Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

32 crash reports3 fire reports16 injury reports

Electronic Stability Control (esc) complaints

15 reports

Clear category filter

53,217 miles · Feb 25, 2009

Electronic Stability Control (esc)Steering

Read full complaint

WIFE WAS DRIVING ON CLEAN DRY ROAD. SUDDENLY, THE VCS LIGHT AND TRACTION LIGHTS CAME ON THE DASHBOARD WHILE ALARM SOUNDING CAME ON AS WELL. CAR SUDDENLY BRAKED, BRAKES MADE A GRINDING SOUND, AND CAR JERKED TO THE RIGHT. TRIED TO DRIVE FORWARD AND IT WOULD NOT GO OVER 10MPH. IF THE CAR DID, THE ABOVE HAPPENED AGAIN. CAR WAS NOT DRIVABLE, AND WAS TOWED TO THE NEAREST TOYOTA DEALERSHIP. THE SITUATION WAS VERY DANGEROUS, AS THE BEHAVIOR OF THE CAR, NOT CONTROLLED BY MY WIFE, THE DRIVER, COULD HAVE EASILY CAUSED AN ACCIDENT. TURNS OUT, THE DEALERSHIP STATED THE STEERING ANGLE SENSOR WENT ON THE CAR. FIRST...THE CAR ONLY HAS 53K MILES ON IT. THIS IS NOT A 'WEAR AND TEAR' PART. THIS PART SHOULD NEVER GO WITH ONLY THIS MANY MILES ON IT. GARBAGE. SECOND, THE FAILURE OF THIS PART CAUSES A VERY DANGEROUS SITUATION ON THE ROAD, AS ONCE IT GOES, THE DRIVER BASICALLY HAS NO CONTROL OVER THE CAR UNTIL IT SLOWS DOWN TO UNDER 10 MILES AN HOUR. TOYOTA NEEDS TO STAND BEHIND THEIR PRODUCT, FOCUS ON THE SAFETY OF THE PUBLIC, AND ISSUE A RECALL FOR THIS PROBLEM. I'VE RESEARCHED THIS ON THE INTERNET AND THERE ARE MANY, MANY COMPLAINTS AND DOCUMENTED CASES OF THIS SAME PROBLEM HAPPENING ON TOYOTA VEHICLES. THE DEALERSHIP FIXED THE PART FOR $700. RIP OFF. *TR

NHTSA ODI #10259942

49,450 miles · Jan 6, 2009

Electronic Stability Control (esc)

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING 5 MPH, THE CONTACT EXPERIENCED UNWANTED TRACTION CONTROL ACTIVITY, WHICH CAUSED THE VEHICLE TO BRAKE EXCESSIVELY. HE TOOK THE VEHICLE TO A LOCAL REPAIR SHOP AND THE MECHANIC REPROGRAMMED THE PCM MEMORY, WHICH REMEDIED THE FAILURE. THE DEALER COULD NOT DETERMINE THE C…

Read full complaint

NHTSA ODI #10254022

86,210 miles · Dec 24, 2008

Electronic Stability Control (esc)Service Brakes, Hydraulic

Read full complaint

THE CAR'S VSC (VEHICLE SKID CONTROL) SYSTEM ACTIVATED ON A DRY STRAIGHT ROAD. THE BRAKES WENT ON AND REDUCED THE SPEED TO ABOUT 5MPH, MAKING THE CAR UNDRIVABLE. GLAD THIS DIDN'T HAPPEN IN TRAFFIC. THE CAR WAS TURNED OFF, AND RESTARTED, AND I COULD GET IT TO ABOUT 10MPH, AND THEN IT WOULD APPLY THE BRAKES QUICKLY AND REDUCED POWER NO-MATTER WHAT THE THROTTLE POSITION WAS, AND THE CAR WAS LIMITED TO ABOUT 5MPH. ONCE THIS HAPPENED THE CAR HAS NOT BEEN ABLE TO BE DRIVEN, UNLESS THE FUSES FOR THE ANTI-LOCK BRAKES ARE REMOVED. I DID THIS JUST TO GET IT TO THE DEALER... IT HAD BUZZERS AND WARNING LIGHTS GOING OFF. THE DEALER LOOKED AT IT AND THOUGHT THAT IT WAS THE ANTI-LOCK BRAKE & VSC "ECU", WHICH WAS GOING TO COST $2,400, BUT THERE COULD BE EXTRA SENSORS THAT NEEDED TO BE REPLACED TOO. THIS SEEMED VERY EXCESSIVE SO I DIDN'T HAVE THE WORK DONE. NOW THE CAR IS SITTING. I'VE HEARD THERE IS A SERVICE BULLETIN OUT ON THIS BUT I HAVEN'T BEEN ABLE TO FIND IT. I'VE HEARD THAT IT CAN BE THE STEERING ANGLE SENSOR, OR THE WHEEL ROTATIONS SENSORS, OR THE G-CENTER (ACCELEROMETER). EACH ONE IS SEVERAL HUNDRED DOLLARS APIECE. A FAILURE IN THE SKID CONTROL SYSTEM SHOULD JUST STOP WORKING AND NOT CAUSE THE BRAKES TO BE SLAMMED ON, LEAVING THE CAR UNDRIVABLE. AND THE REPAIR COST SHOULD NOT BE $2,500 TO OVER $4,000. THIS IS RIDICULOUS. *TR

NHTSA ODI #10252755

25,000 miles · Mar 13, 2008

Electronic Stability Control (esc)Vehicle Speed Control

VSC SYSTEM ACTIVATED AND STARTED APPLYING BRAKES WHEN THE AUTO WAS ON DRY ROADS. SYSTEM HAS NO DISCONNECT SWITCH IN ORDER TO DISABLE SYSTEM. DROVE AUTO HOME AT ABOUT 10 MILES AN HOUR BECAUSE SYSTEM WOULD NOT DIS-ENGAGE. THE AUTO ONLY HAS 25,000 MILES. HAPPENED ONCE BEFORE AT 4,000 MILES. *TR

NHTSA ODI #10221087

39,000 miles · Jan 7, 2008

Electronic Stability Control (esc)

Read full complaint

TL*THE CONTACT OWNS A 2004 TOYOTA HIGHLANDER. WHILE DRIVING 40 MPH, THE VEHICLE STABILITY SYSTEM ACTIVATED ON DRY SURFACE AND ATTEMPTED TO STEER THE VEHICLE. THE FAILURE AFFECTS THE STEERING AND OCCURS EVERY FEW FEET. SINCE THAT TIME, THE SYSTEM ATTEMPTS TO ACTIVATE AUTOMATICALLY WHILE DRIVING 15-20 MPH. THE VEHICLE STABILITY SYSTEM ACTIVATES AT FULL SPEED WHEN DRIVING AT HIGHWAY SPEEDS. THE DEALER STATED THAT THE FAILURE WAS IN THE MICROTRIP THAT CONTROLS THE VEHICLE STABILITY SYSTEM. THE DEALER IS CURRENTLY ATTEMPTING TO HAVE IT REPROGRAMMED. THE PURCHASE DATE WAS UNKNOWN. THE CURRENT AND FAILURE MILEAGES WERE 39,000.

NHTSA ODI #10214029

Official recalls

11V539000 · Engine And Engine Cooling

Nov 9, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Consequence & remedy

Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V112000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence & remedy

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder

Oct 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Consequence & remedy

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

06V253000 · Vehicle Speed Control:accelerator Pedal

Jul 13, 2006

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Consequence & remedy

Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

04V181000 · Latches/locks/linkages:doors:latch

Apr 15, 2004

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

Consequence & remedy

Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.

Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal