When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 0 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
NHTSA owner reports · September 18, 2026 snapshot.
Official recalls
11Mar 25, 2008
DAIMLER TRUCKS IS RECALLING 28,764 MY 2001 THROUGH 2008 FCCC B2 AND FS65 SCHOOL BUS CHASSIS, FCCC FB65 CONVENTIONAL BUSES, AND STERLING ACTERRA, FREIGHTLINER FLN, AND BUSINESS CLASS M2 HEAVY TRUCKS, BUILT FROM JANUARY 26, 2000, THROUGH MARCH 24, 2008, MANUFACTURED WITH ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 THROUGH 8,000 POUND FRONT AXLES UTILIZING A FOUR PIECE SPINDLE-NUT SET. THESE AXLE ASSEMBLIES MAY HAVE BEEN PRODUCED WITH A THIN SPINDLE NUT WHICH MAY LEAD TO INCORRECT END PLAY, CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.
Consequence & remedy
Consequence: CONTINUED OPERATION MAY LEAD TO WHEEL SEPARATION AND POSSIBLY A VEHICLE CRASH.
Remedy: DAIMLER TRUCKS WILL NOTIFY OWNERS AND WILL REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 8, 2009. OWNERS MAY CONTACT DAIMLER TRUCKS AT 1-800-547-0712.
Mar 30, 2005
ON CERTAIN TRUCKS AND FIRE TRUCKS EQUIPPED WITH KYS 4735-43782-02 ENGINE COOLING FANS AND BUILT ON CATERPILLAR 3126, C7, MBE906, MBE926, OR CUMMINS ISC ENGINES, THE STEEL FAN INSERT ON THE COOLING FANS CAN CRACK.
Consequence & remedy
Consequence: THIS CAN RESULT IN FAN BREAKAGE, RESULTING IN VEHICLE DAMAGE OR PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ENGINE COOLING FAN FREE OF CHARGE. THE RECALL BEGAN ON JUNE 8, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
Jun 7, 2004
ON CERTAIN TRUCKS BUILT WITH 8,000 OR 6,000 POUND FRONT AXLES AND FOUR-PIECE SPINDLE NUT SETS, PREMATURE FRONT ,WHEEL BEARING WEAR MAY BE CAUSED BY INCONSISTENT BEARING ENDPLAY ADJUSTMENT.
Consequence & remedy
Consequence: IF ALLOWED TO PROGRESS, THE FRONT WHEEL ASSEMBLY MAY SEPARATE FROM THE VEHICLE, WHICH COULD RESULT IN A CRASH.
Remedy: THE DEALERS WILL REPLACE THE FRONT AXLE OIL SEALS AND HUB CAP GASKETS ON BOTH SIDES. THE RECALL BEGAN SEPTEMBER 7, 2004. OWNERS SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Mar 21, 2003
ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.
Consequence & remedy
Consequence: SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.
Remedy: DEALERS WILL REPLACE BOTH FRONT HUBS. OWNER NOTIFICATION IS EXPECTED TO BEGIN ON OR BEFORE SEPTEMBER 20, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Dec 13, 2002
ON CERTAIN HEAVY TRUCKS, THE CAST OUTPUT YOKE ON THE MERCEDES-BENZ TRANSMISSIONS COULD FRACTURE ON VEHICLE WITH 1610 OR 16T SERIES DRIVELINES.
Consequence & remedy
Consequence: IF PIECES OF THE YOKE SEPARATE, THE DEBRIS CAN REPRESENT A POTENTIAL HZARD TO PEOPLE OUTSIDE THE VHEICLE AND TO OTHER PASSING VEHICLES.
Remedy: DEALERS WILL REPLACE THE CAST TRANSMISSION OUTPUT YOKE WITH A FORGED PART. OWNER NOTIFICATION BEGAN ON JANUARY 30, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Apr 10, 2002
ON CERTAIN TRUCKS EQUIPPED WITH MERITOR BRAND 12" X 4" DCM DRUM PARKING BRAKE, THE BOLTS USED TO ATTACH THE PARKING BRAKE ASSEMBLY TO THE FLANGE YOKE ARE TOO LARGE AND CAN INTERFERE WITH THE PROPER ENGAGEMENT OF THE BRAKING SYSTEM AND POSSIBLY DISENGAGE.
Consequence & remedy
Consequence: IMPROPER ENGAGEMENT OF THE PARKING BRAKE COULD RESULT IN THE VEHICLE ROLLING AWAY WITHOUT PRIOR WARNING POSSIBLY RESULTING IN PERSONAL INJURY OR DEATH.
Remedy: DEALERS WILL REPLACE THE ATTACHING BOLTS WITH THE CORRECT SIZE BOLTS FREE OF CHARGE. OWNER NOTIFICATION IS EXPECTED TO BEGIN DURING OCTOBER 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Mar 20, 2002
ON CERTAIN TRUCKS, A CAPACITOR IN THE POWER LINE CONTROL (PLC) FILTER COULD OVERHEAT AND/OR IGNITE WHEN SUBJECTED TO REVERSE POLARITY ELECTRICAL SPIKES.
Consequence & remedy
Consequence: THIS COULD CAUSE AN ELECTRICAL FIRE IN THE AREA OF THE PLC FILTER WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL DISCONNECT AND SECURE THE PLC FILTER GROUND WIRE. OWNER NOTIFICATION BEGAN SEPTEMBER 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Jan 22, 2002
ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH MERITOR WABCO PNEUMATIC ANITLOCK BRAKE SYSTEM (ABS) VALVE PACKAGES, THE ASSEMBLY BOLTS ON THESE VALVE PACKAGES WERE NOT TIGHTENED CORRECTLY.
Consequence & remedy
Consequence: BOLTS TORQUED BELOW SPECIFICATION WILL NOT RELIABLY PREVENT AIR LEAKAGE AT THE AFFECTED ABS VALVE PACKAGE INTERFACE JOINTS ONCE THE COMPONENT BEGINS NORMAL VEHICLE OPERATION. IF AIR LEAKS DEVELOP AT ANY OF THE ABS VALVE PACKAGE INTERFACE JOINTS, BRAKE SYSTEM PRESSURE REDUCTIONS COULD OCCUR DURING BRAKING OR NORMAL OPERATION WITH UNITS EQUIPPED WITH THE TRACTION CONTROL OPTION, POTENTIALLY EXTENDING STOPPING DISTANCES, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: DEALERS WILL TIGHTEN THE FASTENERS TO THE PROPER SPECIFICATION. OWNER NOTIFICATION BEGAN APRIL 4, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Nov 29, 2001
ON CERTAIN TRUCKS, THE WELDS THAT ATTACH THE REAR SUSPENSION CONTROL ROD BRACKETS TO THE AXLE HOUSING MAY NOT MEET SPECIFICATIONS.
Consequence & remedy
Consequence: A WELD COULD FRACTURE, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE REAR SUSPENSION BRACKET WELDS TO DETERMINE IF THEY MEET SPECIFICATIONS AND RE-WELD IF NECESSARY. OWNER NOTIFICATION BEGAN JULY 31, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Jun 14, 2001
VEHICLE DESCRIPTION: VEHICLES EQUIPPED WITH CERTAIN HALDEX BRAKE SYSTEM TWO AND FOUR PORT RELAY VALVES. THE VALVE MAY STICK OPEN WHEN A HIGH-PRESSURE APPLICATION IS RELEASED.
Consequence & remedy
Consequence: WHEN THE VALVE STICKS OPEN, IT CAN RESULT IN A TOTAL LOSS OF AIR FROM EITHER THE SERVICE OR THE PARK BRAKE SYSTEM. THE DRIVER MAY LOSE BRAKING ABILITY UNDER A SERVICE APPLICATION, POSSIBLY RESULTING IN A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THESE VALVES. OWNER NOTIFICATION BEGAN OCTOBER 17, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Mar 12, 2001
VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH HYDRAULIC BRAKES AND A DURAPARK PARK BRAKE SYSTEM MANUFACTURED BY ARVINMERITOR. AIR IS ENTERING THE HYDRAULIC REAR BRAKE CYLINDERS THROUGH AN UNKNOWN PATH AND THE REAR SELF-ADJUSTING BRAKES MAY NOT BE OPERATING PROPERLY.
Consequence & remedy
Consequence: THIS RESULTS IN SPONGY OR SOFT FEEL TO THE BRAKE PEDAL AND A LOSS OF REAR BRAKING CAPABILITY.
Remedy: DEALERS WILL REMOVE AND REPLACE THE ABS ECU AND INSPECT THE BRAKE PEDAL FOR PROPER TRAVEL. IF EXCESSIVE TRAVEL IS DETECTED, THE BRAKE SYSTEM WILL BE BLED AND REAR BRAKES ADJUSTED. AS AN INTERIM MEASURE, FREIGHTLINER WILL NOTIFY ALL OWNERS TO HAVE THEIR VEHICLES INSPECTED TO ASSURE PROPER FUNCTION OF THE BRAKE SYSTEM. THIS WILL INCLUDE ADJUSTING AND BLEEDING THE BRAKES. ALSO, OWNERS WILL BE INSTRUCTED THAT ON A REGULAR BASIS THEY SHOULD DO SEVERAL HARD BRAKE APPLICATIONS WHILE STOPPED. THIS WILL EXERCISE THE SELF-ADJUSTING SYSTEM AND IF THEY OBSERVE A LOW OR SPONGY BRAKE PEDAL THEY WILL BE INSTRUCTED TO TAKE THEIR VEHICLE IN FOR ADDITIONAL SERVICE. OWNER NOTIFICATION BEGAN MARCH 21, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ07003 · Front Wheel Separation
Opened Dec 5, 2007 · Closed Mar 26, 2008
Status: closed (inferred from source dates) · Suspension:front:hub; Suspension:front:wheel Bearing ; Wheels:hub
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Additional source detail variants (3)
Suspension:front:hub
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Suspension:front:wheel Bearing
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Wheels:hub
ODI IS CLOSING THIS INVESTIGATION BASED ON DAIMLER TRUCK NORTH AMERICA 'S (DTNA) MARCH 19, 2008, DEFECT NOTIFICATION REPORT WHICH OUTLINES DTNA'S INTENTION TO CAMPAIGN 28,764 FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS VEHICLES [EQUIPPED WITH EITHER ARVINMERITOR OR AXLE ALLIANCE COMPANY 6,000 - 8,000 POUND RATED FRONT AXLE ASSEMBLIES UTILIZING A FOUR PIECE SPINDLE NUT SET] MANUFACTURED BETWEEN JANUARY 26, 2000, AND MARCH 24, 2008.DTNA HAS PROPOSED PROVIDING A REMEDY FOR THE CURRENTLY INSTALLED FOUR PIECE SPINDLE NUT SYSTEMS WHICH MAY LEAD TO INCORRECT END PLAY, [BEARING] CONE SPIN, EXCESSIVE HEAT, DEGRADATION OF LUBRICATION, WEAR OF THE SPINDLE NUT [BACKFACE] AND BEARING JOURNAL, OIL CONTAMINATION WITH METAL SHAVINGS, AND PREMATURE BEARING FAILURE.CONTINUED OPERATION MAY LEAD TO A WHEEL SEPARATION.ODI HAS RELIEVED DTNA OF THE RESPONSIBILITY TO PROVIDE THE INFORMATION REQUESTED AS PART OF THIS RQ SO THAT DTNA COULD FOCUS THEIR EFFORTS ON INVESTIGATION OF THE WHEEL SEPARATION ISSUES AND PLANNING AND IMPLEMENTING A RESPONSIVE AND TIMELY FIELD ACTION (CAMPAIGN).
Illustration