WHEN ONE PERSON EXITS THE VEHICLE AND LOCKS THEIR DOOR THE SECOND PERSON IS STUCK. ALL ELECTRIC LOCKS ARE INSTANTLY DISABLED. THE ONLY WAY TO EXIT IS TO USE THE MANUAL LOCK BUTTON WHICH WILL SET OFF THE ALARM 30 SECONDS AFTER. THE PASSENGER INSIDE HAS TO MANUALLY UNLOCK THE DOOR, AND SET OFF THE ALARM. THE ONLY WAY TO PREVE…
Read full complaint
WHEN ONE PERSON EXITS THE VEHICLE AND LOCKS THEIR DOOR THE SECOND PERSON IS STUCK. ALL ELECTRIC LOCKS ARE INSTANTLY DISABLED. THE ONLY WAY TO EXIT IS TO USE THE MANUAL LOCK BUTTON WHICH WILL SET OFF THE ALARM 30 SECONDS AFTER. THE PASSENGER INSIDE HAS TO MANUALLY UNLOCK THE DOOR, AND SET OFF THE ALARM. THE ONLY WAY TO PREVENT, IS TO TURN THE IGNITION ON BEFORE EXITING, BUT ISN'T POSSIBLE FOR MOST PASSENGERS. TS SCC
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.
Consequence & remedy
Consequence: IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
Remedy: DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Toyota Highlander Problems, Complaints & Recalls | Skip That Year
Illustration