IllustrationWHILE STARTING ENGINE REVVED A LITTLE AND COOLING FAN EXPLODED, PIECE OF FAN FLEW AS FAR AS 30 FEET AWAY, ALMOST INJURING A BYSTANDER. FAN PIERCED A HOLE IN BATTERY, ALLOWING ACID TO SPILL ONTO THE FLOOR. MECHANIC STATED THAT THIS WAS A POOR DESIGN IN COOLING FAN. AND A VERY DANGEROUS SITUATION.*AK
1990 Toyota 4RUNNER
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1990 Toyota 4RUNNER do not stand out strongly from the model-year median of 58.
About this comparison →How this year compares
Owner complaints by model year
Compare all 4RUNNER years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 15 of 78 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 38 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Power Train. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Structure. Review the 8 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
10 crash reports6 fire reports6 injury reports
Engine And Engine Cooling complaints
38 reportsENGINE BLEW AT 13000 MILES AND VEHICLE STARTED HESITATING AND CUTTING OFF WITHOUT PRIOR WARNING. DEALERSHIP WAS AWARE OF PROBLEM.*AK
VEHICLE WAS IN FOR OIL CHANGE 4 WEEKS PRIOR TO INCIDENT. ENGINE BEGAN TO MAKE A LOUD BANGING NOISE. STOPPED AT A JIFFYLUBE, AND FOUND OIL VERY LOW. FILLED WITH OIL AND WAS TOLD THAT IT SOUNDS LIKE I THREW A ROD, BUT IT SHOULD BE OKAY TO GET ME WHERE I WAS GOING (ABOUT 5 MILES UP THE ROAD). APPROXIMATELY 2 MILES LATER, WHITE …
Read full complaint
VEHICLE WAS IN FOR OIL CHANGE 4 WEEKS PRIOR TO INCIDENT. ENGINE BEGAN TO MAKE A LOUD BANGING NOISE. STOPPED AT A JIFFYLUBE, AND FOUND OIL VERY LOW. FILLED WITH OIL AND WAS TOLD THAT IT SOUNDS LIKE I THREW A ROD, BUT IT SHOULD BE OKAY TO GET ME WHERE I WAS GOING (ABOUT 5 MILES UP THE ROAD). APPROXIMATELY 2 MILES LATER, WHITE SMOKE BEGAN COMING OUT THE BACK OF THE VEHICLE, AND THE BANGING STOPPED. THE SMOKE BECAME VERY BAD, AND I WAS ABOUT TO PULL INTO A GAS STATION WHEN SOMEONE PULLING OUT YELLED TO ME THAT IT WAS ON FIRE (IN THE ENGINE COMPARTMENT). I GOT ME AND MY 2 SMALL BOYS OUT, AND CAME HOME THAT SAME NIGHT TO THE HEAD GASKET RECALL NOTICE IN THE MAIL. I IMMEDIATELY CALLED TOYOTA, WHO SENT SOMEONE OUT TO INVESTIGATE, BUT THEY SAID THAT THE INVESTIGATION CONCLUDED THAT THE CAUSE WAS NOT KNOWN, AND IT WAS NOT THEIR RESPONSIBILITY. I WAS READING MORE HORROR STORIES ABOUT THIS ON YOUR SITE. WHAT CAN BE DONE? MY VEHICLE WAS PAID FOR AND MY INSURANCE DID NOT COVER FIRE. WHY DID IT TAKE THEM SO LONG TO GET THE HEAD GASKET RECALL NOTICE TO ME? IT APPEARS THAT THIS WAS AN ISSUE FOR SEVERAL YEARS. I BASICALLY DROPPED THE ISSUE FOR SEVERAL YEARS FIGURING I WAS FIGHTING A LOSING BATTLE, UNTIL I DISCOVERED THIS SITE. THANKS.*AK
PASSENGER'S SIDE EXTERIOR MIRROR WOULD SEVERELY VIBRATE WHEN TRAVELING AT 30MPH OR MORE. THIS CAUSED POOR VISIBILITY. DEALER NOTIFIED, AND WAS UNWILLING TO ASSIST ON THIS MATTER. FEEL FREE TO PROVIDE ANY FURTHER INFORMATION ON THIS PROBLEM.*AK
VEHICLE WAS REPAIRED FOR A RECALL ISSUED BY MANUFAC. ON THE HEAD GASKET, BUT THAN IT BLEWUP AGAIN. CONSUMER ALSO FOUND PAPER IN OIL PAN. DEALER WILL REPAIR BUT ON CONSUMER'S COSTS.*AK
MY TOYOTA 4-RUNNER BLEW A HEAD GASKET 10 MONTHS AFTER PURCHASE. I CONTACTED BOTH RENO TOYOTA AND CARSON TOYOTA. NIETHER DEALER WERE HELPFULL IN RECALL INFORMATION. AFTER REPLACING THE MOTOR, MY MECHANIC ASSURED ME THAT IT WAS A COMMON ACCURANCE IN THE 4-RUNNER TO HAVE FAULTY HEAD GASKETS. I THEN CONTACTED CARSON TOYOTA AND T…
Read full complaint
MY TOYOTA 4-RUNNER BLEW A HEAD GASKET 10 MONTHS AFTER PURCHASE. I CONTACTED BOTH RENO TOYOTA AND CARSON TOYOTA. NIETHER DEALER WERE HELPFULL IN RECALL INFORMATION. AFTER REPLACING THE MOTOR, MY MECHANIC ASSURED ME THAT IT WAS A COMMON ACCURANCE IN THE 4-RUNNER TO HAVE FAULTY HEAD GASKETS. I THEN CONTACTED CARSON TOYOTA AND THEY TOLD ME THAT THEY WOULD FIX THE PROBLEM BUT NOT PAY FOR ANYONE ELSE TO DO SO. BY THE TIME THEY CONTACTED ME THE WORK WAS COMPLETE AND A BILL OF OVER $6500 WAS INCURED. I DONT BELIEVE THEY WOULD HAVE OFFERED TO FIX THE PROBLEM IF THEY DIDN'T KNOW IT EXISTED. I CAN'T SEEM TO GET ANY RECALL INFORMATION FROM TOYOTA, AND I WAS HOPING YOU COULD HELP. THANKYOU , RON COLLINS. *AK
WATER IS BEING SUCKED INTO ENGINE, AND HEAD GASKET PROBLEM. THERE IS A DEFECT IN HEAD ENGINE GASKET. TOYOTA IS AWARE OF PROBLEM. *AK
THIS PARTICULAR TYPE OF HEAD GASKET FAILURE (COOLANT LEAKAGE INTO THE CYLINDER) IS A KNOWN PROBLEM ON THE 3VZ-E ENGINE, TOYOTA INITIATED A SPECIAL SERVICE CAMPAIGN (V06) TO REPAIR MOST, HOWEVER THE CONSUMER'S VEHICLE DOES NOT QUALIFY DUE TO THE VIN # RANGE. *MJS
STARTED AND LOW SPEED STRANGE NOISE AND ANTIFREZE SPEWING, HEAD GASKET BLOWN (REPLACED IN 1998) ONLY 42 K MILES INTO NEW GASKET. *AK
THREW A ROD, RESULTING IN TOTAL ENGINE FAILURE. COMPLETE OIL LOSS BLAMED - CAUSE UNKNOWN. HEAD GASKET REPLACED IN APRIL OF 1996. THIS OCCURRED IN MAY OF 1997.*AK
Official recalls
105V389000 · Steering:linkages:rod:relay:connecting
Sep 6, 2005
ON CERTAIN PICKUP TRUCKS AND SPORT UTILITY VEHICLES, IF THE STEERING WHEEL IS REPEATEDLY TURNED UNDER CERTAIN CONDITIONS WHERE HIGH STEERING EFFORT AND POWER ASSIST ARE REQUIRED, FOR INSTANCE, WHEN FULLY TURNING THE WHEEL WHILE THE VEHICLE IS STOPPED, A FATIGUE CRACK MAY DEVELOP IN THE STEERING RELAY ROD.
Consequence & remedy
Consequence: IF THE VEHICLE IS CONTINUED TO BE OPERATED IN THIS CONDITION, THE RELAY ROD MAY FRACTURE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE STEERING RELAY ROD. THE RECALL BEGAN OCTOBER 5, 2005. OWNERS MAY CONTACT TOYOTA AT 1-800-331-4331.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
4DP02002 · Rear Seat Belt Routing
Opened Mar 26, 2002 · Closed Aug 26, 2002
Status: closed (inferred from source dates) · Seat Belts:rear/other
No summary supplied.
SQ99003 · Corroded Brake Lines
Opened Jan 27, 1999 · Closed Apr 22, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
TOYOTA IS CONDUCTING A SAFETY RECALL IN CANADA 98-253. CORRODED BRAKE LINES COULD FAIL RESULTING IN A PARTIAL BRAK SYSTEM LOSS AND INCREASED STOPPING DISTANCES
EA92011 · Loss Of Brk Effectiveness
Opened Mar 24, 1992 · Closed Jan 21, 1993
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91147 · Loss Of Brake Effectivenes
Opened Nov 6, 1991 · Closed Mar 24, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
===