Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 3 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Engine And Engine Cooling. Review the 2 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports1 injury reports
What owners actually said
3 reports
58,335 miles · Sep 28, 2004
Engine And Engine CoolingInjury
THE SCHOOL BUS LEAKED ANTIFREEZE AND FUMES SEEPED OUT INTO THE SCHOOL BUS. *JB MANUFACTURES DEFECT, ANTIFREEZE VAPORS INSIDE PASSENGER COMPARTMENT. PUMP TO POWERFUL OMITS ANTIFREEZE VAPORS. THE CONSUMER STATED THAT DRIVERS ACROSS THE COUNTRY ARE GETTING PERMINENT LUNG DAMAGE FROM THE FUMES. THE CONSUMER STATED THAT SHE HAS…
Read full complaint
THE SCHOOL BUS LEAKED ANTIFREEZE AND FUMES SEEPED OUT INTO THE SCHOOL BUS. *JB MANUFACTURES DEFECT, ANTIFREEZE VAPORS INSIDE PASSENGER COMPARTMENT. PUMP TO POWERFUL OMITS ANTIFREEZE VAPORS. THE CONSUMER STATED THAT DRIVERS ACROSS THE COUNTRY ARE GETTING PERMINENT LUNG DAMAGE FROM THE FUMES. THE CONSUMER STATED THAT SHE HAS BEEN SICK EVER SINCE THE BUS WAS ASSIGNED. THE CONSUMER STATED THAT THE HEATER PUMP IS TO LARGE IN THE BUSES HOSES HELD ON WITH TINY CLAMS. THE CONSUMER STATED THAT THE EMPLOYER REFUSED TO GIVE HER THE VIN NUMBER. *TC
NHTSA ODI #10009419
Mileage unknown · Mar 23, 2004
Engine And Engine Cooling
WHILE DRIVING 70 MPH VEHICLE SHUT OFF. THIS RESULTED IN LOSS OF STEERING CAPABILITY AND POWER BRAKING. AFTER BEING SERVICED TECHNICIAN WAS UNABLE TO DUPLICATE THE PROBLEM. *AK
NHTSA ODI #10064710
Mileage unknown · Jan 11, 2002
Electrical System
ALTERNATOR IS CLOSE TO OIL FILTER. LOWER BRACKET FELL WHERE ALTERNATOR IS LOCATED TOUCHING OIL FILTER. CONTACTED DEALER. *AK
NHTSA ODI #8002058
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
ODI HAS RECEIVED SEVERAL FAILED SWITCHES THAT SHOW SIGNS OF MELTING OR DAMAGE FROM OVER- HEATING.THE SWITCH SUPPLIER HAS INITIATED A TEST PROGRAM TO DETERMINE THE CAUSE OF THESE FAILURES.ODI IS CONCERNED ABOUT THE PRESENCE OF A HEAT SOURCE THAT POTENTIALLY COULD LEAD TO AN ELECTRICAL FIRE, AS WELL AS THE ABSENCE OF NECESSARY VEHICLE LIGHTING.ODI WILL CONTINUE ITS INVESTIGATION TO VERIFY THE EXTENT OF THE PROBLEM REPRESENTED BY THE REPORTED FAILURES AND EVALUATE THE ASSOCIATED RISKS.
Additional source detail variants (2)
Exterior Lighting:headlights:switch
ODI HAS RECEIVED SEVERAL FAILED SWITCHES THAT SHOW SIGNS OF MELTING OR DAMAGE FROM OVER- HEATING.THE SWITCH SUPPLIER HAS INITIATED A TEST PROGRAM TO DETERMINE THE CAUSE OF THESE FAILURES.ODI IS CONCERNED ABOUT THE PRESENCE OF A HEAT SOURCE THAT POTENTIALLY COULD LEAD TO AN ELECTRICAL FIRE, AS WELL AS THE ABSENCE OF NECESSARY VEHICLE LIGHTING.ODI WILL CONTINUE ITS INVESTIGATION TO VERIFY THE EXTENT OF THE PROBLEM REPRESENTED BY THE REPORTED FAILURES AND EVALUATE THE ASSOCIATED RISKS.
Interior Lighting
ODI HAS RECEIVED SEVERAL FAILED SWITCHES THAT SHOW SIGNS OF MELTING OR DAMAGE FROM OVER- HEATING.THE SWITCH SUPPLIER HAS INITIATED A TEST PROGRAM TO DETERMINE THE CAUSE OF THESE FAILURES.ODI IS CONCERNED ABOUT THE PRESENCE OF A HEAT SOURCE THAT POTENTIALLY COULD LEAD TO AN ELECTRICAL FIRE, AS WELL AS THE ABSENCE OF NECESSARY VEHICLE LIGHTING.ODI WILL CONTINUE ITS INVESTIGATION TO VERIFY THE EXTENT OF THE PROBLEM REPRESENTED BY THE REPORTED FAILURES AND EVALUATE THE ASSOCIATED RISKS.
1999 Thomas School Bus Problems, Complaints & Recalls | Skip That Year
Illustration