THE CENTER CUPHOLDERS ARE POORLY DESIGNED AND ARE A SAFETY HAZARD. WHEN YOU ARE REMOVING A DRINK FROM THE CUPHOLDER, IT HITS THE GEARSHIFT LEVER KNOCKING THE DRINK OUT OF YOUR HAND AND CAUSING IT AND ITS CONTENTS TO GO ALL OVER THE PLACE. ON OCCASION, IT KNOCKS THE GEARSHIFT LEVER OUT OF GEAR CAUSING A RAPID DEACCELERATION OF TH…
Read full complaint
THE CENTER CUPHOLDERS ARE POORLY DESIGNED AND ARE A SAFETY HAZARD. WHEN YOU ARE REMOVING A DRINK FROM THE CUPHOLDER, IT HITS THE GEARSHIFT LEVER KNOCKING THE DRINK OUT OF YOUR HAND AND CAUSING IT AND ITS CONTENTS TO GO ALL OVER THE PLACE. ON OCCASION, IT KNOCKS THE GEARSHIFT LEVER OUT OF GEAR CAUSING A RAPID DEACCELERATION OF THE VEHICLE.E
NHTSA ODI #759288
Mileage unknown · Oct 23, 2001
Structure
AIR NOISE (COKE BOTTLE EFFECT) AT HIGH SPEED AND CROSS WIND. SEVERAL COMPLAINTS TO TOYOTA IGNORED. TOYOTA CONSIDERS THIS DEFECT ACCEPTABLE. *AK
NHTSA ODI #753582
Mileage unknown · Jun 29, 2001
Structure
WHEN OPENING THE BACK WINDOW THE ENTIRE VEHICLE BEGAN TO VIBRATE WILDLY AND THERE WAS TERRIBLE PRESSURE IN THE DRIVERS EARS ALONG WITH A LOUD NOISE, THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND AFTER SOME TRIAL AND ERROR THE DRIVER DISCOVERED THAT THE PROBLEM COULD BE ALLEVIATED BY OPENING THE FRONT WINDOWS FIRST, …
Read full complaint
WHEN OPENING THE BACK WINDOW THE ENTIRE VEHICLE BEGAN TO VIBRATE WILDLY AND THERE WAS TERRIBLE PRESSURE IN THE DRIVERS EARS ALONG WITH A LOUD NOISE, THE DRIVER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE AND AFTER SOME TRIAL AND ERROR THE DRIVER DISCOVERED THAT THE PROBLEM COULD BE ALLEVIATED BY OPENING THE FRONT WINDOWS FIRST, THE DEALER WAS NOTIFIED AND TOLD THE CONSUMER THAT ALL HIGHLANDERS EXPERIENCE THIS PROBLEM DUE TO THE AERODYNAMICS. NLM *SLC
CERTAIN SPORT UTILITY VEHICLES HAVE A CHILD PROTECTION LOCK (CPL) SYSTEM ON BOTH OF THE REAR SIDE DOORS. WHEN AN OPERATOR OF THE VEHICLE CLOSES THE DOOR VERY HARD WITH THE CPL LEVER SET TO THE LOCK POSITION, THERE IS A POSSIBILITY THAT THE LEVER MAY CONTACT THE BODY PANEL, CAUSING THE CPL LEVER TO MOVE INTO THE UNLOCK POSITION.
Consequence & remedy
Consequence: THIS CONDITION COULD ALLOW THE DOOR TO BE OPENED WITH THE INSIDE WHILE THE OPERATOR BELIEVES THAT THE CPL WAS ACTIVATED. IF THE DOOR WERE OPENED FROM THE INSIDE WHILE THE VEHICLE WAS IN MOTION, AN OCCUPANT COULD FALL OUT AND BE INJURED.
Remedy: DEALERS WILL SHORTEN THE CPL LEVER. OWNER NOTIFICATION BEGAN MAY 7, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
ON SPORT UTILITY VEHICLES, THERE IS A BREATHER HOSE THAT ATTACHES TO THE NOZZLE OF THE ON-BOARD REFUELING VAPOR RECOVERY (ORVR) VALVE, WHICH IS LOCATED ON THE TOPSIDE OF THE FUEL TANK. THE BREATHER HOSE IS ATTACHED WITH A CLAMP, WHOSE "TABS" FACE IN THE UPWARD DIRECTION. WHEN THE VEHICLE WAS CRASHED UNDER THE NEW CAR ASSESSMENT PROGRAM (NCAP) TEST (I.E., 35 MPH FRONTAL BARRIER CRASH), THE CLAMP "TABS" CONTACTED THE UNDERSIDE OF THE BODY DUE TO MOVEMENT OF THE FUEL TANK, CAUSING THE NOZZLE TO BREAK.
Consequence & remedy
Consequence: IN THE WORST CASE, NOZZLE BREAKAGE COULD RESULT IN FUEL LEAKAGE IF THE VEHICLE ROLLS-OVER AFTER A HIGH SPEED FRONTAL CRASH.
Remedy: DEALERS WILL ROTATE THE SPECIFIED CLAMP. OWNER NOTIFICATION BEGAN SEPTEMBER 23, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
VEHICLE DESCRIPTION: SPORT UTIITY VEHICLES. THE RESERVOIR FILLER CAP OF THE BRAKE MASTER CYLINDER MAY INDUCE A VACUUM, INTRODUCING SOME AIR INTO THE BRAKE MASTER CYLINDER RESERVOIR. THIS COULD CAUSE ABNORMAL BRAKE NOISE AND INCREASED PEDAL STROKE WHEN THE BRAKES ARE APPLIED.
Consequence & remedy
Consequence: THE INCREASED PEDAL STROKE WILL LENGTHEN THE STOPPING DISTANCE OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL BLEED THE AIR FROM THE BRAKE LINES AND REPLACE THE RESERVOIR FILLER CAP. OWNER NOTIFICATION BEGAN JULY 30, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2001 Toyota Highlander Problems, Complaints & Recalls | Skip That Year
Illustration