Air Bags. Review the 552 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 382 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Vehicle Speed Control. Review the 197 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

186 crash reports12 fire reports87 injury reports

What owners actually said

1,459 reports

65,349 miles · Apr 9, 2015

Vehicle Speed Control

I WAS DRIVING ABOUT 5 MPH ON A PARKING LOT WITH A SLIGHT INCLINE WHEN THE CAR SUDDENLY SURGED. I WAS ABLE TO APPLY THE BRAKES, BUT THE VEHICLE TRAVELED FORWARD ABOUT 6 TO 10 FEET. *TR

NHTSA ODI #10704655

60,000 miles · Mar 31, 2015

Fuel/propulsion System

Read full complaint

AFTER FILLING THE GAS TANK AND DRIVING UP A HILL THE CHECK ENGINE LIGHT (CEL) CAME ON AND THE ENGINE RAN ROUGH. I NURSED THE CAR UP THE HILL AND DROVE HOME. I FOUND THE GAS CAP WAS NOT TIGHT EVEN THOUGH IT HAD BEEN CLICKED ONE TIME WHEN THE TANK WAS FILLED JUST A FEW MINUTES EARLIER. A SEARCH FOR THIS ON THE INTERNET REVEALED THAT OTHERS HAVE HAD THIS SAME PROBLEM. I TIGHTENED IT TO ONE CLICK, OF COURSE. A FEW DAYS LATER I BOUGHT A TOYOTA GAS CAP AT A LOCAL TOYOTA DEALERSHIP. THIS SEQUENCE REPEATED MULTIPLE TIMES; CEL TURNED ON, ENGINE RUNS ROUGH, LOSE OF ENGINE POWER. IN ONE INSTANCE I WAS PASSING A CAR ON A FOUR LANE HIGHWAY WHEN THE ENGINE HESITATED AND THE CEL TURNED ON. IN ANOTHER INSTANCE I WAS TURNING LEFT TO GO SLOWLY UP A STEEP HILL WHEN IT HAPPENED AGAIN. IN EVERY INSTANCE THE GAS CAP WAS LOOSE. IT HAPPENED ONCE WHEN I STARTED THE ENGINE IN A PARKING LOT. I'VE COME TO THE POINT OF CHECKING THE GAS CAP TO BE SURE IT WAS TIGHT EVERY TIME BEFORE I START THE ENGINE. IN EARLY 2015 I BOUGHT ANOTHER NEW TOYOTA GAS CAP AT A TOYOTA DEALER. IT'S NOW MARCH 31. THIS SAME SEQUENCE OF EVENTS... CEL COMES ON, ENGINE RUNS ROUGH, LOSE OF POWER FOR ABOUT 15 SECONDS... HAS HAPPENED ABOUT 12 TIMES WITH THIS NEWEST GAS CAP IN LESS THAN THREE MONTHS. I ALWAYS TIGHTEN THE GAS CAP TO THE FIRST CLICK AS IT SHOULD BE. THIS CAN BE DANGEROUS IF IT HAPPENS WHEN WE NEED MAXIMUM ENGINE POWER, AS IN PASSING. A SEARCH ON THE INTERNET SHOWS THAT OTHERS HAVE HAD THIS SAME PROBLEM. COMMENTS ON BUYING NEW TOYOTA GAS CAPS AT AMAZON SHOW THAT STILL OTHERS ARE STRUGGLING WITH THIS. I CAN UNDERSTAND FAIR WEAR AND TEAR ON THE "O" RING IN THE CAP. BUT WHEN TWO NEW CAPS COME LOOSE AFTER BEING CLICKED AS INSTRUCTED THEN SOMETHING IS NOT RIGHT. MECHANICS AT THE DEALERSHIP DON'T HAVE A GOOD ANSWER FOR THIS. *TR

NHTSA ODI #10702958

89,000 miles · Mar 19, 2015

Electrical System

Read full complaint

AT 89,000 MILES, THE BATTERY LIGHT CAME ON EARLY IN THE DAY BUT I CONTINUED TO DRIVE IT AFTER STOPPING AT TOYOTA WHO CONFIRMED IT WAS A "BATTERY LIGHT." LATER IN THE DAY, WHILE TRAVELING CLOSE TO HOME AT ABOUT 25MPH, ALL THE LIGHTS CAME ON IN THE DASHBOARD AND THE CAR STARTED TO SEIZE UP: STEERING WHEEL BECAME DIFFICULT TO MANEUVER AND I COULD BARELY GET THE CAR OVER TO THE CURB (IT HAPPENED WITHIN MINUTES). THE CAR COMPLETELY SHUT DOWN. IT TURNED OUT TO BE AN ALTERNATOR GONE BAD. FRIGHTENING EXPERIENCE BUT I AM GLAD IT HAPPENED AT 25 MPH AND NOT ON THE FREEWAY EARLIER IN THE DAY, OR IT COULD HAVE CAUSED AN ACCIDENT. IN THE FUTURE, I WILL GET ALL WARNING LIGHTS CHECKED OUT PROMPTLY AND NOT ASSUME THAT A BATTERY SYMBOL MEANS ONLY THE BATTERY IS DYING. PERHAPS TOYOTA NEEDS AN "ALTERNATOR LIGHT" AS WELL, AS THIS IS A SERIOUS SITUATION. *TR

NHTSA ODI #10695396

49,729 miles · Mar 11, 2015

Engine

Read full complaint

IN 2013, WE DISCOVERED THAT MY 2009 TOYOTA COROLLA S WAS USING EXCESSIVE OIL. WE REPORTED THIS TO OUR LOCAL DEALERSHIP SERVICE DEPARTMENT AND THEY ADDED A NOTE TO MY SERVICE RECORD, BUT NOTHING WAS DONE ABOUT IT. SINCE WE ALWAYS HAVE OUR SERVICE DONE THERE, AND I HAVE THE OIL CHANGED LONG BEFORE IT'S DUE, WE DON'T NORMALLY CHECK THE OIL OURSELVES. HOWEVER, WHILE WASHING THE CAR ON SUNDAY, 03/08/2015, MY HUSBAND CHECKED IT AND HAD TO PUT IN 1-1/2 QUARTS OF OIL. ON MONDAY, 03/09/2015, I TOOK THE CAR IN FOR AN OIL CHANGE AND APPRISED THE SERVICE DEPARTMENT AGAIN OF THE EXCESSIVE OIL USE. THEY AGAIN MADE A NOTE TO MY SERVICE RECORD. THE SERVICE TECH TOLD ME SHE HAD A LOT OF CARS IN WITH THE SAME PROBLEM AND THAT TOYOTA DID NOT HAVE A FIX FOR IT. SHE SAID MINE WAS NOT ONE LISTED AS HAVING THIS PROBLEM, BUT IT IS. SHE ALSO STATED THAT THEY HAD TO PUT IN 1-1/2 QUARTS OF OIL. I WAS ADVISED TO BRING IT BACK IN FOR A CHECK AT THE NEXT 1,100 MILES. THE WORST PART IS THAT MY CAR WAS STILL UNDER WARRANTY WHEN FIRST REPORTED. WARRANTY HAS NOW EXPIRED SO IF MY ENGINE BLOWS I COULD BE LOOKING AT THOUSANDS OF DOLLARS TO HAVE MY ENGINE REPLACED!!!!! SHAME ON YOU, TOYOTA!!! I THOUGHT I HAD PURCHASED A TRUSTWORTHY VEHICLE FROM A TRUSTWORTHY MANUFACTURER! *TR

NHTSA ODI #10693651

105,000 miles · Mar 2, 2015

Engine

Read full complaint

WHILE DRIVING ON INTERSTATE 395 IN CONNECTICUT THE ENGINE DIED. I WAS ABLE TO COAST OVER TO THE SIDE OF THE ROAD AND AFTER MULTIPLE TRIES THE CAR STATED. I DROVE A LITTLE FURTHER AND THE ENGINE DIED ONCE AGAIN WHILE I WAS DRIVING. I WAS ABLE TO START THE CAR AND GET IT TO MY MECHANIC. THE ENGINE ERROR CODE STATED THAT 2 OF THE 4 STARTER COILS FAILED. THE MECHANIC REPLACED THE 2 STARTER COILS AND THE CAR DROVE FINE. AFTER THE CAR SPENT THE NIGHT IN MY GARAGE IT WOULD NOT START AGAIN. I HAD THE CAR TOWED TO MECHANIC AND HE REPLACED THE CRANK SHAFT SENSOR. THE CAR AGAIN RAN FINE FOR 1 DAY THAN AFTER THE OVERNIGHT IN THE GARAGE THE CAR WOULD NOT START. AT THE RECOMMENDATION OF MY MECHANIC I HAD THE CAR TOWED TO VALENTI TOYOTA IN WESTERLY. RI WHERE I PURCHASED THE CAR. THEY KEPT THE CAR FOR A WEEK FIRST STATING THAT THE COMPUTER WAS BAD AND NEEDED TO BE REPLACED. I POINTED OUT THAT TOYOTA HAD A RECALL OF COMPUTERS IN 2008 COROLLA AND SINCE MY CAR WAS BUILT IN 2008 DID THEY USE THE SAME FAULTY COMPUTERS? THEY STATED NO AND WOULD ORDER A NEW COMPUTER AND HAVE IT THE NEXT DAY. I RECEIVED A CALL FROM THE DEALERSHIP STATING THAT TOYOTA WOULD NOT RELEASE THE PART TO THEM AND THEY WOULD BE DEALING WITH THE REGIONAL PARTS ENGINEER. AFTER 4 DAYS AND STILL NO COMPUTER VALENTI TOYOTA CALLED ME BACK AND STATED THAT ALL 4 STARTER COILS NEEDED REPLACING AND THAT THE CAR IS RUNNING NOW. THE CHARGE FOR THE REPAIR WAS $768.52 (CUSTOMER #20437 AND INVOICE #TOCS275417) THIS DOES NOT MAKE A LOT OF SENSE TO ME AS I HAVE NEVER HEARD OF A COMPANY NOT RELEASING PARTS TO ITS OWN DEALERSHIP. MY QUESTION IS DID MY CAR HAVE A FAULTY COMPUTER AND IS THIS A COVER-UP? WHY WOULD THE CAR ENGINE JUST STOP WHEN DRIVING AT A SPEED OF 60 MPH? LUCKILY I HAD NO ONE BEHIND ME AND WAS ABLE TO COAST TO SAFETY. *TR

NHTSA ODI #10691550

Mileage unknown · Feb 5, 2015

Steering

WELL I RECEIVED A RECALL LETTER IN MAY 2014 STATING MY COROLLA WAS RECALLED FOR A SPIRAL CABLE ASSEMBLY AND TO THIS DAY I STILL HAVE NOT HEARD FROM TOYOTA REGARDING THIS RECALL AND IT WILL BE A YEAR AND IM NOT GETTING ANYWHERE WITH THEN. PLEASE LOOK INTO THIS MATTER. THANK YOU *TR

NHTSA ODI #10681629

19,000 miles · Feb 5, 2015

Engine

Read full complaint

I PURCHASED THE CAR USED 12/3/11 WITH 12,716 MILES. WITHIN 6 MONTHS I WOULD HEAR A GRINDING/SCREECHING NOISE WHEN STARTING THE CAR. THIS WOULD HAPPEN INTERMITTENTLY ON COLD STARTS. I HAD TO LEAVE THE VEHICLE WITH THE DEALERSHIP FOR OVER A WEEK FOR THEM TO FINALLY ACKNOWLEDGE THE ISSUE. ON 7/13/12 THEY REPLACED THE TIMING GEAR ASSEMBLY AND THE CAMSHAFT GEAR. TO DATE, THE CAR HAS ONLY 52,700 MILES AND THE NOISE APPEARS TO HAVE COME BACK. I HAVE CHECKED THE BATTERY, ALTERNATOR AND STARTER AND THEY ARE FINE. I HAD ORIGINALLY PURCHASED AN EXTENDED WARRANTY WITH 6 YEAR/100,000 MILES AND WAS TOLD THAT JANUARY 1, 2015 THAT EXPIRED. SO, I HAVE A DEFECTIVE CAR WITH CAMSHAFT ISSUE THAT RETURNS? I AM FRUSTRATED BECAUSE THERE ARE MANY STORIES OF PEOPLE HAVING THIS RE-OCCURRING ISSUE EVERY 30,000 MILES (HTTP://WWW.CARCOMPLAINTS.COM/TOYOTA/COROLLA/2009/ENGINE/ENGINE.SHTML). I KNOW THERE IS A TOYOTA SERVICE BULLETIN ON THE CAMSHAFT, BUT FEEL IT SHOULD HAVE BEEN A RECALL. NEITHER THE CUSTOMER SERVICE OR WARRANTY CARRIER ARE WILLING TO WORK WITH ME AND THIS IS DANGEROUS BECAUSE ONE CAN BECOME STRANDED OR BLOW A ROD DRIVING DOWN THE STREET. *TR

NHTSA ODI #10681581

148,000 miles · Feb 3, 2015

Electronic Stability Control (esc)SuspensionVehicle Speed Control

THE VSC LIGHT, CHECK ENGINE LIGHT, TRACTION CONTROL LIGHT ALL ARE ON. CANNOT GET TO TURN OFF. *TR

NHTSA ODI #10680773

81,000 miles · Jan 31, 2015

Service Brakes

ABS AND BRAKE LIGHTS CAME ON. THE MECHANIC TELLS ME THAT BOTH REAR ABS SENSORS ARE BAD (CODES C0210 AND C0215). THIS IS A TOYOTA COROLLA 2009 LE WITH ONLY 81K MILES AND I HEAR THE SAME PROBLEM EXISTS IN SOME FRIEND'S CARS. WE HAVE LOTS OF SNOW IN CLEVELAND AREA AND IT IS RIDICULOUS NOT TO HAVE ABS WORKING BECAUSE OF THIS PROBLEM…

Read full complaint

NHTSA ODI #10680171

87,000 miles · Jan 21, 2015

Steering

Read full complaint

THERE IS A LOUD CLUNKING NOISE COMING FROM THE STEERING COLUMN. THE ROAD SURFACES CAUSES THE STEERING WHEEL TO JERK AND CREATES A RATTLING CLUNK NOISE AND LOW SPEEDS. IF THE STEERING WHEEL SHOOK SIDE TO SIDE, THE APPARENT NOISE IS CLICKING. I SUSPECT THIS IS A FAULTY STEERING INTERMEDIATE SHAFT. AT HIGHWAY SPEEDS, THE CAR TENDS TO DRIFT OUT OF THE LANE. UNEVEN ROAD SURFACES CAUSES THE WHEEL TO JERK AT CITY AND HIGHWAY SPEEDS. WHEEL BALANCING AND VEHICLE ALIGNMENT WERE PERFORMED. THE ISSUE HAS NOT BEEN FIXED. REPLACING THE INTERMEDIATE SHAFT SHOULD BE A RECALL AS WELL AS THE REPLACEMENT/REPROGRAM OF THE EPS MODULE. *TR

NHTSA ODI #10677027

Official recalls

19V741000 · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

Oct 17, 2019

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Additional source detail variants (2)

Air Bags:frontal:passenger Side:inflator Module

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.

Air Bags:frontal:driver Side:inflator Module

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

18V024000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2018

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013 Scion xB, Toyota Corolla, Corolla Matrix, Sienna, 4Runner, Lexus IS250, IS350, IS250C, IS350C, IS-F, and GX460 vehicles sold, ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP (Saipan), and the U.S. VI or "Zone A." Toyota is also recalling certain 2010 Scion xB, Toyota Corolla, Corolla Matrix, Yaris, 4Runner, Lexus IS250, IS350, IS250C, IS350C, ES350, IS-F, GX460, and Pontiac Vibe vehicles sold, ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Toyota is also recalling certain 2009 Scion xB, Toyota Corolla, Corolla Matrix, Yaris, Lexus IS250, IS350, ES350, IS-F, and Pontiac Vibe vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began on January 29, 2018. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.

17V006000 · Air Bags:frontal:passenger Side:inflator Module

Jan 9, 2017

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2012 Toyota 4Runner, Corolla, Corolla Matrix, Sienna, Yaris, Scion xB, Lexus ES350, GX460, IS-F, IS250, IS350, IS250C, IS350C, and Lexus LFA vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain 2009 Toyota Corolla, Corolla Matrix, Yaris, Yaris HB, Scion xB, Pontiac Vibe, Lexus, ES350, IS250, IS350, and IS-F vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Toyota is recalling certain 2006-2008 Lexus IS250 and IS350, 2007-2008 Lexus ES350, Toyota Yaris, Yaris HB, and 2008 Lexus IS-F and Scion xB vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on February 1, 2017. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), H0A (Toyota Zone C), GLG (Lexus Zone A), GLH (Lexus Zone B) and HLA (Lexus Zone C).

16V396000 · Seats:front Assembly:seat Heater/cooler

Jun 2, 2016

Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.

Consequence & remedy

Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.

Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.

16V340000 · Air Bags:frontal:passenger Side:inflator Module

May 23, 2016

Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.

Consequence & remedy

Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.

Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).

15V689000 · Visibility:power Window Devices And Controls

Oct 22, 2015

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Consequence & remedy

Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

14V168000 · Air Bags:frontal:driver Side:inflator Module

Apr 9, 2014

Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.

Consequence & remedy

Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.

Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.

12V491000 · Visibility:power Window Devices And Controls

Oct 10, 2012

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Consequence & remedy

Consequence: If the switch overheats, it may melt, possibly resulting in a fire.

Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

10V035000 · Equipment:other:labels

Feb 3, 2010

GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.

10V036000 · Equipment:other:labels

Feb 3, 2010

SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.

Consequence & remedy

Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.

Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.

10V023000 · Vehicle Speed Control:accelerator Pedal

Jan 27, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

10V017000 · Vehicle Speed Control:accelerator Pedal

Jan 21, 2010

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.

Consequence & remedy

Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.

Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

09V338000 · Service Brakes, Hydraulic:power Assist:vacuum

Aug 27, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2009 SCION XD AND MY 2009-2010 COROLLA, AND COROLLA MATRIX VEHICLES EQUIPPED WITH 1.8L ENGINE AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, IOWA, KANSAS, MAINE, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WHEN DRIVING UNDER CERTAIN UNIQUE CONDITIONS IN EXTREMELY LOW AMBIENT TEMPERATURES, THE INTAKE MANIFOLD SUCTION PORT FOR THE BRAKE VACUUM CAN BECOME BLOCKED DUE TO THE FREEZING OF CONDENSATION RESULTING FROM POSITIVE CRANKCASE VENTILATION.

Consequence & remedy

Consequence: THIS COULD LEAD TO AN INCREASE IN VEHICLE STOPPING DISTANCE AND A CRASH COULD OCCUR.

Remedy: DEALERS WILL INSTALL A NEWLY DESIGNED INTAKE AIR CONNECTOR WHICH WILL RELOCATE THE BRAKE SYSTEM VACUUM PORT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 21, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

EA21002 · Desiccated Air Bag Inflator Rupture

Opened Sep 17, 2021 · No close date supplied

Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module

From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.

Additional source detail variants (2)

Air Bags:frontal:driver Side:inflator Module

Air Bags:frontal:passenger Side:inflator Module

DP14003 · Low-speed Surging

Opened Sep 19, 2014 · Closed Apr 29, 2015

Status: closed (inferred from source dates) · Vehicle Speed Control

The Agency received a petition on September 11, 2014 requesting an investigation into, low-speed surging in the 2006-2010 Toyota Corolla [vehicles] with ETCS-i, in which the brakes fail to stop the vehicle in time to prevent a crash.NHTSA conducted a technical review of the material cited and provided by the petitioner, material Toyota submitted in response to a NHTSA formal request, interviews with complainants and manufacturer representatives, as well as the results of testing of the complaint vehicle.Taking into account the allocation of agency resources, agency priorities, and the likelihood that an additional investigation would result in a finding that a defect related to motor vehicle safety exists, NHTSA has concluded that further investigation of the issues raised by the petition is not warranted.The agency accordingly has denied the petition.The official petition denial, as published in the Federal Register, is available in the document file for this defect petition, as well as copies of reference material related to the denial.Regarding the VOQs associated with the closing of this investigation, the scope as defined by the petitioner is MY 2006 through 2010 Toyota Corollas.Of the 163 VOQs submitted by the petitioner, 149 are within that specific population (11 of the 163 were outside the model and model year scope of investigation as defined by the petitioner and 3 VOQs were submitted by owners from foreign countries) and 6 of the 163 are duplicate submissions.Therefore, there are 143 unique vehicles vins are within the specific population.Of the 143 only 105 fit the alleged defect category as defined by the petitioner.The single complaint and crash noted in the Failure Report above is the petitioner's VOQ.The 143 VOQs are: 10165337, 10166526, 10209540, 10216514, 10256808 (duplicate with 10266580 and 10335955), 10272505, 10293497, 10293688, 10294727, 10297407, 10298012, 10302217, 10302877, 10303106, 10303469, 10303730, 10304192, 10305748, 10305845, 10306012, 10306480, 10307953, 10310973, 10311137, 10311176, 10311185, 10311756, 10312246, 10312272 (duplicate with 10343088), 10312771, 10313972, 10314880, 10315240, 10315442, 10315836, 10315927, 10316192, 10316627, 10316643, 10316800, 10316952, 10317128, 10317598, 10317725, 10317804, 10317894, 10317972, 10317978, 10318562, 10319589, 10320693, 10320720, 10322163, 10322213, 10322333, 10322415, 10324355, 10325755, 10326481, 10327623, 10328492, 10328519, 10329537, 10330026 (duplicate with 10356866), 10330952, 10332679, 10334005 (duplicate with 10340570 and 10547602), 10334028, 10334628, 10334936, 10336649, 10339772, 10339969, 10341515, 10342670, 10342932, 10343174, 10344874, 10345714, 10348120, 10350342, 10351112, 10352668, 10352691, 10353587, 10358767, 10359645, 10360875, 10360905, 10361254, 10363529, 10363685, 10363866, 10364127, 10366100, 10366413, 10369073, 10369494, 10371991, 10376535, 10376721, 10377193, 10379320, 10380210, 10381365, 10381849, 10382018, 10392618, 10396747, 10402827, 10412382, 10433860, 10437011, 10437801, 10450183, 10461118, 10479582, 10482133, 10489344, 10494568, 10496026, 10499932, 10520195, 10521013, 10523677, 10534094, 10537426, 10543949, 10549101, 10551478, 10552563, 10558153, 10562577, 10564980, 10566370, 10572873, 10578871, 10579722, 10587140, 10597296, 10621449, and 10637908 (which is the petitioner's VOQ and not one of the 163 submitted with the petition).The three VOQs that were submitted from foreign countries: 10303105, 10303749, and 10308974. The eleven VOQs that are out of the specified population by model or model year: 10447756, 10453401, 10490200, 10507434, 10521377, 10563214, 10563585, 10575230, 10583796, 10584534,

PE10008 · Steering Wander Or Drift

Opened Feb 18, 2010 · Closed May 4, 2011

Status: closed (inferred from source dates) · Steering

On February 18, 2010, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE10-008 to investigate complaints of steering wander or drift in model year (MY) 2009 and 2010 Toyota Corolla and Matrix vehicles.The complaint descriptions indicated dissatisfaction with the on-center steering feel in the subject vehicles. Some drivers (~25%) related the feel to driving in a strong crosswind and others indicated that the effort and attention required to maintain heading increased driver fatigue on long trips.These complaints all relate to the system operating as designed and do not involve failure of any steering system components.The subject vehicles are equipped with an electronic power steering system that was introduced in the MY 2009 vehicles.The power assist, including on-center steering feel, is controlled electronically and is part of the system calibration.Toyota responded to steering feel concerns from some customers by issuing a technical service bulletin (TSB-0140-10 STEERING ON-CENTER FEEL) that released an optional EPS electronic control unit that has a re-calibrated on-center feel.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted by the circumstances.For further details see the attached VRTC and ODI Closing Reports.

Go deeper into Toyota Corolla problems

Toyota Corolla electrical problems →Toyota Corolla transmission problems →