2021 Subaru Outback

I'm on my 3rd windshield in under 12 months. I have not changed my driving habits and have been in typical weather for my area. The vehicle is garage kept. First windshield had a center driver's side ding that lasted all winter. We had some unseasonable spring weather changes that caused it to crack and spiderweb replaced 4/10/23, 24K miles. 2nd windshield, cracked 5/15/23, got dinged at the bottom and spiderwebbed immediately, again on driver's side. 3rd windshield, 12 inch line center passenger side from the edge, no ding or chip, no obvious cause for crack, occurred 1/28/24.

I have had 3 windshields crack spontaneously during normal use in the past year. Each incident was repaired by a certified repair shop and at time the damage was noticed, no chips, signs of damage, or impacts were noted. The crack appeared to be internal and was not able to be felt from outside or within. In each incident the crack began near the edge of the glass and spread across the entire length of the windshield. The most recent was 12/27/2023, the approximate dates of the previous are 12/2022, and 03/2023. All three occurred in periods of clear weather, no ice, or snow present, although all three occurred in the cold, while parked outside overnight either at work or home.

The contact owns a 2021 Subaru Outback. The contact stated that upon approaching the vehicle, she became aware that the front windshield had suddenly cracked, extending from the center of the windshield to the passenger’s side bezel. The vehicle was taken to the dealer, who determined that the crack was the result of the impact of a small, unknown object. The vehicle was not repaired. After investigating the failure, the contact related the failure to NHTSA Campaign Number: 22V712000 (Visibility), but the VIN was not included. The manufacturer was not notified of the failure. The failure mileage was 23,000.

While my husband was driving up a hill at low speed (25-30miles/hr) the car lost power, struggled and felt like it was going to stall. 5 days later, I was driving up a hill going 25miles/hr, the car lost acceleration the stalled, was unreponsive to gas pedal being depressed, the car then started again on its own. I brought the car to Subaru but they couldn't find anything wrong. Luckily nobody was behind me when the car stalled.

My vehicle is equipped with EYESIGHT. I was driving to my home after work at night and suddenly the infotainment system screen went blank; including Braking Assist, Adaptive Cruise control, Lane assist, Emergency Braking etc including Navigation, also the HVAC shut off and EYESIGHT that controls these as well, shut off. It was suffocating in the car due to no A/C and thusf I tried to pull over at a remote text-stop place and tried restarting the car but in vain. All screens were dark, no warm air, I couldn’t see what direction I was driving to, as well as I solely relied on navigation. I brought this car for it’s safety features and warmth in this cold temperature in UPSTATE NY and this happened. I waited for 20 mins, charged my phone for only 4-5% with a fellow citizen who was waiting there as well and checked online just to see a lot of people reported the same issue with 2021 Subarus with EYESIGHT. And there is NO way one can fix it. I tried contacting the dealer but in vain. I am afraid that if this would happen again, I wouldn’t be in a situation to face this scary experience.

I have experienced premature rear brake wear and excessive tire wear. Issues with infotainment system and pre-collision braking system. (1) Regarding Tires: Performed all dealer recommended tire rotations and aligned vehicle when recommended. Needed new tires at 31,169 miles. Tires showed excessive inside wear. Bought new tires from a 3rd party shop and had alignment done with hunter alignment system. Showed rear right camber at -2.0. Subaru recommends -1.8 to 0.3. Rear camber is not adjustable on this model. Took vehicle back to dealer for brake job and they said camber was fine...there is a spec for a reason. Did not want to attempt to bring it in spec with aftermarket kits (i.e. adjustable cam bolt) or fix under warranty. (2) Regarding Brakes: Needed new brakes at 31,169 miles. Not covered under warranty and not what I would consider typical wear based on my driving style and my past experience with Subaru vehicles. If this is an expected side affect of the EBD system I would highly recommend Subaru consider ways of improving brake life on their vehicles. (3) I have the Onyx XT trim with navigation. Infotainment system is constantly glitchy. Examples include booting with blank black screen, failing to load, excessive lag while operating system or will freeze and beep repeatedly while buffing a menu selection. Also, had my car battery replaced under warranty within the first two years due to a bad battery. (4) Issues with ADAS system, specifically pre-collision breaking. This system is extremely sensitive and will over-react / take control in certain situations where I didn't need it to even when I was in the process of braking. Have had this system activate on the highway at high speeds while switching lanes on the highway or when having a vehicle merge quickly into my lane in front of me. Constantly, have to turn off this system which is a chore as this system is defaulted to always being on. Do not feel safe driving with this system on.

Received error code P2682, a faulty Thermo Control Valve. This happened on 11/17/2023. Car potentially could have quit running in traffic. Subaru has identified the issue with TSB 09-80-21R. They have changed the design of the valve due to the many failures. My car has 74,000 miles. My brother in law has the same vehicle with 57,000, and his car is in the shop today for the same issue. The service tech working on his vehicle stated that he does a couple of these repairs a week, and that Subaru knows this part will fail and should issue a recall

The contact owns a 2021 Subaru Outback. The contact became aware that the VIN was included in NHTSA Campaign Number: 23V755000 (Power Train) however, the part to do the recall repair was not yet available. An unknown local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.