Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

32 crash reports3 fire reports16 injury reports

Structure complaints

8 reports

Clear category filter

190,000 miles · Oct 27, 2023

Structure

Read full complaint

The contact owns a 2004 Toyota Highlander. The contact stated while driving at an undisclosed speed, the front bumper inadvertently detached. The vehicle was taken to an independent mechanic where it was determined that the front lower bumper covers had been attached with mounting tabs and that the bumper assembly had failed and needed to be replaced. The vehicle was not repaired. The contact was informed of an unknown recall. Neither the dealer nor the manufacturer was notified of the failure. The failure mileage was approximately 190,000.

NHTSA ODI #11552313

127,243 miles · May 27, 2015

StructureUnknown Or OtherVisibility/wiperCrash

GAS STATION DID NOT CLOSE HOOD COMPLETELY AND IT BLEW OPEN WHILE TRYING TO ENTER THE HIGHWAY AT JUST OVER 40 MILES PER HOUR.THE SECONDARY SAFETY CATCH DID NOT HOLD OR WORK ! THE HOOD BLEW OPEN AND SHATTERED THE WINDSHIELD AND BENT THE HOOD UP INTO THE ROOF.THE TOPS OF THE FENDERS NEAR THE HINGES WERE ALSO RIPPED UP.

NHTSA ODI #10721835

30,000 miles · Mar 3, 2013

StructureCrash

MY HIGHLANDER WAS INVOLVED IN A TOTAL LOSS CRASH BACK IN 2007, AND THE INSURANCE COMPANY PAID OUT A TOTAL LOSS CLAIM AND TOOK THE SALVAGE. I HAVE REPEATEDLY UPDATED TOYOTA THAT THE VEHICLE WAS DESTROYED, YET THEY HAVE CONTINUED TO SEND RECALL NOTICES FOR THE PSAT 4 YEARS. PLEASE MAKE THEM STOP !! *TR

NHTSA ODI #10501099

73,658 miles · Jun 1, 2010

Structure

Read full complaint

TL* THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. THE CONTACT STATED WHILE REVERSING FROM HER DRIVEWAY AT RELATIVELY LOW SPEEDS OF 1 MPH, THE FRONT BUMPER FRACTURED FROM THE VEHICLE. SHE FURTHER INSPECTED THE VEHICLE AND FOUND THAT THE COMPONENTS THAT HELD THE BUMPER TO THE VEHICLE WERE ALSO BROKEN. SHE CONTACTED THE DEALER WHO REFERRED HER TO THE MANUFACTURER. THE MANUFACTURER REFERRED HER BACK TO THE DEALER. THE CONTACT STATED THE VEHICLE WAS NOT DRIVABLE AND WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 73,658.

NHTSA ODI #10334006

55,000 miles · Jun 16, 2008

Structure

I WANTED TO OPEN MY SUNROOF. I STARTED TO SLIDE BACK AND GOT STUCK. I HAD TO TAKE IT TO A REPAIR SHOP JUST TO HAVE THEM CLOSE IT. THEY ADVISED ME THAT THIS WAS 8TH ONE THAT WHERE THE SUNROOF BROKE. THEY HAD TO DISCONNECT THE SUNROOF JUST TO CLOSE IT. *TR

NHTSA ODI #10231110

1,000 miles · Feb 18, 2005

Structure

OWNER STATED THAT WHILE AT THE DEALERSHIP HE TEST DROVE A TOYOTA HIGHLANDER. THE OWNER FOUND THAT THE MEASUREMENTS FROM THE STEERING WHEEL TO THE ACCELERATOR PEDAL WERE NOT THE SAME IN EACH VEHICLE THAT WAS TEST DRIVEN. *AK

NHTSA ODI #10111786

7 miles · Aug 2, 2004

Structure

Read full complaint

THE 1994 TOYOTA HIGHLANDER HAS A STRUCTURAL DEFECT THE CAN BE VERY DANGEROUS AND AT THE VERY LEAST UNACCEPTABLE FROM A QUALITY CONSUMER STANDPOINT. WHEN THE REAR WINDOW IS PUT DOWN IT CREATES A WIND NOISE AND VIBRATION THAT IS DANGEROUS TO THE PASSENGERS AND DRIVER. IT IS HARD TO IMAGINE THAT TOYOTA COULD LET THIS GO ON WITHOUT A RECALL OR AT THE VERY LEAST A WARNING AND A BETTER SOLUTION THAN "OPEN UP THE FRONT WINDOWS BEFORE OPERATING THE BACK ONES". AFTER JUST ONE MONTH OF OPERATION I AM REALLY QUESTIONING IF I WILL EVER OWN A TOYOTA AGAIN.*AK

NHTSA ODI #10083154

250 miles · Mar 15, 2004

Structure

Read full complaint

I HAVE A 2004 TOYOTA HIGHLANDER. ON MY WAY TO GEORGIA ON INTERSTATE 75, WHILE GOING 70 MILES PER HOUR, I ROLLED DOWN THE BACK WINDOWS.THE VEHICLE VIOLENTLY SHOOK AND THE PRESSURE INSIDE WAS PIERCING TO MY EARS, I FELT LIKE THE BACK REAR WINDOW WAS GOING TO BLOW OUT. THE VHEICLE SHOOK SO VIOLENTY, I HAD A VERY HARD TIME KEEPING UNDER CONTROL WHILE I ROLLED UP THE WINDOWS IT SCARED ME SO BAD, I ALMOST LOST CONTROL OF THE VEHICLE. I REQUESTED THAT THE DEALER (COURTESTY TOYOTA) PUT IN WIND BREAKS OR VENTS, OVER THE SIDE WINDOWS SO THAT I WAS ABLE TO ROLL DOWN THE WINDOWS AND DRIVE SAFELY AND THE DEALER REFUSED MY REQUEST. I TOLD THE DEALER, THAT I BELIEVED THIS SITUATION WAS A SAFETY ISSUE AND THEY STILL REFUSED MY REQUEST. I ASKED TO SEE THE SERVICE MANAGER AND THE SERVICE MANAGER TOLD ME HE WAS AWARE OF THE PROBLEM, THAT WIND BREAKS "WOULD NOT HELP" THE SITUATION. HE SAID THAT IF I WOULD PUT DOWN THE FRONT WINDOWS A FIVE OR SIX INCHES, I WOULD NOT HAVE THE WIND PROBLEM IN THE REAR OF THE VEHICLE. I TOLD HIM, I DO NOT ALWAYS WANT THE FRONT WINDOW OPEN, WHEN I AM DRIVING, SOMETIMES, I WOULD JUST LIKE TO HAVE SOME AIR IN THE BACK. (I ALSO SAID, SUPPOSE SOME CHILD IN THE BACK SEAT SUDDENLY DECIDED TO ROLL DOWN THE WINDOW WHILE THE MOTHER WAS DRIVING ON THE INTERSTATE). AT INTERSTATE SPEEDS YOU WILL LOOSE CONTROL OF THE VEHICLE WITH THE WIND AND THE VEHICLE SHAKING SO VIOLENTLY. THE REASON I CHOSE THE HIGHLANDER WAS THAT THE BACK WINDOWS OPENED. I TAKE MY DOGS WITH ME WHEN I TRAVEL AND THEY CAN GET AIR WHILE THEY ARE RIDING IN THE BACK.*AK

NHTSA ODI #10062206

Official recalls

11V539000 · Engine And Engine Cooling

Nov 9, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Consequence & remedy

Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V112000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence & remedy

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder

Oct 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Consequence & remedy

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

06V253000 · Vehicle Speed Control:accelerator Pedal

Jul 13, 2006

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Consequence & remedy

Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

04V181000 · Latches/locks/linkages:doors:latch

Apr 15, 2004

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

Consequence & remedy

Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.

Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal