Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Fuel System, Diesel. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
303,087 miles · Oct 12, 2006
Fuel System, Diesel
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE FUEL LINE ASSEMBLY BURST WITHOUT WARNING SPRAYING DIESEL FUEL ONTO THE VEHICLE AND THE HIGHWAY. THE CONTACT MANAGED TO PARK THE VEHICLE ON THE SIDE OF THE HIGHWAY WITHOUT FURTHER INCIDENT. THE CONTACT INSPECTED THE VEHICLE AND DETERMINED THE FUEL LINES WERE FRACTURED IN…
Read full complaint
DT*: THE CONTACT STATED WHILE DRIVING VARIOUS SPEEDS, THE FUEL LINE ASSEMBLY BURST WITHOUT WARNING SPRAYING DIESEL FUEL ONTO THE VEHICLE AND THE HIGHWAY. THE CONTACT MANAGED TO PARK THE VEHICLE ON THE SIDE OF THE HIGHWAY WITHOUT FURTHER INCIDENT. THE CONTACT INSPECTED THE VEHICLE AND DETERMINED THE FUEL LINES WERE FRACTURED INTO AND NEEDED REPLACED. A NHTSA RECALL, #05V469000 REMEDY REPAIR TO THE ENGINE BY EMC RECALIBRATION AND REPLACEMENT OF THE FUEL LIFT PUMP WAS PERFORMED WHICH PERTAINED TO THE FUEL SYSTEM. HOWEVER, THE RECALL DID NOT REMEDY THE PROBLEM. THE DEALERSHIP WOULD NOT OFFER AN ADDITIONAL REPAIR WITHOUT CHARGE UNDER THE RECALL. THE MANUFACTURER WAS ALERTED.
CERTAIN FREIGHTLINER SCHOOL BUS CHASSIS, HEAVY TRUCKS, AND THOMAS BUILT SCHOOL BUSES MANUFACTURED BETWEEN JULY 2002 AND JULY 3, 2007, EQUIPPED WITH BENDIX SR-7 SPRING BRAKE CONTROL VALVES. THE PARKER SCV BRASS 90 DEGREE SINGLE CHECK VALVES (SCV) WHICH ATTACH TO THE SUPPLY PORT OF A BENDIX SR-7 SPRING BRAKE MODULATING VALVE CAN BREAK APART. PIECES OF THE PARKER SCV CAN BECOME LODGED INSIDE THE SR-7 SPRING BRAKE MODULATING VALVE, POTENTIALLY CAUSING EITHER LEAKAGE OUT OF THE SR-7 VALVE OR PREVENTING AIR FROM PROPERLY EXHAUSTING FROM THE SR-7 VALVE. ALSO, DUE TO A MANUFACTURING DEFECT IN THE INTERNAL RUBBER CHECK VALVE INSIDE THE SR-7 SPRING BRAKE MODULATING VALVES, THE VALVES CAN BECOME DEFORMED AND NOT SEAT PROPERLY.
Consequence & remedy
Consequence: THESE CONDITIONS COULD EITHER RESULT IN LEAKAGE AND CAUSE A DELAY IN THE APPLICATION OF THE SPRING BRAKE WITHOUT WARNING OR POSSIBLY LEAD TO UNINTENDED VEHICLE ROLLAWAY OR BRAKE DRAG WHICH COULD RESULT IN A VEHICLE CRASH, PERSONAL INJURY, OR DEATH.
Remedy: FREIGHTLINER WILL NOTIFY OWNERS AND REPAIR THE VEHICLES FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 11, 2008 TO FREIGHTLINER, STERLING, AND FREIGHTLINER CUSTOM CHASSIS OWNERS; TO THOMAS BUILT BUS OWNERS ON FEBRUARY 1, 2008. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
ON CERTAIN TRUCKS AND FIRE TRUCKS EQUIPPED WITH KYS 4735-43782-02 ENGINE COOLING FANS AND BUILT ON CATERPILLAR 3126, C7, MBE906, MBE926, OR CUMMINS ISC ENGINES, THE STEEL FAN INSERT ON THE COOLING FANS CAN CRACK.
Consequence & remedy
Consequence: THIS CAN RESULT IN FAN BREAKAGE, RESULTING IN VEHICLE DAMAGE OR PERSONAL INJURY.
Remedy: DEALERS WILL REPLACE THE ENGINE COOLING FAN FREE OF CHARGE. THE RECALL BEGAN ON JUNE 8, 2005. OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2003 Sterling A-LINE Problems, Complaints & Recalls | Skip That Year
Illustration