← New search

2007 Toyota Camry Hybrid

Owner reports · Recalls · Investigations

Limited comparison data

There is not enough comparable history to draw a useful model-year comparison.

About this comparison →

When problems were reported

Mileage at the reported incident

543 reports with mileage · 59 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Service Brakes. Review the 391 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Vehicle Speed Control. Review the 160 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electronic Stability Control (esc). Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

31 crash reports7 fire reports14 injury reports

What owners actually said

602 reports
46,000 miles · Mar 6, 2011
Hybrid Propulsion System

HYBRID BATTERY DOESN'T TURN ON IF VEHICLE IS NOT TURNED ON WITHIN A WEEK. WHEN I TURN THE HEATER ON, INSIDE THE CAR SMELLS LIKE ROTTEN. IN ADDITION, THE ACCELERATOR PEDAL NEEDS TO BE REPLACED, RECEIVED LETTER FROM TOYOTA COMPANY TO MAKE AN APPOINTMENT TO HAVE IT REPLACED. *TR

NHTSA ODI #10386589

77,000 miles · Feb 27, 2011
Visibility

WE HAVE A 2007 TOYOTA CAMRY HYBRID. FOR NO REASON THE DRIVERS SIDE SUN VISOR FLOPS DOWN CAUSING A VISIBILITY HAZARD. DEALER CLAIMS THIS IS RARE, INTERNET SHOWS OTHERWISE. REPAIR COSTS $140 FOR REPLACEMENT. I FEEL POOR MANUFACTURER DESIGN AS THERE IS NOTHING BROKEN. I ALSO FEEL IT SHOULD BE RECALLED. THIS IS MY 19TH VEHICLE AND I…

Read full complaint

WE HAVE A 2007 TOYOTA CAMRY HYBRID. FOR NO REASON THE DRIVERS SIDE SUN VISOR FLOPS DOWN CAUSING A VISIBILITY HAZARD. DEALER CLAIMS THIS IS RARE, INTERNET SHOWS OTHERWISE. REPAIR COSTS $140 FOR REPLACEMENT. I FEEL POOR MANUFACTURER DESIGN AS THERE IS NOTHING BROKEN. I ALSO FEEL IT SHOULD BE RECALLED. THIS IS MY 19TH VEHICLE AND I HAVE NEVER HAD A SUN VISOR ISSUE. THANKS FOR YOUR TIME. *TR

NHTSA ODI #10384674

27,217 miles · Feb 11, 2011
Service Brakes, Hydraulic

TL* THE CONTACT OWNS A 2007 CAMRY HYBRID. THE CONTACT WAS DRIVING 65 MPH WHEN THE BRAKE WARNING, VEHICLE STABILITY CONTROL WARNING AND SYSTEM CONTROL WARNING LIGHTS ILLUMINATED, CAUSING AN ABNORMAL INCREASE IN STOPPING DISTANCE. THE CONTACT BROUGHT THE VEHICLE TO A STOP FOR A FEW MOMENTS AND AS HE RESUMED DRIVING, THE WARNING LI…

Read full complaint

TL* THE CONTACT OWNS A 2007 CAMRY HYBRID. THE CONTACT WAS DRIVING 65 MPH WHEN THE BRAKE WARNING, VEHICLE STABILITY CONTROL WARNING AND SYSTEM CONTROL WARNING LIGHTS ILLUMINATED, CAUSING AN ABNORMAL INCREASE IN STOPPING DISTANCE. THE CONTACT BROUGHT THE VEHICLE TO A STOP FOR A FEW MOMENTS AND AS HE RESUMED DRIVING, THE WARNING LIGHTS WERE NO LONGER ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE A DIAGNOSTIC TEST WAS PERFORMED BUT DID NOT PRODUCE ANY FAILURE CODES. THE DEALER ALSO TEST DROVE THE VEHICLE, BUT WAS UNABLE TO DUPLICATE THE FAILURE. THE FAILURE MILEAGE WAS 27,217 AND THE CURRENT MILEAGE WAS 27,300.

NHTSA ODI #10381553

70,000 miles · Jan 25, 2011
Visibility

HELLO, I HAVE A 2007 TOYOTA CAMRY HYBRID. THE DRIVERS SIDE SUN VISOR WILL FLOP DOWN UNEXPECTEDLY CAUSING A VISIBILITY ISSUE. THE DEALER WANTS $120 TO REPLACE. TOYOTA SAYS IT IS NOT COMMON AND NO RECALL IS NEEDED. I HAVE READ NUMEROUS COMPLAINTS ON VARIOUS FORUMS AND THINK A SAFETY ISSUE IS PRESENT. *TR

NHTSA ODI #10378595

54,000 miles · Jan 4, 2011
Vehicle Speed ControlCrash

TL*THE CONTACT OWNS A 2007 TOYOTA CAMRY HV. WHILE DRIVING 2 MPH, THE CONTACT HEARD A LOUD ROARING SOUND AND THE VEHICLE ACCELERATED. THE VEHICLE STOPPED WHEN IT CRASHED INTO A TREE. THERE WERE NO INJURIES. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT STATED THAT THE MANUFACTURER WOULD INSPECT THE VEHICLE JANUARY 17, 2011. THE …

Read full complaint

TL*THE CONTACT OWNS A 2007 TOYOTA CAMRY HV. WHILE DRIVING 2 MPH, THE CONTACT HEARD A LOUD ROARING SOUND AND THE VEHICLE ACCELERATED. THE VEHICLE STOPPED WHEN IT CRASHED INTO A TREE. THERE WERE NO INJURIES. THE VEHICLE HAD NOT BEEN REPAIRED. THE CONTACT STATED THAT THE MANUFACTURER WOULD INSPECT THE VEHICLE JANUARY 17, 2011. THE CONTACT STATED BOTH RECALLS 09V388000 AND 10V017000 (VEHICLE SPEED CONTROL: ACCELERATOR PEDAL) WERE PERFORMED IN 2010. THE FAILURE MILEAGE WAS APPROXIMATELY 54,000.

NHTSA ODI #10374617

70,000 miles · Dec 31, 2010
Engine And Engine Cooling

I PURCHASED A NEW 2007 TOYOTA CAMRY HYBRID IN 2007. ABOUT A MONTH AGO, MY WATER PUMP STARTED TO LEAK. THIS WAS UNUSUAL BECAUSE CARS THAT I PREVIOUSLY OWNED, THE WATER PUMPS LASTED FOR MUCH LONGER THAN 3 YRS. RECENTLY, I FOUND OUT THAT TOYOTA HAD DID A NATIONAL RECALL ON 2004-2007 PRIUS HYBRID MODELS FOR WATER PUMPS THAT LEAKE…

Read full complaint

I PURCHASED A NEW 2007 TOYOTA CAMRY HYBRID IN 2007. ABOUT A MONTH AGO, MY WATER PUMP STARTED TO LEAK. THIS WAS UNUSUAL BECAUSE CARS THAT I PREVIOUSLY OWNED, THE WATER PUMPS LASTED FOR MUCH LONGER THAN 3 YRS. RECENTLY, I FOUND OUT THAT TOYOTA HAD DID A NATIONAL RECALL ON 2004-2007 PRIUS HYBRID MODELS FOR WATER PUMPS THAT LEAKED. SO TODAY, I CHECKED ON ONLINE FORUMS, AND I FOUND OUT THAT MANY OWNERS WITH THE 2007 TOYOTA CAMRY HYBRIDS HAD ALSO HAD ISSUES WITH LEAKING OF THEIR WATER PUMPS, AND HAD TO HAVE THEM REPLACED. I HAD TO SPEND $750 TO HAVE MINES REPLACED AT THE DEALERSHIP. PLEASE INVESTIGATE! *TR

NHTSA ODI #10373586

52,000 miles · Dec 29, 2010
Visibility

DRIVERS SIDE SUN VISOR SUDDENLY BROKE, OBSTRUCTING VIEW WHILE DRIVING. THE VISOR WILL NO LONGER RETURN TO THE UPRIGHT POSITION AND FLOPS TOWARD THE DRIVER. I AM AFRAID IN AN ACCIDENT I MIGHT SLAM MY HEAD DIRECTLY INTO THE SUN VISOR, SO I THINK THIS IS A SERIOUS SAFETY HAZARD. CONTACTED THE DEALER, AND THEY WANT $260 TO REPLACE W…

Read full complaint

DRIVERS SIDE SUN VISOR SUDDENLY BROKE, OBSTRUCTING VIEW WHILE DRIVING. THE VISOR WILL NO LONGER RETURN TO THE UPRIGHT POSITION AND FLOPS TOWARD THE DRIVER. I AM AFRAID IN AN ACCIDENT I MIGHT SLAM MY HEAD DIRECTLY INTO THE SUN VISOR, SO I THINK THIS IS A SERIOUS SAFETY HAZARD. CONTACTED THE DEALER, AND THEY WANT $260 TO REPLACE WITH THE SAME VISOR. LOOKING ONLINE, THIS APPEARS TO BE A COMMON PROBLEM, AND I SHOULD EXPECT THE REPLACEMENT TO BREAK AS WELL, INCLUDING THE PASSENGER SIDE EVENTUALLY. PLEASE ASK FOR A SAFETY RECALL BEFORE SOMEONE GETS HURT! IN THE MEANTIME I INTEND TO REMOVE THE VISOR AND JUST DRIVE WITHOUT ONE AS THERE IS NO SAFE REPLACEMENT AVAILABLE AND TOYOTA HAS NOT ADDRESSED THE ISSUE DESPITE NUMEROUS COMPLAINTS ONLINE. JUST GOOGLE TOYOTA SUN VISOR PROBLEM AND YOU WILL SEE SEVERAL MODELS WITH THIS MANUFACTURING DEFECT. *TR

NHTSA ODI #10373372

40,000 miles · Dec 25, 2010
Traction Control System

IT HAPPENED ON A WINTER DAY WITH LIGHT SNOWING. THE GROUND TEMPERATURE WAS BELOW FREEZING POINT. THE SNOW LAYER WAS THIN, BARELY SEVERAL MILLIMETERS, NO ICE UNDER IT. I MADE A RIGHT TURN AFTER A FULL STOP AT A STOP SIGN. THE ROAD WAS UPHILL, WITH A STEEP SLOPE. WHEN CLIMBING ONTO THE HILL, MY DRIVING WHEELS WERE SUDDENLY …

Read full complaint

IT HAPPENED ON A WINTER DAY WITH LIGHT SNOWING. THE GROUND TEMPERATURE WAS BELOW FREEZING POINT. THE SNOW LAYER WAS THIN, BARELY SEVERAL MILLIMETERS, NO ICE UNDER IT. I MADE A RIGHT TURN AFTER A FULL STOP AT A STOP SIGN. THE ROAD WAS UPHILL, WITH A STEEP SLOPE. WHEN CLIMBING ONTO THE HILL, MY DRIVING WHEELS WERE SUDDENLY STOPPED BY THE TRACTION CONTROL SYSTEM, DID NOT REINGAGE, AND MY CAR STARTED TO DECELERATE AND THEN COMPLETELY STOPPED. A LARGE TRUCK WAS DRIVING BEHIND ME AT A VERY CLOSE DISTANCE. ITS DRIVER COULD NOT IMAGINE THAT MY CAR WOULD SUDDENLY STOP IN THE MIDDLE OF THE SLOPE WITHOUT ANY GOOD REASON. ONLY THANKS TO HIS GREAT SKILL AND REACTION THE COLLISION HAS BEEN AVOIDED. THE TRACTION CONTROL SYSTEM PREVENTS USING MY CAR EVEN WITH THE LIGHTEST SNOW DUSTING ON THE GROUND. WITH ANY NORMAL CAR, THE WHEELS MAKE A TURN, CUT THROUGH THE SNOW, REACH THE PAVEMENT, AND GET GRIP. ON THE CONTRARY, MY TOYOTA IS UNCONTROLLABLE EVEN WITH THE LIGHTEST SNOW DUSTING AND GENERATES MULTIPLE PROBLEMS FOR ME IN THE NEW ENGLAND CLIMATE. I FAILED TO FIND IN THE MANUAL THE INSTRUCTION HOW TO DISABLE THE TRACTION CONTROL. A MECHANIC AT TOYOTA SERVICE STATION TOLD ME THAT IT IS IMPOSSIBLE TO DISABLE THE TRACTION CONTROL IN TOYOTAS FOR SOFTWARE REASONS. I THINK THAT THE ABILITY TO DISABLE A TRACTION CONTROL SYSTEM MUST BE MANDATORY. OTHERWISE, IN THE SNOWING CONDITIONS IT IS IMPOSSIBLE TO START THE CAR MOVING AFTER A STOP, SAY, IN FRONT OF A LIGHT. *TR

NHTSA ODI #10372375

143,000 miles · Dec 15, 2010
Service Brakes, Hydraulic

TL*THE CONTACT OWNS A 2007 CAMRY HYBRID. THE CONTACT STATED THAT WHILE DRIVING 35 MPH THE CHECK VSC, BRAKE AND ABS LIGHT CAME ON AND THE VEHICLE BECAME DIFFICULT TO STOP WHEN THE BRAKES WERE ENGAGED. AFTER SEVERAL ATTEMPTS, THE CONTACT WAS ABLE TO STOP THE VEHICLE AND SHUT IT OFF. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE …

Read full complaint

TL*THE CONTACT OWNS A 2007 CAMRY HYBRID. THE CONTACT STATED THAT WHILE DRIVING 35 MPH THE CHECK VSC, BRAKE AND ABS LIGHT CAME ON AND THE VEHICLE BECAME DIFFICULT TO STOP WHEN THE BRAKES WERE ENGAGED. AFTER SEVERAL ATTEMPTS, THE CONTACT WAS ABLE TO STOP THE VEHICLE AND SHUT IT OFF. THE CONTACT HAD NOT TAKEN THE VEHICLE TO THE DEALER NOR THE MANUFACTURER REGARDING THE BRAKING SYSTEM. THE CONTACT STATED THAT A CRASH COULD HAVE OCCURRED DUE TO THE BRAKES MALFUNCTIONING. THE FAILURE MILEAGE WAS 143,000.

NHTSA ODI #10370823

38,147 miles · Nov 2, 2010
Vehicle Speed ControlCrash

TL* THE CONTACT OWNS A 2007 TOYOTA CAMRY HYBRID. THE CONTACT WAS BRAKING FROM 25 MPH AND APPROACHING A STOP SIGN WHEN THE VEHICLE ABNORMALLY ACCELERATED. THE CONTACT ENGAGED THE BRAKES WITH MORE EXTREME FORCE YET THE VEHICLE CONTINUED TO ACCELERATE AND CRASHED INTO ANOTHER VEHICLE. THERE WERE NO INJURIES. A POLICE REPORT WAS …

Read full complaint

TL* THE CONTACT OWNS A 2007 TOYOTA CAMRY HYBRID. THE CONTACT WAS BRAKING FROM 25 MPH AND APPROACHING A STOP SIGN WHEN THE VEHICLE ABNORMALLY ACCELERATED. THE CONTACT ENGAGED THE BRAKES WITH MORE EXTREME FORCE YET THE VEHICLE CONTINUED TO ACCELERATE AND CRASHED INTO ANOTHER VEHICLE. THERE WERE NO INJURIES. A POLICE REPORT WAS AVAILABLE. THE VEHICLE SUSTAINED DAMAGES TO THE DRIVER SIDE OF HER VEHICLE. THE VEHICLE WAS REPAIRED. THE FAILURE MILEAGE WAS 38,147 AND THE CURRENT MILEAGE WAS 38,247. UPDATED 01/13/11*LJ UPDATED 01/27/11.

NHTSA ODI #10363766

Official recalls

3

15V689000 · Visibility:power Window Devices And Controls

Oct 22, 2015

Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.

Consequence & remedy

Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.

Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.

12V491000 · Visibility:power Window Devices And Controls

Oct 10, 2012

Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.

Consequence & remedy

Consequence: If the switch overheats, it may melt, possibly resulting in a fire.

Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.

09V388000 · Vehicle Speed Control:accelerator Pedal

Oct 5, 2009

TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.

Consequence & remedy

Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.

Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

4

DP22005 · Pedestrian Alert Sounds

Opened Jan 27, 2023 · Closed Aug 7, 2023

Status: closed (inferred from source dates) · Electrical System:propulsion System

NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.

PE14001 · Brake Actuator Malfunction

Opened Jan 23, 2014 · Closed Aug 22, 2014

Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Air:supply:reservoir/tank; Service Brakes, Electric; Service Brakes, Hydraulic:power Assist

On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.

Additional source detail variants (4)

Service Brakes, Air:supply:reservoir/tank

On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.

Service Brakes, Electric

On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.

Service Brakes, Hydraulic:power Assist

On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.

Service Brakes

On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.

EA12006 · Power Window Master Switch Fire

Opened Jun 14, 2012 · Closed Feb 12, 2013

Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other

On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.

Additional source detail variants (3)

Electrical System

On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.

Structure:body

On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.

Unknown Or Other

On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.

PE12002 · Power Window Master Switch Fire

Opened Feb 6, 2012 · Closed Jun 14, 2012

Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other

ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.

Additional source detail variants (3)

Electrical System

ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.

Structure:body

ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.

Unknown Or Other

ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.