2007 Suzuki XL7

I have this airbag light on problem stated below. It seems it should be a safety recall. Possible solution for Airbag light on Seat Sensor Ok, I'm going to ask a couple of questions and hope that [XXX] or someone with knowledge chimes in. I originally had this problem in my wife's car a couple of months ago, airbag light on, clock flashing after going over a bump with my 240lb ass in the passenger seat. We got home, turned the car off, restarted it and it went through the power-up self test I guess and the fault cleared itself. The other day it started up again, no bump but still had the fat guy in the seat. I noticed that I only saw this issue referring to 2004 model xl7s. I've looked and haven't seen 2003s, or 2005s. The TSB for this issue ONLY refers to 2004 models and says that this is the updated part number 86605-53JA1. If you look at this site that has them in stock: [XXX] It says that part fits 2004-2006. I found the published date for the TSB somewhere online as 12/2004 so they apparently knew the problem early, made an update/change and moved on. Probably changing the design sometime mid-year 04? I don't like the idea of spending $1400 for a part. So, I checked [XXX] and found a nice passenger seat from a 2005 locally for about $75 in a boneyard. Does anyone have any advice why swapping in a 2005 seat (or just the base if the color is wrong, whatever) is a bad idea? Does anyone know if there has to be any special dealer magic/ calibration/ etc done if I put this in myself? I haven't yet had the time to pull the seat out of the car, flip it over and check things out. But I'm not super hopeful that I can fix whatever this sensor is since nobody else has posted anything in the last 13 years. Thanks for your interest. VIN [XXX] For reference, Here's the text from the TSB And there is no recall information at Home | National Highway Traffic Safety Admin INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The contact owns a 2007 Suzuki XL7. The contact stated that the vehicle was taken to the dealer after she discovered that the VIN was included in NHTSA Campaign Number: 12V597000 (Fuel System, Gasoline). The contact stated that after the vehicle was retrieved from the dealer and the recall was presumably completed, the vehicle was driven to the residence and parked. The contact then stated on the same day while driving at an undisclosed speed, there was an abnormal fuel odor throughout the cabin of the vehicle before the vehicle stalled. The vehicle was towed back to the residence. The contact then notified the dealer of the failure, but the contact was denied service. The vehicle was towed to an independent mechanic to be diagnosed. The contact was informed that the crank shaft position sensor was faulty. The contact stated that she previously had the vehicle diagnosed by a different independent mechanic and was informed that the engine was not getting fuel when the vehicle was started. The contact was informed that the fuel pump module assembly needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and the contact was informed that the recall was completed, and further repairs would be at the expense of the owner. The failure mileage was approximately 215,000.

The contact owns a 2007 Suzuki XL7. The contact stated while approaching the vehicle, the contact became aware of gasoline fumes outside of the vehicle. Additionally, while attempting to start the vehicle, several attempts were needed to start the vehicle. The contact took the vehicle to an independent mechanic to be diagnosed. The contact stated that the failure was with the pressure line attached to the fuel pump which leaked and cracked. The mechanic installed a seal into the crack of the fuel pump to temporarily repair the failure. The mechanic recommended that the fuel pump be replaced. The vehicle was not yet repaired. The manufacture was not made aware of the failure. The approximate failure mileage was 194,000.

TL* THE CONTACT OWNS A 2007 SUZUKI XL7. THE CONTACT STATED THAT HE BECAME AWARE THAT THE FUEL PUMP WAS LEAKING FUEL NEARBY THE REAR PASSENGER'S SIDE TIRE. THE CONTACT STATED THAT THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC AND HE WAS INFORMED THAT THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT YET DIAGNOSED NOR REPAIRED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS INFORMED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 223,000.

TL* THE CONTACT OWNS A 2007 SUZUKI XL7. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE WOULD NOT ACCELERATE. THE CONTACT WAS ABLE TO PULL THE VEHICLE OVER AND IT RESTARTED AFTER SEVERAL ATTEMPTS. THE FAILURE OCCURRED INTERMITTENTLY. ALSO, THE CHECK ENGINE WARNING INDICATOR ILLUMINATED. THE DEALER AND MANUFACTURER WERE NOT NOTIFIED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 172,000.