2021 Subaru Outback

I am filing this complaint regarding multiple serious safety defects in my 2021 Subaru Outback purchased in July 2021, currently at 48000 miles THERMO CONTROL VALVE FAILURE (26,307 miles) While traveling in the center lane on [XXX] southbound in [XXX] the evening of 1/6/2024 my vehicle suddenly experienced a complete loss of control. It seemed that the car was accelerating and braking at the same time without driver input making it impossible to operate safely. It started shaking and several lights were illuminated on the dashboard, power steering was not working. The car coasted to the right shoulder and starlink was used to call for help. The car was towed to the dealership for repairs. The diagnosis was a failed thermo control valve and related sensor circuit. There were no dashboard lights before the incident that fore shadowed this event. This failure rendered the vehicle completely inoperable at highway speed and posed and extreme risk to the safety of the driver, passenger and other motorists. I am aware that Subaru has extended the warranty on the thermo controls valve to 15 years/150000 miles for 2020-2022 Outback’s which suggests that Subaru had knowledge of the defect. Since the incident several other premature “wear” defects have presented under 48000 miles on a 2021 vehicle: - 41,402 miles: driver side rear strut replaced - 41,402 miles: rear brake pads and rotors - 41,402 miles: driver side front window motor, regulator and run Chanel - 41808 miles: rear knuckle assembly, rear wheel bearing and backing plate replaced - 45,768 miles: front brake pads and and rotors replaced - 48,000 miles: complete exhaust system - 48,000 miles: passenger side front window motor, regulator and run chanel This vehicle has proven to be uncharacteristically unreliable for a Subaru Outback. The intended use for this vehicle is for my children to drive to college nearly 600 miles from home in the fall. This car is not appropriate for this purpose. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION

The car flashed “eye sight off” before flickering and shutting off while I was braking at a stop light. I tried putting my car into park and then turning it off and restarting it but it would not turn back on. I tried this a few more times but I was in the middle lane of a heavily trafficked street. The steering wheel was locked and I was not able to immediately remove it from the road and maybe an hour later it was able to be shifted into neutral and moved out of the street. However, it would still not turn on and when I did open my power gate, the gate would not secure closed. I took it to the dealership that I purchased it at and where it is also regularly serviced (with the last service date only over one week ago,) and they were not able to determine what happened but instead mentioned that my car had no internal data of any errors occurring and that the car was able to be started when they serviced it. I took a picture of the dash as it was flashing with all of the error codes and submitted that to the tech that was working on my car, but they asked me if I’d had someone “clear my codes” which is not something I’m familiar with or even capable of doing- I don’t even know anyone that would be capable of doing that for me. The whole ordeal cost me a day of work and now my peace of mind as I am unsure of if this may happen again and now I am worried it may happen while my kids are in the car. I’ve had similar issues with my center console messing up but nothing as urgent as my whole car shutting down and my steering wheel locking in the middle of traffic.

The car was built & sold new, with the rear suspension not aligned properly, and cannot be aligned to factory specifications. The car has been taken to 4 service stations, 3 Subaru dealer service repair shops, without being able to be aligned.after further investigation, I’ve found this to be a common problem for this vehicle type. I consider this Safety related due to the unusual tire wear & risk of tire failure.

The contact's wife owns a 2021 Subaru Outback. The contact stated that while driving at various speeds, the vehicle experienced loss of power steering as the power steering warning light and several unknown warning lights were illuminated. The contact stated that the failure occurred on several occasions. The vehicle was taken to a local dealer, where it was diagnosed that the power steering rack needed to be replaced. The vehicle was repaired; however, that the failure recurred. The vehicle was then taken back to the dealer, where it was diagnosed that the power steering wiring harness needed to be replaced. The vehicle remained at the dealer awaiting repairs. The manufacturer was made aware of the failure. The approximate failure mileage was 17,500. The VIN was not available.

While moving forward slowly with foot lightly on the brakes and pulling into a parking space at local shopping center the car accelerated and the steering wheel turned to the right. The result of the cars actions made the car jump the curb, drive across the sidewalk and then across small hedges in the landscaped area. Car finally came to a stop about 20 feet later, with me pushing hard on the brake, just prior to entering parking lot roadway cross traffic. There was no alarm, warning or any other indication from any of the safety systems. As far as the automobile was concerned, nothing wrong had happened. Luckily there were no other vehicles or pedestrians on sidewalk or in the landscaped area between the parking space and roadway. There was no vehicle damage as the shrubs were all fairly short and the car simply drove over them. My husband disabled the lane departure system and I continue to operate the car. Based on all the previous incidents reported on this site, my husband indicates that Subaru will blame operator error. I have a perfect driving record and this incident was not caused by me incorrectly stepping on the gas.