TL* THE CONTACT OWNS A 2005 SUZUKI FORENZA. THE CONTACT STATED THAT THE DRIVER SIDE DOOR AUTOMATICALLY LOCKS WHEN THE VEHICLE WAS PLACED IN DRIVE. THE CONTACT MENTIONED THAT THERE WAS NO BUTTONS TO UNLOCK THE DOORS FROM THE INSIDE. AS A RESULT, THE CONTACT STATED THAT THEY WERE STUCK IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE …
Read full complaint
TL* THE CONTACT OWNS A 2005 SUZUKI FORENZA. THE CONTACT STATED THAT THE DRIVER SIDE DOOR AUTOMATICALLY LOCKS WHEN THE VEHICLE WAS PLACED IN DRIVE. THE CONTACT MENTIONED THAT THERE WAS NO BUTTONS TO UNLOCK THE DOORS FROM THE INSIDE. AS A RESULT, THE CONTACT STATED THAT THEY WERE STUCK IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE WHO DID NOT OFFER ANY ASSISTANCE. THE FAILURE MILEAGE WAS UNKNOWN, BUT THE CURRENT MILEAGE WAS 130,000.
NHTSA ODI #10480694
17,437 miles · Sep 5, 2006
Air BagsElectrical SystemLatches/locks/linkages
SUZUKI AUTOMOTIVE OF CERRITOS AND SANTA ANA HAVE FAILED TO TIMELY REPAIR AND/OR INSTALL DAMAGED/DEFECTIVE PARTS ON MY 2005 FORENZA. DEFECTIVE/DAMAGED PARTS INCLUDE INTERIOR DOOR HANDLES, AIR BAG HARNESS/WIRING, AC KNOBS, STEREO BUTTONS ATTACHED TO STEERING WHEEL. FURTHER, SUZUKI HAS FAILED TO PROPERLY CORRESPOND WITH ME CONCERNI…
Read full complaint
SUZUKI AUTOMOTIVE OF CERRITOS AND SANTA ANA HAVE FAILED TO TIMELY REPAIR AND/OR INSTALL DAMAGED/DEFECTIVE PARTS ON MY 2005 FORENZA. DEFECTIVE/DAMAGED PARTS INCLUDE INTERIOR DOOR HANDLES, AIR BAG HARNESS/WIRING, AC KNOBS, STEREO BUTTONS ATTACHED TO STEERING WHEEL. FURTHER, SUZUKI HAS FAILED TO PROPERLY CORRESPOND WITH ME CONCERNING THESE ISSUES. MOST CONTACTS WERE INITIATED BY ME. *JB
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2008 Forenza vehicles, and 2005-2008 Reno vehicles manufactured from September 1, 2003, through July 30, 2008. In the affected vehicles, heat may be generated in the headlamp switch or daytime running light (DRL) module which could melt the headlamp switch or the DRL module.
Consequence & remedy
Consequence: If the heat generated within the headlamp switch or DRL module located on the left side of the steering column melts the headlamp switch or DRL module, there is an increased risk of a fire.
Remedy: Suzuki will replace the signal switch and add a jumper relay kit and will replace the DRL Module in teh instrument panel harness. Suzuki distributed to owners an interim letter on July 30, 2014. The recall began October 29, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's number for this recall is XA.
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence & remedy
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Additional source detail variants (2)
Exterior Lighting:headlights
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Electrical System:wiring:interior/under Dash
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.
Consequence & remedy
Consequence: INAPPROPRIATE LIGHTING COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.
Remedy: DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRL FREE OF CHARGE. THE RECALL WILL BE MAILED IN THREE PHASES, STARTING AT THE END OF OCTOBER 2007 AND CONCLUDING BY THE END OF JANUARY 2008;. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE07039 · Headlight / Drl Malfunction
Opened Jul 24, 2007 · Closed Oct 2, 2007
Status: closed (inferred from source dates) · Exterior Lighting:headlights
ON SEPTEMBER 25, 2007, SUZUKI NOTIFIED THE AGENCY THAT IT WILL RECALL MODEL YEARS 2004 -2006 FORENZA AND RENO VEHICLES TO CORRECT A DEFECT THAT CAN RESULT IN LOSS OF HEADLIGHT AND/OR DRL FUNCTION.THIS RECALL AFFECTS 93,963 VEHICLES.NHTSA ASSIGNED NUMBER 07V-452 FOR THIS RECALL.NHTSA'S INVESTIGATION INITIALLY FOCUSED ON 2005 FORENZAS, THEN EXPANDED IT TO 2004-2005 FORENZAS (TOTAL OF 58,448 VEHICLES). SUZUKI BROADENED THE RECALL SCOPE TO COVER 2004-2006 FORENZAS & RENOS (93,963 VEHICLES).THE WIRING HARNESS BEHIND THE INSTRUMENT PANEL CONTAINS A SPLICE PACK TO CONNECT THE POWER CIRCUIT WIRES FOR LOW-BEAM HEADLAMPS AND DAYTIME RUNNING LAMPS (DRL).INCREASED RESISTANCE DUE TO POOR CONTACT BETWEEN TERMINALS CAN GENERATE HEAT WHICH CAN LEAD TO MELTING OF THE SPLICE PACK IN THE AREA OF WIRES AND THE LOSS OF HEADLIGHT AND/OR DRL FUNCTION. FOR THE REMEDY, DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRLS FREE OF CHARGE.SUZUKI'S RECALL CAMPAIGN (MANUFACTURER RECALL NO. NB) IS EXPECTED TO START AT THE END OF OCTOBER 2007.CUSTOMERS MAY CONTACT SUZUKI AT 1-800-934-0934.
2005 Suzuki Forenza Problems, Complaints & Recalls | Skip That Year
Illustration