IllustrationWHEN INSERTING KEY THE LOOK FELL INSIDE THE DOOR (NOTE: THIS PROBLEM WAS SUBJECT TO AN NHTSA RECALL, BUT MY VIN NUMBER WAS NOT INCLUDED)
2004 Suzuki Forenza
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2004 Suzuki Forenza do not stand out strongly from the model-year median of 156.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forenza years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
120–25K
625–50K
1150–75K
575–100K
6100–150K
0150K+
40 reports with mileage · 23 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 10 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
9 crash reports5 fire reports3 injury reports
Structure complaints
5 reportsTL* THE CONTACT OWNS A 2004 SUZUKI FORENZA. WHILE EXITING THE VEHICLE, THE CONTACT REACHED FOR THE FRONT DRIVER SIDE DOOR HANDLE AND IT DETACHED IN ITS ENTIRETY. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 52,000.
TL*THE CONTACT OWNS A 2004 SUZUKI FORENZA. A 10 MONTH OLD BABY WAS ABLE TO REMOVE THE COVER FOR THE DOOR SCREW. THE COVER WAS LOCATED UNDER THE HANDLE. THE BABY WAS NOT RESTRAINED IN A CHILD SEAT AND HAD THE COVER IN HIS MOUTH. THE DEALER STATED THAT THE COVERS WERE DESIGNED TO POP OFF. THE CURRENT AND FAILURE MILEAGES WERE…
Read full complaint
TL*THE CONTACT OWNS A 2004 SUZUKI FORENZA. A 10 MONTH OLD BABY WAS ABLE TO REMOVE THE COVER FOR THE DOOR SCREW. THE COVER WAS LOCATED UNDER THE HANDLE. THE BABY WAS NOT RESTRAINED IN A CHILD SEAT AND HAD THE COVER IN HIS MOUTH. THE DEALER STATED THAT THE COVERS WERE DESIGNED TO POP OFF. THE CURRENT AND FAILURE MILEAGES WERE 72,000. UPDATED 12/11/07
DT: CONSUMER'S VEHICLE REAREND. NOISE COMING FROM THE DRIVETRAIN. CONSUMER TOOK VEHICLE TO DEALER TO BE REPAIRED. DEALER COULD FIND NO PROBLEM , CONSUMER TOOK IT BACK TO THE DEALER AND THE DEALER KEPT THE VEHICLE FOR A WEEK. THEN, DEALER SAID PROBLEM WAS COMING FROM THE FIREWALL OR THE ASHTRAY, THE SECOND TIME, AFTER THE VE…
Read full complaint
DT: CONSUMER'S VEHICLE REAREND. NOISE COMING FROM THE DRIVETRAIN. CONSUMER TOOK VEHICLE TO DEALER TO BE REPAIRED. DEALER COULD FIND NO PROBLEM , CONSUMER TOOK IT BACK TO THE DEALER AND THE DEALER KEPT THE VEHICLE FOR A WEEK. THEN, DEALER SAID PROBLEM WAS COMING FROM THE FIREWALL OR THE ASHTRAY, THE SECOND TIME, AFTER THE VEHICLE WAS PICKED UP BY THE CONSUMER, DID NOT RECEIVE PAPER WORK, WHEN CONSUMER RECEIVED PAPER WORK IT STATEDTHAT THE REAR BRAKES WERE RUSTED. *AK
I PURCHASED A SUZUKI FORENZA 9/2004. THE MAIN REASON I PURCHASED IT WAS BECAUSE OF THE MPGS. IT WAS SOLD AS 22-28 MPG. I HAVE NOT RECEIVED BETTER THAN 17 MPGS UNDER ANY CONDITIONS!!!! THIS IS NOT EVEN CLOSE. IT IS ALSO A 4 CYLINDER. THE DEALER HAS BEEN NOTIFIED, AND STATED THAT THEY ARE GETTING A LOT OF COMPLAINTS. THEY STATED T…
Read full complaint
I PURCHASED A SUZUKI FORENZA 9/2004. THE MAIN REASON I PURCHASED IT WAS BECAUSE OF THE MPGS. IT WAS SOLD AS 22-28 MPG. I HAVE NOT RECEIVED BETTER THAN 17 MPGS UNDER ANY CONDITIONS!!!! THIS IS NOT EVEN CLOSE. IT IS ALSO A 4 CYLINDER. THE DEALER HAS BEEN NOTIFIED, AND STATED THAT THEY ARE GETTING A LOT OF COMPLAINTS. THEY STATED THE GOVERNMENT FIXES THESE MPG'S-DOESN'T THAT MEAN THEY ARE RESPONSIBLE TO MEET THESE GUIDELINES. WITH GAS PRICES WHAT THEY ARE, THIS CAR IS NO LINGER FUEL ECONOMIC. *AK
Official recalls
514V262000 · Exterior Lighting:headlights
May 19, 2014
Suzuki Motor of America, Inc. (Suzuki) is recalling certain model year 2004-2008 Forenza vehicles, and 2005-2008 Reno vehicles manufactured from September 1, 2003, through July 30, 2008. In the affected vehicles, heat may be generated in the headlamp switch or daytime running light (DRL) module which could melt the headlamp switch or the DRL module.
Consequence & remedy
Consequence: If the heat generated within the headlamp switch or DRL module located on the left side of the steering column melts the headlamp switch or DRL module, there is an increased risk of a fire.
Remedy: Suzuki will replace the signal switch and add a jumper relay kit and will replace the DRL Module in teh instrument panel harness. Suzuki distributed to owners an interim letter on July 30, 2014. The recall began October 29, 2014. Owners may contact Suzuki at 1-800-934-0934. Suzuki's number for this recall is XA.
12V397000 · Electrical System:wiring:interior/under Dash; Exterior Lighting:headlights
Aug 14, 2012
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence & remedy
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Additional source detail variants (2)
Exterior Lighting:headlights
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
Electrical System:wiring:interior/under Dash
Suzuki is recalling certain model year 2004-2006 Forenza and model year 2005-2006 Reno vehicles manufactured from September 23, 2003, through March 7, 2006. Increased resistance due to poor contact between the terminals of certain wires can generate heat that can melt the splice pack used to connect the power circuit wires for the headlamps. This can result in intermittent or total loss of low/high beam headlamp function.
Consequence: If the headlamps fail to function, this will lead to reduced driver visibility, increasing the risk of a crash.
Remedy: Suzuki will notify owners, and Suzuki dealers will reconnect the affected wires with two heat-shrink crimps, free of charge. The safety recall began on September 25, 2012. Owners may contact Suzuki at 1-877-697-8985.
07V452000 · Exterior Lighting
Sep 25, 2007
ON CERTAIN PASSENGER VEHICLES, HEADLAMP LOW BEAM OR DAYTIME RUNNING LIGHT (DRL) FUNCTION MAY BE INOPERATIVE DUE TO A MELTED SPLICE PACK ON THE WIRING HARNESS.
Consequence & remedy
Consequence: INAPPROPRIATE LIGHTING COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.
Remedy: DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRL FREE OF CHARGE. THE RECALL WILL BE MAILED IN THREE PHASES, STARTING AT THE END OF OCTOBER 2007 AND CONCLUDING BY THE END OF JANUARY 2008;. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
05V022000 · Exterior Lighting:brake Lights:switch
Jan 28, 2005
ON CERTAIN PASSENGER VEHICLES, THE BRAKE LIGHT SWITCH MAY BECOME MISADJUSTED IF AN UPWARD/REARWARD FORCE IS APPLIED TO THE BRAKE PEDAL. IF THIS SHOULD OCCUR, THE BRAKE LIGHT SWITCH WILL NOT FUNCTION PROPERLY, CAUSING THE BRAKE LIGHTS, INCLUDING THE HIGH MOUNTED STOP LAMP, TO REMAIN ILLUMINATED CONTINUOUSLY WITHOUT BRAKE PEDAL APPLICATION, WITH THE IGNITION SWITCH IN THE ON OR OFF POSITION.
Consequence & remedy
Consequence: IF THE BRAKE LIGHTS REMAIN ON CONTINUOUSLY WHILE DRIVING,A FOLLOWING DRIVER MAY NOT KNOW WHEN YOUR BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING. THIS CONDITION MAY ALSO DISCHARGE THE VEHICLE'S BATTERY, AND, THE AUTOMATIC TRANSMISSION TORQUE CONVERTER CLUTCH, CRUISE CONTROL AND TRACTION CONTROL SYSTEM, IF EQUIPPED, WILL BECOME DISABLED.
Remedy: DEALERS WILL REPLACE THE BRAKE LIGHT SWITCH FREE OF CHARGE. THE RECALL BEGAN ON MARCH 16, 2005. OWNERS MAY CONTACT SUZUKI AT 1-800-934-0934.
03V426000 · Air Bags:frontal
Oct 29, 2003
ON CERTAIN PASSENGER CARS, THE DUAL STAGE DRIVER'S AIR BAG DEPLOYS IN AN IMPROPER SEQUENCE.
Consequence & remedy
Consequence: IF THE DRIVER'S AIR BAG DEPLOYS IMPROPERLY DURING A FRONTAL VEHICLE CRASH, THE DRIVER COULD BE SEVERELY INJURED OR KILLED.
Remedy: DEALERS WILL INSTALL AN ADAPTING WIRING HARNESS. OWNER NOTIFICATION BEGAN ON OCTOBER 30, 2003, TO VERONA VEHICLE OWNERS. ALL FORENZA VEHICLES WERE REPAIRED AT THE PORT OF ENTRY. THERE ARE NO OWNER NOTIFICATIONS NECESSARY FOR THE FORENZA MODEL VEHICLES. OWNERS SHOULD CONTACT SUZUKI AT 1-800-934-0934.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE07039 · Headlight / Drl Malfunction
Opened Jul 24, 2007 · Closed Oct 2, 2007
Status: closed (inferred from source dates) · Exterior Lighting:headlights
ON SEPTEMBER 25, 2007, SUZUKI NOTIFIED THE AGENCY THAT IT WILL RECALL MODEL YEARS 2004 -2006 FORENZA AND RENO VEHICLES TO CORRECT A DEFECT THAT CAN RESULT IN LOSS OF HEADLIGHT AND/OR DRL FUNCTION.THIS RECALL AFFECTS 93,963 VEHICLES.NHTSA ASSIGNED NUMBER 07V-452 FOR THIS RECALL.NHTSA'S INVESTIGATION INITIALLY FOCUSED ON 2005 FORENZAS, THEN EXPANDED IT TO 2004-2005 FORENZAS (TOTAL OF 58,448 VEHICLES). SUZUKI BROADENED THE RECALL SCOPE TO COVER 2004-2006 FORENZAS & RENOS (93,963 VEHICLES).THE WIRING HARNESS BEHIND THE INSTRUMENT PANEL CONTAINS A SPLICE PACK TO CONNECT THE POWER CIRCUIT WIRES FOR LOW-BEAM HEADLAMPS AND DAYTIME RUNNING LAMPS (DRL).INCREASED RESISTANCE DUE TO POOR CONTACT BETWEEN TERMINALS CAN GENERATE HEAT WHICH CAN LEAD TO MELTING OF THE SPLICE PACK IN THE AREA OF WIRES AND THE LOSS OF HEADLIGHT AND/OR DRL FUNCTION. FOR THE REMEDY, DEALERS WILL SPLICE THE POWER CIRCUIT WIRES FOR THE LOW-BEAM HEADLAMPS AND DRLS FREE OF CHARGE.SUZUKI'S RECALL CAMPAIGN (MANUFACTURER RECALL NO. NB) IS EXPECTED TO START AT THE END OF OCTOBER 2007.CUSTOMERS MAY CONTACT SUZUKI AT 1-800-934-0934.