2002 ALLEGRO RV, NEW, HAS DEMONSTRATED REPEATED SAFETY VIOLATIONS, WINDSHIELD WIPERS (2) INOPERATIVE/FAILURE TWICE, ONCE AFTER REPAIRED. SEAT BELT INOPERATIVE/FAILURE TWICE, ONCE AFTER REPAIRED. WINDSHIELDS (2) REPLACE TWICE DUE TO STRESS BREAKAGE. OVERHEAD A/C BLOWS FUSES, BECAUSE OF SHORTAGE, FUSE PANEL LOCATED UNDER CLOSET OV…
Read full complaint
2002 ALLEGRO RV, NEW, HAS DEMONSTRATED REPEATED SAFETY VIOLATIONS, WINDSHIELD WIPERS (2) INOPERATIVE/FAILURE TWICE, ONCE AFTER REPAIRED. SEAT BELT INOPERATIVE/FAILURE TWICE, ONCE AFTER REPAIRED. WINDSHIELDS (2) REPLACE TWICE DUE TO STRESS BREAKAGE. OVERHEAD A/C BLOWS FUSES, BECAUSE OF SHORTAGE, FUSE PANEL LOCATED UNDER CLOSET OVER THE PROPPANE TANK. IF PANEL FAILS THEN FIRE COULD CAUSE DEATH OR INJURY. HAVE ALL RELATED CORRESPONDENCE, CAN FURNISH YOUR OFFICE. RV PLACE "IN-OP STATUS" WITH CA DMV BECAUSE OWNER AFRAID TO OPERATE UNDER CURENT CONDITIONS. *AK
NHTSA ODI #10116749
3,134 miles · Mar 29, 2005
Electrical SystemEquipmentLatches/locks/linkages
2002 TIFFIN ALLEGRO HAS PROBLEMS WITH WINDSHIELD WIPERS, SEAT BELT MALFUNCTIONED, AND DOOR LOCKS.*MR THE CONSUMER WAS UNABLE TO LATCH THE SEAT BELT, THE MOTOR UNIT OF THE WINDSHIELD WIPERS WAS COMPLETELY DETACHED FROM THE BODY, BOTH WINDSHIELDS BROKE DUE TO STRESS. THE VEHICLE HAD AN ELECTRICAL DEFECT THAT CONTINUOUSLY CAUSED…
Read full complaint
2002 TIFFIN ALLEGRO HAS PROBLEMS WITH WINDSHIELD WIPERS, SEAT BELT MALFUNCTIONED, AND DOOR LOCKS.*MR THE CONSUMER WAS UNABLE TO LATCH THE SEAT BELT, THE MOTOR UNIT OF THE WINDSHIELD WIPERS WAS COMPLETELY DETACHED FROM THE BODY, BOTH WINDSHIELDS BROKE DUE TO STRESS. THE VEHICLE HAD AN ELECTRICAL DEFECT THAT CONTINUOUSLY CAUSED POWER FAILURES AND CIRCUIT BREAKERS TO BLOW. THE COMMODE WAS INOPERABLE. THE RV HAD A DEFECT IN THE DESIGN WHICH ALLOWED STRUCTURAL MOVEMENT.*JB
NHTSA ODI #10117504
Mileage unknown · Feb 7, 2005
Electrical SystemEngine And Engine CoolingEquipment
TIFFIN MOTORHOME PROBLEMS EXPERIENCE WITH RV DRIVERS SEAT BELT , BOTH WINDSHIELD WIPERS AND ELECTRICAL SYSTEM. VEHICLE WARPED AND MISALIGNED BODY CHASSIS. *BF THE VEHICLE OVERHEAD A/C FAILED. THE 20 AMP FUSE BLEW INTERMITTENTLY WHEN THE CONSUMER TRIED TO USE THE A/C. WHEN THE CONSUMER ATTEMPTED TO BUCKLE THE BELT IT TIGHTEN…
Read full complaint
TIFFIN MOTORHOME PROBLEMS EXPERIENCE WITH RV DRIVERS SEAT BELT , BOTH WINDSHIELD WIPERS AND ELECTRICAL SYSTEM. VEHICLE WARPED AND MISALIGNED BODY CHASSIS. *BF THE VEHICLE OVERHEAD A/C FAILED. THE 20 AMP FUSE BLEW INTERMITTENTLY WHEN THE CONSUMER TRIED TO USE THE A/C. WHEN THE CONSUMER ATTEMPTED TO BUCKLE THE BELT IT TIGHTENED AND WOULDN'T RELEASE. THE ENTRANCE DOOR WAS OUT OF ALIGNMENT THEREFORE IT COULDN'T BE LOCKED FORM THE OUTSIDE. THE DINING SEAT TOP RAISED UP ABOUT AND INCH BECAUSE IT HAD NOTHING UNDER IT FOR SECURITY. THE EXHAUST PIPE WAS NOT ATTACHED TO THE FRAME OF THE VEHICLE. THE TOILET VALVE STUCK IN THE OPEN POSITION LEAVING THE TANK EXPOSED OR THE SMELL TO COME BACK INTO THE VEHICLE. THE REARVIEW MIRROR MOVED WHILE THE CONSUMER WAS YIELDING INTO TRAFFIC. THE WINDSHIELD HAD STRESS CRACKS FROM BEING INSTALLED INCORRECTLY. *NM
TIFFIN MOTORHOMES IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence & remedy
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: TIFFIN MOTORHOMES IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE SAFETY RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101.
TIFFIN IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
Consequence & remedy
Consequence: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
Remedy: TIFFIN IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN ON FEBRUARY 17, 2011. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR TIFFIN AT 1-256-356-8661.
NAVISTAR IS RECALLING CERTAIN MODEL YEAR MY 2001-2008 WORKHORSE W20, W21 AND W22 CHASSIS AND CERTAIN MODEL YEAR 2009 THROUGH 2011 MONACO RV ADMIRAL, ARISTA, MONARCH, AND RIPTIDE RECREATIONAL VEHICLES EQUIPPED WITH AXLES THAT INCLUDE BOSCH ZOPS OR ZOHT PIN SLIDE HYDRAULIC DISC BRAKES. WHEN COMBINED WITH OCCASIONAL OR SEASONAL VEHICLE OPERATION MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION. THIS CAN RESULT IN ABNORMAL HEAT GENERATION AT THE WHEEL END CAUSING BRAKE DRAG. THE DRIVER WOULD NORMALLY HAVE WARNING OF THE BRAKE DRAG IF UNDETECTED BY THE DRIVER.
Consequence & remedy
Consequence: THE TEMPERATURE INCREASE AT THE WHEEL END CAN EVENTUALLY LEAD TO SOFT PEDAL CONDITIONS DUE TO BRAKE FLUID BOIL, AND POSSIBLE EXTENDED STOPPING DISTANCE INCREASING THE RISK OF A CRASH.
Remedy: WORKHORSE DEALERS WILL REPLACE ALL FOUR BOSCH BRAKE CALIPER ASSEMBLIES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON SEPTEMBER 16, 2010. OWNERS MAY CONTACT WORKHORSE AT 1-877-246-7731.
ON CERTAIN MOTOR HOMES EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION, THESE REFRIGERATORS MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: TIFFIN MOTORHOMES WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR TIFFIN AT 1-256-356-8661.
CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105, "HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY STANDARD.
Consequence & remedy
Consequence: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE BRAKE SYSTEM WARNING INDICATOR.
Remedy: DEALERS WILL REPAIR THE BRAKE WARNING LAMP CIRCUIT. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT TIFFIN AT 1-256-356-8661.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Tiffin Allegro Problems, Complaints & Recalls | Skip That Year
Illustration