2024 Toyota Corolla

Car has broke down a total of 4 times since I have gotten it from Toyota back in December of 2023. I have a dash-cam now that has footage of the car breaking down. Toyota fails to acknowledge my concerns and comes up with excuses and tells me to wait until it happens more frequently. I would love to have this car inspected, but as Toyota has stated they cannot get the issue to repeat. My safety for others and myself feel uneasy with the whole ordeal as it happens at the most random times. The first few times my car has broke down, the steering wheel locked up and forced itself all the way to the left on its own causing me to hit a curb and median. Manual control over the steering wheel was not possible. Luckily with this occurring both times I was going a slow speed. The other two times I had full control of the wheel but my engine would stop and the engine stopped message would appear on my dash screen. Vehicle has been inspected by the dealership 4 times with no luck on repeating the issue. Breaking down presented a dash message of engine stopped, abs system stopped, power steering stopped and would quickly cycle through warnings and shutdown.

Upon startup in cold weather conditions, a brief but loud grinding/rattling sound will occur. The noise is related to an inadequate spring inside of the intake camshaft gear which will not push a small cylinder in place to lock the intake camshaft gear in place. When not in its proper place, the gear will rattle in its housing, causing the brief noise. If the gear rattles against its housing too hard overtime, it can break and cause catastrophic engine failure by sending metal pieces into the engine, including pistons and rods.

My son reported driving home from school. He was stopped an intersection ready to make a turn. When he stepped on the gas pedal to go, the engine stopped and a message "Engine Stopped, Steering Power Low" message appeared in the dashboard. Engine light and steering light also came "on" the dash. This may occur while driving and put the driver at risk. His 2024 Toyota Corolla was brought in to the Wesley Chapel Toyota Dealership yesterday 10/29/2024. The technician did not find any error codes and found the battery and alternator to be in good working condition. Issue unresolved by the dealership.

Morning of 08/11/2024, started car and put in Sport mode. Drove under 20 mph for 3 blocks to leave neighborhood. Got to main street intersection and waited for an opening, then pressed the gas and nothing happened except the check engine light came on and dash message of Ignition On, but car was not operating. Pushed ignition button and it came on and dash cleared. Has not happened again and dealership could not replicate and no codes saved.

My vehicle stalled when pulling out into traffic. I lost power steering and electrical and the engine died. The vehicle had to be restarted to continue driving. I was going about 1 to 2 mph when the issue happened. The vehicle was in motion and stalled while other vehicles were in motion putting my safety at risk, had I been going any faster or if there was an increased amount of traffic. I reported the problem to the dealer service center, but they were unable to reproduce it. The vehicle was inspected by Toyota only, no police or insurance. When the issue happened, a warning light appeared on the dash similar to a circle with an exclamation mark inside. There were no messages and no other symptoms prior to the failure.

The contact owns a 2024 Toyota Corolla. The contact stated that while driving at undisclosed speeds and decelerating, the vehicle was jerking abnormally. There were no warning lights illuminated. The vehicle was taken to the dealer however, the dealer was unable to determine the cause of the failure. The vehicle had not been repaired. The manufacturer was made of the failure and a case was filed; however, the contact had not received any communication from the manufacturer. The failure mileage was 27,000.