IllustrationWAS DRIVING, AND HYBRID SYSTEM CHECK LIGHT CAME ON...CONTINUED DRIVING SLOWLY THEN CAR LOST A BIT OF POWER..LIKE PARKING BREAK WAS ON AND VCS FAILURE LIGHT CAME ON. DROVE HOME AFTER WITH HYBRID SYSTEM CHECK STILL ON.
2007 Toyota Camry Hybrid
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Camry Hybrid years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
350–25K
5325–50K
8650–75K
11975–100K
169100–150K
81150K+
543 reports with mileage · 59 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Service Brakes. Review the 391 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 160 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electronic Stability Control (esc). Review the 115 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
31 crash reports7 fire reports14 injury reports
Electrical System complaints
46 reportsTL* THE CONTACT OWNS A 2007 TOYOTA CAMRY HYBRID. THE CONTACT RECEIVED NOTIFICATION FROM THE MANUFACTURER FOR A SERVICE CAMPAIGN TO ADDRESS THE INTERNAL MALFUNCTION OF THE BRAKE ACTUATOR ASSEMBLY. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN THREE TIMES FOR DIAGNOSTIC TESTING. THE DEALER WAS NOT ABLE TO REMEDY THE FAILURE WITH T…
Read full complaint
TL* THE CONTACT OWNS A 2007 TOYOTA CAMRY HYBRID. THE CONTACT RECEIVED NOTIFICATION FROM THE MANUFACTURER FOR A SERVICE CAMPAIGN TO ADDRESS THE INTERNAL MALFUNCTION OF THE BRAKE ACTUATOR ASSEMBLY. THE VEHICLE WAS TAKEN TO THE DEALER MORE THAN THREE TIMES FOR DIAGNOSTIC TESTING. THE DEALER WAS NOT ABLE TO REMEDY THE FAILURE WITH THE MANUFACTURER'S SERVICE CAMPAIGN ZE1. AFTER THE REPAIR, THE SERVICE ENGINE SOON WARNING LIGHT, ABS WARNING LIGHT, TRACTION CONTROL WARNING LIGHT, AND SLIP INDICATOR CONTINUED TO RANDOMLY FLASH AND REMAINED ILLUMINATED. THE CONTACT ALSO STATED THAT THE PUSH BUTTON START WOULD NOT PROPERLY FUNCTION INTERMITTENTLY AND THE CONTACT WAS NOT ABLE TO START THE VEHICLE NUMEROUS TIMES WITHOUT WARNING. THE MANUFACTURER WAS ALSO NOTIFIED SEVERAL TIMES THAT THE SERVICE CAMPAIGN DID NOT PREVENT THE FAILURE FROM OCCURRING. THE VEHICLE WAS TO BE TAKEN BACK TO THE DEALER FOR FURTHER TESTING. THE CONTACT WAS WAITING ON INSTRUCTIONS FROM THE MANUFACTURER TO PROVIDE A PERMANENT REMEDY FOR THE CONDITION TO ADDRESS THE FAILURE AND RECEIVED NO RESOLUTION. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 126,355.
THE HYBRID BATTERY OVERHEATED ACCORDING THE MECHANIC AT THE DEALERSHIP. THE MECHANIC STATED THAT OTHER HYBRID BATTERIES HAVE HAD THE SAME PROBLEM BECAUSE OF A DEFECTIVE FILTER AT THE FRONT OF THE CAR, WHICH ALLOWS DEBRIS AND DIRT TO GET INTO THE COMPARTMENT THAT HOUSES THE HYBRID BATTERY. IT IS A $3,900 COST TO REPLACE THE HYDRI…
Read full complaint
THE HYBRID BATTERY OVERHEATED ACCORDING THE MECHANIC AT THE DEALERSHIP. THE MECHANIC STATED THAT OTHER HYBRID BATTERIES HAVE HAD THE SAME PROBLEM BECAUSE OF A DEFECTIVE FILTER AT THE FRONT OF THE CAR, WHICH ALLOWS DEBRIS AND DIRT TO GET INTO THE COMPARTMENT THAT HOUSES THE HYBRID BATTERY. IT IS A $3,900 COST TO REPLACE THE HYDRID BATTERY SINCE IT IS NO LONGER UNDER WARRANTY WITH 200,000 MILES ON THE CAR. THE MECHANIC STATED THAT TOYOTA HAD MODIFIED THE NEW FILTER TO STOP THE DEBRIS AND OVERHEATING PROBLEM, AND THAT THE NEW FILTER WOULD NOT ALLOW DEBRIS IN. SINCE TOYOTA WAS AWARE OF THE FILTER ALLOWING DEBRIS INTO THE HYDRID BATTERY DEPARTMENT, AND MODIFIED THE NEW FILTER TO RESOLVE THE PROBLEM WHY WAS I NOT NOTIFIED TO REPLACE THE FILTER BEFORE IT ALLOWED THE BATTERY TO OVERHEAT THE HYBRID BATTERY TO BE DESTROYED?
THE HYBRID BATTERY OVERHEATED ACCORDING TO THE SHOP OF THE DEALER. ACCORDING TO THE MECHANIC THIS IS NOT A NEW PROBLEM WITH THE CAR. THE WARRANTY IS 8 YEARS OR 100,000 MILES ON HYBRID BATTERY. THE MECHANIC STATED THAT THE FRONT FILTER ALLOWS DIRT INTO THE HYBRID BATTERY COMPARTMENT, WHICH RESULTS IN THE OVERHEATING. IT IS A $3,9…
Read full complaint
THE HYBRID BATTERY OVERHEATED ACCORDING TO THE SHOP OF THE DEALER. ACCORDING TO THE MECHANIC THIS IS NOT A NEW PROBLEM WITH THE CAR. THE WARRANTY IS 8 YEARS OR 100,000 MILES ON HYBRID BATTERY. THE MECHANIC STATED THAT THE FRONT FILTER ALLOWS DIRT INTO THE HYBRID BATTERY COMPARTMENT, WHICH RESULTS IN THE OVERHEATING. IT IS A $3,900.00 COST TO REPLACE THE HYBRID BATTERY. THE MECHANIC ALSO STATES THAT THE NEW FILTER HAS BEEN MODIFIED IN ORDER TO NOT ALLOW THE DEBRIS TO GET INTO THE HYBRID BATTERY. IF TOYOTA WAS AWARE TO THE POINT OF MODIFYING THE FILTER IN ORDER TO PREVENT THE DEBRIS FROM GETTING INTO THE HYBRID BATTERY AREA WHY DIDN'T THEY TELL ME THAT THE FILTER WAS DEFECTIVE AND NEEDED REPLACED TO PROTECT THE HYBRID BATTERY?
SUDDENLY,THE CHECK VSC SYSTEM WENT ON FOR NO REASON.I BELIEVE THAT TOYOTA IS TO BLAME FOR THE CONDITION BECAUSE THE CAR IS FAILING PREMATURELY.TOYOTA SHOULD RECALL THE 2007 CAMRY HYBRID IMMEDIATELY BECAUSE THIS CAN CAUSE DANGER TO THE OCCUPANTS IN THE CAR AS WELL AS PEDESTRIANS ALIKE. *TR
BRAKE ALERT LIGHTS APPEARED ON DASH ON NIGHT OF 9/5/14 UPON STARTING THE VEHICLE. READ CODES IN OWNER'S MANUAL, AND DROVE FEW BLOCKS TO HOME AT SLOW SPEED (15 MPH). ON SATURDAY MORNING, 9/6/14, THE INCIDENT OCCURRED AGAIN WHEN I WAS DRIVING AT ABOUT 25-30 MILES PER HOUR. NOT ONLY DID THE ALERT LIGHTS APPEAR, BUT THE BRAK…
Read full complaint
BRAKE ALERT LIGHTS APPEARED ON DASH ON NIGHT OF 9/5/14 UPON STARTING THE VEHICLE. READ CODES IN OWNER'S MANUAL, AND DROVE FEW BLOCKS TO HOME AT SLOW SPEED (15 MPH). ON SATURDAY MORNING, 9/6/14, THE INCIDENT OCCURRED AGAIN WHEN I WAS DRIVING AT ABOUT 25-30 MILES PER HOUR. NOT ONLY DID THE ALERT LIGHTS APPEAR, BUT THE BRAKES "BLED" THROUGH TO THE FLOOR, AND IT FELT AS IF THE CAR ACCELERATED. BRAKES WORKED ONLY AFTER PUMPING THE BRAKE PEDAL. I HAD THE VEHICLE TOWED TO SERVICE CENTER. AFTER DIAGNOSTICS AND DRIVING FOR 90 MILES OVER 4 DAYS, THE INCIDENT COULD NOT BE REPLICATED, NOR DID ANY CODES APPEAR ON THE COMPUTER. VEHICLE WAS RELEASED AFTER PAYING DIAGNOSTIC FEES. THE INCIDENT OCCURRED AGAIN ON 10/2/14: BRAKE LIGHTS APPEARED ON DASH, THE CAR FELT IT WAS ACCELERATING, AND THE BRAKES FAILED TEMPORARILY. MY FOOT BLED THROUGH, I PUMPED THE PEDAL BEFORE BRAKES BEGAN TO WORK. THE VEHICLE WAS TOWED TO DEALERSHIP. AGAIN, DIAGNOSTICS DID NOT REVEAL CODES NOR WAS THE INCIDENT ABLE TO BE REPLICATED. DEALERSHIP REPLACED THE BRAKE FLUID RESERVOIR ACCORDING TO TOYOTA CORPORATE DIRECTIONS. FOUND INFO ONLINE THAT NHTSA CITED 59 COMPLAINTS OF BRAKE FAILURE FOR 2007-08 CAMRY HYBRIDS. REPORTED THESE INCIDENTS TO TOYOTA CORPORATE, WHO ASSIGNED A CASE NO. HAVE NOT HEARD FROM CORPORATE CASE MGR. YET, BUT EXPECT TO BY MONDAY, 10/06/14. CORPORATE SAID THEY DO NOT OFFER A LOANER VEHICLE WHILE THIS IS BEING ADDRESSED, BUT TO ASK DEALERSHIP. DEALERSHIP SAID THEY COULD NOT PROVIDE A LOANER VEHICLE. *TR
I WAS DRIVING FROM WORK ON THE FREEWAY WHEN ALL OF A SUDDEN ALL MY LIGHTS ON MY DASHBOARD POPPED UP, I LOST TRACTION CONTROL, AND THE NOTIFICATION PANEL STARTED BEEPING CHECK HYBRID SYSTEM AND CHECK VSC SYSTEM. A FEW DAYS LATER THE VSC WENT AWAY AND THEN CAME BACK SO I TOOK IT TO A DEALER SHIP WHERE THEY SPENT 5 HOURS LOOKING OV…
Read full complaint
I WAS DRIVING FROM WORK ON THE FREEWAY WHEN ALL OF A SUDDEN ALL MY LIGHTS ON MY DASHBOARD POPPED UP, I LOST TRACTION CONTROL, AND THE NOTIFICATION PANEL STARTED BEEPING CHECK HYBRID SYSTEM AND CHECK VSC SYSTEM. A FEW DAYS LATER THE VSC WENT AWAY AND THEN CAME BACK SO I TOOK IT TO A DEALER SHIP WHERE THEY SPENT 5 HOURS LOOKING OVER MY CAR AND COULDN'T TELL ME WHAT WAS WRONG OTHER THEN A MONITORING SYSTEM IS BAD OR THE BATTERY IS BAD AND QUOTED ME FOR THE SYSTEM IT WOULD BE $1700 AND THE BATTERY AROUND $4000. *TR
ON 4/24/14 I WAS DRIVING MY CAR AND THOUGHT IT FELT A LITTLE SLUGGISH OR STRANGE. THEN WHEN I GOT UP TO GO TO WORK ON THE 25TH, WHEN I STARTED THE CAR EVERY LIGHT ON THE DASH CAME UP AND IT DISPLAYED MULTIPLE MESSAGES. I CALLED DEALERSHIP AND THEY ADVISED I HAVE CAR TOWED TO THEM. I DID THAT AND THEY DETERMINED THAT THE HYBRI…
Read full complaint
ON 4/24/14 I WAS DRIVING MY CAR AND THOUGHT IT FELT A LITTLE SLUGGISH OR STRANGE. THEN WHEN I GOT UP TO GO TO WORK ON THE 25TH, WHEN I STARTED THE CAR EVERY LIGHT ON THE DASH CAME UP AND IT DISPLAYED MULTIPLE MESSAGES. I CALLED DEALERSHIP AND THEY ADVISED I HAVE CAR TOWED TO THEM. I DID THAT AND THEY DETERMINED THAT THE HYBRID BATTERY PACK WAS BAD. THE WARRANTY EXPIRED AT 100,000 MILES AND I HAD 116,000 MILES ON THE CAR. *TR
WHILE DRIVING I ATTEMPTED BRAKE TO SLOW ENTRY INTO UPHILL DRIVEWAY. ALL LIGHTS ON DRIVER PANEL LIT UP. BRAKES DID NOT RESPOND TO SLOW DOWN OR STOP. WITH FULL FORCE I DEPRESSED BRAKE PEDAL. SINCE DRIVE WAY WAS UPHILL, I COASTED TO STOP JUST SHORT OF GARAGE DOOR BEFORE CRASHING. THIS WAS NOT THE FIRST TIME THE BRAKES TOTALLY FAIL…
Read full complaint
WHILE DRIVING I ATTEMPTED BRAKE TO SLOW ENTRY INTO UPHILL DRIVEWAY. ALL LIGHTS ON DRIVER PANEL LIT UP. BRAKES DID NOT RESPOND TO SLOW DOWN OR STOP. WITH FULL FORCE I DEPRESSED BRAKE PEDAL. SINCE DRIVE WAY WAS UPHILL, I COASTED TO STOP JUST SHORT OF GARAGE DOOR BEFORE CRASHING. THIS WAS NOT THE FIRST TIME THE BRAKES TOTALLY FAILED DURING LAST COUPLE OF MONTHS. I DROVE TO DEALERSHIP FOR SECOND TIME TO HAVE BEAKS INSPECTED. THE CAR WAS ALSO MAKING LOUD NOISE WHENEVER BRAKES APPLIED. THE SERVICE MANAGER SAID THE BRAKE SYSTEM WAS EXAMINED BY SEVERAL TECHNICIANS. AGAIN, THEY FOUND NOTHING WRONG WITH BRAKES AND TOLD ME THE CAR WAS SAFE TO DRIVE! DESPITE SEVERAL RECENT BRAKE FAILURES, TWO VISITS TO TOYOTA DEALERSHIP, THE SERVICE MANAGER SAID THE LOUD NOISE WHEN BRAKING CAME FROM THE "BRAKE ACTUATOR," WHICH COULD BE REPLACED FOR $2,900! QUOTE FROM SERVICE INVOICE OF MARCH 18, 2014, FOLLOWS: "TECH 165630 PERFORMED DIAGNOSIS ON BRAKE NOISE FROM INSIDE CAB OF VEHICLE. TEST DROVE WITH CUSTOMER TO VERIFY NOISE. FOUND THAT BRAKE ACTUATOR IS THE CAUSE OF INTERNAL NOISE WHEN AT A STOP WHILE BRAKE IS APPLIED. SUGGEST NEW BRAKE ACTUATOR AND BRAKE FLUSH AND RE-TEST FOR NOISE AGAIN." SERVICE MANAGER AND TECHNICIANS SAID, "IT' SAFE TO DRIVE." I DO NOT BELIEVE IT IS SAFE TO DRIVE. SINCE I AM A VISITING HOSPICE NURSE, THAT CAR IS MY OFFICE. I WONDER WHEN THE BRAKES WILL FAIL AGAIN, AND WHEN THE INCESSANT LOUD NOISE WILL STOP. I TOOK THE CAR TO AN INDEPENDENT FOREIGN CAR REPAIR SHOP. THEY SAID, "THE ACTUATOR IS THE SOURCE OF THE NOISE AND YOUR BRAKING PROBLEM. HOWEVER, WE CAN'T GET AN ACTUATOR TO REPLACE TOYOTA'S PART BECAUSE IT IS A "LOCKED PART" IN THE ENGINE. ONLY TOYOTA DEALERS CAN OBTAIN THE PART, AND ONLY A TOYOTA DEALER CAN INSTALL THE PART." WILL YOU HELP? *TR
I WAS ONLY DRIVING MY VEHICLE ABOUT A MILE WHEN IT FIRST HAPPENED. I WAS APPROACHING A STOP LIGHT AND ATTEMPTED TO APPLY THE BRAKES. NOTHING HAPPENED. THE STEERING WENT OUT AND THE BRAKES FELT LIKE THEY WEREN'T CATCHING. THANKFULLY, I WAS ONLY GOING ABOUT 25-30 MPH, AND HAD ENOUGH SPACE TO STOP BEFORE HITTING ANOTHER CAR THAT WA…
Read full complaint
I WAS ONLY DRIVING MY VEHICLE ABOUT A MILE WHEN IT FIRST HAPPENED. I WAS APPROACHING A STOP LIGHT AND ATTEMPTED TO APPLY THE BRAKES. NOTHING HAPPENED. THE STEERING WENT OUT AND THE BRAKES FELT LIKE THEY WEREN'T CATCHING. THANKFULLY, I WAS ONLY GOING ABOUT 25-30 MPH, AND HAD ENOUGH SPACE TO STOP BEFORE HITTING ANOTHER CAR THAT WAS STOPPED AT THE LIGHT. I LOOKED AT THE DASHBOARD DISPLAY AND NOTICED SOMETHING THAT READ, "CHECK VSC SYSTEM". THERE WAS ALSO A WARNING TRIANGLE. THE CAMRY MANUAL INSTRUCTED US TO BRING IT TO THE DEALERSHIP - BUT I CAN'T AFFORD THAT. THE NEXT DAY, IT WORKED FINE. A FEW WEEKS LATER, THE INCIDENT HAPPENED AGAIN WHILE I WAS EXITING THE HIGHWAY AND COMING TO A RED LIGHT. I WAS DECELERATING FROM ABOUT 65 MPH TO A FULL STOP AND FELT THE BRAKES GIVE AGAIN AND THE STEERING WAS DIFFICULT. I WAS ABLE TO PULL OVER, TURN OFF THE CAR, AND RESTART AND IT WAS FINE AGAIN. I HAD THE BRAKE PADS CHANGED, BUT DON'T UNDERSTAND WHAT IS HAPPENING. WE DIDN'T HAVE THE PROBLEM FOR SEVERAL MONTHS. BUT NOW IT FEELS LIKE THE BRAKES WANT TO GIVE WHEN I AM IDLING IN TRAFFIC. WHILE MY FOOT IS ON THE BRAKE, THE CAR WILL SQUEAK AND SUBTLY JERK FORWARD LIKE THE BRAKES ARE ABOUT TO GIVE UP THE GHOST. IT'S REALLY SCARY, BUT I CAN'T AFFORD ANOTHER CAR AT THIS TIME. I'VE LOOKED INTO THE VSC SYSTEM AND DON'T UNDERSTAND WHY THAT WOULD INTERMITTENTLY AFFECT MY BRAKING AND STEERING ABILITY. *TR
Official recalls
315V689000 · Visibility:power Window Devices And Controls
Oct 22, 2015
Toyota Motor Company (Toyota) is recalling certain model year 2009-2011 Tundra, Sequoia, Corolla, Corolla Matrix and Scion xB, 2008-2011 Highlander and Highlander Hybrid, 2007 Camry and Camry Hybrid, 2009 Camry and Camry Hybrid, 2006-2011 RAV4, 2006-2010 Yaris, and 2009-2010 Scion xD and Pontiac Vibe vehicles. During the manufacturing of the Power Window Master Switch (PWMS), grease lubricant may have been inconsistently applied to the sliding electrical contacts.
Consequence & remedy
Consequence: If the sliding electrical contacts are not protected by lubricant, debris and moisture that get into the switch may cause a short circuit and the switch assembly may overheat and melt, increasing the risk of a fire.
Remedy: Toyota will notify owners, and dealers will inspect the switch, applying a lubricant if no abnormality is found. If abnormality is found, the PWMS circuit board will be replaced, free of charge. The recall is expected to begin December 20, 2015. Owners may contact Toyota customer service at 1-800-331-4331. Toyota's number for this recall is C0M.
12V491000 · Visibility:power Window Devices And Controls
Oct 10, 2012
Toyota is recalling certain model year 2007-2009 Camry, Camry Hybrid, RAV4, Corolla, Corolla Matrix, Tundra, Sequoia, Highlander, Highlander Hybrid, Yaris, Scion xB, Scion xD and Pontiac Vibe vehicles. The power window master switch assemblies in some of these vehicles were built using a less precise process for lubricating the internal components of the switch assemblies. Irregularities in this lubrication process may cause the power window master switch assemblies to malfunction and overheat.
Consequence & remedy
Consequence: If the switch overheats, it may melt, possibly resulting in a fire.
Remedy: Toyota will notify its owners, and dealers will inspect the switch and apply a special grease that inhibits heat build up or replace any switch damaged by the defect, free of charge. Toyota owners that experience a problem with a switch should not attempt to make repairs, but should contact their Toyota dealer or the Toyota Customer Experience Center at 1-800-331-4331. General Motors will contact the Pontiac Vibe owners affected by this recall and GM dealers will inspect and repair switches as necessary. Those owners may contact Pontiac Customer Care at 1-800-762-2737.
09V388000 · Vehicle Speed Control:accelerator Pedal
Oct 5, 2009
TOYOTA IS RECALLING CERTAIN MODEL YEAR 2004-2010 PASSENGER VEHICLES. THE ACCELERATOR PEDAL CAN GET STUCK IN THE WIDE OPEN POSITION DUE TO ITS BEING TRAPPED BY AN UNSECURED OR INCOMPATIBLE DRIVER'S FLOOR MAT.
Consequence & remedy
Consequence: A STUCK OPEN ACCELERATOR PEDAL MAY RESULT IN VERY HIGH VEHICLE SPEEDS AND MAKE IT DIFFICULT TO STOP THE VEHICLE, WHICH COULD CAUSE A CRASH, SERIOUS INJURY OR DEATH.
Remedy: TOYOTA FILED AN AMENDED DEFECT REPORT ON NOVEMBER 25, 2009, STATING THAT DEALERS WILL MODIFY THE ACCELERATOR PEDAL AND, ON CERTAIN VEHICLES, ALTER THE SHAPE OF THE FLOOR SURFACE UNDER THE PEDAL. THESE CHANGES ADDRESS THE RISK OF PEDAL ENTRAPMENT DUE TO INTERFERENCE WITH THE FLOOR MAT. REDESIGNED ACCELERATOR PEDALS WILL BECOME AVAILABLE BEGINNING IN APRIL 2010 AND DEALERS WILL REPLACE ANY MODIFIED PEDAL WITH THE NEW PEDAL IF DESIRED. ALSO, DEALERS WILL REPLACE ANY GENUINE TOYOTA OR LEXUS ALL-WEATHER FLOOR MATS WITH REDESIGNED ALL-WEATHER MATS, OR REPURCHASE THE PREVIOUS MATS FROM OWNERS WHO DO NOT WANT THE NEW ONES. ADDITIONALLY, SOFTWARE MODIFICATIONS WILL BE INSTALLED ON CAMRY, AVALON AND LEXUS ES 350, IS 350 AND IS 250 MODELS THAT WILL ENSURE THAT THE BRAKE OVERRIDES THE ACCELERATOR IN THE EVENT BOTH BRAKE AND ACCELERATOR PEDALS ARE APPLIED. TOYOTA WILL BEGIN MAILING LETTERS TO OWNERS ON DECEMBER 31, 2009. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331, LEXUS AT 1-800-255-3987.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP22005 · Pedestrian Alert Sounds
Opened Jan 27, 2023 · Closed Aug 7, 2023
Status: closed (inferred from source dates) · Electrical System:propulsion System
NHTSA received a petition on or about July 18, 2022, requesting that Federal Motor Vehicle Safety Standard (FMVSS) 141 be applied to all electric and hybrid vehicles operating in the United States. The petition can be reviewed at NHTSA.gov under ODI Number 11486072. FMVSS 141 establishes performance requirements for pedestrian alert sounds for motor vehicles. The standard applies to hybrid and electric vehicles that have a gross vehicle weight rating of 4,536 KG or less or are defined as low-speed vehicles. The standard became fully applicable to all such vehicles manufactured on or after March 1, 2021.On January 27, 2023, NHTSA opened Defect Petition (DP) 22-005 to evaluate the subject matter described in the petition. On June 24, 2023 and as supplemented on June 25, 2023, the petitioner notified NHTSA he was withdrawing his petition. The petitioner indicated that, based on his review of data, there is no justification for asserting potential benefits that could be derived from actions sought by my petition. Based on the petitioner's withdrawal, DP22-005 is closed. Closure of this DP does not represent a determination by NHTSA regarding the subject matter of the petition.
PE14001 · Brake Actuator Malfunction
Opened Jan 23, 2014 · Closed Aug 22, 2014
Status: closed (inferred from source dates) · Service Brakes; Service Brakes, Air:supply:reservoir/tank; Service Brakes, Electric; Service Brakes, Hydraulic:power Assist
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Additional source detail variants (4)
Service Brakes, Air:supply:reservoir/tank
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes, Electric
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes, Hydraulic:power Assist
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
Service Brakes
On June 25, 2014, Toyota initiated a Warranty Enhancement Program (ZE1) to extend warranty coverage for the brake actuator assembly and skid control ECU/brake pedal stroke sensor in certain MY 2007 to 2011 Toyota Camry hybrid vehicles. Toyota's program covers repairs related to two conditions:internal malfunctions of the Brake Actuator assembly; and overly sensitive monitoring logic for the Brake Pedal Stroke Sensor.Primary coverage provides warranty enhancement until November 30, 2015, with no mileage limitation.After the primary coverage period ends, secondary coverage is provided for 10 years or 150,000 miles from the date of first use, whichever occurs first.In addition, on July 10, 2014, Toyota initiated Limited Service Campaign E0U to replace the Brake Reservoir Tank in MY 2007 through 2011 Toyota Camry hybrid vehicles.The LSC will be available until June 30, 2017, and will only be available at an authorized Toyota dealer.ODI's analysis of failure data determined that the majority of records were related to the Brake Actuator condition, which appeared to be the causal component in 734 complaints/field reports and 864 warranty claims.The Brake Pedal Stroke Sensor (80 reports/189 claims) and Brake Reservoir Tank (91 reports/44 claims) conditions were identified in far fewer records.Analysis of the failure data indicate that each condition provides warning prior to any reduction in power assisted braking, with less than 10 percent of all reports and claims involving diagnostic codes or complaint narratives indicating increased braking effort or reduced brake effectiveness.In addition, most of the incidents in which reduced braking assist appears to have occurred involved operation in a reduced assist mode and not a sudden, complete loss of power assisted braking.ODI assessed reduced assist mode in a subjective driving evaluation which indicated that the brake system provided normal and harddeceleration capability with reasonable increases in pedal effort.Less than one percent of reports and claims analyzed by ODI included evidence indicating a complete loss of power assisted braking occurred and this mode requires operation for a significant period of time with multiple audible and visual warnings.Repair expense was cited in many of the complaints reviewed by ODI, especially those related to the Brake Actuator, which had repair costs exceeding $3,000 according to some complaints.High repair cost appears to have been a factor in the only crash identified by ODI for the fault conditions identified by Toyota, which involved a Brake Actuator failure that was diagnosed but the owner declined repair approximately eight months prior to the reported crash incident.This preliminary evaluation is closed.The closing of this investigation does not constitute a finding that a safety-related defect does not exist.For additional information regarding this investigation, including analysis of the Brake Actuator, Brake Pedal Stroke Sensor, and Brake Reservoir Tank fault conditions and failure experience, see Attachment A to this closing resume.
EA12006 · Power Window Master Switch Fire
Opened Jun 14, 2012 · Closed Feb 12, 2013
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Additional source detail variants (3)
Electrical System
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Structure:body
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
Unknown Or Other
On October 10, 2012, Toyota initiated a safety recall of approximately 2.5 million U.S. vehicles involving the following models and model years:2007-2009 Camry and Camry Hybrid, 2009 Corolla and Corolla Matrix, 2008 Highlander and Highlander Hybrid, 2007-2009 RAV4, 2008-2009 Scion xB and xD, 2008-2009 Sequoia, 2007-2008 Tundra, 2007-2008 Yaris, and 2009 Pontiac Vibe.See NHTSA recall number 12V-491 for more details, including the affected vehicle manufacture dates for each vehicle model.Note that only early-production 2009 model year vehicles are included in the recall.Toyota and GM dealers will inspect the power window master switch (PWMS) assemblies and apply a specialized grease that inhibits heat build-up.The circuit board in the PWMS may be replaced with a new one if notchy or sticking feeling is observed during the inspection.The failure report summary above shows counts for the vehicles identified at the start of this Engineering Analysis, specifically the approximately 1.4 million vehicles that share an identical PWMS assembly design including, model year 2007-2009 Camry, Camry Hybrid, RAV4, and Yaris built from September 2006 through August 2008, as well as all 2008 Highlander Hybrid.Toyota subsequently identified approximately one million additional vehicles that have a slightly different PWMS design but contain the same defect condition.Note that the totals for complaints and fires shown above may include duplicative reports (between ODI and manufacturer reports).This Engineering Analysis is closed.See attached report for additional information.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10323848, 10360414, 10392622, 10394453, 10411328, 10429983, 10436663, 10446699, 10447416, 10447417, 10447419, 10447444, 10447515, 10447845, 10447947, 10449270, 10450133, 10450568, 10450606, 10450641, 10451821, 10455540, 10455614, 10456353, 10456438, 10457854, 10457955, 10459730, 10460166, 10460691, 10461220, 10462140, 10462200, 10462247, 10462404, 10462705, 10462761, 10464451, 10464769, 10465421, 10466279, 10466667, 10468126, 10468265, 10475230, 10470313, 10470684, 10471551, 10471824, 10472336, 10472910, 10473753, 10473967, 10473969, 10476921, 10477469, 10478563 and 10478657.
PE12002 · Power Window Master Switch Fire
Opened Feb 6, 2012 · Closed Jun 14, 2012
Status: closed (inferred from source dates) · Electrical System; Structure:body; Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Additional source detail variants (3)
Electrical System
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Structure:body
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.
Unknown Or Other
ODI has identified certain Toyota vehicles experiencing a higher rate of fire and thermal event incidents among all Toyota vehicles that use the same power window master switch design.They include a total of approximately 1.4 million model year (MY) 2007 through 2009 Camry, Camry Hybrid, RAV4 and Yaris vehicles built from approximately September 2006 through August 2008, as well as all MY 2008 Highlander Hybrid vehicles.This Preliminary Evaluation has been upgraded to an Engineering Analysis (EA12-006) to further study the alleged defect and its consequences.The ODI reports cited above can be viewed at www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10461220, 10460691, 10460166, 10459730, 10457955, 10457854, 10456438, 10456353, 10455614, 10455540, 10451821, 10450641, 10450606, 10450568, 10450133, 10449270, 10447947, 10447845, 10447515, 10447444, 10447419, 10447417, 10447416, 10446699, 10436663, 10429983, 10411328, 10407290, 10394453, 10392622, 10360414, 10323848.