IllustrationWHILE IN REVERSE, AUDIO CONTROL IS LOST. ALTERATION TO CHANNEL OR VOLUME OR TURNING OFF AUDIO IS DISABLED - WHICH CAN BE HIGHLY DISTRACTING IF THE SETTING WERE LEFT EXTREMELY LOUD SINCE THE AUDIO WILL INITIALIZE SEVERAL SECONDS AFTER STARTING AND REVERSING IS ALREADY IN PROGRESS AT THAT TIME.
2018 Subaru Forester
Owner reports · Recalls · Investigations
More warning signs than most Forester years
Owner complaints for the 2018 Subaru Forester are substantially higher than the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1560–25K
6525–50K
1350–75K
575–100K
2100–150K
0150K+
241 reports with mileage · 252 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility/wiper. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports1 fire reports6 injury reports
What owners actually said
493 reportsI WAS IN AN ACCIDENT IN WHICH A CAR T-BONED MY PASSENGER SIDE. NO AIRBAGS DEPLOYED AND WE SUFFERED INJURY AS A RESULT. THE OTHER CAR THAT HIT US HAD ALL AIR BAGS DEPLOYED. THIS WAS A MALFUNCTION IN THE SUBARU I DRIVE. THE ACCIDENT OCCURRED WHILE I WAS IN MOTION GOING 40MPH AND A CAR HIT ME AFTER RUNNING A RED LIGHT GOING 45MPH
I HAVE HAD THIS CAR SINCE APRIL 2018. DURING MY FIRST WEEK OF OWNERSHIP A SMALL ROCK HIT MY WINDSHIELD WHILE DRIVING ON THE HIGHWAY AND PUT A CRACK IN IT I GOT REPAIRED. I'M CONSTANTLY GETTING CHIPS. I AVOID DRIVING BEHIND SEMIS AND OTHER LARGE TRUCKS.I HAVE BEEN READING THAT THIS IS A VERY COMMON PROBLEM WITH LATE YEAR SUBARU'…
Read full complaint
I HAVE HAD THIS CAR SINCE APRIL 2018. DURING MY FIRST WEEK OF OWNERSHIP A SMALL ROCK HIT MY WINDSHIELD WHILE DRIVING ON THE HIGHWAY AND PUT A CRACK IN IT I GOT REPAIRED. I'M CONSTANTLY GETTING CHIPS. I AVOID DRIVING BEHIND SEMIS AND OTHER LARGE TRUCKS.I HAVE BEEN READING THAT THIS IS A VERY COMMON PROBLEM WITH LATE YEAR SUBARU'S. I FEEL SUBARU NEEDS TO IMPROVE THE QUALITY OF GLASS THEY USE. I WANT MY EXPERIENCE WITH SUBARU DOCUMENTED. HOPE SOMETHING CAN BE DONE. I'VE NEVER HAD SUCH A BRITTLE WINDSHIELD BEFORE.
NOTICED SMALL CRACK IN WINDSHIELD LAST TUESDAY, STARTING JUST ABOVE A CLIP ON WIPER. ASSUMED, AT FIRST IT WAS DIRTY WINDSHIELD FROM LIGHT RAIN & WIPER USE, BUT THEN SATURDAY IT MOVED ABOUT 6 INCHES MID DAY PARKED THEN HALFWAY ACROSS DRIVER SIDE A COUPLE OF HOURS LATER PARKED. I HAVE NOT BEEN HIT BY ANYTHING BIG OR SMALL. I HA…
Read full complaint
NOTICED SMALL CRACK IN WINDSHIELD LAST TUESDAY, STARTING JUST ABOVE A CLIP ON WIPER. ASSUMED, AT FIRST IT WAS DIRTY WINDSHIELD FROM LIGHT RAIN & WIPER USE, BUT THEN SATURDAY IT MOVED ABOUT 6 INCHES MID DAY PARKED THEN HALFWAY ACROSS DRIVER SIDE A COUPLE OF HOURS LATER PARKED. I HAVE NOT BEEN HIT BY ANYTHING BIG OR SMALL. I HAVE READ THAT THIS WINDSHIELD ISSUE HAS BEEN IN EVERY SUBARU MODELS. I WANT SUBARU TO PAY FOR THIS!
AIRBAG LIGHT COMES ON, PASSENGER SIDE AIRBAG SAYS 'OFF' ON PANEL WHEN PERSON IS ON SEAT. STARLINK EMAILS ME THAT THERE IS AN AIRBAG ISSUE.
FRONT PASSENGER SEAT AIRBAG SENSOR BEGAN NOT RECOGNIZING PASSENGERS SITTING IN THE SEAT SHORTLY AFTER PURCHASING MY BRAND NEW 2018 SUBARU FORESTER. THIS STARTED OCCURING WHILE DRIVING, TURNING OFF AND ON. AFTER A WHILE, IT COMPLETELY STOPPED RECOGNIZING ANY PERSON SITTING IN THE SEAT EVEN AFTER ONLY JUST TURNING THE CAR ON. THE …
Read full complaint
FRONT PASSENGER SEAT AIRBAG SENSOR BEGAN NOT RECOGNIZING PASSENGERS SITTING IN THE SEAT SHORTLY AFTER PURCHASING MY BRAND NEW 2018 SUBARU FORESTER. THIS STARTED OCCURING WHILE DRIVING, TURNING OFF AND ON. AFTER A WHILE, IT COMPLETELY STOPPED RECOGNIZING ANY PERSON SITTING IN THE SEAT EVEN AFTER ONLY JUST TURNING THE CAR ON. THE DEALERSHIP REPLACED IT SINCE IT WAS IN THE WARRANTY PERIOD BUT BLAMED US FOR IT MALFUNCTIONING SAYING THAT WE MUST HAVE GOTTEN THE SEAT WET, CAUSING THE SENSOR TO FAIL. WE TOLD THEM THAT WE HADN'T EVER GOTTEN THE SEAT WET. ONE YEAR AND 3 MONTHS AFTER WE'D GOTTEN OUR FORESTER BACK FROM THE DEALERSHIP AFTER THE AIRBAG SENSOR REPAIR, A PASSENGER THAT SAT IN THE SEAT BROUGHT TO OUR ATTENTION THE FACT THAT THE PART OF THE SEATBELT THAT SITS TO THE LEFT OF THE FRONT PASSENGER SEAT WAS LOOSE. WE TOOK IT TO THE SAME DEALERSHIP AGAIN AND THEY TOLD US THAT THE TECHNICIAN HAD REINSTALLED THE SEAT BELT INCORRECTLY AFTER THE AIRBAG SENSOR REPAIR AND THAT IT WAS MISSING A PART AND THAT'S WHY IT WAS LOOSE AND NOT ANCHORED PROPERLY. THEY WERE ORDERING THE PART AND IT WOULD ARRIVE WITHIN A WEEK. WHEN WE RETURNED A WEEK LATER THEY INFORMED US THAT THEY ORDERED THE WRONG PART AND NOW WE'D HAVE TO WAIT ANOTHER WEEK FOR THE SEAT BELT TO BE ANCHORED PROPERLY. STILL WAITING FOR THE CORRECT PART TO ARRIVE FOR THE SEAT BELT TO BE ANCHORED PROPERLY.
AS I WAS EASING INTO A PARKING SPACE IN MY TOWNHOME COMMUNITY IN FRONT OF MY NEIGHBOR'S HOUSE, THE CAR SUDDENLY ACCELERATED ON ITS OWN AND JUMPED THE CURB, LANDING ON THE SIDEWALK AND PUSHING IN THE WALL OF THE HOUSE. AIRBAGS DID NOT GO OFF AND LUCKILY NOBODY WAS HOME OR STANDING ON THE SIDEWALK. I WAS NOT INJURED. THE CAR SUSTA…
Read full complaint
AS I WAS EASING INTO A PARKING SPACE IN MY TOWNHOME COMMUNITY IN FRONT OF MY NEIGHBOR'S HOUSE, THE CAR SUDDENLY ACCELERATED ON ITS OWN AND JUMPED THE CURB, LANDING ON THE SIDEWALK AND PUSHING IN THE WALL OF THE HOUSE. AIRBAGS DID NOT GO OFF AND LUCKILY NOBODY WAS HOME OR STANDING ON THE SIDEWALK. I WAS NOT INJURED. THE CAR SUSTAINED MINIMAL DAMAGE (BUMPER WAS ASKEW) BUT THE HOUSE WALL NEEDED TO BE REPLACED AND THE TENANTS WERE UNABLE TO LIVE THERE FOR TWO WEEKS.
2018 SUBARU FORESTER. CONSUMER WRITES IN REGARDS TO BRAKING ISSUE. *LD THE CONSUMER STATED THE BRAKE PEDAL BECAME SPONGY/MUSHY AFTER DRIVING SEVERAL MILES. THE PEDAL WOULD CONTINUE TO TRAVEL TO THE FLOOR AFTER BEING DEPRESSED. *JS THE CONSUMER STATED THE MANUFACTURER AND DEALER WERE NOTIFIED. THE DEALER STATED THE VEHICLE …
Read full complaint
2018 SUBARU FORESTER. CONSUMER WRITES IN REGARDS TO BRAKING ISSUE. *LD THE CONSUMER STATED THE BRAKE PEDAL BECAME SPONGY/MUSHY AFTER DRIVING SEVERAL MILES. THE PEDAL WOULD CONTINUE TO TRAVEL TO THE FLOOR AFTER BEING DEPRESSED. *JS THE CONSUMER STATED THE MANUFACTURER AND DEALER WERE NOTIFIED. THE DEALER STATED THE VEHICLE WAS OPERATING AS DESIGNED. THE CONSUMER WAS UNSATISFIED WITH THIS RESPONSE. *JS
THE PASSENGER AIRBAG SYSTEM INTERMITTENTLY TURNS OFF EVEN IF SOMEONE IS SITTING IN THE SEAT. IT CAN BE WHILE PARKED OR DURING DRIVING. THERE'S NO SET CAUSE OR CIRCUMSTANCES THAT TRIGGER THIS.
THIS CAR HAS A MANUAL TRANSMISSION AND ONLY HAS BEEN DRIVEN 3,370 MILES. EVERY SO OFTEN AFTER STARTUP, WHILE BEGINNING TO MOVE FORWARD, THE STEERING BECOMES EXTREMELY DIFFICULT. THIS EFFECT LASTS, PERHAPS, FOR UP TO 5 SECONDS OR SO.
Official recalls
321V587000 · Fuel System, Gasoline:delivery:fuel Pump
Jul 29, 2021
Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2018 Forester, 2018-2020 Impreza, Legacy, Outback, 2018-2019 BRZ, WRX, and Toyota 86 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the low-pressure fuel pump, free of charge. Owner notification letters were mailed September 24, 2021. Subaru and Toyota owners may call customer service at 1-844-373-6614. Subaru's number for this recall is WRG-21.
19V701000 · Air Bags:sensor:occupant Classification
Oct 3, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2015-2018 Forester vehicles equipped with heated seats. An electrical connection in the front passenger seat for the Occupant Detection System (ODS) may loosen.
Consequence & remedy
Consequence: If the connection loosens, the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.
Remedy: Subaru will notify owners, and dealers will inspect and, as necessary, replace the ODS sensor mat harness, free of charge. The recall began February 11, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUM-98.
18V455000 · Equipment:other:labels; Tires
Jul 10, 2018
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Additional source detail variants (2)
Equipment:other:labels
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Tires
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19009 · Occupant Detection System (ods) Failure
Opened Aug 6, 2019 · Closed Jan 22, 2020
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Additional source detail variants (4)
Air Bags:frontal:passenger Side:inflator Module
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:frontal
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.