Power Train. Review the 58 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 35 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

32 crash reports3 fire reports16 injury reports

Electrical System complaints

18 reports

Clear category filter

Mileage unknown · Jun 8, 2009

Electrical SystemPower TrainSteering

Read full complaint

2004 HIGHLANDER, HAVING SAME PROBLEMS AS ALL OTHER REPORTED PROBLEMS FOR THIS VEHICLE. HESITATION, STEERING SHAFT REPLACEMENT, 2 WHEEL BEARING REPLACEMENTS, LOUSY ORIGINAL TIRES, BAD SODERING OF HEAT/AIR BOARD LEADING TO NOT WORKING PROPERLY, CAN NOT HAVE BACK WINDOWS DOWN DUE TO NOISE AND VEHICLE SHAKING, HAD REAR WIPER MOTOR REPLACED WITHIN 1ST MONTH OF OWNERSHIP. WHILE I DID PURCHASE THE EXTENDED WARRANTY, WHICH DID COVER THE COST OF THE WHEEL BEARING REPLACEMENT, IT DID NOT COVER THE COST OF HAVING TO REPLACE THE TIRES DAMAGED BY THE BAD BEARING - AND TOYOTA DOES NOT CARE. IN THEIR RACE TO BECOME THE NUMBER ONE CAR MAKER, THEY HAVE GIVEN UP ON BEING THE SAFEST, MOST RELIABLE CAR MAKER - AND THEY HAVE CERTAINLY GIVEN UP ON BEING CUSTOMER FRIENDLY. ACCORDING TO SEVERAL TOYOTA DEALERS, THEY DON'T HAVE TO, SINCE THEY CONTINUE TO BE POPULAR SELLING VEHICLES. I AM GETTING NERVOUS AS THE TIME FOR MY WARRANTY COMES DUE TO EXPIRE - AND FOR THE FIRST TIME AM SERIOUSLY CONSIDERING TRADING IT IN BEFORE THAT HAPPENS. THAT WAS NOT THE INTENT WHEN I BOUGHT THE VEHICLE, BUT AFTER READING ALL THE PEOPLE HAVING ALL THE SAME PROBLEMS, I AM VERY CONCERNED. *TR

NHTSA ODI #10273069

69,500 miles · Feb 16, 2009

Electrical System

Read full complaint

THE HEAT WOULD NOT ALWAYS WORK. IT WOULD BLOW COLD AIR. SOMETIMES I COULD MOVE THE KNOB AROUND AND IT WOULD COME BACK ON BUT IT DIDN'T ALWAYS WORK LIKE THAT. I GOOGLED THE PROBLEM AND CAME UP WITH MORE THAN A DOZEN PEOPLE WITH THE SAME PROBLEM. THEY DEALER SAID THE PART WAS OVER $600 TO REPLACE, THEN ON TOP OF THAT, THE DECAL WAS GOING TO COST ANOTHER $30. ONE OF THE GOOGLE SEARCHES HAD A FIX FOR IT. IT INVOLVED REMOVING THE GLOVEBOX AND PULLING THE CIRCUIT BOARD OUT. THEY SAID THERE WOULD PROBABLY BE A WIRE THAT WAS BROKEN OFF AND SURE ENOUGH THERE WAS. MY HUSBAND SOLDERED IT BACK ON, PUT THE BOAR BACK IN, AND IT WORKS LIKE A CHARM NOW. *TR

NHTSA ODI #10258737

58,000 miles · Dec 14, 2008

Electrical System

Read full complaint

SINCE I BOUGHT THE CAR IN 2004, I WOULD HAVE TROUBLE WITH THE CLOCK - SOMETIMES IT WOULD SHOW OTHER TIMES NOT. I HAVE A NAVIGATION SYSTEM IN THE CAR AND THE TIME IS TIED INTO IT. THIS YEAR, THE GPS STOPPED WORKING, AND WOULD KNOCK OUT THE RADIO, HEAT AND DEFROSTER. WHEN I BROUGHT IT TO TOYOTA, THEY SAID IS WAS A GPS FAILURE AND SINCE I WAS NOT UNDER WARRANTY ANYMORE, IT WOULD COST ME ABOUT $1600.00 TO REPLACE IT. I WOULD THINK THAT SOMETHING I COMPLAINED ABOUT FROM THE BEGINNING WOULD BE LOOKED NOT AND THAT A RECALL SHOULD HAVE OCCURRED IF THE DEFROSTING SYSTEM DIDN'T WORK. THAT IS A DRIVING DANGER. I HAD TO PAY FOR IT FOR THE WINTER BUT AM NOW LOOKING FOR A NEW CAR AND WILL SURELY NOT BE LOOKING AT A TOYOTA EVER AGAIN. SINCE I GOT THE REFURBISHED GPS, MY TIME IS ALWAYS THERE. *TR

NHTSA ODI #10251753

41,864 miles · Nov 27, 2008

Electrical System

NAVIGATION SYSTEMS SAYS EXTERNAL SYSTEM IS DISCONNECTED CAUSING THE HEAT/ AIR CONDITIONER & DEFROSTER TO BE DISABLED NEW SYSTEM WILL COST 5795.00 USED PART WILL COST 1500-1700.00 CAR ONLY HAS 41,864 2004 TOYOTA HIGHLANDER. *TR

NHTSA ODI #10250015

35,000 miles · Jul 18, 2006

Electrical System

THE AIR/HEAT KEEP GOING IN AN OUT. MOST OF THE TIME WHEN YOU TRY TO SWITCH IT OVER THE AC IT STAYS HOT AND SAME W/ HOT. STOPPED BY TOYOTA DEALER AND THEY SAID THAT ON THIS YEAR MODEL HIGHLANDERS THE CIRCUIT BOARD FOR THE HEAT AND AIR ARE GOING BAD. BUT THEY WON'T DO A RECALL. IT EVEN MESSED 1 OF THE ACCUATORS UP AND WE HAD TO RE…

Read full complaint

NHTSA ODI #10162736

12,000 miles · Jan 25, 2006

Electrical SystemPower Train

Read full complaint

DT*: THE CONTACT STATED WHILE DEPRESSING THE ACCELERATOR PEDAL, THE TRANSMISSION MOMENTARILY HESITATES BEFORE PROPERLY SELECTING THE CORRECT GEAR TO ENGAGE. THE VEHICLE WAS TAKEN TO THE DEALERSHIP SEVERAL TIMES FOR INSPECTION. THE DEALERSHIP MECHANIC RESET THE SOFTWARE THREE TIMES, BUT THIS DID NOT CORRECT THE PROBLEM. DIAGNOSTIC TESTING WERE PERFORMED ON THE VEHICLE. THE MANUFACTURER WAS CONTACTED AND SENT A REPRESENTATIVE TO INSPECT THE VEHICLE. THE REPRESENTATIVE DROVE THE VEHICLE AND EXPERIENCED THE HESITATION AND EXPLAINED, THIS IS A FLAW IN THE DESIGN AND THE VEHICLE IS FREE-WHEELING. THE REPRESENTATIVE WOULD CONTACT THE ENGINEERS AND TRY TO SOLVE THE PROBLEM. UPDATED 03/17/06. *JB

NHTSA ODI #10148539

6,000 miles · Jan 2, 2006

Electrical SystemFuel System, GasolineSteering

Read full complaint

IDENTICAL TO COMPLAINT #10114548 MY EVENT HAPPENED JANUARY 6, 2005 WITH LESS THAN 10,000 MILES ON VEHICLE. NOW, AT 35,750 MILES, I HAVE O2 SENSOR PROBLEMS ON A ROUTINE BASIS(3RD SENSOR ON ORDER FROM DEALER RIGHT NOW). I AM VERY CONCERNED THAT THESE PROBLEMS WILL CONTINUE PAST WARRANTY, I HAVE LITTLE FAITH IN THIS VEHICLES SAFETY AND PERFORMANCE -EVERY DAY I CROSS MY FINGERS THAT NOTHING ELSE GOES "BRAKES" WHILE DRIVING WITH MY 2 SMALL CHILDREN. THIS NEEDS TO BE INVESTIGATED. *NM

NHTSA ODI #10146704

50,556 miles · Dec 16, 2005

Electrical SystemSteering

Read full complaint

I BOUGHT A 2004 TOYOTA HIGHLANDER IN NOVEMBER OF 2003 BECAUSE MY HUSBAND AND I FOUND OUT WE WERE PREGNANT AND NEEDED A BIGGER CAR. THREE MONTHS AND 5000 MILES LATER I HAD TO BE TOWED TO THE DEALERSHIP BECAUSE OF A DEFECT IN A CHIP IN THE "MOTHERBOARD." (SOME SENSOR DEFECT THAT CAUSED THE ASC MECHANISM TO FOUL UP.) ANYWAY, ON MONDAY, THE SAME THING HAPPENED AGAIN AT 50500 MILES, BUT THIS TIME THE CAUSE WAS A STEERING SENSOR ACTUATOR. OF COURSE, THE CAR IS NO LONGER UNDER WARRANTY. I RAISED CANE BECAUSE TWO MAJOR THINGS HAVE CAUSED ME TO BE TOWED TO THE DEALERSHIP WITH BARELY 50000 MILES ON THE CAR. THEY ARE PAYING FOR THE COST OF THE PARTS BUT THAT'S IT. I TRULY BELIEVE TOYOTA SHOULD HAVE PAID FOR THE ENTIRE ORDEAL, INCLUDING TOWING, LABOR AND RENTAL CAR BECAUSE OF MY INCONVENIENCE AND OBVIOUS DEFECT IN THE CAR. TOYOTA IS ONE OF THE HIGHEST QUALITY BRAND NAMES OF CARS AND YOU DON'T EXPECT TO DEAL WITH THESE TYPES OF ISSUES WHEN BUYING ONE. I FEEL THAT THEY REALIZE I HAVE A DEFECTIVE CAR AND HAVE DECIDED NOT TO CARE. NOW I DON'T TRUST THE VEHICLE AND WANT TO TRADE IT IN FOR A NON TOYOTA CAR. THANKS FOR YOUR TIME AND CONSIDERATION. *JB

NHTSA ODI #10145437

Official recalls

11V539000 · Engine And Engine Cooling

Nov 9, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004 AVALON VEHICLES; 2004 AND 2005 CAMRY, CAMRY SOLARA, HIGHLANDER, AND SIENNA VEHICLES, 2006 HIGHLANDER HYBRID; 2004 AND 2005 LEXUS ES330 AND RX330; AND 2006 LEXUS RX400H VEHICLES MANUFACTURED FROM JUNE 1, 2004 THROUGH MARCH 31, 2005, EQUIPPED WITH THE 1MZ-FE OR 3MZ-FE ENGINE. THE AMOUNT OF ADHESIVE AGENT APPLIED BETWEEN THE OUTER RING AND THE TORSIONAL RUBBER DAMPER (INNER RING) IN THE CRANKSHAFT PULLEY MAY BE INADEQUATE. IF THE ADHESIVE IS INSUFFICIENT, THERE IS A POSSIBILITY THAT THE OUTER RING MAY BECOME MISALIGNED AND IT MAY NOT PROPERLY ROTATE WITH THE INNER RING, CAUSING NOISE AND/OR ILLUMINATION OF THE BATTERY DISCHARGE INDICATOR LIGHT.

Consequence & remedy

Consequence: IN SOME CASES, THE BELT FOR THE POWER STEERING PUMP MAY BECOME DETACHED FROM THE PULLEY WHICH COULD RESULT IN A LOSS OF POWER STEERING AND A SUDDEN INCREASE IN STEERING EFFORT, INCREASING THE RISK OF A CRASH.

Remedy: TOYOTA WILL NOTIFY OWNERS, AND DEALERS WILL CHECK THE CRANKSHAFT PULLEY TO IDENTIFY WHETHER IT WAS PRODUCED BY THE U.S. SUPPLIER. IF SO, THE DEALER WILL REPLACE THE PULLEY WITH A NEW ONE AT NO CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING EARLY JANUARY 2012. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

11V112000 · Vehicle Speed Control:accelerator Pedal

Feb 24, 2011

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2006 HIGHLANDER, HIGHLANDER HYBRID, AND MODEL YEAR 2004-2007 LEXUS RX330, RX350, AND RX400H VEHICLES. IF THE FORWARD RETENTION CLIP USED TO SECURE THE FLOOR CARPET COVER, WHICH IS LOCATED IN FRONT OF THE CENTER CONSOLE, IS NOT INSTALLED PROPERLY THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL AND INTERFERE WITH THE ACCELERATOR PEDAL ARM.

Consequence & remedy

Consequence: IF THIS OCCURS, THE ACCELERATOR PEDAL MAY TEMPORARILY BECOME STUCK IN A PARTIALLY DEPRESSED POSITION RATHER THAN RETURN TO THE IDLE POSITION. A STUCK ACCELERATOR PEDAL MAY RESULT IN UNINTENDED AND SUSTAINED VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP, INCREASING THE RISK OF A VEHICLE CRASH.

Remedy: DEALERS WILL REPLACE THE FLOOR CARPET COVER WITH A NEWLY DESIGNED ONE FREE OR CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING MARCH 2011. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V499000 · Service Brakes, Hydraulic:foundation Components:master Cylinder

Oct 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2006 AVALON, MODEL YEAR 2004-2006 HIGHLANDER, MODEL YEAR 2004-2006 LEXUS RX, AND MODEL YEAR 2006 LEXUS GS AND IS VEHICLES. BRAKE FLUID CONTAINING POLYMERS IS USED THAT ACTS AS LUBRICANTS FOR CERTAIN BRAKE SYSTEM COMPONENTS. IF REPLACEMENT BRAKE FLUID IS USED THAT DOES NOT CONTAIN SUCH POLYMERS, OR THAT CONTAINS ONLY SMALL AMOUNTS, A PART OF THE RUBBER SEAL LOCATED AT THE REAR OF THE BRAKE MASTER CYLINDER MAY BECOME DRY, AND THE SEAL MAY CURL DURING MOVEMENT OF THE PISTON. IF THIS OCCURS, A SMALL AMOUNT OF BRAKE FLUID COULD SLOWLY LEAK FROM THE SEAL INTO THE BRAKE BOOSTER.

Consequence & remedy

Consequence: A LEAK OF BRAKE FLUID COULD LEAD TO A CHANGE IN BRAKE PEDAL FEEL AND OVERTIME A DEGRADATION IN BRAKING PERFORMANCE INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE SEAL WITH A NEWLY DESIGNED ONE. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 AND LEXUS AT 1-800-255-3987.

06V253000 · Vehicle Speed Control:accelerator Pedal

Jul 13, 2006

ON CERTAIN SPORT UTILITY AND HYBRID VEHICLES, THE TWO RETAINING CLIPS FOR THE DRIVER'S SIDE FORWARD CENTER CONSOLE CAN BECOME LOOSE. IF BOTH CLIPS SEPARATE FROM THE FLOOR CARPET COVER, THE COVER MAY LEAN TOWARD THE ACCELERATOR PEDAL, CAUSING INTERFERENCE WITH THE ACCELERATOR PEDAL ROD.

Consequence & remedy

Consequence: THIS CONDITION MAY INTERFERE WITH THE ACCELERATOR PEDAL RETURNING TO THE IDLE POSITION INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL REPLACE THE TWO FLOOR CARPET COVER RETAINING CLIPS FREE OF CHARGE. THE RECALL BEGAN ON JULY 24, 2006, AND SHOULD BE COMPLETED BY EARLY SEPTEMBER 2006. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-800-255-3987.

04V181000 · Latches/locks/linkages:doors:latch

Apr 15, 2004

CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.

Consequence & remedy

Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.

Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

RQ10003 · Unintended And Uncontrolled Acceleration

Opened Feb 16, 2010 · Closed Mar 1, 2011

Status: closed (inferred from source dates) · Electrical System:software; Vehicle Speed Control:accelerator Pedal

On February 16, 2010, NHTSA's Office of Defects Investigation (ODI) opened RQ10-003 to determine whether the scope of prior Toyota recalls relating to potential unintended acceleration were sufficiently broad, including, among others, Toyota recalls 07E-082, 09V-388, 10V-017, and 10V-023.NHTSA also requested information regarding potential electronic causes of unintended acceleration in Toyota and Lexus vehicles.I. Pedal Interference from Floor mats, Carpet Covers and Plastic Pads in Carpets.During the RQ10-003 investigation, ODI reviewed a large volume of documents to assess whether additional vehicles should be recalled.Following the agency's analysis, NHTSA requested that Toyota recall additional vehicles.Toyota complied with the agency's request.The details of these recalls are set forth more fully in Toyota's reports to NHTSA pursuant to 49 CFR Part 573.These recalls are as follows:Recall 11V-112: (1) model year (MY) 2004-2006 Toyota Highlander and Highlander Hybrid; and, (2) MY 2004-2007 Lexus RX330,RX350, and RX400h (hybrid model). The total estimated population under this recall is 769,379 vehicles.This recall remedies potential accelerator pedal entrapment caused by a loose floor carpet cover (trim panel). Recall 11V-113: (1) MY 2003-2009 through 2009 Toyota 4Runner; (2) MY 2006-2010 Toyota RAV4; and, (3) MY 2008-2011 Lexus LX570.The total estimated population under this recall is 1,381,000 vehicles.This recall supplements recall 09V-388 and remedies potential accelerator pedal entrapment by an unsecured floor mat.Recall 11V-115: (1) MY 2006-2007 Lexus GS300 (all wheel drive vehicles); and, (2) MY 2006-2007 Lexus GS350 (all wheel drive vehicles). The total estimated population under this recall is 19,647 vehicles.This recall remedies potential accelerator pedal entrapment caused by inadequate clearance between the pedal linkage and a plastic pad embedded in the vehicle's carpet.II. Potential Electronic Causes of Unintended Acceleration.After NHTSA opened RQ10-003, NHTSA launched a ten-month study of potential electronic causes of unintended acceleration in Toyota vehicles.NHTSA launched the study in the spring of 2010 in light of concerns aired in Congressional hearings.NHTSA enlisted engineers at the National Aeronautics and Space Administration (NASA) with expertise in areas such as computer controlled electronic systems, electromagnetic interference and software integrity to assess whether electronic systems or electromagnetic interference played a role in incidents of unintended acceleration in Toyota vehicles.That study has concluded.Two reports are associated with the study and are available on NHTSA's website.NASA's report is entitled Technical Support to the National Highway Traffic Safety Administration (NHTSA) on the Reported Toyota Motor Corporation (TMC) Unintended Acceleration (UA) Investigation, NESC Assessment No. TI-10-00618 (Jan. 18, 2011).NHTSA's report is entitled Technical Assessment of Toyota Electronic Throttle Control (ETC) Systems (Feb. 2011).Both reports should be read in conjunction with each other. As stated in its report, NASA did not find an electronic cause of large throttle openings that can result in unintended acceleration incidents. NHTSA did not find a vehicle-based cause of unintended acceleration incidents other than the physical pedal interference causes that are being addressed by Toyota's recalls. This RQ is closed.

Additional source detail variants (6)

Electrical System:software

Vehicle Speed Control:accelerator Pedal