NHTSA owner reports · September 18, 2026 snapshot.
Tires complaints
54 reportsClear category filterMileage unknown · Feb 26, 2004
Engine And Engine CoolingStructureTires
ROTTEN EGG SMELL SINCE THE CAR WAS PURCHASED. COMPLAINED TO TOYOTA DEALERSHIP AND THE REGIONAL REP WITHOUT A RESOLUTION. THE REP SUGGESTION WAS TO JUST PUT PREMIUM GAS IN IT. CERTAINLY NOT WHAT I EXPECTED FROM TOYOTA BUT I HAVE BEEN PUTTING PREMIUM GAS IN THE CAR AND IT DOES SEEMS TO TAME THE SMELL SOMEWHAT. IN ADDITION WE H…
Read full complaint
ROTTEN EGG SMELL SINCE THE CAR WAS PURCHASED. COMPLAINED TO TOYOTA DEALERSHIP AND THE REGIONAL REP WITHOUT A RESOLUTION. THE REP SUGGESTION WAS TO JUST PUT PREMIUM GAS IN IT. CERTAINLY NOT WHAT I EXPECTED FROM TOYOTA BUT I HAVE BEEN PUTTING PREMIUM GAS IN THE CAR AND IT DOES SEEMS TO TAME THE SMELL SOMEWHAT. IN ADDITION WE HAVE HAD PROBLEMS WITH THE FRONT ALIGNMENT AND THE CAR PULLS TO THE LEFT. HAVE PURCHASED A LIFE TIME ALIGNMENT WARRANTY BUT IT STILL SEEMS TO GO OUT OF ALIGNMENT QUICKLY. ALSO HAVE A CONSTANT WIND PROBLEM WITH THE DRIVER SIDE FRONT DOOR. BEEN REPAIRED ONCE, GOING INTO THE SHOP AGAIN TO REPAIR. ALSO THE ORIGINAL TIRES HAD TO BE REPLACED AT 24,000 MILES. I WOULDN'T CONSIDER A TOYOTA IN FUTURE CAR PURCHASES.*AK
NHTSA ODI #10059062
Mileage unknown · Dec 10, 2003
Tires
THE TIRE SHOWED SIGNS OF EXCESSIVE WEAR ON THE INSIDE AND OUTSIDE OF THEM. THE CONSUMER TOOK THE VEHICLE TO THE DEALERSHIP AND HAD THE TIRES ROTATED, BALANCE AND ALIGNED. CONTINENTAL TOURING CONTACT AS LSIZE# P205/65R15 DOT# ACUR3K42702. *JB *SCC
NHTSA ODI #10044677
26,000 miles · Dec 2, 2003
Tires
WHILE DRIVING FRONT DRIVER'S SIDE TIRE TREAD SEPARATED. *AK
NHTSA ODI #10049870
Mileage unknown · Nov 26, 2003
Tires
CAR PULLED TO THE LEFT FROM THE DAY IT WAS PURCHASED. DEALERSHIP TRIED ON 3 SEPARATE OCCASIONS TO FIX THE PROBLEM WITH NO LUCK. THEY BLAMED THE ROADS. TIRES WERE ALSO USELESS UNDER SNOWY CONDITIONS, PROVIDING MINIMAL TRACTION. *LA
NHTSA ODI #10047635
Mileage unknown · Nov 26, 2003
Tires
HI! THIS IS REGARDING MY CAMRY 2002. TIRES STARTED BALDING UNEVENLY, NOTICED AT 4000 MILES SECONDARY TO FAULTY ALIGNMENT. TIRES FRONT TWO ONLY REPLACED BY TOYOTA ON LODGING A COMPLAINT. TIRES WERE AGAIN BALDING AFTER ANOTHER 4000 MILES OR SO. FAULTY ALIGNMENT. TOYOTA AND DEALER REFUSE TO ACKNOWLEDGE MY CONCERNS AND HAVE GOT ALI…
Read full complaint
HI! THIS IS REGARDING MY CAMRY 2002. TIRES STARTED BALDING UNEVENLY, NOTICED AT 4000 MILES SECONDARY TO FAULTY ALIGNMENT. TIRES FRONT TWO ONLY REPLACED BY TOYOTA ON LODGING A COMPLAINT. TIRES WERE AGAIN BALDING AFTER ANOTHER 4000 MILES OR SO. FAULTY ALIGNMENT. TOYOTA AND DEALER REFUSE TO ACKNOWLEDGE MY CONCERNS AND HAVE GOT ALIGNMENT CHECKED ON A MONTHLY BASIS TIMES 3 AND HAS BEEN FAULTY ON EACH OCCASION. TIRES WENT COMPLETELY WORN OUT, BALD WITH THE METAL WIRES COMING OUT.(HAVE ALL 4 TIRES AS EVIDENCE). I HAD TO PURCHASE FOUR NEW TIRES AND GET THE ALIGNMENT FIXED ON EACH OCCASION WITHIN THE FIRST ONE YEAR OF PURCHASING MY NEW CAMRY. I HAVE SPENT MORE THAN $1000 ON TIRES AND ALIGNMENT AND TOYOTA REFUSES TO HELP ME OUT IN CORRECTING THE FAULTY ALIGNMENT AND ALL THE TROUBLE I HAVE BEEN THROUGH WITH A NEW CAR!!! *LA
NHTSA ODI #10047591
Mileage unknown · Nov 5, 2003
Tires
2002 TOYOTA CAMRY NOTICEABLE PULLING TO THE LEFT AFTER REGULAR TIRE ROTATION, ALIGNMENT. PREMATURE WEAR OF TIRES TO THE POINT OF REPLACEMENT AT 21,XXX MILES.FTER RESEARCHING ON TOYOTA MESSAGE BOARDS, THIS APPEARS TO BE A COMMON AND POTENTIALLY SERIOUS ISSUE THAT NEEDS TO BE ADDRESSED BY TOYOTA.*AK
NHTSA ODI #10045520
24,000 miles · Nov 5, 2003
Tires
THE VEHICLE WAS TAKEN IN FOR ROUTINE INSPECTION AND THE MECHANIC NOTICED ALL 4 TIRES WERE WEARING ON THE INSIDE AND OUTSIDE, SOME PIECES OF PLY WERE STICKING THROUGH. *AK ALL FOUR TIRES WERE ROTATED TWICE AND THE AIR PRESSURE WAS GOOD. CONTINENTAL REP. STATED "TOO BAD NOT THEIR PROBLEM CUSTOMER ABUSE OR MECHANICAL PROBLEM." …
Read full complaint
THE VEHICLE WAS TAKEN IN FOR ROUTINE INSPECTION AND THE MECHANIC NOTICED ALL 4 TIRES WERE WEARING ON THE INSIDE AND OUTSIDE, SOME PIECES OF PLY WERE STICKING THROUGH. *AK ALL FOUR TIRES WERE ROTATED TWICE AND THE AIR PRESSURE WAS GOOD. CONTINENTAL REP. STATED "TOO BAD NOT THEIR PROBLEM CUSTOMER ABUSE OR MECHANICAL PROBLEM." *PH *JB
NHTSA ODI #10042469
Mileage unknown · Oct 6, 2003
Tires
WHILE DRIVING AT 65 MPH REAR DRIVER'S SIDE TIRE BLEW OUT, CAUSING THE DRIVER TO PULL OFF THE ROAD. OWNER HAS CONTACTED THE DEALERSHIP.*AK
NHTSA ODI #10042308
18,000 miles · Oct 1, 2003
Tires
ON SEPT. 27 THE LEFT REAR TIRE EXPLODED WHILE DRIVING ON THE HIGHWAY AT 60 MPH. I PULLED OVER TO THE SHOULDER AND EXAMINED TIRE. TIRE HAD SUSTAINED MANY RIPS AND TEARS ALONG THE SIDE AND NUMEROUS FIBERS WERE EXPOSED WITHIN THE RIPS AND TEARS. THE TIRE WAS NOT FLATTENED. ALL THE DAMAGE WAS ON THE SIDE OF THE TIRE. THE TIRES …
Read full complaint
ON SEPT. 27 THE LEFT REAR TIRE EXPLODED WHILE DRIVING ON THE HIGHWAY AT 60 MPH. I PULLED OVER TO THE SHOULDER AND EXAMINED TIRE. TIRE HAD SUSTAINED MANY RIPS AND TEARS ALONG THE SIDE AND NUMEROUS FIBERS WERE EXPOSED WITHIN THE RIPS AND TEARS. THE TIRE WAS NOT FLATTENED. ALL THE DAMAGE WAS ON THE SIDE OF THE TIRE. THE TIRES ON MY 2002 CAMRY CAME WITH THE PURCHASE OF THE VEHICLE AND HAD ONLY 18,000 MILES. THE BRIDGESTONE/FIRESTONE INSPECTOR UPON EXAMINATION OF THE TIRE DENIED IT WAS DEFECTIVE. *LA
NHTSA ODI #10041018
Mileage unknown · Jul 21, 2003
Tires
WHILE DRIVING REAR PASSENGER SIDE TIRE BLEW OUT. WHEN CHANGING THE TIRE, SEVEN PUNCTURED HOLES WERE FOUND ON THE INSIDE SIDEWALL OF THE TIRE. BRIDGESTONE FIRESTONE RADIAL TIRE. *AK
NHTSA ODI #10029708
Official recalls
4Jul 13, 2004
ON CERTAIN VEHICLES EQUIPPED WITH CURTAIN SHIELD AIR BAGS (CSA), ONE OR BOTH OF THE CURTAIN AIR BAGS MAY BE TWISTED NEAR THE INFLATOR DUE TO IMPROPER ASSEMBLY.
Consequence & remedy
Consequence: IF THIS OCCURS, THE CSA MAY NOT DEPLOY RAPIDLY ENOUGH WHEN ACTIVATED IN A SIDE IMPACT COLLISION. THIS MAY RESULT IN FAILURE TO PROVIDE THE INTENDED HEAD PROTECTION, INCREASING THE RISK OF INJURY.
Remedy: DEALERS WILL INSPECT THE CSAS AND REPLACE THE AIR BAG ASSEMBLY IF NECESSARY. THE RECALL BEGAN ON AUGUST 6, 2004. OWNERS SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Dec 11, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A THREE-SPOKE STYLE STEERING WHEEL. DURING AIR BAG DEPLOYMENT, IT IS POSSIBLE THAT THE BOTTOM SEAM OF THE FRONT DRIVER'S SIDE AIR BAG MODULE COVER (HORN PAD) COULD BE TORN AWAY ALLOWING THE BOTTOM PORTION OF THE COVER TO COMPLETELY DETACH FROM THE AIR BAG MODULE.
Consequence & remedy
Consequence: IF THIS SHOULD OCCUR, THERE IS A POSSIBILITY THAT THE DETACHED BOTTOM PORTION MAY STRIKE THE DRIVER CAUSING PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE DRIVER'S SIDE AIR BAG MODULE. OWNER NOTIFICATION BEGAN DECEMBER 28, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331 OR LEXUS AT 1-888-333-9376.
Oct 1, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH CONTINENTAL TOURING TIRES, P205-65R15 92S, INSTALLED AT THE PORTS IN JACKSONVILLE, FLORIDA. THE INCORRECT TIRES WERE INSTALLED ON VEHICLES THAT HAD DAMAGED TIRES. THE TIRES WERE DAMAGED DURING A PORT UPGRADE TO ALUMINUM WHEELS.
Consequence & remedy
Consequence: THE TIRES DO NOT CONFORM TO THE SPEED RATING FOR THE VEHICLE. IF THE VEHICLE EXCEEDED THE MAXIMUM SPEED RATING (112 MPH), POSSIBLE TIRE FAILURE COULD OCCUR.
Remedy: DEALERS WILL REPLACE ALL FIVE TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 13, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SOUTHEAST TOYOTA AT 1-800-301-6859.
Sep 25, 2001
VEHICLE DESCRIPTION: PASSENGER VEHICLES. INCOMPLETE DEPLOYMENT OF THE FRONT PASSENGER SIDE AIR BAG COULD OCCUR IN THE EVENT OF A CRASH.
Consequence & remedy
Consequence: UNEXPECTED AIR BAG DEPLOYMENT CAN RESULT IN OCCUPANT INJURY.
Remedy: DEALERS WILL REPLACE THE FRONT PASSENGER SIDE AIR BAG ASSEMBLY. BOTH OWNERS WERE NOTIFIED BY TELEPHONE AND ARRANGEMENTS HAVE BEEN MADE TO CORRECT THIS PROBLEM. THIS CAMPAIGN IS 100% COMPLETED. BOTH OWNERS HAVE BEEN NOTIFIED AND THEIR VEHICLES REPAIRED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP06003 · Engine Surging
Opened Sep 14, 2006 · Closed Apr 3, 2007
Status: closed (inferred from source dates) · Vehicle Speed Control; Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Additional source detail variants (2)
Vehicle Speed Control:accelerator Pedal
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
Vehicle Speed Control
THE PETITIONER OWNS A MY 2006 TOYOTA CAMRY WITH A 4-CYLINDER ENGINE THAT WAS PURCHASED NEW IN JANUARY 2006. THE PETITIONER ALSO PREVIOUSLY OWNED A MY 2005 CAMRY. HE ALLEGES THAT BOTH VEHICLES EXHIBITED VEHICLE ENGINE SURGING, WHICH HE DESCRIBED AS A SHORT DURATION (1 TO 2 SECOND) INCREASE IN ENGINE SPEED OCCURRING WHILE THE ACCELERATOR PEDAL IS NOT DEPRESSED. IN AN INITIAL INTERVIEW, THE PETITIONER ESTIMATED THAT 6 TO 8 SURGE INCIDENTS, OF VARYING SEVERITY, OCCURRED IN THE MY 2006 VEHICLE OVER THE COURSE OF 10,000 MILES AND 7 MONTHS OF OWNERSHIP. THE PETITIONER REPORTS THAT THE BRAKE SYSTEM IS EFFECTIVE AT OVERCOMING THE SURGE. HOWEVER, HE IS CONCERNED ABOUT REPORTS FILED WITH NHTSA ALLEGING UNCONTROLLEDSURGING IN MY 2002 TO 2006 CAMRY VEHICLES BRINGING THOSE VEHICLES TO A HIGH RATE OF SPEED (IN SOME CASES, PURPORTEDLY, WITH THE BRAKES APPLIED).AFTER REVIEW AND ANALYSIS OF THE AVAILABLE INFORMATION, ODI HAS NOT IDENTIFIED A VEHICLE-BASED DEFECT THAT WOULD HAVE PRODUCED THE ALLEGED ENGINE SURGE IN THE PETITIONER?S VEHICLE, NOR WAS IT ABLE TO WITNESS SUCH AN EVENT WHEN ROAD TESTING THE PETITIONER?S VEHICLE.EVALUATION OF A SUSPECT THROTTLE ACTUATOR REMOVED FROM THE PETITIONER?S VEHICLE DID NOT REVEAL A COMPONENT PROBLEM. WARRANTY AND PARTS SALES OF THE ACTUATOR ARE UNREMARKABLE.THESE DATA DO NOT SUPPORT THE EXISTENCE OF A WIDE-SPREAD DEFECT OR ONGOING CONCERN. THE FAULT DETECTION AND REACTION STRATEGY DESCRIBED IN TOYOTA?S TECHNICAL DOCUMENTS INDICATES THAT A LOSS OF THROTTLE CONTROL DUE TO A COMPONENT OR SYSTEM FAILURE WOULD BE DETECTED WITHIN A ONE SECOND PERIODAFTER WHICH ENGINE POWER WOULD BE LIMITED. THE PETITIONER?S MY 2006 VEHICLE BRAKE SYSTEM OVERCOMES FULL ENGINE POWER AT EASILY ACHIEVABLE BRAKE PEDAL FORCES. BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY?S SAFETY MISSION, THE PETITION IS DENIED.PLEASE SEE THE MARCH 9, 2007 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS.
DP05002 · Vehicle Speed Control
Opened Aug 5, 2005 · Closed Jan 5, 2006
Status: closed (inferred from source dates) · Vehicle Speed Control
IN A LETTER DATED JULY 8, 2005, AND AFTER EXPERIENCING TWO INCIDENTS (AND ONE CRASH) WHERE HE ALLEGES HIS MODEL YEAR (MY) 2002 CAMRY ACCELERATED WITHOUT DRIVER INPUT, MR. JORDAN ZIPRIN PETITIONED THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION?S (NHTSA) OFFICE OF DEFECTS INVESTIGATION (ODI) TO COMMENCE A PROCEEDING TO DETERMINE THE EXISTENCE OF A DEFECT WITHIN THE ETC SYSTEM IN MY 2002 TO 2005 TOYOTA AND LEXUS VEHICLES, OR TO REOPEN A PRIOR INVESTIGATION PRELIMINARY EVALUATION (PE) 04-021.IN A LETTER DATED AUGUST 18, 2005, MR. ZIPRIN AMENDED HIS PETITION TO INCLUDE ALLEGATIONS OF INTERRELATED BRAKE AND ACCELERATION PROBLEMS THAT ALLEGEDLY RESULT IN INAPPROPRIATE AND UNCONTROLLABLE VEHICLE ACCELERATIONS.THE 1172 VEHICLE OWNER QUESTIONNAIRE REPORTS CITED BY THE PETITIONER INVOLVE 4 LEXUS AND 15 TOYOTA MODELS DEFINING A POPULATION OF 7 MILLION VEHICLES.THE REPORTS TYPICALLY ALLEGED A DEFECT IN THE BRAKE SYSTEM, THE THROTTLE CONTROL SYSTEM, OR A COMBINATION OF BOTH SYSTEMS.IN ITS REVIEW OF THE REPORTS, ODI A) FAILED TO FIND EVIDENCE TO SUPPORT THE EXISTENCE OF A BRAKE RELATED DEFECT IN THE CITED MODELS, AND B) DETERMINED THAT MANY CITED PRODUCTS WERE NOT EQUIPPED WITH ETC.ACCORDINGLY, ODI RESTRICTED ITS ANALYSIS TO THE 432 PETITIONER REPORTS INVOLVING MY 2002 TO 2005 CAMRY, SOLARA, AND ES MODELS (ALL EQUIPPED WITH ETC) THAT ALLEGED AN ABNORMAL THROTTLE CONTROL EVENT (SEE THE JANUARY 3, 2006 FEDERAL REGISTER NOTICE FOR FURTHER DETAILS).ABOUT 40% OF THE 432 REPORTS INVOLVE A DRIVEABILITY CONCERN WHERE THE OPERATOR INTENTIONALLY APPLIES THE THROTTLE PEDAL, IN EXPECTATION THAT THE VEHICLE WILL ACCELERATE, AND THEN EXPERIENCES A DELAY OR HESITATION IN VEHICLE RESPONSE.THESE REPORTS INVOLVE VEHICLE RESPONSE TO INTENTIONAL DRIVER COMMANDS WHICH ODI CONSIDERS UNRELATED TO THE ALLEGATIONS RAISED BY THE PETITIONER.THEREFORE, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED.ABOUT 20% OF THE REPORTS INVOLVE INCIDENTS WHERE OPERATORS ALLEGE VEHICLE ACCELERATION WITHOUT DRIVER INPUT AND AN INABILITY OF THE BRAKE SYSTEM TO CONTROL THE VEHICLE WHEN APPLIED.NEITHER THE REPORTS, NOR THE INTERVIEWS CONDUCTED BY ODI, IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE INCIDENTS OR DISCLOSED EVIDENCE TO SUPPORT THAT A FAILURE OF THE BRAKE OR THROTTLE CONTROL SYSTEM HAD OCCURRED.BECAUSE THESE REPORTS DO NOT INDICATE A DISTINCT SAFETY DEFECT FOR INVESTIGATION, THE REPORTS DO NOT PROVIDE SUPPORT FOR THE INVESTIGATION REQUESTED BY THE PETITIONERTHE REMAINING REPORTS (~ 40%, SIMILAR TO THE PETITIONER?S AND THOSE OF PE04-021) TYPICALLY DESCRIBE INCIDENTS WHERE A VEHICLE IS BEING MANEUVERED AT SLOW SPEED IN A CLOSE QUARTER SITUATION AT WHICH POINT THE OPERATOR ALLEGES THAT THE VEHICLE ACCELERATES WITHOUT DRIVER INPUT AND CRASHES.IN THE AFTERMATH, OPERATORS ARE UNSURE OF WHETHER THE BRAKES WERE APPLIED OR NOT, SOMETIMES STATING THERE WAS INSUFFICIENT TIME TO USE THE BRAKE; A CRASH OCCURRED AND THE OPERATOR BELIEVES AN UNCOMMANDED ACCELERATION CAUSED IT.IN SPITE OF THE EFFORT EXPENDED DURING PE04-021 AND DURING THIS ANALYSIS, ODI HAS NOT IDENTIFIED ANY VEHICLE-BASED CAUSE TO EXPLAIN THE REPORTS, OR UNCOVERED ANY EVIDENCE TO INDICATE THAT A THROTTLE CONTROL SYSTEM FAILURE OCCURRED.THEREFORE, THE REPORTS HAVE AMBIGUOUS SIGNIFICANCE AND DO NOT CONSTITUTE A BASIS ON WHICH ANY FURTHER INVESTIGATIVE ACTION IS WARRANTED.BASED ON THE ANALYSIS CONDUCTED, IT IS UNLIKELY THAT THE NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION AND REMEDY OF A SAFETY RELATED DEFECT AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.CONSEQUENTLY, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE NHTSA?S LIMITED RESOURCES T
PE04021 · Throttle Control System
Opened Mar 3, 2004 · Closed Jul 22, 2004
Status: closed (inferred from source dates) · Vehicle Speed Control
THE LEXUS MODELS WERE THE SUBJECT OF DEFECT PETITION (DP) 04-003.TWELVE ODI COMPLAINTS ARE DUPLICATIVE TO TOYOTA REPORTS, INCLUDING THE TWO MINOR CRASHES.THE V6 EQUIPPED SOLARA MODELS HAVE BEEN EXCLUDED BECAUSE THEY DO NOT CONTAIN THE SUBJECT THROTTLE CONTROL SYSTEM.TOYOTA INTRODUCED ELECTRONIC THROTTLE CONTROL (ETC) ON THE SUBJECT VEHICLES BEGINNING IN MODEL YEAR (MY) 2002.ODI OPENED THE INVESTIGATION TO DETERMINE IF THE SYSTEM COULD BE THE CAUSE OF COMPLAINTS ALLEGING THE ENGINE SPEED INCREASED, OR FAILED TO DECREASE, (FOR A SHORT DURATION) WHEN THE ACCELERATOR PEDAL WAS NOT DEPRESSED (THE ALLEGED DEFECT).DURING THE COURSE OF THE INVESTIGATION, ODI ANALYZED AGENCY DATA AND REVIEWED VEHICLE OWNER QUESTIONNAIRE (VOQ) REPORTS, CONDUCTED INTERVIEWS INVOLVING 113 VOQ AND 36 TOYOTA REPORTS, INSPECTED TWO COMPLAINANT VEHICLES, REVIEWED RELEVANT TOYOTA SERVICE AND NEW CAR FEATURE DOCUMENTATION, REVIEWED AND ANALYZED TOYOTA?S RESPONSES TO ODI?S INFORMATION REQUEST LETTER, CONDUCTED A LIMITED CONTROL PEDAL ASSESSMENT, AND ATTENDED A TOYOTA TECHNICAL PRESENTATION THAT INCLUDED THE ASSESSMENT OF TWO DEMONSTRATION VEHICLES.THROUGH INTERVIEWS, ODI IDENTIFIED 14 VOQ AND 6 TOYOTA REPORTS (20 UNIQUE VEHICLES) WHERE COMPLAINANTS REPORT MULTIPLE OCCURRENCES OF THE ALLEGED DEFECT.IN SOME CASES THE CONDITION WAS EXPERIENCED BY DIFFERENT VEHICLE OPERATORS OR WAS WITNESSED BY OTHER OCCUPANTS.ODI WAS UNABLE TO MAKE A DETERMINATION AS TO THE CAUSE OF 9 TOYOTA AND AN ADDITIONAL 37 VOQ REPORTS (WHICH DESCRIBE 28 UNIQUE INCIDENTS) DUE TO INSUFFICIENT INFORMATION.THE REMAINING COMPLAINANTS INTERVIEWED (62 VOQ, 21 TOYOTA) DESCRIBED CONDITIONS NOT CAUSED BY A FAILURE OF THE THROTTLE CONTROL SYSTEM AND WERE THUS CONSIDERED UNRELATED TO THE INVESTIGATION.NONE OF THE COMPLAINANTS INTERVIEWED REPORTED A COMPONENT FAILURE (OR OTHER INDICATOR OF A SYSTEM FAILURE) AS THE POTENTIAL CAUSE OF INCIDENTS RELEVANT TO THIS INVESTIGATION.IN MANY CASES, THE COMPLAINT VEHICLES WERE SUBSEQUENTLY INSPECTED BY DEALERSHIP OR MANUFACTURER REPRESENTATIVES WHO ALSO FAILED TO IDENTIFY A FAULT WITHIN THE VEHICLE.TOYOTA IDENTIFIED 43 RELATED WARRANTY CLAIMS, 24 OF WHICH WERE FOR DIAGNOSTIC PURPOSES ONLY (NO REPAIRS PERFORMED).ODI FOUND NOTHING ABNORMAL IN THE CONTROL PEDAL CONFIGURATION OF THE SUBJECT VEHICLES.A DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE THE ATTACHED SUMMARY FOR FURTHER DETAIL.
PE02079 · Engine Compartment Fire
Opened Oct 22, 2002 · Closed Mar 18, 2003
Status: closed (inferred from source dates) · Engine And Engine Cooling
ODI'S DATA ANALYSIS FOUND THE FIRES RATES TO BE CONSISTENTLY LOW AND EVENLY DISTRIBUTED AMONG SIX MODEL YEARS AND SIX DIFFERENT ENGINE CONFIGURATIONS.ODI EXAMINED A VARIETY OF ROOT CAUSES, THOSE BEING DETONATION (RESULTING IN OIL PAN PUNCTURE FROM CONNECTING ROD), STARTER FIRES, VARIOUS FUEL RELATED FIRES, LEAKING OIL FILTERS, WIRING ISSUES, IMPROPER REPAIRS AND BRAKE FLUID LEAKS.NONE OF THE ISSUES EXAMINED HAD REPORTS THAT INDICATED A TREND WHEN NORMALIZED FOR POPULATON AND EXPOSURE.SEE ATTACHED REPORT FOR FULL DETAILS.
Illustration