IllustrationFront drivers side control arm broke at bracket point and lost control of vehicle steering. And car was damaged hitting a post. Vehicle per recall for control arm had already been “fixed” contacted Subaru if control arms were replaced under recall or the “rust proofing” applied.
2006 Subaru Forester
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2006 Subaru Forester do not stand out strongly from the model-year median of 131.
About this comparison →How this year compares
Owner complaints by model year
Compare all Forester years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
200–25K
1325–50K
950–75K
1075–100K
13100–150K
4150K+
69 reports with mileage · 19 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Vehicle Speed Control. Review the 20 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Suspension. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 11 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
12 crash reports7 fire reports4 injury reports
Steering complaints
9 reportsFront control arm failed on car. Which snapped the front axle and sway bar link on right side. Found out it was a known issue that was taken care of by dealer. Waiting to see if they will cover repairs.
I was made a turn at roughly 15mph and the front passenger side control arm sheared in half causing me to lose control of the vehicle and then abruptly come to an immediate stop. My family was in the car and at a higher speed this could have been fatal. Had there been any vehicles behind me that could have caused an accident wit…
Read full complaint
I was made a turn at roughly 15mph and the front passenger side control arm sheared in half causing me to lose control of the vehicle and then abruptly come to an immediate stop. My family was in the car and at a higher speed this could have been fatal. Had there been any vehicles behind me that could have caused an accident with unknown results. Had this been moments early I would have been in a head on collision. This is a known issue for this year, make, and model that was not properly resolved in the past by the manufacturer. The part should not fail in that manner. There were no warnings. The failure was inspected by the tow truck driver.
TL* THE CONTACT OWNS 2016 SUBARU FORESTER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO BRATTLEBORO SUBARU (1234 PUTNEY RD, BRATTLEBORO, VT 05301) TO BE SERVICED FOR AN UNKNOWN MANUFACTURER RECALL. THE CONTACT STATED THAT UPON RETRIEVING THE VEHICLE FROM THE DEALER, THE VEHICLE WAS STARTED AND THE POWER STEERING WAS INOPERAB…
Read full complaint
TL* THE CONTACT OWNS 2016 SUBARU FORESTER. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO BRATTLEBORO SUBARU (1234 PUTNEY RD, BRATTLEBORO, VT 05301) TO BE SERVICED FOR AN UNKNOWN MANUFACTURER RECALL. THE CONTACT STATED THAT UPON RETRIEVING THE VEHICLE FROM THE DEALER, THE VEHICLE WAS STARTED AND THE POWER STEERING WAS INOPERABLE. THE CONTACT STATED THAT THE POWER STEERING FAILURE WARNING LIGHT WAS ILLUMINATED. THE CONTACT STATED THAT EXTRA EFFORT WAS NEEDED TO TURN THE STEERING WHEEL IN EITHER DIRECTION. THE VEHICLE WAS NOT TAKEN BACK TO DEALER. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND OFFERED TO FIX THE VEHICLE FREE OF CHARGE. THE FAILURE MILEAGE WAS 51,000. THE VIN WAS INVALID.
EVERY TIME I REACH SPEED OF 80MPH IN THE FREEWAY MY STEERING WHEEL IS VIBRATING OUT OF CONTROL
WHILE THE VEHICLE WAS IN MOTION ON A HIGHWAY, I DROVE OVER A POTHOLE ON THE PASSENGER SIDE AND MY LOWER CONTROL ARM BROKE DUE TO A KNOWN PROBLEM WITH CORROSION IN THIS MODEL YEAR. THERE WAS A NOTICEABLE PROBLEM WITH WHEEL ALIGNMENT WHICH WAS ABLE TO BE FELT IN THE STEERING WHEEL. SUBARU RECALL WVX-34 WAS SUPPOSED TO FIX THIS SAF…
Read full complaint
WHILE THE VEHICLE WAS IN MOTION ON A HIGHWAY, I DROVE OVER A POTHOLE ON THE PASSENGER SIDE AND MY LOWER CONTROL ARM BROKE DUE TO A KNOWN PROBLEM WITH CORROSION IN THIS MODEL YEAR. THERE WAS A NOTICEABLE PROBLEM WITH WHEEL ALIGNMENT WHICH WAS ABLE TO BE FELT IN THE STEERING WHEEL. SUBARU RECALL WVX-34 WAS SUPPOSED TO FIX THIS SAFETY ISSUE. THE 'REPAIR' WAS COMPLETED ON MY VEHICLE IN JANUARY OF 2012. AS YOU CAN SEE FROM THE PHOTOS, THE RUST PROOFING DID NOT HELP.
CONTROL ARM IS RUSTED COMPLETELY THROUGH. I NEED TO FULLY REPLACE THE ENTIRE ARM. IT'S URGENT, AS THE ENTIRE WHEEL AND MECHANISM COULD FALL OFF AT ANY TIME.
THE FRONT CONTROL ARMS ON MY 2006 SUBARU FORESTER FAILED ON MAY 15, 2015. THERE WAS NO WARNING (NO SOUND, NO SHIMMYING, NO STEERING ISSUES) TO SUGGEST THAT SOMETHING WAS ABOUT TO HAPPEN. THE MAIN SAFETY ISSUE IS THAT IN 2012, SUBARU ISSUED A RECALL FOR FORESTERS AND IMPREZAS, RUSTPROOFING THE CONTROL ARMS. I BROUGHT MY CAR IN A…
Read full complaint
THE FRONT CONTROL ARMS ON MY 2006 SUBARU FORESTER FAILED ON MAY 15, 2015. THERE WAS NO WARNING (NO SOUND, NO SHIMMYING, NO STEERING ISSUES) TO SUGGEST THAT SOMETHING WAS ABOUT TO HAPPEN. THE MAIN SAFETY ISSUE IS THAT IN 2012, SUBARU ISSUED A RECALL FOR FORESTERS AND IMPREZAS, RUSTPROOFING THE CONTROL ARMS. I BROUGHT MY CAR IN AT THAT TIME, AND HAVE THE PAPERWORK THAT INDICATES THAT THIS SERVICE WAS PERFORMED. I THEREFORE ASSUMED THE CAR WAS SAFE. THERE HAS BEEN NO OTHER RECALL. MY CAR HAD 118,000 MILES ON IT, AND IS WELL TAKEN CARE OF. I AM NOT AN AGGRESSIVE, POOR OR OFF-ROAD DRIVER. MY HUSBAND IS EXPERIENCED WITH CARS AND CAR REPAIRS, AND HE ALSO HEARD AND FELT NOTHING TO SUGGEST MY CAR MIGHT HAVE A PROBLEM WHEN HE DROVE THE CAR PRIOR TO THE ACCIDENT. FORTUNATELY, I WAS EXITING A ROTARY ONTO A HIGHWAY, SO HADN'T YET REACHED FULL SPEED. THE CAR GLIDED ACROSS ANOTHER LANE AS I HIT THE BRAKE, AND A RAISED DIVIDER KEPT THE CAR FROM CONTINUING INTO ONCOMING TRAFFIC. THIS FAILURE COULD HAPPEN TO ANYONE ELSE WITH A SIMILAR CAR HISTORY. THAT PERSON COULD BE DRIVING AT FULL SPEED, AND MIGHT NOT BE AS LUCKY AS I WAS IN BEING ABLE TO STOP SAFELY. A DEPUTY SHERIFF CALLED AAA FOR ME, AND I WAS TOWED TO A LOCAL SUBARU DEALERSHIP. THEY REPLACED BOTH CONTROL ARMS, SWAY BARS, AND THE AXLE. SUBARU PAID FOR ALL THE REPAIRS, AND OFFERED TO PAY FOR THE TOWING. IN 2014, THE REAR CONTROL ARMS WERE REPLACED; I BROUGHT THE CAR IN BECAUSE IT WAS MAKING A NOISE AND THE REAR OF THE CAR WAS NOT RESPONDING CORRECTLY. SUBARU DIDN'T COVER THAT EXPENSE, AND I DIDN'T REALIZE THAT I SHOULD HAVE INSISTED THAT THEY DO SO. THE EXPERIENCE SUGGESTED TO ME, HOWEVER, THAT I WOULD HAVE PLENTY OF WARNING SHOULD SOMETHING HAPPEN TO THE OTHER CONTROL ARMS. THIS WAS NOT THE CASE IN MY SITUATION, AND OTHERS SHOULD BE MADE OF AWARE OF THE EXTREME DANGER THEY FACE.
2006 SUBARU FORESTER. CONSUMER WRITES IN REGARDS TO WHEEL BEARING MALFUNCTION. *SMD THE CONSUMER STATED WHILE DRIVING, THE VEHICLE BEGAN TO MAKE SOME UNUSUAL SOUNDS. SHE PULLED OVER TO CHECK THE TIRES, BECAUSE IT SOUNDED LIKE A FLAT TIRE. HOWEVER, EVERYTHING LOOKED NORMAL, SO SHE CONTINUED DRIVING. AS SHE DROVE A LITTLE FURTH…
Read full complaint
2006 SUBARU FORESTER. CONSUMER WRITES IN REGARDS TO WHEEL BEARING MALFUNCTION. *SMD THE CONSUMER STATED WHILE DRIVING, THE VEHICLE BEGAN TO MAKE SOME UNUSUAL SOUNDS. SHE PULLED OVER TO CHECK THE TIRES, BECAUSE IT SOUNDED LIKE A FLAT TIRE. HOWEVER, EVERYTHING LOOKED NORMAL, SO SHE CONTINUED DRIVING. AS SHE DROVE A LITTLE FURTHER AND MADE A LEFT TURN, THE BRAKES WENT OUT. SHE SLOWLY EASED THE VEHICLE TO THE SIDE OF THE ROAD, WHERE THE REAR TIRE FELL OFF THE AXLE. THE VEHICLE WAS TOWED TO THE DEALER. AN INSPECTION REVEALED THE WHEEL BEARING BROKE. THE CONSUMER STATED THE SAME BEARING WAS REPLACED ON APRIL 29, 2011. ALSO, THE POWER STEERING PUMP WAS REPLACED. *JB
Official recalls
211V464000 · Suspension:front:control Arm:lower Arm
Sep 6, 2011
SUBARU IS RECALLING CERTAIN MODEL YEAR 2002-2007 IMPREZA, MODEL YEAR 2003-2008 FORESTER, AND MODEL YEAR 2005-2006 SAAB 9-2X VEHICLES MANUFACTURED FROM SEPTEMBER 5, 2000 THROUGH NOVEMBER 26, 2007 ORIGINALLY SOLD, OR CURRENTLY REGISTERED IN, MASSACHUSETTS, MARYLAND, MICHIGAN, NEW HAMPSHIRE, NEW YORK, PENNSYLVANIA, VERMONT, WISCONSIN, CONNECTICUT, DELAWARE, IOWA, ILLINOIS, INDIANA, MAINE, MINNESOTA, MISSOURI, NEW JERSEY, OHIO, RHODE ISLAND, WEST VIRGINIA AND THE DISTRICT OF COLUMBIA. THE FRONT LOWER CONTROL ARMS MAY BREAK AT THE HANGER BRACKETS DUE TO CORROSION IF THE HANGER BRACKET IS EXPOSED TO SALTY AND HUMID ENVIRONMENTS SUCH AS ROADS CONTAINING SNOW MELTING AGENT.
Consequence & remedy
Consequence: A BROKEN CONTROL ARM CAN RESULT IN THE LOSS OF CONTROL OF THE VEHICLE, INCREASING THE RISK OF A CRASH.
Remedy: SUBARU WILL HANDLE THEIR VEHICLES AND SAAB WILL HANDLE THEIRS. DEALERS WILL INSPECT THE DEGREE OF CORROSION OF THE FRONT LOWER CONTROL ARMS, AND WILL EITHER RUSTPROOF OR REPLACE THEM. THIS SERVICE WILL BE PERFORMED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING DECEMBER 2011. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783. OWNERS MAY CONTACT SAAB AT 1-800-955-9007.
07V043000 · Air Bags:frontal
Feb 12, 2007
ON CERTAIN VEHICLES, THE WIRING HARNESS FOR THE AIR BAG OCCUPANT DETECTION SYSTEM IN THE FRONT PASSENGER SEAT MAY HAVE BEEN PINCHED DURING PRODUCTION. PINCHING OF THE WIRING HARNESS BETWEEN THE FLOOR CROSSMEMBER AND THE SEAT MOUNTING BRACKET COULD RESULT IN A SHORT CIRCUIT.
Consequence & remedy
Consequence: THE PASSENGER'S FRONT AIR BAG COULD BECOME DISABLED AND MAY NOT DEPLOY IN THE EVENT OF A CRASH INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT. ALSO AN ELECTRICAL SHORT CIRCUIT COULD CAUSE A FIRE.
Remedy: DEALERS WILL INSPECT TO SEE IF THE WIRING HAD BEEN INCORRECTLY ROUTED UNDER THE SEAT BRACKET. IF SO, THE DEALER WILL REPAIR ANY DAMAGED WIRING, REROUTE AND SECURE THE WIRING HARNESS IN THE CORRECT LOCATION, AND RE-CALIBRATE THE OCCUPANT DETECTION SYSTEM AS NECESSARY. THE RECALL BEGAN ON MARCH 9, 2007. OWNERS MAY CONTACT SUBARU AT 1-800-782-2783.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE11011 · Front Suspension Control Arm Failure
Opened Apr 7, 2011 · Closed Sep 23, 2011
Status: closed (inferred from source dates) · Suspension; Suspension:front; Suspension:front:control Arm; Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Additional source detail variants (4)
Suspension:front:control Arm:lower Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front:control Arm
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension:front
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.
Suspension
On September 6, 2011, Fuji Heavy Industries USA, Inc, on behalf of Subaru of America, Inc notified the Office of Defects Investigation (ODI) it would be conducting a safety recall of certain model year (MY) 2002 through 2007 Subaru Impreza, MY 2003 through 2008 Subaru Forester, and MY 2005 through 2006 Saab 9-2X vehicles originally sold or currently registered in one the salt belt states including the District of Columbia (DC). For the purpose of this investigation, salt belt states include Connecticut, Delaware, Illinois, Indiana, Iowa, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and DC.ODI's analysis of consumer complaint data identified 11 reports alleging failure of either the right or left lower control arm due to excessive corrosion. All of these complaints were associated with vehicles currently registered or originally sold in a salt belt state. Through a similar analysis of complaint and warranty data submitted to ODI by Subaru, ODI identified 18 consumer complaints and 6 warranty claims associated with failure of the left or right front lower control arm due to excessive corrosion. All of these consumer complaints associated with vehicles either currently registered of originally sold in a salt belt state.Accordingly, this investigation is closed.