2008 Subaru Legacy

The issue occurred on a 08 Subaru Legacy GT Limited while the driver was driving the car with their family on a local street around 35-40mph. Initially, while the car was stopped at a traffic light, the driver noticed that the brake pedal seems off where it seems to be depressed much deeper than usual. While coming up on a second red traffic light, the driver noticed that the pedal has to be depressed all the way down to the floor before bringing the car close to a stop while using the emergency brake to complete the stop. The driver knows that this is a major issue given the symptoms and drove to a safe spot to stop the car and inspect the issue. At this time, the brake light has also came on in the dashboard. Upon the driver's preliminary inspection, there was brake fluid leakage coming from the rear passenger wheel area and the brake fluid in the reservoir has reached the minimum line which would confirm why the brake light came on. Given the situation, the vehicle was then brought to the Subaru official dealer immediately to be dropped off for a diagnostic on the next Monday since the dealer was closed when the driver arrived. After the diagnostic by the Subaru mechanic, they confirmed with the driver's suspicious where the brake line has been broken due to corrosion to a bare metal area of the rear brake line that was supposed to be addressed by the brake line corrosion recall, WQK-047. The line was broken at one of the clip point where the brake line has no sleeve over it to protect the line from corrosion. Subaru issued a recall on this area as they know that this was a design flaw where salt used on the road from the winter might get in accelerating the corrosion of the line causing it to leak or break. This is an serious issue since the car could have crashed if the brake fails completely without any brake fluid anymore. NHTSA should intervene on this as many owners have this issue and SOA, who boast about safety, did not address the issue with the recall.

I had the recall done in 2017 and I was recently driving on the highway when my brakes had no pressure, I nearly crashed my car. Pulled over and realized my brake lines were leaking from where they said it had been fixed during the recall. I called the Subaru Stealership that did the recall and they informed me when I brought the vehicle in “it showed no signs of leakage” so they sprayed “anti corrosion” on the lines. I called Subaru of America and they want me to pay $200 to diagnose the issue and pay for the repair since the lines busted from “wear and tear”. Spraying anti-corrosion does nothing when the rust has already ruined the integrity of the brake line. Subaru is trying to pull a fast one and scam their customers by spraying anti-corrosion when the lines need to be replaced instead.

I received my Subaru legacy from the dealer after an unrelated repair. My wife got in the car and very slowly drove through the lot to exit the dealership. She was going 5-6 mph at most and luckily after putting the car into gear she had her hand resting on the center console literally right above the hand brake. As she approached the stop sign to exit the dealership, she put her foot on the brake pedal and it went immediately straight to the floor with no resistance or application of the brakes. She immediately grabbed and pulled the hand emergency brake to stop the vehicle from entering a busy route 3 (West Chester Pike.) After nursing the car back to service at very low mph she parked the car again using the hand brake. Service looked at the car and found ruptured brake lines. The lines were the subject of a recall in 2015 and were supposedly inspected and an anticorrosive was applied.

I have a great suspicion that Kia has not only sold bad engined vehicles that are their own make and models but I believe they are selling used cars they buy like that as well. The car I bought has major engine problems that were hid from me at the time of the sales leading to a $5000 repair bill for a 7200$ car. I only had it for a couple weeks before it became un-drivable. Not only did they hide and lie about fact in the sales of their own cars , I have evidence showing that they are doing the same to used cars they're selling. They are barely doing the bare minimum to fix anything. They have lied to AUTOCAP on record about facts as well when I have recordings or them telling me other wise.

The CV axle on the passenger side caught on fire. It was the rubber boot on the inner side over the catalytic converter. There were no warnings other than the smell of smoke. Fortunately, I caught it early and put out the fire with a fire extinguisher. I had been driving 25 to 40 MPH on city streets for about 5 miles before the incident.

The contact owns a 2008 Subaru Legacy. The contact stated while driving approximately 30-35 mph, the brake pedal went to the floorboard while depressed. The contact was concerned that the brake was failing with her husband and four-month-old baby in the vehicle. The contact veered to the shoulder and turned off the vehicle. The contact’s husband inspected the vehicle and saw that there was fluid dripping near the rear passenger’s side tire, below the fuel tank. The contact’s husband then drove the vehicle back to the residence. The manufacturer was made aware of the failure and informed the contact that the dealer had performed a recall repair on the brakes on January 22, 2021. The contact was informed that anti-corrosion wax was sprayed onto the brake line connectors as part of the remedy. The manufacturer referred the contact back to the same dealer where the vehicle was repaired under recall, to have the vehicle diagnosed. The vehicle was taken to the dealer and diagnosed that rodents had chewed the brake line and the brake line was not part of the recall repair. The vehicle was not repaired. The manufacturer was contacted and informed the contact that the vehicle was not repairable. The manufacturer offered a $ 1,000 voucher for a newer vehicle. The failure mileage was 76,877.

TL* THE CONTACT OWNS A 2008 SUBARU LEGACY. THE CONTACT STATED WHILE INSPECTING THE VEHICLE, HE BECAME AWARE OF CORROSION AROUND THE BRAKE LINE. THERE WAS FLUID LEAKING FROM THE BRAKE LINE. THE CONTACT STATED THAT WHILE DRIVING, THE BRAKE PEDAL FELT SOFT WHEN DEPRESSED. A DEALER WAS NOT CONTACTED. THERE WAS NO WARNING LIGHT ILLUMINATED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE HOWEVER, INFORMED THE CONTACT THAT THE VIN WAS NOT UNDER RECALL. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 14V311000 (SERVICE BRAKES, HYDRAULIC) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS 183,000.