2002 Toyota Highlander

THIS IS THE FOURTH SUN VISOR ON THE DRIVERS SIDE OF THIS CAR WHICH WILL NO LONGER STAY UP BLOCKING MY VISION WHILE DRIVING. THE FIRST WAS REPLACED 09/03 AT ABOUT 22,600 MILES UNDER WARRANTY WITH A HOME LINK INCLUDED AS WAS THE ORIGINAL. THE SECOND REPLACEMENT WAS 01/07 AT 65,300 MILES AND THE PASSENGER ONE WAS REPLACED AT THE SAME TIME. THESE DID NOT HAVE THE HOME LINK FEATURE AS IT WAS TOO EXPENSIVE. THE PROBLEM RECURRED IN 3/10 AT 86,000 MILES AND WAS ONCE AGAIN REPLACED. IT IS NOW 3/16 WITH 115,000 MILES AND THE SAME PROBLEM AS BEFORE EXISTS. IT FALLS RIGHT AT EYE LEVEL WHICH IMPAIRS VISIBILITY. WITH THE NUMBER OF COMPLAINTS TOYOTA HAS RECEIVED ON THIS AND OTHER MODELS, A MANDATORY REPLACEMENT IS WARRANTED.

AIR BAG WARNING LIGHT ON DASHBOARD DOES NOT TURN OFF IN COLD WEATHER (20 DEGREES F, OR LOWER). THE WARNING WILL STAY ON EVEN WHEN ENGINE AND INTERIOR ARE WARM. IF THE ENGINE IS TURNED OFF ONCE WARM, AND THEN TURNED BACK ON, AIR BAG WARNING LIGHT TURNS OFF WITH ALL OTHER PANEL LIGHTS, AS IT SHOULD. WITH COLD WEATHER, THE AIRBAG LIGHT WILL STAY ON WHEN VEHICLE IS STATIONARY, OR IN MOTION, AND AT ANY SPEED AND WILL ONLY SHUT OFF IF CAR IS TURNED OFF AND THEN RESTARTED.

I DROVE VEHICLE CROWN TOYOTA FOR A MINOR SERVICE AND MENTIONED THAT THERE WAS DRIPPING OF COOLANT NOTICED ON THE GARAGE FLOOR. REQUESTED 'CHECK AND ADVISE' ON THIS. AFTER APPROXIMATELY 3.0 HOURS, I WENT TO THE SERVICE DESK FOR INFORMATION REGARDING LEAK. I WAS TAKEN TO THE SERVICE ADVISOR [XXX] AND HE TOLD ME THAT THEY COULD NOT REPAIR THE LEAK BECAUSE THAT SITUATION IS DUE TO THE HEAD BOLTS PULLING OUT OF THE BLOCK. THE ESTIMATE FOR SUCH REPAIR WAS $6,780.28 PLUS TAX AND WOULD INVOLVE REPLACING THE SHORT BLOCK. HE MENTIONED THIS PROBLEM WAS KNOWN TO OCCUR WITH VEHICLES HAVING THE 2AZ-FE ENGINES SUCH AS THE ABOVE HIGHLANDER AND THAT I COULD RESEARCH SAME. SINCE I WAS BUYING ONLY TOYOTA CARS SINCE 1972 AND HAVE OWNED 4 SUCH CARS AND ONE LEXUS BASED ON MY EXPERIENCE AND CONCLUSION THAT RELIABILITY IS NUMBER ONE WITH TOYOTA. I CAN ONLY SAY I WAS IN SHOCK. WHEN I TOLD MY WIFE (THIS IS ACTUALLY HER AUTO), SHE WAS SICK FOR THE NEXT THREE DAYS. A SHORT DISCUSSION WITH AAA. SUGGESTED WE LOOK AT THIS WEB SITE FOR COMPLAINTS, ETC. IT TURNS OUT THAT THIS PROBLEM HAS OCCURRED MANY TIMES BEFORE AND APPLIES TO SEVERAL MODELS INCLUDING THE RAV-4 AND HIGHLANDER SOME WITH MUCH LOWER MILEAGE BUT THERE IS NO ACTUAL RECALL OR LETTER NOTICE FROM TOYOTA. ALSO, NO PROPOSED ACTION BY DEALERSHIPS TO RESOLVE THE PROBLEM. I THINK THAT DUMPING THIS SUDDEN, MAJOR EXPENSE PROBLEM ON OWNERS IS VERY IRRESPONSIBLE- NOT WORTHY OF TOYOTA. COMPENSATION REGARDING THE TIME LOSS AND EXPENSE SHOULD BE OFFERED TO OWNERS OR DEALERS SHOULD BE INSTRUCTED BY TOYOTA TO RESOLVE WHEN FOUND. PLEASE NOTE THAT THIS VEHICLE AND ALL THE PREVIOUS WAS SERVICED BY TOYOTA /LEXUS DEALERSHIPS. A POSITIVE RESPONSE WOULD BE APPRECIATED. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

TL* THE CONTACT OWNED A 2002 TOYOTA HIGHLANDER. WHILE DRIVING APPROXIMATELY 50 MPH, THE CONTACT CRASHED INTO ANOTHER VEHICLE AND THE AIR BAGS FAILED TO DEPLOY. A POLICE REPORT WAS FILED. THE CONTACT SUSTAINED NECK, LOWER BACK, AND CHEST INJURIES THAT REQUIRED MEDICAL ATTENTION. THE VEHICLE WAS DESTROYED. THE VEHICLE WAS NOT TAKEN TO A MECHANIC FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 200,000.

THE DRIVERS SIDE SUN VISOR NO LONGER STAYS FULLY UP. IT STAYS 1/2 DOWN WHICH BLOCKS VISIBILITY. IT SUDDENLY FALLS DOWN FURTHER, BLOCKING MY VIEW EVEN MORE, ESPECIALLY WHEN I BRAKE (EVEN LIGHT BRAKING), CHANGE LANES OR CHANGE VEHICLE SPEEDS. AFTER SEVERAL TIMES OF GETTING SCARED WHEN THE VISOR SUDDENLY FLIPS DOWN, I NOW HAVE TO USE BUNGEE CORDS OR RUBBER BANDS TO HOLD THE VISOR UP SO THAT I CAN SEE. UNFORTUNATELY, THAT MEANS THAT I CANNOT EASILY FLIP IT DOWN TO BLOCK THE SUN, WHICH IS ITS PURPOSE, AND I LIVE IN "SUNNY CALIFORNIA!" I HAVE SEEN DOZENS OF OTHER PEOPLE COMPLAIN ONLINE FALLS ABOUT THIS SAFETY ISSUE OVER THE PAST FEW YEARS. MY RESEARCH A FEW YEARS AGO SHOWED THAT THE REPLACEMENT FOR THE VISOR WAS RIDICULOUSLY OVER $800 (I THINK BECAUSE IT HAS A LIGHTED MIRROR). MY ASSUMPTION IS THAT IT ONLY NEEDS A SPRING REPLACED AND TOYOTA SHOULD DO THIS TO PROTECT ITS CUSTOMERS. *TR