NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
197 reportsClear category filter5,050 miles · Mar 22, 2010
Vehicle Speed Control
TL*THE CONTACT OWNS A 2009 TOYOTA COROLLA. WHILE TRAVELING AT 30 MPH THE VEHICLE SUDDENLY ACCELERATED WITHOUT ENGAGING THE ACCELERATOR PEDAL. THE CONTACT THEN SHIFTED THE VEHICLE INTO NEUTRAL GEAR WHICH DECREASED THE VEHICLES SPEED. THE CONTACT NOTICED THAT THE FAILURE DID NOT OCCUR UNTIL NHTSA RECALL # 10V017000 AND 10V023000 V…
Read full complaint
TL*THE CONTACT OWNS A 2009 TOYOTA COROLLA. WHILE TRAVELING AT 30 MPH THE VEHICLE SUDDENLY ACCELERATED WITHOUT ENGAGING THE ACCELERATOR PEDAL. THE CONTACT THEN SHIFTED THE VEHICLE INTO NEUTRAL GEAR WHICH DECREASED THE VEHICLES SPEED. THE CONTACT NOTICED THAT THE FAILURE DID NOT OCCUR UNTIL NHTSA RECALL # 10V017000 AND 10V023000 VEHICLE SPEED CONTROL: ACCELERATOR PEDAL WAS PERFORMED ON THE VEHICLE. DIAGNOSTIC TESTING WAS BEING PERFORMED BY THE DEALER WHEN THE COMPLAINT WAS FILED. THE VIN WAS NOT AVAILABLE. THE FAILURE AND THE CURRENT MILEAGE WAS 5050.
NHTSA ODI #10321399
17,000 miles · Mar 19, 2010
Vehicle Speed Control
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. WHILE THE VEHICLE WAS STOPPED AT A STOP LIGHT THE VEHICLE SUDDENLY BEGAN TO ACCELERATE WITHOUT WARNING. TO STOP THE ACCELERATION THE CONTACT HAD TO TURN THE VEHICLE OFF. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEA…
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. WHILE THE VEHICLE WAS STOPPED AT A STOP LIGHT THE VEHICLE SUDDENLY BEGAN TO ACCELERATE WITHOUT WARNING. TO STOP THE ACCELERATION THE CONTACT HAD TO TURN THE VEHICLE OFF. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALERSHIP AND THERE WERE NO PRIOR WARNINGS. THE CURRENT AND FAILURE MILEAGES WERE 17000.
NHTSA ODI #10320966
Mileage unknown · Mar 18, 2010
Service Brakes, HydraulicVehicle Speed ControlCrashInjury
S10 APPROPRIATE HANDLING RE TOYOTA VEHICLE PROBLEMS FWD COPY OF POLICE REPORT DOCUMENTING AN ACCIDENT INVOLVING BRAKING FAILURE AND BELIEVE TOYOTA DEALERSHIPS ARE STILL SELLING DEFECTIVE VEHICLES. *TGW 2009 TOYOTA COROLLA. THE CONSUMER STATED THE BRAKES FAILED WHICH CAUSED HER TO CRASH INTO TWO GUARDRAILS.
NHTSA ODI #10320851
Mileage unknown · Mar 18, 2010
Vehicle Speed Control
ON 3/18/10 MY SON WAS DRIVING OUR 2009 TOYOTA COROLLA. HE ACCELERATED ONTO THE INTERSTATE AND DROVE FOR NEARLY A MILE. HE WAS USING THE BLUE TOOTH PHONE THAT IS BUILT IN TO THE CAR. HE HUNG UP FROM THE CALL AND WITHIN SECONDS THE CARS RPM QUICKLY INCREASED FOR AT LEAST 10 -20 SECONDS. THE VSC, CK ENGINE, AND TRAC LIGHTS ALL CAM…
Read full complaint
ON 3/18/10 MY SON WAS DRIVING OUR 2009 TOYOTA COROLLA. HE ACCELERATED ONTO THE INTERSTATE AND DROVE FOR NEARLY A MILE. HE WAS USING THE BLUE TOOTH PHONE THAT IS BUILT IN TO THE CAR. HE HUNG UP FROM THE CALL AND WITHIN SECONDS THE CARS RPM QUICKLY INCREASED FOR AT LEAST 10 -20 SECONDS. THE VSC, CK ENGINE, AND TRAC LIGHTS ALL CAME ON AT THE SAME TIME. HE TOOK HIS FOOT OFF THE GAS PEDAL AND IT FELT LIKE IT WAS ALL THE WAY BACK, NOT STICKING BUT THE RPM'S WERE RACING.- AND GOING ABOUT 70 MPH. HE PUT THE CAR IN NEUTRAL- IT IS A MANUAL AND PULLED OVER. THE RPM WAS STILL RACING. HE SHUT THE VEHICLE OFF. WHEN HE TURNED IT BACK ON THE RPM WAS NORMAL BUT THE WARNING LIGHTS STAYED ON. THE CAR HAD THE RECALL REPAIRS COMPLETED ON FEB. 19, 2010. HE CONTACTED THE LOCAL TOYOTA DEALER AND THEY ASKED HIM TO DRIVE IT IN, WHICH HE DID. THEY CHECKED HIS FLOOR MATS AND THERE WAS NOT AN ISSUE WITH THEM. THEY HAVE OPENED A SERVICE REPAIR WITH TOYOTA CORP. THE CAR IS AT THE DEALER AT THIS TIME. THIS IS THE FIRST TIME THE CAR HAS DONE THIS. *TR
NHTSA ODI #10320744
39,400 miles · Mar 18, 2010
Vehicle Speed Control
ON MY 2009 COROLLA, I HAVE CONTINUED TO HAVE AN ISSUE WITH SLIGHT ACCELERATION AND SUDDEN RPM INCREASE WHILE THE ACCELERATOR IS NOT BEING APPLIED, AND USUALLY WHEN THE BRAKE IS BEING ENGAGED. THIS MAINLY HAPPENS WHILE GOING DOWNHILL AND IT CAUSES A FORWARD MOTION JERK IN THE CAR THAT IS FELT BY ALL PASSENGERS. I HAVE HAD THE REC…
Read full complaint
ON MY 2009 COROLLA, I HAVE CONTINUED TO HAVE AN ISSUE WITH SLIGHT ACCELERATION AND SUDDEN RPM INCREASE WHILE THE ACCELERATOR IS NOT BEING APPLIED, AND USUALLY WHEN THE BRAKE IS BEING ENGAGED. THIS MAINLY HAPPENS WHILE GOING DOWNHILL AND IT CAUSES A FORWARD MOTION JERK IN THE CAR THAT IS FELT BY ALL PASSENGERS. I HAVE HAD THE RECALL REGARDING THE METAL ACCELERATOR PATCH, FIXED. I HAVE ALSO TAKEN MY CAR INTO THE DEALERSHIP SINCE THE RECALL FIX TO ADDRESS THIS PROBLEM AND I WAS INFORMED THAT ALL TOYOTA CARS DO 'THIS' AND THAT IT IS NORMAL. THEY DID HOOK MY CAR UP FOR A HEALTH DIAGNOSTIC WHICH SHOWED NOTHING ABNORMAL. I HAVE DRIVEN A LARGE NUMBER OF CARS WHICH INCLUDE OTHER TOYOTAS, AND I HAVE NEVER EXPERIENCED THIS PHENOMENA. I HAVE ALSO HAD MULTIPLE THIRD PARTIES IN MY CAR AND THEY HAVE SHOWN SURPRISE AND CONCERN WHEN THE CAR EXHIBITED THIS BEHAVIOR. I DO NEED TO SAY THAT I HAVE NEVER FELT LIKE I HAVE LOST CONTROL OF MY CAR WHILE THIS OCCURS. HOWEVER, BASED ON RECENT ACCOUNTS FROM OTHER PEOPLE THAT OWN TOYOTAS, AND COROLLAS SPECIFICALLY, I AM NOT INCLINED TO TAKE A 'WAIT AND SEE' APPROACH TO THIS MATTER. THIS PROBLEM HAPPENS ON AN ALMOST DAILY BASIS, SOMETIMES MULTIPLE INSTANCES IN ONE DAY WITH 8-10 SEPARATE INSTANCES BEING THE MOST COUNTED IN A 24 HOUR PERIOD OF TIME. THE MECHANIC THAT RAN THE HEALTH DIAGNOSTICS (3/18/10) TOLD ME THAT GIVEN THE NUMBER OF COMPUTERS THAT 'RUN MY CAR' THERE COULD BE A NUMBER OF THINGS GOING ON THAT WOULD CAUSE THIS TO HAPPEN BUT THAT ANY ABNORMALITIES WOULD COME UP ON THEIR COMPUTER SYSTEM, ONCE THE TESTS WERE RUN. NOTHING APPARENTLY SHOWED UP. APPROXIMATE INCIDENT DATE BELOW SHOWS THE DATE THAT THIS LAST OCCURRED IN MY VEHICLE, BUT SINCE THERE IS NOT AN OPTION FOR DATE RANGE, IT IS NOT GOING TO ACCURATELY REFLECT THE AMOUNT OF TIME THIS HAS BEEN GOING ON (WHICH HAS BEEN ALMOST THE WHOLE TIME I HAVE OWNED THE CAR, 2 YEARS IN JULY 2010). *TR
NHTSA ODI #10320660
40,000 miles · Mar 16, 2010
Vehicle Speed ControlCrash
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH BACKING OUT OF THE DRIVEWAY. THE BRAKES FAILED TO ENGAGE WHEN PRESSURE WAS APPLIED. THE VEHICLE INCREASED ACCELERATION WITHOUT WARNING AND CRASHED INTO A MAILBOX. THERE WERE NO INJURIES. THE FAILURE WAS A ONE TIME OCCURRENCE. THE FAILURE AND …
Read full complaint
TL* THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT WAS DRIVING APPROXIMATELY 5 MPH BACKING OUT OF THE DRIVEWAY. THE BRAKES FAILED TO ENGAGE WHEN PRESSURE WAS APPLIED. THE VEHICLE INCREASED ACCELERATION WITHOUT WARNING AND CRASHED INTO A MAILBOX. THERE WERE NO INJURIES. THE FAILURE WAS A ONE TIME OCCURRENCE. THE FAILURE AND CURRENT MILEAGES WERE 40,000.
NHTSA ODI #10320101
28,900 miles · Mar 15, 2010
Fuel System, DieselVehicle Speed Control
I HAVE A 2009 TOYOTA COROLLA WITH A SERIAL NUMBER STARTING WITH A "J". TOYOTA TOLD ME MY CAR ISN'T PART OF THE RECALL. I HAVE EXPERIENCED TWO OCCASIONS WHERE THE ACCELERATOR PEDAL HAS BEEN STUCK. ONCE WHEN THE CAR WAS IN PARK ABOUT TWO MONTHS AGO AND I THOUGH IT WAS THE FLOOR MAT SO I SWITCHED OUT FLOOR MATS SINCE MY CAR WAS …
Read full complaint
I HAVE A 2009 TOYOTA COROLLA WITH A SERIAL NUMBER STARTING WITH A "J". TOYOTA TOLD ME MY CAR ISN'T PART OF THE RECALL. I HAVE EXPERIENCED TWO OCCASIONS WHERE THE ACCELERATOR PEDAL HAS BEEN STUCK. ONCE WHEN THE CAR WAS IN PARK ABOUT TWO MONTHS AGO AND I THOUGH IT WAS THE FLOOR MAT SO I SWITCHED OUT FLOOR MATS SINCE MY CAR WAS NOT PART OF THE RECALL. THEN ON SAT, 3/13/10 I WAS MERGING ON TO THE HIGHWAY AND I PRESSED DOWN HARD ON THE GAS PEDAL TO SPEED UP BECAUSE A CAR WAS BESIDE ME. ALL OF THE SUDDEN THE PEDAL WAS STUCK AND I CONTINUED TO SPEED UP WHEN I LET PRESSURE OFF THE GAS PEDAL. I PUT MY FOOT ON THE BRAKE AND THE CAR WASN'T STOPPING. THINKING I WASN'T PRESSING HARD ENOUGH I PUT BOTH FEET ON THE PETAL STILL NOT EVEN SLOWING DOWN. FINALLY, I SHIFTED THE CAR INTO NEUTRAL AND COULD STILL HEAR THE ENGINE REVVING BUT THE CAR SLOWED DOWN QUICKLY. THINKING THAT I WAS IMAGING IT WHEN THE CAR SLOWED ENOUGH I SHIFTED IT BACK TO DRIVE AND IT TOOK OFF AGAIN WITHOUT PRESSING THE GAS PEDAL. I QUICKLY SHIFTED IT BACK INTO NEUTRAL AND WAS WONDERING WHAT I WAS GOING TO DO AND I HEARD A LOUD POP OR SNAP WITH THE GAS PEDAL AND THEN THE CAR WAS FINE. IT STOPPED ACCELERATING ON IT'S OWN WITHOUT ME TURNING OFF THE CAR. I CHECKED THE FLOOR MAT AND IT WASN'T STUCK. I CALLED THE TOYOTA DEALERSHIP AND THEY ARE LOOKING AT THE PROBLEM BUT SAID THEY HAVE BEEN INSTRUCTED NOT TO FIX ANYTHING IF THEY CAN'T REPLICATE THE PROBLEM BECAUSE IT'S NOT PART OF THE RECALL AS THE CAR I HAVE WAS MADE IN JAPAN. I ALSO CALLED THE TOYOTA GENERAL LINE AND REPORTED THE PROBLEM. MY CONCERN IS THAT MY CAR WON'T BE FIXED AS THE WARRANTY RUNS OUT AT 30,000 MILES AND I HAVE 29,000 MILES ON MY CAR AND THE RECALL DOESN'T COVER MY MODEL. I AM NEARLY CERTAIN THAT TOYOTA HASN'T RECALLED ALL OF THE CAR AFFECTED BECAUSE IT'S NOT THE SPECIFIC GAS PEDAL THAT'S THE PROBLEM AS MY CAR DOESN'T HAVE THE IDENTIFIED GAS PEDAL. THE PROBLEM ISN'T RELATED TO THE GAS PEDAL. I DON'T THINK THEY KNOW WHAT THE PROBLEM IS. *TR
NHTSA ODI #10320042
20,000 miles · Mar 15, 2010
Vehicle Speed Control
HAD RECALL WORK COMPLETED ON MY 2009 TOYOTA COROLLA ON MARCH 13TH, 2010 REGARDING ACCELERATOR PEDAL. NO PROBLEMS AT ALL PRIOR TO RECALL WORK. ON MARCH 15TH, 2010 THE ACCELERATOR PEDAL FAILED TO RETURN TO ITS PROPER POSITION AFTER IT WAS DEPRESSED. I WAS PULLING INTO THE GARAGE AND GOING VERY SLOW AND BRAKING EASILY STOPPED THE…
Read full complaint
HAD RECALL WORK COMPLETED ON MY 2009 TOYOTA COROLLA ON MARCH 13TH, 2010 REGARDING ACCELERATOR PEDAL. NO PROBLEMS AT ALL PRIOR TO RECALL WORK. ON MARCH 15TH, 2010 THE ACCELERATOR PEDAL FAILED TO RETURN TO ITS PROPER POSITION AFTER IT WAS DEPRESSED. I WAS PULLING INTO THE GARAGE AND GOING VERY SLOW AND BRAKING EASILY STOPPED THE CAR. I TAPPED THE PEDAL QUICKLY AND IT APPARENTLY RETURNED TO PROPER (NOT DEPRESSED / FULL OUT) POSITION.THE FLOOR MAT IN THE CAR IS AFTERMARKET AND DOES NOT IN ANY WAY INTERFERE WITH THE PEDAL. WILL CONTACT DEALER WHO PERFORMED RECALL WORK AND HAVE THEM RECHECK PEDAL. PLEASE FEEL FREE TO CONTACT ME IF YOU THINK IT NECESSARY. *TR
NHTSA ODI #10319905
9,630 miles · Mar 15, 2010
Vehicle Speed ControlCrashInjury
TL*THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH. WHILE THE VEHICLE WAS DECELERATING THE BRAKE PEDAL WAS ENGAGED WITH NO RESPONSE. THE CONTACT WAS UNABLE TO SLOW THE VEHICLE DOWN AND CRASHED INTO A TREE. THE CONTACT SUSTAINED INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE HAS NOT BEEN REP…
Read full complaint
TL*THE CONTACT OWNS A 2009 TOYOTA COROLLA. THE CONTACT WAS DRIVING APPROXIMATELY 40 MPH. WHILE THE VEHICLE WAS DECELERATING THE BRAKE PEDAL WAS ENGAGED WITH NO RESPONSE. THE CONTACT WAS UNABLE TO SLOW THE VEHICLE DOWN AND CRASHED INTO A TREE. THE CONTACT SUSTAINED INJURIES. A POLICE REPORT WAS FILED. THE VEHICLE HAS NOT BEEN REPAIRED AT THIS TIME. THE FAILURE MILEAGE WAS 9,630. UPDATED 04/16/10. *LJ UPDATED 04/30/10.*JB
NHTSA ODI #10319879
5,000 miles · Mar 15, 2010
Equipment Adaptive/mobilityVehicle Speed Control
I OWN A TOYOTA COROLLA YEAR 2009 WHICH IS SUBJECT TO RECALL FOR THE GAS PEDAL AND THE FLOOR MAT (AS PER TOYOTA WEBSITE) I HAVE SCHEDULED AN APPOINTMENT WITH MY DEALER HUDSON TOYOTA ON 03/12/2010 TO HAVE IT FIXED. WHEN I GOT THERE, MY DEALER REFUSED TO SERVICE MY CAR CLAIMING THAT THE PARTS HAVE NOT BEEN PROVIDED YET BY THE COMPA…
Read full complaint
I OWN A TOYOTA COROLLA YEAR 2009 WHICH IS SUBJECT TO RECALL FOR THE GAS PEDAL AND THE FLOOR MAT (AS PER TOYOTA WEBSITE) I HAVE SCHEDULED AN APPOINTMENT WITH MY DEALER HUDSON TOYOTA ON 03/12/2010 TO HAVE IT FIXED. WHEN I GOT THERE, MY DEALER REFUSED TO SERVICE MY CAR CLAIMING THAT THE PARTS HAVE NOT BEEN PROVIDED YET BY THE COMPANY. PLEASE ADVISE ME AS TO WHAT SHOULD I DO . THANKS *TR
NHTSA ODI #10319635
Official recalls
13Oct 17, 2019
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Additional source detail variants (2)
Air Bags:frontal:passenger Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Air Bags:frontal:driver Side:inflator Module
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2010-2016 4Runner, 2003-2006 Tundra, 2003-2013 Corolla, 2009-2010 Corolla Matrix, 2004-2005 RAV4, 2002-2007 Sequoia, 2011-2013 Sienna, 2008-2012 Scion xB, 2008-2009 Lexus IS-F, 2007-2012 Yaris and Lexus ES350, 2010-2017 Lexus GX460, 2002-2010 Lexus SC430, 2006-2012 Lexus IS250 and IS350 and 2010-2015 Lexus IS250C and IS350C vehicles. These vehicles had their driver or passenger frontal air bag inflators previously replaced under a prior recall using inflators of the same design. The inflators may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify owners. Depending on the vehicle model, dealers will replace the front driver inflator, front passenger airbag inflator, the airbag assembly, or the front passenger airbag sub-assembly and inflator. The recall began November 20, 2019. Owners may contact Toyota customer service at 1-888-270-9371 or Lexus customer service at 1-800-255-3987. Toyota's numbers for this recall are J0A, J0B, and J0C. Lexus' numbers for this recall are JLI, JLJ, and JLK.
Jan 9, 2018
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2013 Scion xB, Toyota Corolla, Corolla Matrix, Sienna, 4Runner, Lexus IS250, IS350, IS250C, IS350C, IS-F, and GX460 vehicles sold, ever registered, in the states of AL, CA, FL, GA, HI, LA, MS, SC, TX, PR, AS, GU, the MP (Saipan), and the U.S. VI or "Zone A." Toyota is also recalling certain 2010 Scion xB, Toyota Corolla, Corolla Matrix, Yaris, 4Runner, Lexus IS250, IS350, IS250C, IS350C, ES350, IS-F, GX460, and Pontiac Vibe vehicles sold, ever registered, in the states of AZ, AR, DE, DC, IL, IN, KS, KY, MD, MO, NE, NV, NJ, NM, NC, OH, OK, PA, TN, VA, and WV or "Zone B." Toyota is also recalling certain 2009 Scion xB, Toyota Corolla, Corolla Matrix, Yaris, Lexus IS250, IS350, ES350, IS-F, and Pontiac Vibe vehicles ever registered in the states of AK, CO, CT, ID, IA, ME, MA, MI, MN, MT, NH, NY, ND, OR, RI, SD, UT, VT, WA, WI, and WY or "Zone C." These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may explode due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the vehicle model, dealers will replace the front passenger air bag inflator, or replace the air bag assembly. The recall began on January 29, 2018. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for this recall are "Zone A" Toyota: G0P, Lexus: GLG; "Zone B" Toyota: G0R, Lexus GLH; "Zone C" Toyota: H0A, and Lexus: HLA.
Jan 9, 2017
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain 2012 Toyota 4Runner, Corolla, Corolla Matrix, Sienna, Yaris, Scion xB, Lexus ES350, GX460, IS-F, IS250, IS350, IS250C, IS350C, and Lexus LFA vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain 2009 Toyota Corolla, Corolla Matrix, Yaris, Yaris HB, Scion xB, Pontiac Vibe, Lexus, ES350, IS250, IS350, and IS-F vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Toyota is recalling certain 2006-2008 Lexus IS250 and IS350, 2007-2008 Lexus ES350, Toyota Yaris, Yaris HB, and 2008 Lexus IS-F and Scion xB vehicles originally sold, or ever registered in Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota, Scion and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on February 1, 2017. Owners may contact Toyota customer service at 1-800-331-4331, or Pontiac customer service at 1-800-762-2737. Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), H0A (Toyota Zone C), GLG (Lexus Zone A), GLH (Lexus Zone B) and HLA (Lexus Zone C).
Jun 2, 2016
Southeast Toyota Distributors, LLC (SET) is recalling certain 2005-2011 4Runner, Highlander, Sequoia, and Sienna, 2005-2010 Avalon and Tundra, 2006-2008 Camry Solara, 2006-2010 Highlander hybrid, 2006-2011 Rav4 and Tacoma, 2007-2010 FJ Cruiser, 2007-2011 Camry hybrid, 2009-2010 Venza, 2010-2012 Prius, 1988-1990 and 2005-2010 Camry, and 1989 and 2009-2010 Corolla vehicles equipped with aftermarket accessory seat heaters with a copper strand heating element. The electrical wiring in the seat heaters may be damaged when the seat cushion is compressed.
Consequence & remedy
Consequence: If damaged, the copper strand heating element may short circuit, increasing the risk of a fire.
Remedy: SET will notify owners, and dealers will disconnect the seat heaters, free of charge, and refund the purchase price of the seat heater accessory. The recall began on July 14, 2016. Owners may contact SET customer service at 1-866-405-4226. SET number for this recall is SET16B.
May 23, 2016
Toyota Motor Engineering & Manufacturing (Toyota) is recalling certain model year 2008-2011 Scion xB and Lexus IS F, 2009-2011 Toyota Corolla and Corolla Matrix, 2006-2011 Toyota Yaris, Lexus IS250 and Lexus IS350, 2010-2011 Toyota 4Runner, Lexus IS250C, Lexus IS350C and Lexus GX460, 2011 Sienna, 2007-2011 Lexus ES350, and 2009-2010 Pontiac Vibe vehicles, originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Toyota is recalling certain model year 2008 Scion xB and Lexus IS F, 2007-2008 Toyota Yaris, 2006-2008 Lexus IS250 and Lexus IS350 and 2007-2008 Lexus ES350 vehicles, originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Vehicles of these model years and models that were not originally sold or ever registered in either Zones A or B are not subject to this safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Toyota will notify the Toyota and Lexus owners. General Motors will contact the Pontiac owners. Depending on the model, dealers will replace the passenger frontal air bag inflator or the air bag assembly, free of charge. The recall began on December 6, 2016. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's numbers for interim notification for this campaign are G1P (Toyota Zone A), G1R (Toyota Zone B), G2G (Lexus Zone A), and G2H (Lexus Zone B). Toyota's numbers for final remedy for this campaign are G0P (Toyota Zone A), G0R (Toyota Zone B), GLG (Lexus Zone A), and GLH (Lexus Zone B).
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
Apr 9, 2014
Toyota is recalling certain model year 2006-2008 RAV4, 2006-2010 Yaris, 2008-2010 Highlander, and 2009-2010 Tacoma, Corolla, Corolla Matrix and General Motors Pontiac Vibe vehicles. In the affected vehicles, the steering column assembly contains electrical connections to the driver's airbag module housed in a spiral cable assembly, which includes a Flexible Flat Cable (FFC). Due to the shape and location of the FFC's retainer, the FFC could become damaged when the steering wheel is turned.
Consequence & remedy
Consequence: If the FFC is damaged, connectivity to the driver's air bag module could be lost and the air bag deactivated. The failure of the driver's air bag to deploy in the event of a crash that typically necessitates deployment increases the risk of injury to the driver.
Remedy: Toyota will notify the Toyota vehicle owners, and General Motors will notify the Pontiac Vibe owners. Toyota sent owners an interim notification letter in May 2014 to advise owners of the recall. Toyota will mail owners a second letter when remedy parts are available. General Motors sent Pontiac Vibe owners an Interim letter on June 20, 2014 notifying them that parts are currently unavailable. General Motors sent notices to the Pontiac Vibe owners on September 15, 2014, that a remedy is available. The recall began on October 27, 2014. Owners may contact Toyota at 1-800-331-4331. Owners may contact General Motors at 1-800-762-2737.
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
Feb 3, 2010
GULF STATES TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD BETWEEN SEPTEMBER 1, 2005 AND JUNE 2, 2008 WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: THIS DOES NOT MEET THE STANDARD REQUIREMENTS.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. DEALERS WILL ALSO CORRECT THE OWNER'S MANUAL. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT GULF STATES TOYOTA AT 713-580-3300.
Feb 3, 2010
SOUTHEAST TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2011 PASSENGER VEHICLES FOR FAILING TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 110, "TIRE SELECTION AND RIMS." THESE VEHICLES WERE SOLD WITHOUT THE REQUISITE LOAD CARRYING CAPACITY MODIFICATION LABELS.
Consequence & remedy
Consequence: A DRIVER MAY OVERLOAD A VEHICLE WHICH MAY INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL MAIL TO CONSUMERS THE CORRECTED LABEL OR THE CUSTOMER WILL HAVE THE OPTION FOR DEALERS TO INSTALL THE LABEL FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MAY 27, 2010. OWNERS MAY CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Jan 27, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2010 HIGHLANDER, MODEL YEAR 2009-2010 COROLLA, VENZA AND MATRIX PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT. THIS RECALL IS AN EXPANSION OF A CAMPAIGN OF 3.8 MILLION OTHER TOYOTA VEHICLES ANNOUNCED IN 2009 FOR THE SAME ISSUE (SEE 09V-388).
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA WILL MODIFY OR REPLACE THE ACCELERATOR PEDALS ON THE SUBJECT VEHICLES. FLOOR SURFACE MODIFICATIONS ARE ALSO BEING CONSIDERED AND WILL BE INCLUDED FOR ANY MODEL FOR WHICH IT IS DEEMED APPROPRIATE. INITIALLY, DEALERS WILL BE INSTRUCTED ON HOW TO RESHAPE THE ACCELERATOR PEDAL FOR THE REPAIR. AS REPLACEMENT PARTS WITH THE SAME SHAPE AS THE MODIFIED PEDAL BECOME AVAILABLE, THEY WILL BE MADE AVAILABLE TO THE DEALERS FOR THE REPAIR. CUSTOMERS WHO HAVE HAD THE PEDAL RESHAPE REMEDY COMPLETED WILL HAVE THE OPPORTUNITY TO RECEIVE A NEW PEDAL IF THEY DESIRE, AFTER REPLACEMENT PEDALS BECOME AVAILABLE. IN ADDITION, TOYOTA WILL REPLACE ANY TOYOTA ALL-WEATHER FLOOR MAT IN A SUBJECT VEHICLE WITH A NEWLY DESIGNED MAT, FREE OF CHARGE. FOR THOSE CUSTOMERS WHO HAVE THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT BUT DO NOT NEED OR WANT THE NEWLY DESIGNED ALL-WEATHER FLOOR MAT, TOYOTA WILL RECOVER THE PREVIOUS DESIGN ALL-WEATHER FLOOR MAT AND REIMBURSE ITS PRICE. THE SAFETY RECALL BEGAN MARCH 30, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Jan 21, 2010
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2005-2010 AVALON, MODEL YEAR 2007-2010 CAMRY, MODEL YEAR 2009-2010 COROLLA, COROLLA MATRIX, RAV4, MODEL YEAR 2010 HIGHLANDER, MODEL YEAR 2008-2010 SEQUOIA, AND MODEL YEAR 2007-2010 TUNDRA VEHICLES. DUE TO THE MANNER IN WHICH THE FRICTION LEVER INTERACTS WITH THE SLIDING SURFACE OF THE ACCELERATOR PEDAL INSIDE THE PEDAL SENSOR ASSEMBLY, THE SLIDING SURFACE OF THE LEVER MAY BECOME SMOOTH DURING VEHICLE OPERATION. IN THIS CONDITION, IF CONDENSATION OCCURS ON THE SURFACE, AS MAY OCCUR FROM HEATER OPERATION (WITHOUT A/C) WHEN THE PEDAL ASSEMBLY IS COLD, THE FRICTION WHEN THE ACCELERATOR PEDAL IS OPERATED MAY INCREASE, WHICH MAY RESULT IN THE ACCELERATOR PEDAL BECOMING HARDER TO DEPRESS, SLOWER TO RETURN, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION.
Consequence & remedy
Consequence: THE ACCELERATOR PEDAL MAY BECOME HARD TO DEPRESS, SLOW TO RETURN TO IDLE, OR, IN THE WORST CASE, MECHANICALLY STUCK IN A PARTIALLY DEPRESSED POSITION, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL A REINFORCEMENT BAR IN THE ACCELERATOR PEDAL WHICH WILL ALLOW THE PEDAL TO OPERATE SMOOTHLY. GM WILL NOTIFY OWNERS FOR THE PONTIAC VIBE PLEASE SEE 10V-018. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON FEBRUARY 5, 2010 AND WILL BE COMPLETED ON MARCH 15, 2010. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Aug 27, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2008-2009 SCION XD AND MY 2009-2010 COROLLA, AND COROLLA MATRIX VEHICLES EQUIPPED WITH 1.8L ENGINE AND ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ALASKA, COLORADO, IDAHO, ILLINOIS, IOWA, KANSAS, MAINE, MICHIGAN, MINNESOTA, MONTANA, NEBRASKA, NEVADA, NEW HAMPSHIRE, NEW YORK, NORTH DAKOTA, SOUTH DAKOTA, VERMONT, WISCONSIN, AND WYOMING. WHEN DRIVING UNDER CERTAIN UNIQUE CONDITIONS IN EXTREMELY LOW AMBIENT TEMPERATURES, THE INTAKE MANIFOLD SUCTION PORT FOR THE BRAKE VACUUM CAN BECOME BLOCKED DUE TO THE FREEZING OF CONDENSATION RESULTING FROM POSITIVE CRANKCASE VENTILATION.
Consequence & remedy
Consequence: THIS COULD LEAD TO AN INCREASE IN VEHICLE STOPPING DISTANCE AND A CRASH COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEWLY DESIGNED INTAKE AIR CONNECTOR WHICH WILL RELOCATE THE BRAKE SYSTEM VACUUM PORT. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE RECALL BEGAN ON SEPTEMBER 21, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA21002 · Desiccated Air Bag Inflator Rupture
Opened Sep 17, 2021 · No close date supplied
Status: open (inferred from source dates) · Air Bags:frontal:driver Side:inflator Module; Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
Air Bags:frontal:passenger Side:inflator Module
From 2000 through 2017, Takata produced millions of air bag inflators using two types of phase-stabilized ammonium nitrate ("PSAN") propellant -- propellant 2004 and propellant 2004L. After prolonged exposure to high temperature cycles and humidity, inflators using propellant 2004 can degrade, causing the propellant to burn too quickly when ignited. The rapid burning can cause the inflator to rupture during deployment, potentially causing serious or even fatal injury to vehicle occupants. See 2016 Blomquist Report at www.nhtsa.gov/sites/nhtsa.gov/files/documents/expert_report-hrblomquist.pdf.Consequently, all frontal inflators using propellant 2004 that do not contain a "desiccant" (a substance that traps and holds moisture) in US vehicles are under recall. These "non-desiccated" inflators either have been or are required to be replaced.In some cases, the remedy part for these recalled inflators was, or will be, an inflator using either propellant 2004 or 2004L that does contain a desiccant. None of these "desiccated" remedy parts (which were installed in older model year vehicles) are currently under recall for a degradation concern. Certain subsets of desiccated PSAN inflators using propellant 2004 for use as original equipment, however, have been recalled for a degradation concern. All Takata inflators produced with propellant 2004L contain desiccant, and none of these desiccated inflators using propellant 2004L are under recall for a degradation concern. There have been no reported field ruptures in any non-recalled desiccated PSAN inflators.It is understood that desiccants fully saturate at some threshold, at which point any additional moisture will not be captured. This means the degradation process observed in non-desiccated inflators using propellant 2004 may also occur in non-recalled desiccated inflators using propellant 2004, assuming additional moisture enters the inflator and high temperature cycling occurs. Based on available information, desiccant saturation can occur within the first five years in the worst environments, and the time required for full saturation is affected by multiple factors. While no present safety risk has been identified, further work is needed to evaluate the future risk of non-recalled desiccated inflators using propellant 2004.Three entities -- Takata (now known as TK Global), the Independent Testing Coalition, and Exponent -- have been studying the long-term behavior of Takata desiccated PSAN inflators using propellant 2004L (as well as 2004) in the presence of moisture and temperature cycling. The research efforts, which include development of predictive modeling techniques and field sample analysis, are ongoing. To date, none of the researchers have identified field evidence showing that propellant 2004L is undergoing a degradation process that leads to aggressive deployment and potential rupture. However, the time in service of such inflators remains short compared to that of the inflators using propellant 2004. Further study is needed to assess the long-term safety of desiccated inflators using propellant 2004L.The Office of Defects Investigation is opening this investigation to examine whether a safety defect related to propellant degradation exists in non-recalled desiccated PSAN frontal inflators manufactured by Takata. This investigation will require extensive information on Takata production processes and surveys of inflators in the field. Lists of recall actions that may have used desiccated PSAN inflators as remedy parts, as well as the makes and models originally manufactured with them, is available with the downloadable version of this document (see nhtsa.gov/recalls?nhtsaId=EA21002 -- note this information is subject to change/revision as the investigation proceeds). This investigation does not supersede EA15-001, which remains open.
DP14003 · Low-speed Surging
Opened Sep 19, 2014 · Closed Apr 29, 2015
Status: closed (inferred from source dates) · Vehicle Speed Control
The Agency received a petition on September 11, 2014 requesting an investigation into, low-speed surging in the 2006-2010 Toyota Corolla [vehicles] with ETCS-i, in which the brakes fail to stop the vehicle in time to prevent a crash.NHTSA conducted a technical review of the material cited and provided by the petitioner, material Toyota submitted in response to a NHTSA formal request, interviews with complainants and manufacturer representatives, as well as the results of testing of the complaint vehicle.Taking into account the allocation of agency resources, agency priorities, and the likelihood that an additional investigation would result in a finding that a defect related to motor vehicle safety exists, NHTSA has concluded that further investigation of the issues raised by the petition is not warranted.The agency accordingly has denied the petition.The official petition denial, as published in the Federal Register, is available in the document file for this defect petition, as well as copies of reference material related to the denial.Regarding the VOQs associated with the closing of this investigation, the scope as defined by the petitioner is MY 2006 through 2010 Toyota Corollas.Of the 163 VOQs submitted by the petitioner, 149 are within that specific population (11 of the 163 were outside the model and model year scope of investigation as defined by the petitioner and 3 VOQs were submitted by owners from foreign countries) and 6 of the 163 are duplicate submissions.Therefore, there are 143 unique vehicles vins are within the specific population.Of the 143 only 105 fit the alleged defect category as defined by the petitioner.The single complaint and crash noted in the Failure Report above is the petitioner's VOQ.The 143 VOQs are: 10165337, 10166526, 10209540, 10216514, 10256808 (duplicate with 10266580 and 10335955), 10272505, 10293497, 10293688, 10294727, 10297407, 10298012, 10302217, 10302877, 10303106, 10303469, 10303730, 10304192, 10305748, 10305845, 10306012, 10306480, 10307953, 10310973, 10311137, 10311176, 10311185, 10311756, 10312246, 10312272 (duplicate with 10343088), 10312771, 10313972, 10314880, 10315240, 10315442, 10315836, 10315927, 10316192, 10316627, 10316643, 10316800, 10316952, 10317128, 10317598, 10317725, 10317804, 10317894, 10317972, 10317978, 10318562, 10319589, 10320693, 10320720, 10322163, 10322213, 10322333, 10322415, 10324355, 10325755, 10326481, 10327623, 10328492, 10328519, 10329537, 10330026 (duplicate with 10356866), 10330952, 10332679, 10334005 (duplicate with 10340570 and 10547602), 10334028, 10334628, 10334936, 10336649, 10339772, 10339969, 10341515, 10342670, 10342932, 10343174, 10344874, 10345714, 10348120, 10350342, 10351112, 10352668, 10352691, 10353587, 10358767, 10359645, 10360875, 10360905, 10361254, 10363529, 10363685, 10363866, 10364127, 10366100, 10366413, 10369073, 10369494, 10371991, 10376535, 10376721, 10377193, 10379320, 10380210, 10381365, 10381849, 10382018, 10392618, 10396747, 10402827, 10412382, 10433860, 10437011, 10437801, 10450183, 10461118, 10479582, 10482133, 10489344, 10494568, 10496026, 10499932, 10520195, 10521013, 10523677, 10534094, 10537426, 10543949, 10549101, 10551478, 10552563, 10558153, 10562577, 10564980, 10566370, 10572873, 10578871, 10579722, 10587140, 10597296, 10621449, and 10637908 (which is the petitioner's VOQ and not one of the 163 submitted with the petition).The three VOQs that were submitted from foreign countries: 10303105, 10303749, and 10308974. The eleven VOQs that are out of the specified population by model or model year: 10447756, 10453401, 10490200, 10507434, 10521377, 10563214, 10563585, 10575230, 10583796, 10584534,
PE10008 · Steering Wander Or Drift
Opened Feb 18, 2010 · Closed May 4, 2011
Status: closed (inferred from source dates) · Steering
On February 18, 2010, the Office of Defects Investigation (ODI) opened Preliminary Evaluation PE10-008 to investigate complaints of steering wander or drift in model year (MY) 2009 and 2010 Toyota Corolla and Matrix vehicles.The complaint descriptions indicated dissatisfaction with the on-center steering feel in the subject vehicles. Some drivers (~25%) related the feel to driving in a strong crosswind and others indicated that the effort and attention required to maintain heading increased driver fatigue on long trips.These complaints all relate to the system operating as designed and do not involve failure of any steering system components.The subject vehicles are equipped with an electronic power steering system that was introduced in the MY 2009 vehicles.The power assist, including on-center steering feel, is controlled electronically and is part of the system calibration.Toyota responded to steering feel concerns from some customers by issuing a technical service bulletin (TSB-0140-10 STEERING ON-CENTER FEEL) that released an optional EPS electronic control unit that has a re-calibrated on-center feel.Accordingly, this investigation is closed.The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The agency will continue to monitor complaints and other information relating to the alleged defect in the subject vehicles and take further action in the future if warranted by the circumstances.For further details see the attached VRTC and ODI Closing Reports.
Illustration