TL* THE CONTACT OWNS A 2002 SUZUKI XL7. THE CONTACT STATED THAT THE VEHICLE WOULD PULL TO THE RIGHT ABNORMALLY WHEN DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FAILURE WAS LOCATED AS THE FRONT CROSS MEMBER BEING BROKEN DUE TO DEFECTIVE MATERIAL. THE FAILURE CAUSED THE ENGINE TO LEAN TO THE RIGHT. THE …
Read full complaint
TL* THE CONTACT OWNS A 2002 SUZUKI XL7. THE CONTACT STATED THAT THE VEHICLE WOULD PULL TO THE RIGHT ABNORMALLY WHEN DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC AND THE FAILURE WAS LOCATED AS THE FRONT CROSS MEMBER BEING BROKEN DUE TO DEFECTIVE MATERIAL. THE FAILURE CAUSED THE ENGINE TO LEAN TO THE RIGHT. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 137,000 AND THE CURRENT MILEAGE WAS 141,000.
NHTSA ODI #10459408
Mileage unknown · Dec 18, 2003
Suspension
EXCESSIVE TIRE WEAR ON FRONT INSIDE TIRES. TIRES WEAR THROUGH TREAD ON INSIDE WHEEL WITHIN 5,000 MILES OF BEING PLACED ON FRONT OF CAR. MANUFACTURER REFUSES TO DO ANYTHING ABOUT . CAR HAS BEEN IN 4 TIMES TO SUZUKI DEALER.*AK
ON CERTAIN SPORT UTILITY VEHICLES EQUIPPED WITH 16-INCH WHEELS, THE FRONT BRAKE DISCS MAY BREAK UNDER SEVERE DRIVING CONDITIONS. THE BREAKAGE CAN OCCUR IN CONDITIONS WHERE THE VEHICLE IS DRIVEN ON A REGULAR BASIS ON EXTREMELY STEEP PAVED DOWN-SLOPES WHILE CONTINUOUSLY APPLYING THE BRAKES.
Consequence & remedy
Consequence: THE FRONT BRAKES MAY BECOME INOPERATIVE AND THE VEHICLE MAY PULL TO ONE SIDE. THIS COULD RESULT IN A CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL REPLACE THE FRONT BRAKE DISCS ON THESE VEHICLES. THE RECALL BEGAN ON NOVEMBER 10, 2005. THESE VEHICLES ARE LOCATED ON ST. THOMAS ISLAND (VIRGIN ISLANDS). OWNERS MAY CONTACT SUZUKI DEL CARIBE AT 787-622-0600.
ON CERTAIN SPORT UTILITY VEHICLES, THE ACCELERATOR CABLE CASING CAP THAT IS ATTACHED TO THE VEHICLE FIREWALL CAN CRACK DUE TO EXTENDED EXPOSURE TO FORCES FROM THE ACCELERATOR CABLE AND INSUFFICIENT LONG-TERM DURABILITY OF THE PLASTIC CASING CAP. IF THE CASING CAP BECOMES CRACKED, MOVEMENT OF THE INNER ACCELERATOR CABLE THROUGH THE CAP CAN CAUSE THE INNER ACCELERATOR CABLE TO BECOME FRAYED.
Consequence & remedy
Consequence: IF THE INNER ACCELERATOR CABLE BECOMES FRAYED, IT CAN STICK DURING VEHICLE OPERATION. IN THE CASE WHERE AN ACCELERATOR CABLE STICKS, THE DRIVER COULD HAVE DIFFICULTY CONTROLLING VEHICLE SPEED, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL REPLACE THE ACCELERATOR CABLE, WHICH INCLUDES THE PLASTIC CASING CAP. OWNER NOTIFICATION BEGAN ON JANUARY 5, 2004. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2002 Suzuki XL-7 Problems, Complaints & Recalls | Skip That Year
Illustration