULD NOT RELEASE AND AS A RESULT IT HAD TO BE CUT. THE CONTACT ALSO STATED HE HEARD A KNOCKING NOISE EMITTING FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE TECHNI…
Read full complaint
TL* THE CONTACT OWNS 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE PARKED THE REAR PASSENGER DOOR SIDE SEAT BELT WOULD NOT RELEASE AND AS A RESULT IT HAD TO BE CUT. THE CONTACT ALSO STATED HE HEARD A KNOCKING NOISE EMITTING FROM THE STEERING COLUMN. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TESTING. THE TECHNICIAN STATED THE SEAT BELT AND THE LOWER STEERING SHAFT NEEDED TO BE REPLACED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND STATED THE VEHICLE WAS NOT INCLUDED IN ANY RECALLS. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 82,600 AND THE CURRENT MILEAGE WAS 93,000. UPDATED 12/12/12 *CN
NHTSA ODI #10485260
21,000 miles · Sep 18, 2012
Steering
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE CONTACT HEARD A KNOCKING SOUND IN THE STEERING WHEEL AND THE VEHICLE BEGAN TO SHAKE ABNORMALLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND A REPAIR WAS MADE HOWEVER, THE CONTACT WAS UNAWARE OF THE NATURE OF THE REPAIR. AFTER…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING 10 MPH, THE CONTACT HEARD A KNOCKING SOUND IN THE STEERING WHEEL AND THE VEHICLE BEGAN TO SHAKE ABNORMALLY. THE VEHICLE WAS TAKEN TO A DEALER FOR DIAGNOSIS AND A REPAIR WAS MADE HOWEVER, THE CONTACT WAS UNAWARE OF THE NATURE OF THE REPAIR. AFTER LEAVING THE DEALER THE VEHICLE BEGAN TO SHAKE AGAIN. THE VEHICLE WAS TAKEN BACK TO THE DEALER AT LEAST THREE TIMES WHO THEN ADVISED THAT THEY WERE UNSURE OF WHAT WAS CAUSING THE FAILURE. THE VEHICLE WAS NOT FURTHER REPAIRED. THE FAILURE MILEAGE WAS 21,000 AND THE CURRENT MILEAGE WAS 60,000.
NHTSA ODI #10475876
58,000 miles · May 17, 2011
Steering
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING FAILED AND THE STEERING WHEEL BEGAN ABNORMALLY MOVING FROM LEFT TO RIGHT INDEPENDENTLY. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HIM THAT THE POWER STEERING CONTROL MODULE HAD FAILED AND NEEDED…
Read full complaint
TL* THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE POWER STEERING FAILED AND THE STEERING WHEEL BEGAN ABNORMALLY MOVING FROM LEFT TO RIGHT INDEPENDENTLY. THE VEHICLE WAS INSPECTED BY A DEALER AND THEY ADVISED HIM THAT THE POWER STEERING CONTROL MODULE HAD FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED FOR THE POWER STEERING CONTROL MODULE. THE MANUFACTURER WAS CONTACTED AND THEY ADVISED HIM THAT THEY WOULD COVER FIFTY PERCENT OF THE REPAIR COSTS. THE FAILURE MILEAGE WAS APPROXIMATELY 58,000.
NHTSA ODI #10401333
13,000 miles · Feb 23, 2010
SteeringVehicle Speed ControlCrashInjury
TL*THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. ON FEBRUARY 10, 2008 WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SUDDENLY ACCELERATED WHEN SHE PUT HER FOOT ON THE BRAKE PEDAL. THE VEHICLE FAILED TO SLOW DOWN. SHE LOST CONTROL AND SWERVED THE INTO THE LEFT LANE AND CRASHED INTO ANOTHER VEHICLES REAR BUMPER CAUSING THAT VEHICLE…
Read full complaint
TL*THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. ON FEBRUARY 10, 2008 WHILE DRIVING APPROXIMATELY 35 MPH, THE VEHICLE SUDDENLY ACCELERATED WHEN SHE PUT HER FOOT ON THE BRAKE PEDAL. THE VEHICLE FAILED TO SLOW DOWN. SHE LOST CONTROL AND SWERVED THE INTO THE LEFT LANE AND CRASHED INTO ANOTHER VEHICLES REAR BUMPER CAUSING THAT VEHICLE TO CRASH INTO THE VEHICLE IN FRONT OF THEM. SHE SUSTAINED INJURIES TO HER RIBS. THE OTHER TWO DRIVERS ALSO SUSTAINED INJURIES. THE INSURANCE COMPANY WAS IN THE PROCESS OF INVESTIGATING THE FAILURE. THE VEHICLE WAS DESTROYED. THE FAILURE AND THE CURRENT MILEAGES WERE 13,000. A POLICE REPORT WAS FILED. UPDATED 03/30/10. *LJ THE CONSUMER STATED THERE MAY HAVE BEEN POSSIBLE STEERING PROBLEMS AS WELL. ACCORDING TO THE POLICE REPORT, THE CONSUMER WAS TRAVELING TOO FAST FOR THE ROAD CONDITIONS. UPDATED 06/28/10*JB
NHTSA ODI #10313330
2,000 miles · Feb 19, 2010
Steering
TL*THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DRIVING AT LOW SPEEDS WITH HIS FOOT ON THE BRAKE PEDAL, THE POWER STEERING LOCKED AND IT WAS VERY DIFFICULT TO MAKE A LEFT OR RIGHT TURN. THE VEHICLE ALSO BECAME HARD TO CONTROL AT HIGHER SPEEDS BETWEEN 50 TO 70 MPH. THE FAILURE OCCURRED 10 TIMES. THE DEALER WAS CONTACTED AND S…
Read full complaint
TL*THE CONTACT OWNS A 2008 TOYOTA HIGHLANDER. WHILE DRIVING AT LOW SPEEDS WITH HIS FOOT ON THE BRAKE PEDAL, THE POWER STEERING LOCKED AND IT WAS VERY DIFFICULT TO MAKE A LEFT OR RIGHT TURN. THE VEHICLE ALSO BECAME HARD TO CONTROL AT HIGHER SPEEDS BETWEEN 50 TO 70 MPH. THE FAILURE OCCURRED 10 TIMES. THE DEALER WAS CONTACTED AND STATED THAT THE VEHICLE WAS DESIGNED THAT WAY AND IT WAS NOT MALFUNCTIONING. NO REPAIRS WERE MADE TO THE VEHICLE. THE FAILURE MILEAGE WAS 2000. THE CURRENT MILEAGE WAS 12,050.
NHTSA ODI #10312135
Official recalls
11Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Nov 19, 2014
Southeast Toyota Distributors, LLC (SET) is recalling certain model year 2010-2011 Prius and Corolla, 2009-2011 Venza, 2006-2010 Avalon, 2007-2010 FJ Cruiser, 2005-2011 Sienna and Sequoia, 2006-2011 Tacoma 4x2 and 4x4, Camry, Highlander, Tundra 4x2 and 4x4, and 2007-2011 Rav4 and 4Runner. The affected vehicles may experience compression of the seat cushion which may damage the seat heater wiring.
Consequence & remedy
Consequence: Damage to the seat heater wiring could cause the wires to short, increasing the risk of the seat burning and causing personal injury to the occupant.
Remedy: SET will notify owners, and dealers will disconnect the heaters with copper strand heating elements and refund the purchase price of the seat heater accessory, free of charge. The recall is expected to began in January 2015. Owners may contact SET customer service at 1-866-405-4226.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Apr 21, 2011
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Consequence & remedy
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Additional source detail variants (2)
Air Bags:side/window
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Air Bags
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2007-2008 RAV4 VEHICLES. IN THE CURTAIN SHIELD AIRBAG (CSA) SYSTEM, THERE ARE TWO SENSORS IN THE AIRBAG SENSOR ASSEMBLY WHICH ARE DESIGNED TO DETECT VEHICLE ROLL ANGLE. IF ONE OF THESE SENSORS MALFUNCTIONS, THE AIRBAG WARNING LIGHT (MALFUNCTION INDICATOR LIGHT: MIL) WILL ILLUMINATE AND THE ROLL DETECTION SYSTEM WILL BE SUSPENDED; HOWEVER, THE AIRBAG CSA REMAINS AVAILABLE IN THE EVENT OF A SIDE CRASH. IF BOTH SENSORS FAIL NEARLY SIMULTANEOUSLY AFTER INITIAL AIRBAG SYSTEM CHECK, THE CSA AND THE SEAT BELT PRETENSIONER COULD BE INADVERTENTLY ACTIVATED.
Consequence: INADVERTENT ACTIVATION OF THE CSA AND/OR THE SEAT BELT PRETENSIONER CAN CAUSE INJURY TO A VEHICLE OCCUPANT.
Remedy: TOYOTA WILL REPLACE THE AIRBAG SENSOR ASSEMBLY WITH A NEW ONE CONTAINING IMPROVED ROLL RATE SENSORS, FREE OF CHARGE. TOYOTA INTENDS TO SEND AN INTERIM OWNER NOTIFICATION TO OWNERS EARLY TO MID-MAY, 2011 WHEN SUFFICIENT PARTS AND REMEDY BECOMES AVAILABLE. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Jun 15, 2009
TOYOTA IS RECALLING 27,080 MODEL YEAR 2005 THROUGH 2010 PASSENGER CARS BUILT FROM SEPTEMBER 1, 2005 TO MAY 4, 2009. THESE VEHICLES WERE NOT EQUIPPED WITH LOAD CARRYING CAPACITY MODIFICATION LABELS WHICH FAILS TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS."
Consequence & remedy
Consequence: INCORRECT LOAD CARRYING CAPACITY MODIFICATION LABELS COULD RESULT IN THE VEHICLE BEING OVERLOADED, INCREASING THE RISK OF A CRASH.
Remedy: TOYOTA WILL NOTIFY OWNERS AND PROVIDE THEM WITH A NEW, ACCURATE LABEL TO BE INSTALLED OVER THE INACCURATE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2009. OWNERS MAY CONTACT TOYOTA AT 1-888-270-9371.
Apr 18, 2008
TOYOTA IS RECALLING 90,189 MY 2008 HIGHLANDER AND HIGHLANDER HYBRID PASSENGER VEHICLES EQUIPPED WITH A THIRD ROW SEAT. THESE VEHICLES FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." THE NON-DRIVER DESIGNATED SEATING POSITIONS (DSP) ON THESE VEHICLES IS EQUIPPED WITH SEAT BELT ASSEMBLIES THAT HAVE A FEATURE THAT CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) TO AN AUTOMATIC LOCKING RETRACTOR (ALR). THE BELTS CONVERT TO THE ALR MODE AFTER THE WEBBING HAS BEEN FULLY WITHDRAWN FROM THE RETRACTOR. THE SYSTEM IS DESIGNED SO THAT AS THE BELT IS RELEASED INTO THE RETRACTOR, THE SYSTEM REMAINS IN THE ALR MODE SO THAT A CHILD RESTRAINT SYSTEM (CRS) CAN BE TIGHTLY SECURED.
Consequence & remedy
Consequence: HOWEVER, FOR THE TWO THIRD ROW DSP'S ON THESE VEHICLES, THE ALR MODE DEACTIVATES BEFORE THE WEBBING IS FULLY RETRACTED, SO THAT IT WILL NOT LOCK WHEN CERTAIN REAR-FACING CRS'S THAT HAVE A SHORT SEAT BELT ROUTING PATH ARE INSTALLED IN THE VEHICLE. THIS CAN ALLOW THE SEAT BELT WEBBING TO SPOOL OUT DURING NORMAL DRIVING MANEUVERS, WHICH COULD AFFECT THE STABILITY OF A CHILD RESTRAINT INSTALLED AT THOSE SEATING POSITIONS. AS SUCH, THIS COULD DISCOURAGE THE USE OF A CHILD RESTRAINT AND IN THE EVENT OF A CRASH, THE CHILD MAY NOT BE ADEQUATELY PROTECTED POSSIBLY RESULTING IN INJURY.
Remedy: DEALERS WILL INSTALL A NEWLY DESIGNED SEAT BELT COMPONENT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR ABOUT DECEMBER 18, 2008. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA18006 · Steering Column Separation
Opened Nov 16, 2018 · Closed Apr 2, 2024
Status: closed (inferred from source dates) · Steering; Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Additional source detail variants (2)
Steering:column
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Steering
On November 16, 2018, the Office of Defects Investigation (ODI) opened an Engineering Analysis (EA18-006) as an upgrade to a Preliminary Evaluation (PE18-005). The investigation focused on allegations of steering wheel separation from the lower steering column after using the tilt and/or telescoping mechanism. Given the separation occurring when operating the tilt and/or telescoping function and failure of both shear capsules to maintain the lower steering column mounting position, potential for shear capsule damage in the known failures due to collisions, the overall low rate of occurrence, and the updated manufacturer documentation, this investigation is closed. The closing of this investigation does not constitute a finding by NHTSA that no safety-related defect exists. The agency reserves right to take further action if warranted by the circumstances. A detailed summary of the investigation is attached to this closing resume. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
PE18005 · Upper Steering Column Separation
Opened May 4, 2018 · Closed Nov 20, 2018
Status: closed (inferred from source dates) · Steering; Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Additional source detail variants (2)
Steering:column
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Steering
On May 4, 2018, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE18-005 to investigate three allegations of steering column separation for Model Year (MY) 2008 through 2013 Toyota Highlander vehicles. Two (2) of the 3 complaints were received by ODI in April 2018 and occurred while the vehicle was in motion. Since opening PE18-005, one (1) additional VOQ involving steering column separation has been received. This incident occurred while the vehicle was stationary.As part of PE18-005, ODI examined the field data, warranty data, and relevant technical information submitted by Toyota in response to the PE18-005 information request letter. Ten (10) additional incidents of steering column separation were identified. Four (4) of these instances occurred while driving. During PE18-005, ODI confirmed that the steering columns in the subject vehicles are equipped with breakaway capsules that are designed to collapse/shear during certain types of vehicle collisions. This design feature aims to reduce driver injury severity from impact with the steering wheel in frontal vehicle collisions. There is no direct method for detecting when the capsules in the subject vehicles have sheared. If the driver operates the tilt/telescoping feature after the breakaway capsules have separated, the steering column may drop out of position and could subsequently detach entirely from the rest of the steering assembly. Loss of steering while driving may cause a loss of vehicle control, which could lead to a vehicle crash.To date, ODI has identified 14 incidents involving complete steering column separation, 6 of which occurred while driving. One of these incidents involved a minor crash. Additionally, there have been 16 events where the steering column dropped from the dashboard mounting brackets, but column separation did not occur. Four of these incidents happened while driving. Of these 30 total separation/drop incidents, 5 of the vehicles have evidence of minor collision repairs months or years prior to the steering column failure.This investigation has been upgraded an to Engineering Analysis (EA18-006) in order to 1) conduct a more detailed analysis of the conditions that may cause the steering column breakaway capsules to separate and 2) assess factors that may contribute to the problem of failing to detect and repair breakaway capsules after they have separated. Toyota has recently revised their repair manual and issued a Collision Repair Information Bulletin to help address the second concern.The VOQs associated with this investigation can be viewed at www.NHTSA.gov under the following ODI complaint numbers: 11141761, 11083623, 11083280, 10888043.
Illustration