2006 Toyota Avalon

ON JUNE 7, 2019, I WAS DRIVING THE AVALON, THE ENGINE SUDDENLY STOPPED WHILE I WAS DRIVING THE VEHICLE ON CITY STREET. WITH THE LOSS OF POWER STEERING AND BRAKES, I WAS TRAUMATIZED AND DID MY BEST TO GUIDE THE VEHICLE TO SIDE OF THE ROAD. I HAD THE VEHICLE TOWED HOME AND HOOKED UP TO A CODE READER, WHICH YIELDED CODES P0345, P0300, P0302, P0304, P0306. WE DID FURTHER DIAGNOSTICS AND DISCOVERED THE 3 BOLTS THAT HOLD THE VARIABLE-VALVE TIMING (VVT) GEAR TO THE INTAKE CAMSHAFT CAME LOOSE, THESE BOLTS ARE SUPPOSED TO BE TEMPER-RESISTANT AND NEVER BE REMOVED WHICH LED ME TO BELIEVE THE RESULT OF ENGINE DYING IS CAUSED BY SERIOUS MANUFACTURING AND DESIGN DEFECTS. PLEASE REFER TO ATTACHED THREE PICTURES SHOWING 3 BOLTS LAYING NEXT TO VVT GEAR, VVT GEAR LOOSELY HELD ON AND THE VIBRATION OF BOLT LEFT CUTTING MARK ON THE GEAR, AND ALL INTAKE CAM ROCKERS FALLING OUT. I DID MORE RESEARCH AND CONCLUDED THE ROOT CAUSE OF ENGINE STOPPED WHILE THE VEHICLE IS BEING DRIVEN IN OUR AVALON IS IDENTICAL TO TOYOTA SAFETY RECALL 13V-395 IN LEXUS VEHICLES 2006 TO 2011. PLEASE FIND ATTACHED TWO DOCUMENTS, RCRIT-13V395-3180.PDF ON RECENT RECALL FOR TOYOTA SAFETY RECALL 13V-395, RCDNN-13V395-1839.PDF ON DEFECT INFORMATION REPORT FROM TOYOTA TO NHTSA ON LEXUS INTAKE-SIDE VARIABLE-VALVE TIMING (VVT) SYSTEM PART 573. ON JUNE 27, 2019, I CALLED STEVENS CREEK TOYOTA AND TOYOTA HQ AND LOGGED CASE [XXX]. I WAS INFORMED BY TOYOTA THERE'S NO RECALL FOR AVALON WITH THE VIN, AND THE VEHICLE HAD NO FACTORY WARRANTY (CURRENTLY 153K MILES), AND NO EXTENDED WARRANTY WITH ENGINE STALL FOR AVALON. AS A RESULT, WE NEED TO REPAIR THE VEHICLE IN OUR OWN EXPENSE WHICH REQUIRES ENGINE REBUILT AS ENGINE STALL HAS CAUSED SEVERE DAMAGE TO THE VEHICLE. I WAS APPALLED BY TOYOTA FOR LACK OF INITIATION TO ADDRESS THE SAFETY RISK IN OUR AVALON AND WE APPRECIATE YOUR THOROUGH INVESTIGATION IN THIS MATTER. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TT

STARTED CAR AND SMOKE BEGAN POURING FROM THE EXHAUST WHILE STATIONARY. CHECKED OIL LEVEL AND FOUND TO BE WITHIN NORMAL RANGE. WHEN DRIVING, CAR WAS SLUGGISH UNDER ACCELERATION WITH INTERMITTENT SMOKE. TOOK CAR TO SAN MARCOS TOYOTA AND THEY FOUND THE ENGINE TO BE SLUDGED AND REQUIRE AN OVERHAUL OF THE ENGINE ($4900) OR REPLACEMENT OF THE ENGINE ($6900). THE VEHICLE HAD ONLY 140,000 MILES. WE ENDED UP HAVING AN INDEPENDENT MECHANIC OVERHAUL/CLEANUP THE TOP SIDE OF ENGINE FOR $4000. I HAVE THE ESTIMATES AND RECEIPTS FOR THE WORK IF NEEDED. I HAVE RESEARCHED ON-LINE AND FOUND MANY OTHER AVALON OWNERS WHO HAVE HAD THE SAME PROBLEM. I AM FILING THIS COMPLAINT IN HOPE THAT TOYOTA WILL ACKNOWLEDGE THE POOR ENGINEERING OF THIS V6 ENGINE AND ISSUE A RECALL AND REIMBURSE THEIR CUSTOMERS WHO HAVE EXPERIENCE THIS ENGINE FAILURE.

TL* THE CONTACT OWNS A 2006 TOYOTA AVALON. WHILE DRIVING 60 MPH AND ATTEMPTING TO ACCELERATE, AN ABNORMAL SOUND EMITTED UNDER THE FRONT END OF THE VEHICLE. THE CONTACT MENTIONED THAT THE VEHICLE FAILED TO ACCELERATE AND BEGAN TO SHAKE VIOLENTLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MOTOR MOUNT BOAT DETACHED AND FRACTURED THE ENGINE'S AXLE. THE TECHNICIAN STATED THAT THE MOTOR MOUNT BOAT NEEDED TO BE REMOVED FROM THE ENGINE AND THE ENGINE'S AXLES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 125,000.

WHEN ACCELERATING FROM A STOP THE VEHICLE WILL SOMETIMES MOVE ABOUT 10 FEET AND THEN HESITATE FOR ABOUT 1 TO 2 SECONDS. IT WILL THEN ACCELERATE NORMALLY. WHEN DRIVING IN HEAVY CONDITIONS AT SPEEDS UNDER 35 THE CAR HESISTATES BADLY WHEN YOU TRY TO ACCELERATE AND THEN "JUMPS" FORWARD. SAME THING HAPPENS ON THE DOWNSIDE TO THE POINT THAT IT FEELS LIKE ITS GOING TO STALL. THE SERVICE ADVISOR ALSO SAID THERE HAD BEEN OTHER COMPLAINTS ABOUT THIS CONDITION. THIS CONDITION IS DANGEROUS AND NOT NORMAL.

HEAD GASKET LEAKS BOTH SIDES. UNDER REPAIR. POOR DESIGN OR MANUFACTURING. SHOULD NOT HAVE OCCURRED AT THIS MILEAGE LEVEL. MY REPAIR SERVICE INDICATED THAT THIS HAS HAPPENED ON SEVERAL TOYOTA PRODUCTS. CONCERN FOR ACCIDENT POTENTIAL SHOULD HEAD GASKET BLOW AT HIGH SPEED IN HEAVY TRAFFIC WHERE CONDITIONS DO NOT ALLOW FOR A SAFE EXIT FROM TRAVEL LANES TO SHOULDER. NOTE: VEHICLE REGISTERED UNDER MY WIFE MARIA'S NAME.

TL* THE CONTACT OWNS A 2006 TOYOTA AVALON. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 5 MPH, THE ENGINE RPMS INDEPENDENTLY AND ABNORMALLY INCREASED. THE CONTACT WAS ABLE TO STOP THE VEHICLE WITHOUT INCIDENT. THE VEHICLE WAS NOT TAKEN TO A DEALER. THE MANUFACTURER WAS NOT NOTIFIED OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 60,000.

THE CHECK ENGINE LIGHT CAME ON WITH THE VSC AND SLIP LIGHTS ON THE DASH. HAD IT SCANNED AND THE CODES ARE P2195 AND P0138. I AM HAVING A HUGE PROBLEM WITH THIS, I FEEL THAT TOYOTA SHOULD COVER THIS PROBLEM OR ATLEAST MOST OF IT. IT'S $1700 TO FIX THIS PROBLEM THAT MANY AVALON OWNERS ARE OR HAVE HAD WITH THIS!!! 06 TOYOTA AVALON - EDMUNDS ANSWERS JAN 10, 2009 - P2195 - OXYGEN (A/F) SENSOR SIGNAL STUCK LEAN (BANK 1 SENSOR 1) ... P0138 - OXYGEN SENSOR CIRCUIT HIGH VOLTAGE (BANK 1 SENSOR 2) ..... AFTER OWNING A CERTIFIED PRE-OWNED 2006 AVALON FOR 1 MONTH, THE "CHECK ENGINE" ... 1 (RH) EXHAUST MANIFOLD" IS THAT THE P0031 CODE WAS ON ONE NOT BOTH AF SENSORS. YOU VISITED THIS PAGE ON 3/19/14. P2195 TOYOTA - ENGINE-CODES.COM ENGINE-CODES.COM/P2195_TOYOTA.HTML' 2005-2007 TOYOTA AVALON, 2007-2008 TOYOTA CAMRY SERVICE BULLETIN OBDII CODE P2195 ... 2005-2006 TOYOTA COROLLA SERVICE BULLETIN OBDII CODE P2195. YOU VISITED THIS PAGE ON 3/19/14. TOYOTA TECHNICAL SERVICE BULLETIN INDEX - AUTOPRO IMPORT REPAIR APR 2, 2013 - SOME AVALON CAMRY AND SOLARA VEHICLES MAY EXHIBIT A RATTLE TYPE NOISE COMING FROM ... SOME 2006 - 2009 MODEL YEAR CAMRY AND 2007 - 2009 MODEL YEAR CAMRY HV .... A MIL 'ON' CONDITION WITH DIAGNOSTIC TROUBLE CODE (DTC) P2420 STORED. ..... MIL "ON" DTC P2195, P0138, AND/OR P0031(TSB-0066-10). YOU VISITED THIS PAGE ON 3/19/14. 1 COMPLAINTS: 2005 TOYOTA AVALON CHECK ENGINE LIGHT IS ON WWW.CARCOMPLAINTS.COM/.../AVALON/2005/.../CHECK_ENGINE_LIGHT_IS_ON.S...' MAR 10, 2014 - THE 2005 TOYOTA AVALON HAS 1 COMPLAINTS FOR CHECK ENGINE LIGHT IS ON. ... WAS THE CHECK ENGINE LIGHT CODES = P0138 O2 SENSOR/P2195 AF SENSOR. *TR

I AM IN SHOCK GIVEN THE TODAY?S NEWS. I WAS IN AN ACCIDENT ON 12/01/08 IN MY 2006 TOYOTA AVALON. I COULD NOT STOP THE CAR AND RAN INTO THE T-BAR OF A BOX TRUCK IN FRONT OF ME. MY CAR WAS TOTALED. AFTER THE ACCIDENT WE CALLED THE TOYOTA EXPERIENCE CENTER, THEY CREATED A CLAIM #1001145755 AND ERIKA WITH TOYOTA SAID THEY WOULD BE IN CONTACT WITH US. WE NEXT HEARD FROM A [XXX] WITH TOYOTA WHO THEN TOLD US TO MAIL OUR COMPLAINT TO TOYOTA MOTOR SALES CLAIMS DEPARTMENT IN TORRANCE, CA. WE MAILED OF THE NECESSARY DOCUMENTATION FROM THE ACCIDENT AND NEVER HEARD BACK FROM THEM. WE CALLED BACK ON MANY OCCASIONS ALL TO BE NEVER ANSWERED OR GIVEN A RUN AROUND, ONCE TOLD THEY WERE LOOKING INTO IT. NOTHING EVER CAME OF IT ALL. WE DIDN'T KNOW WHAT TO SO WE GAVE UP, AT THE TIME WE COULD NOT AFFORD A LAWYER. SO TODAY?S NEWS WAS FRUSTRATING. MONTHS PRIOR TO MY ACCIDENT WE TOOK THE AVALON INTO DCH TOYOTA OF SIMI VALLEY TO CHECK OUT ACCELERATION PROBLEMS. THEY SAID NOTHING WAS WRONG WITH IT AND TOLD ME I NEEDED A TRANSMISSION FLUID EXCHANGE AND TO HAVE THE POWER STEERING FLUID FLUSHED. WE WERE TOLD NOTHING WAS WRONG; CLEARLY THERE WAS. I AM JUST CURIOS WHAT ACTIONS WE TAKE NOW. I AM SO FRUSTRATED AND DISAPPOINTED. CAN YOU PLEASE ADVISE ME ON WHAT TO DO? INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR