IllustrationTHE FRAME ON THE PASSENGER SIDE OF THE VEHICLE RUSTED THROUGH JUST IN FRONT OF THE REAR AXLE. THE BRACKET THAT HOLDS THE FRONT OF THE TRAILING ARM SUDDENLY SEPARATED FROM THE DISINTEGRATED FRAME CAUSING THE AXLE TO MOVE FORWARD AND BACKWARD. THE VEHICLE WAS ON THE INTERSTATE AT SPEED AND BECAME WILDLY DIFFICULT TO CONTROL.
1997 Toyota 4RUNNER
Owner reports · Recalls · Investigations
More warning signs than most 4RUNNER years
Owner complaints for the 1997 Toyota 4RUNNER are substantially higher than the model-year median of 58.
About this comparison →How this year compares
Owner complaints by model year
Compare all 4RUNNER years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
40–25K
025–50K
150–75K
175–100K
25100–150K
87150K+
118 reports with mileage · 21 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Structure. Review the 69 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 65 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports2 fire reports5 injury reports
Steering complaints
10 reportsVEHICLE FRAME IS COMPLETELY RUSTING OUT AROUND THE REAR SUSPENSION. TRAILING ARM MOUNT FROM AXLE TO FRAME IS SEPARATED FROM FRAME AND VEHICLE IS NOT SAFE TO DRIVE. *TR
REAR FRAME IS RUSTED BADLY WHERE THE REAR SUSPENSION CONNECTS. *TR
FRAME IS COMPLETELY RUSTED. THE UNDERSIDE OF THE BODY IS FINE BUT THE FRAME IS ROTTED. THERE ARE HOLES RUSTED THROUGH IN MULTIPLE SPOTS INCLUDING SUSPENSION MOUNTS. *TR
I WAS DRIVING MY TOYOTA 4RUNNER AT HIGHWAY SPEEDS (60 TO 70 MPH) AND IT STARTED GETTING HARD TO HANDLE. IF YOU ACCELERATED IT WOULD TURN HARD TO THE RIGHT, IF YOU LET OFF THE GAS IT WOULD VEER BACK HARD TO THE LEFT. WE STOPPED AND CHECKED IT OUT AND THE FRAME MOUNT ON THE PASSENGER SIDE IS RUSTED OFF. *TR
I OWN A 1997 4RUNNER. DURING MY DRIVING THE VEHICLE FEW WEEKS AGO, THE CHASSIS LOCATED ON THE REAR PASSENGER SIDE SPLIT APART AND ALMOST RESULTED IN A FATAL ACCIDENT WITH MY FAMILY. THIS FAILURE, HOWEVER, IS PURELY AN ENGINEERING DESIGN AND MANUFACTURING FAILURES.HENCE, THE VEHICLE HAS BECOME UN-DRIVABLE. WHEN I CONTACTED TOYOT…
Read full complaint
I OWN A 1997 4RUNNER. DURING MY DRIVING THE VEHICLE FEW WEEKS AGO, THE CHASSIS LOCATED ON THE REAR PASSENGER SIDE SPLIT APART AND ALMOST RESULTED IN A FATAL ACCIDENT WITH MY FAMILY. THIS FAILURE, HOWEVER, IS PURELY AN ENGINEERING DESIGN AND MANUFACTURING FAILURES.HENCE, THE VEHICLE HAS BECOME UN-DRIVABLE. WHEN I CONTACTED TOYOTA AND ITS DEALERSHIPS, THEY SAID TO REPAIR THE VEHICLE WILL COST ME $8,100.00. HENCE, I FEEL THAT, IN COMPARISON TO OTHER VEHICLES FROM DIFFERENT BRAND OF CARS COMPANIES, THEREWITH, WHEREBY, THEY ARE STILL ON SOME PART OF THE WORLD, ARE STILL DRIVABLE AND USEFUL. HOWEVER, FOR THE KIND OF MONEY SPENT ON THE PURCHASE, THE REQUIRED MAINTENANCE, THE VEHICLE IS THAT OLD THEY ARE LIABLE FOR A FIFTEEN YEAR OLD VEHICLE. *TR
1997 TOYOTA 4RUNNER FRAME ROTTING OUT. THERE IS A RECALL ON THE 1997 TOYOTA TACOMAS FOR THE SAME REASON, THE 4RUNNER HAS THE SAME FRAME AND HAS THE SAME PROBLEM. TOYOTA REFUSES TO ADD THE 4RUNNER TO THE RECALL OR FIX THE DEFECTIVE FRAMES. MY 4RUNNER IS IN EXCELLENT SHAPE EXCEPT THE FRAME IS ROTTING THROUGH IN SEVERAL LOCATIONS…
Read full complaint
1997 TOYOTA 4RUNNER FRAME ROTTING OUT. THERE IS A RECALL ON THE 1997 TOYOTA TACOMAS FOR THE SAME REASON, THE 4RUNNER HAS THE SAME FRAME AND HAS THE SAME PROBLEM. TOYOTA REFUSES TO ADD THE 4RUNNER TO THE RECALL OR FIX THE DEFECTIVE FRAMES. MY 4RUNNER IS IN EXCELLENT SHAPE EXCEPT THE FRAME IS ROTTING THROUGH IN SEVERAL LOCATIONS. THESE 4RUNNERS SHOULD BE RECALLED THE SAME AS THE TACOMAS TO FIX THE DEFECT.
WE WERE SOUTHBOUND ON I25, EXT 261,STATE OF COLORADO, GOING ABOUT 45 MPH IN LANE #1 WHEN MY VEHICLE, A 1997 TOYOTA 4RUNNER SUDDENLY VEERED TO THE LEFT LANDING ON THE MEDIAN HITTING THE GUARDRAIL AND CAUSING A 3 CAR ACCIDENT. THE WEATHER WAS A LITTLE SNOW AND THE FWY SURFACE APPEARED CLEAR. *TR
TL*THE CONTACT OWNS A 1997 TOYOTA 4RUNNER. ON AUGUST 5 2009, WHILE DRIVING APPROXIMATELY 55 MPH HE HEARD A NOISE AND OBSERVED THAT THE FRAME BROKE. THE DEALER STATED THAT THE LEFT TIE ROD CORRODED AND BROKE IN HALF WHICH CAUSED THE FRAME TO FALL OFF OF THE VEHICLE. THE DEALER ALSO STATED THAT THE FRAME IS NOT REPAIRABLE. THE MAN…
Read full complaint
TL*THE CONTACT OWNS A 1997 TOYOTA 4RUNNER. ON AUGUST 5 2009, WHILE DRIVING APPROXIMATELY 55 MPH HE HEARD A NOISE AND OBSERVED THAT THE FRAME BROKE. THE DEALER STATED THAT THE LEFT TIE ROD CORRODED AND BROKE IN HALF WHICH CAUSED THE FRAME TO FALL OFF OF THE VEHICLE. THE DEALER ALSO STATED THAT THE FRAME IS NOT REPAIRABLE. THE MANUFACTURER CONFIRMED THAT THERE WAS NO EXISTING RECALL AND WILL NOT OFFER ANY ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGES WERE 190,000.
WHILE DRIVING ON THE HIGHWAY AT THE SPEED LIMIT (60 MPH), THE VEHICLE SURGED/JOLTED FORWARD PULLING TO THE RIGHT. I WAS UNABLE TO REGAIN CONTROL OF VEHICLE CAUSING ME TO MERGE INTO THE DIRECTION OF A TRACTOR TRAILER. I TRIED TO TURN AWAY FROM TRACTOR TRAILER TO AVOID COLLISION. MY VEHICLE HIT THE REAR TIRE OF THE TRACTOR TRAI…
Read full complaint
WHILE DRIVING ON THE HIGHWAY AT THE SPEED LIMIT (60 MPH), THE VEHICLE SURGED/JOLTED FORWARD PULLING TO THE RIGHT. I WAS UNABLE TO REGAIN CONTROL OF VEHICLE CAUSING ME TO MERGE INTO THE DIRECTION OF A TRACTOR TRAILER. I TRIED TO TURN AWAY FROM TRACTOR TRAILER TO AVOID COLLISION. MY VEHICLE HIT THE REAR TIRE OF THE TRACTOR TRAILER AND I BEGAN TO SWERVE OUT OF CONTROL. MY BRAKES DIDN'T SEEM TO HELP EITHER, THEY DIDN'T FUNCTION. THIS RESULTED IN THE VEHICLE ROLLING OVER 3+ TIMES, THE CAR WAS TOTALED. ALL PASSENGERS WERE HOSPITALIZED BUT NO OTHER VEHICLES OR PEOPLE WERE HURT FROM THE ACCIDENT. MY CONCERN IS REGARDING THE PERIODIC ENGINE SURGE AND/OR JOLTING AND LACK OF BRAKE CONTROL. THIS IS A SAFETY HAZARD THAT MUST BE ADDRESSED IN ORDER TO AVOID FUTURE INCIDENTS. WE WERE VERY LUCKY TO HAVE NOT BEEN KILLED IN THIS AUTO ACCIDENT. *TR
Official recalls
102V021000 · Suspension
Jan 18, 2002
ON CERTAIN 2-WHEEL-DRIVE (2WD) AND 4-WHEEL-DRIVE (4WD) 4RUNNER SPORT UTILITY VEHICLES, A COMBINATION OF HEAVY LOADING (SIMULTANEOUS LOADING TO REAR GROSS AXLE WEIGHT RATING AND GROSS VEHICLE WEIGHT RATING) AND SEVERE STEERING MANEUVERS COULD CAUSE THE 2WD 4RUNNER TO LOSE DIRECTIONAL STABILITY.
Consequence & remedy
Consequence: THIS MAY RESULT IN A LOSS OF CONTROL AND COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE REAR SUSPENSION PARTS. ALTHOUGH THE 4WD 4RUNNERS DO NOT EXHIBIT THE HANDLING CONDITION, TOYOTA WILL RECALL THESE VEHICLES TO AVOID ANY PUBLIC CONFUSION AS TO WHICH VEHICLES SHOULD RECEIVE THE REPLACEMENT PARTS. OWNER NOTIFICATION BEGAN FEBRUARY 28, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.