IllustrationFRONT WINDSHIELD GLASS WAS CRACKED UNEXPECTEDLY WHEN PARKED, WHEN THE REPLACEMENT WAS INSTALLED, IT CRACKED AGAIN.
2018 Subaru Forester
Owner reports · Recalls · Investigations
More warning signs than most Forester years
Owner complaints for the 2018 Subaru Forester are substantially higher than the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1560–25K
6525–50K
1350–75K
575–100K
2100–150K
0150K+
241 reports with mileage · 252 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Visibility/wiper. Review the 135 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 96 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 70 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
26 crash reports1 fire reports6 injury reports
What owners actually said
493 reportsWHILE DRIVING ON A PAVED ROAD(NO GRAVEL OR ROCKS PRESENT), MY WINDSHIELD CRACKED IN THE LOWER PASSENGER SIDE. I HAD THE WINDSHIELD REPLACED AND THE SAFETY SYSTEM RECALIBRATED AT A COST OF ALMOST $900.I WAS DRIVING ON A STRAIGHT ROAD AT ABOUT 45 MPH AT THE TIME.
THE AIRBAG SYSTEM BECAME DISARMED AND SEATBELT WARNING LIGHT CAME ON WHEN SMARTPHONE WEIGHING 3LBS WAS ON FRONT PASSENGER SEAT. THIS OCCURRED MULTIPLE TIMES THE PASSENGER FRONT SEAT SENSOR IS SUPPOSED TO BECOME ARMED WHEN A 40LB PASSENGER SITS IN PASSENGER FRONT SEAT ONLY. READING THROUGH THE OWNERS MANUAL STATES THAT BOTH DRIV…
Read full complaint
THE AIRBAG SYSTEM BECAME DISARMED AND SEATBELT WARNING LIGHT CAME ON WHEN SMARTPHONE WEIGHING 3LBS WAS ON FRONT PASSENGER SEAT. THIS OCCURRED MULTIPLE TIMES THE PASSENGER FRONT SEAT SENSOR IS SUPPOSED TO BECOME ARMED WHEN A 40LB PASSENGER SITS IN PASSENGER FRONT SEAT ONLY. READING THROUGH THE OWNERS MANUAL STATES THAT BOTH DRIVER AND PASSENGER AIRBAGS MAY NOT DEPLOY WHICH PUTS DRIVER AND PASSENGERS AT RISK FOR INJURY.
BEFORE ENTERING FREEWAY, AT LOW SPEED, A CRACK APPEARED ON THE WINDSHIELD. SEEMS TO STEM FROM THE LOWER BLACK STRIP ON THE WINDSHIELD. THERE IS A SMALL IMPACT POINT STEMMING FROM THE BLACK STRIP ALONG THE LOWER SIDE OF THE WINDSHIELD AND THE CRACK IMMEDIATELY GREW TO ABOUT 10'' VERTICALLY UPWARD FROM THAT. THE NEXT DAY, THE CRAC…
Read full complaint
BEFORE ENTERING FREEWAY, AT LOW SPEED, A CRACK APPEARED ON THE WINDSHIELD. SEEMS TO STEM FROM THE LOWER BLACK STRIP ON THE WINDSHIELD. THERE IS A SMALL IMPACT POINT STEMMING FROM THE BLACK STRIP ALONG THE LOWER SIDE OF THE WINDSHIELD AND THE CRACK IMMEDIATELY GREW TO ABOUT 10'' VERTICALLY UPWARD FROM THAT. THE NEXT DAY, THE CRACK CURVED AND GREW ANOTHER 10-15'' IN LENGTH ACROSS THE PASSENGER SIDE. I DID NOT NOTICE ANYTHING IMPACT THE WINDSHIELD. A CAR WAS AHEAD OF ME BUT WAS ABOUT 2-3 CAR LENGTHS AHEAD AT LOW SPEED AS IT WAS A FRONTAGE ROAD BEFORE ENTERING THE FREEWAY RAMP.
WINDSHIELD DEVELOPED A LINEAR CRACK AFTER BEING STRUCK BY AN EMPTY WIPER ARM DURING THE CHANGING OF A WIPER BLADE. THE CRACK GREW FROM 6 INCHES ON THE FIRST DAY TO 14 INCHES ON THE SECOND DAY.
FRONT PASSENGER AIRBAG HAS BEEN INTERMITTENTLY ON AND OFF, WITH AND WITHOUT A PASSENGER, WITH AND WITHOUT ITEMS ON THE SEAT. THIS IS THE THIRD OR MAYBE FOURTH OCCASION VEHICLE IS AT THE DEALER. ONE OF THE FIRST TIMES THEY INSPECTED THE CAR, AND THEIR SOLUTION WAS TO RELOCATE THE "MODULE" (WHATEVER THE MODULE IS) FOR THAT SEAT. T…
Read full complaint
FRONT PASSENGER AIRBAG HAS BEEN INTERMITTENTLY ON AND OFF, WITH AND WITHOUT A PASSENGER, WITH AND WITHOUT ITEMS ON THE SEAT. THIS IS THE THIRD OR MAYBE FOURTH OCCASION VEHICLE IS AT THE DEALER. ONE OF THE FIRST TIMES THEY INSPECTED THE CAR, AND THEIR SOLUTION WAS TO RELOCATE THE "MODULE" (WHATEVER THE MODULE IS) FOR THAT SEAT. THEY STATED IT WILL SOLVE THE PROBLEM. A MONTH LATER THE CAR STARTED TO DO THE PASSENGER AIRBAG WARNING LIGHT ON AND OFF AGAIN. CAR BACK AGAIN TO DEALER BUT THEN LIGHT WAS GONE OFF. YESTERDAY, SEP 23, 2019 CAR WAS DROPPED AGAIN AT DEALER WITH LIGHT ON AND THE CAR STILL ON, IN ORDER NOT TO LOSE THE SITUATION AT RESTART. THEY JUST CALLED ME AND STATE THE SEAT AIRBAG WAS REPLACED $1,100 UNDER WARRANTY, CAR IS 6500 MILES OR SO. THAT WE COULD NOT LOCATE ANYTHING OTHER THAN A PASSENGER ON THAT SEAT. ANY ITEM, CELLULAR, TABLET, COMPUTER, BATTERY, BAGS, PURSUES, SHOPPING ITEMS, PAPERS, DOCUMENTS ON THAT SEAT WILL POSSIBLY CAUSE THE SITUATION AGAIN AND THEY WONT COVER IT UNDER WARRANTY. ALSO NOTHING IN FRONT OF THAT SEAT BY THE FLOOR..??? NOT POSSIBLE TO RECLINE THE BACK OF THE SEAT.... WHAT? THIS IS MY FIRST CAR DOING THAT. I DON'T CARE WHAT THEY SAY TO US, IT'S THEIR RESPONSIBILITY AND A DEADLY RISK DRIVE THIS CAR WITH THE PASSENGER LIGHT ON AND A PASSENGER IN IT AND BEEN INVOLVED IN AN ACCIDENT. THIS HAPPENS WITH THE CAR ON, BUT PARKED, STOPPED WAITING FOR A LIGHT TO CHANGE, MOVING, GOING FORWARD, GOING REVERSE, AND IS INTERMITTENT.
OUTSIDE TEMPERATURE READINGS ARE BETWEEN 3-7 DEGREES OFF. DEALER SAYS THAT IS NORMAL. AN I TO ASSUME THE TIRE PRESSURE, ENGINE COOLANT TEMPERATURE AND OIL PRESSURE GAUGES ARE ALSO OFF ?
EVER SINCE I PURCHASED THE CAR, THE PASSENGER AIR BAG INDICATOR LIGHT HAS SHOWN 'OFF.' THE NHTSA SITE SHOWS NUMEROUS PEOPLE HAVE HAD THE SAME EXPERIENCE. SOME OF THOSE PEOPLE WERE ADVISED BY SUBARU SERVICE TECHNICIANS THAT THEY MUST HAVE SPILLED SOMETHING ON THE SEAT, AFFECTING THE SENSOR. I WAS TOLD THE SAME WHEN I TOOK MY CA…
Read full complaint
EVER SINCE I PURCHASED THE CAR, THE PASSENGER AIR BAG INDICATOR LIGHT HAS SHOWN 'OFF.' THE NHTSA SITE SHOWS NUMEROUS PEOPLE HAVE HAD THE SAME EXPERIENCE. SOME OF THOSE PEOPLE WERE ADVISED BY SUBARU SERVICE TECHNICIANS THAT THEY MUST HAVE SPILLED SOMETHING ON THE SEAT, AFFECTING THE SENSOR. I WAS TOLD THE SAME WHEN I TOOK MY CAR IN. SUBARU TECHS RAN A DIAGNOSTIC THAT INDICATED NO ERROR CODES. I DISCOVERED ON MY OWN THE APPARENT CAUSE OF THE PROBLEM WITH MY CAR. I HAVE DOGS AND CUSTOMARILY PLACE A TOWEL ON ALL SEATS TO KEEP THEM CLEAN. WHEN I REMOVED THE TOWEL MY HUMAN PASSENGER WAS SEATED ON, THE AIR BAG INDICATOR SHOWED 'ON.' IF YOU LOOK AT THE 2018 SUBARU MANUAL, THIS IS MENTIONED IN SECTION 1-56. IN ADDITION TO NOT USING SEAT COVERS, CUSHIONS, ETC., THE PASSENGER IS ADVISED TO TAKE OFF 'UNNECESSARY ITEMS' OR SIT IN THE BACK SEAT TO ENSURE THE AIR BAG WILL ACTIVATE. THIS SEEMS TO BE A SERIOUS DESIGN FLAW, ONE WHICH SHOULD BE BROUGHT TO SUBARU SERVICE TECHS AND CUSTOMERS' ATTENTION.
TL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT TOOK THE VEHICLE TO ANNAPOLIS SUBARU (149 OLD SOLOMONS ISLAND RD, ANNAPOLIS, MD 21401, 888-409-1189) BECAUSE THE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY WHEN THE VEHICLE WAS STARTED. ALTHOUGH THE VEHICLE HAD BEEN SERVICED AT THE DEALER, THE FAILURE CONTINUED. …
Read full complaint
TL* THE CONTACT OWNS A 2018 SUBARU FORESTER. THE CONTACT TOOK THE VEHICLE TO ANNAPOLIS SUBARU (149 OLD SOLOMONS ISLAND RD, ANNAPOLIS, MD 21401, 888-409-1189) BECAUSE THE AIR BAG WARNING INDICATOR ILLUMINATED INTERMITTENTLY WHEN THE VEHICLE WAS STARTED. ALTHOUGH THE VEHICLE HAD BEEN SERVICED AT THE DEALER, THE FAILURE CONTINUED. WHILE THE CONTACT'S WIFE WAS DRIVING 55 MPH, THE PRECEDING VEHICLE SUDDENLY SLAMMED ON THE BRAKES. DURING THIS INCIDENT, THE CONTACT NOTICED THAT BOTH THE SIDE PASSENGER AIR BAG AND THE DRIVER'S AIR BAG WARNING INDICATORS WERE ILLUMINATED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT A REPRESENTATIVE WOULD CALL HIM BACK. THE CONTACT HAD NOT HEARD BACK FROM THE MANUFACTURER. THE DEALER WAS NOT NOTIFIED OF THE RECENT FAILURE WITH THE VEHICLE. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 8,300.
SRS WARNING LIGHT COMES ON WHILE VEHICLE IS STATIONARY OR IN MOTION AT RANDOM INTERVALS. BASED ON MY KNOWLEDGE THIS MEANS THE SRS AIRBAG SYSTEM IS COMPLETELY DEACTIVATED. WHEN BRINGING IT TO SUBARU'S ATTENTION THEY BLAMED MOISTURE ON THE SEATS MESSING WITH THE SENSORS, BUT THE SEATS HAVE NEVER HAD A SPILL ON THEM.
Official recalls
321V587000 · Fuel System, Gasoline:delivery:fuel Pump
Jul 29, 2021
Subaru of America, Inc. (Subaru) is recalling certain 2019-2020 Ascent, 2018 Forester, 2018-2020 Impreza, Legacy, Outback, 2018-2019 BRZ, WRX, and Toyota 86 vehicles. The low-pressure fuel pump inside the fuel tank may fail.
Consequence & remedy
Consequence: Fuel pump failure can cause an engine stall while driving, increasing the risk of a crash.
Remedy: Dealers will replace the low-pressure fuel pump, free of charge. Owner notification letters were mailed September 24, 2021. Subaru and Toyota owners may call customer service at 1-844-373-6614. Subaru's number for this recall is WRG-21.
19V701000 · Air Bags:sensor:occupant Classification
Oct 3, 2019
Subaru of America, Inc. (Subaru) is recalling certain 2015-2018 Forester vehicles equipped with heated seats. An electrical connection in the front passenger seat for the Occupant Detection System (ODS) may loosen.
Consequence & remedy
Consequence: If the connection loosens, the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.
Remedy: Subaru will notify owners, and dealers will inspect and, as necessary, replace the ODS sensor mat harness, free of charge. The recall began February 11, 2020. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WUM-98.
18V455000 · Equipment:other:labels; Tires
Jul 10, 2018
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence & remedy
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Additional source detail variants (2)
Equipment:other:labels
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Tires
Subaru of America, Inc. (Subaru) is recalling certain 2018 Subaru Forester vehicles. The Certification Label may indicate the incorrect wheel size, tire size, and air pressure. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 110, "Tire Selection and Rims."
Consequence: Installing incorrect tires or applying incorrect tire air pressure may increase the risk of a crash.
Remedy: Subaru will notify owners, and dealers will install a corrected label, free of charge. The recall began July 26, 2018. Owners may contact Subaru customer service at 1-844-373-6614. Subaru's number for this recall is WTS-78.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE19009 · Occupant Detection System (ods) Failure
Opened Aug 6, 2019 · Closed Jan 22, 2020
Status: closed (inferred from source dates) · Air Bags; Air Bags:frontal; Air Bags:frontal:passenger Side:inflator Module; Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Additional source detail variants (4)
Air Bags:frontal:passenger Side:inflator Module
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:frontal
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags:sensor:occupant Classification
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.
Air Bags
The Office of Defects Investigation (ODI) opened PE19-009 to investigate 51 complaints and additional Early Warning Report (EWR) data related to allegations of front passenger seat Occupant Detection System (ODS) malfunctions in model year (MY) 2016 through 2018 Subaru Forester vehicles. These vehicles use a capacitive type ODS, which is intended to classify the occupant of the passenger seat as either full-sized, small stature, a child seat or other object. The complaints reported the ODS failed to operate properly, the SRS (Supplemental Restraint System) warning light illuminated, and/or the ODS incorrectly suppressed (turned off) the front passenger air bag when the seat was occupied by a full-sized passenger. In a frontal crash that is sufficient to warrant deployment, a suppressed air bag may increase the risk of injury to the occupant of the seat.On August 14, 2019 ODI sent an Information Request (IR) to Subaru requesting information on the subject vehicles and MY 2014-2015 Subaru Forester vehicles.On October 3, 2019, Subaru submitted a Defect Information Report (DIR) to NHTSA describing a safety defect in the passenger-side front airbag Occupant Detection System (ODS) harness of 366,282 MY 2015-2018 Subaru Forester vehicles equipped with seat heaters.The DIR stated that over time, due to a decrease in contact pressure between the terminals in the ODS sensor mat harness, a temporarily unstable electrical connection may be possible. If the connection is temporarily unstable, the ODS may not properly determine the status of the right front seat occupant. If the ODS is unable to correctly determine the status of the front occupant, the airbag warning light may illuminate, and the front passenger airbag may deactivate even though the seat is occupied, increasing the risk of injury to the front passenger in the event of a crash.Using vehicle production data and field occurrence frequency, Subaru determined the potentially affected vehicle production range to be between January 20, 2015 ?and August 1, 2017.In addition, Subaru indicated that over 99 percent of the related MY 2015-2018 field reports with vehicles in the production range involved vehicles with seat heaters.NHTSA's analysis of complaint and warranty claim data showed 1,440 of the complaints and 11,672 of the claims involve vehicles with seat heaters that were built within the production range covered by Subaru's recall.In addition, NHTSA's analysis showed a complaint rate of 393.1 per hundred thousand vehicles for the recalled population and 89.0 for MY 2014 through 2018 vehicles that are not included in the recall. Analysis of warranty claim data found a claim rate of 3.2 percent for the recalled population and 0.3 percent for MY 2014 through 2018 vehicles that are not included in the recall.Subaru will instruct owners with Subaru Forester vehicles produced in the affected vehicle production range, to bring their vehicles to a dealer to have the sensor mat harness, inspected and replaced with a new part, including the seat cushion assembly, if necessary.Based on ODI's analysis, the actions taken by Subaru mitigate any unreasonable risk to safety posed by ODS sensor mat failures in the subject vehicles. For subject and peer vehicles outside the recall population and those equipped without seat heaters, ODI's analysis indicates that there is currently no safety-related defect trend. Given these circumstances, further use of the agency resources in this matter does not appear to be warranted. Accordingly, this investigation is closed.