1996 Saturn Sl

TL* - THE CONTACT WOULD LIKE TO MAKE A COMPLAINT CONCERNING THE BRAKES ON 1996 SATURN SL2. THE CONTACT STATED THAT SHE WAS DRIVING 35 MPH WHEN SHE WAS CUT OFF BY ANOTHER CAR. SHE THEN APPLIED THE BRAKE PEDAL WHICH GAVE NO RESISTANCE. THE CONTACT STATED THAT BEFORE BEING CUT OFF THE BRAKES DID WORK. THE CONTACT STATED THAT THE CAR FINALLY STOPPED AFTER SHE PUMPED THE BRAKES. THE CONTACT CONTINUED TO DRIVE AT APPROXIMATELY 5 MPH UNTIL SHE REACHED HER DESTINATION AND HAD THE CAR TOWED TO A SATURN DEALERSHIP. THE CONTACT STATED THAT THIS BRAKE FAILURE OCCURRED APPROXIMATELY DECEMBER 5, 2006. THE CONTACT STATED THAT IT WAS A NICE DAY, AND THAT THE WEATHER WAS NOT A FACTOR. THE CONTACT PULLED MUSCLES IN HER BODY, AND WAS CURRENTLY ON MUSCLE RELAXANTS. THE CONTACT ASKED THE SATURN DEALER FOR THE DAMAGED PARTS AND WAS TOLD THAT THE PARTS WERE THROWN AWAY. THE CONTACT ALSO STATED THAT SHE HAS HAD PROBLEMS WITH THE BRAKES PULSATING AND GOING ALL THE WAY DOWN TO THE FLOOR SINCE SHE PURCHASED THE CAR. THE CONTACT STATED HAD BRAKE WORK DONE IN 2001 AT 36,000 MILES, THE BRAKE CALIPERS HAD FAILED. THE CONTACT WAS REFERRED TO NHTSA BY THE RHODE ISLAND STATE ATTORNEY'S OFFICE. *AK

I REPLACED MY BRAKES AND ROTORS TODAY. THE MECHANIC WANTED TO SHOW ME THE MESS THAT THEY WERE. I LOOKED AT THEM AND HE POINTED OUT HOW UNUSUALLY DESTROYED THE INSIDE PADS ARE. HE SAID HE RARELY SEES ANYTHING THAT BAD. THE HORN WORKS WHEN IT WANTS TO. THE KEY GETS STUCK IN THE IGNITION AND SOME DAYS I REALLY HAVE TO WORK HARD TO GET IT OUT OR GET THE STEERING WHEEL TO RELEASE SO I CAN TURN THE KEY. ALSO THE EXHAUST SYSTEM IS JUST HANGING ON BEFORE THE RUST OVERRUNS IT. *LA

WHEN GOING FROM A HIGHER RATE OF SPEED TO A LOW RATE OF SPEED (65 MPH TO 25 MPH OR 40 MPH TO 15 MPH) THE VEHICLE ACCELERATES WHILE THE BRAKE IS DEPRESSED. ALSO, WHEN APPLYNG THE BRAKES, THE CAR DOES NOT ALWAYS STOP WITHIN THE NORMAL DISTANCE . WHILE DRIVING AT ABOUT 35 MPH AND SLOWING TO A RATE OF ABOUT 15 MPH ENTERING A HIGHWAY RAMP, LOST CONTROL OF THE CAR ON THE WET ROADWAY WHCIH CAUSED ME TO SKID AND GO UP ONTO THE CURB. THE VEHICLE WAS TOWED AND HAD APPROX. $2500 WORTH OF DAMGE. LUCKILY, THERE WERE NO INJURIES TO THE 5 PEOPLE INSIDE THE VEHICLE. I THOUGHT THIS WAS DUE TO ROADWAY CONDITIONS UNTIL IT HAPPENED AGAIN. I WAS TRAVELING AT APPROX. 20 MPH SLOWING FOR A STOP SIGN AHEAD. I PRESSED ON THE BRAKE BUT THE CAR WOULD NOT STOP AND I HAD NO CONTROL OF THE VEHICLE. THANKFULLY, THERE WAS NOT AN ACCIDENT THIS TIME. AGAIN, IT WAS RAINING LIGHTLY. I HAVE MADE AN APPOINTMENT WITH THE DEALER.*AK

ONE TIME AT A STOP SIGN, PRESS THE BRAKING ALL THE WAY TO THE FLOOR BUT NO BRAKING EFFECT. AFTER ADJUSTING THE REAR DRUM OR DISK, PROBLEM DID NOT REPEAT. THE CAR'S ALTERNATOR WAS DEAD AFTER ONLY 36000 BUT DEALER WOULD NOT PAY FOR THE REPAIR. THE CAR START TO SHAKING FROM THE START TO END OF BRAKING PROCESS. DO NOT KNOW WHAT THE PROBLEM IS.*AK

BRAKE FAILURE WHEN COMING TO A STOP.BRAKE PEDAL WENT TO THE FLOOR CAR WAS VERY SLOW TO STOP.AFTER THE FIRST FAILURE BRAKE SHOP WAS UNABLE TO FIND A PROBLEM WITH THE BRAKE SYSTEM.THE SECOND FAILURE WAS AT THE SAME SPEED 35 M/H WITH THE BRAKE PEDAL HAVING THE SAME ACTION.SATURN WAS UNABLE TO FIND PROBLEM THE SECOND TIME AND TESTED IT TWO TIMES.*AK

1,2,3. BRAKES HAVE BEEN A CONSTANT PROBLEM ON THIS VEHICLE. FIRST KNOWN PROBLEM WAS ABOUT 08/99 WHEN DEALER FOUND PITTED & BLISTERED REAR BRAKE ROTORS. REPLACED THEM "AS A FAVOR" SINCE CAR WAS STILL UNDER WARRANTY (LESS THAN 36,000 MILES). I HAD COMPLAINED ABOUT LOWER GAS MILEAGE AND FEELING LIKE CAR WAS "DRAGGING" AND HAD BEEN TOLD EARLIER THAT THERE WERE NO PROBLEMS - USE A LOWER GEAR. IN JUNE, 2000, I NOTICED THAT MY RIGHT REAR BRAKE DISK WAS GLOWING RED AFTER A 36 MILE FREEWAY DRIVE. LATER, WHEN I WAS ABLE TO GET UNDER THE CAR, I FOUND THAT THE PARKING BRAKE ACTUATOR ON THE DRIVER'S SIDE REAR CALIPER WAS FROZEN IN THE "ON" POSITION. WD40 AND MUSCLE FREED IT, BUT IT HAD TO BE LEFT OFF AT ALL TIMES. THE DEALER FOUND THE DISKS TO BE WARPED, CALIPER RUINED AND FRONT DISKS ALSO WARPED. PADS WERE NOT TERRIBLY WORN ON THE FRONT. I HAVE ROUTINELY GONE 50,000 ON PADS IN PREVIOUS CALLS; THE REAR PADS ON THIS CAR HAD LESS THAN 15,000!! AGAIN, DEALER IMPLIED IT WAS MY FAULT AND NOT A DEFECT BY SATURN. #4. SPEED CONTROL - DEVICE BEGAN ERRATIC FUNCTION - SPED UP AND SLOWED DOWN WITHOUT WARNING; AT TIMES WOULDN'T TURN ON. DEALER FIXED UNDER WARRANTY, BUT NO NOTICE OF THIS PROBLEM. #5. IGNITION SWITCH - STARTED HAVING DIFFICULTY IN TURNING ON OR FULLY OFF (LOCKED POSITION). FIRST TOLD BY DEALER IT MUST BE JAMMED WITH KEY SHAVINGS-IF KEY SHOWS BRASS COLOR, MUST BE REPLACED. DEALER FOUND THAT THERE WAS A GROOVE IN THE SWITCH HOUSING-DUE TO USE OF A "HEAVY KEY CHAIN BY PREVIOUS OWNER". I PAID 50% - LOOKS LIKE CHEAP, SOFT METAL HOUSING-DESIGN FLAW. #6. HORN FAILED WITHOUT WARNING AT AROUND 26,000 MILES - 3 1/2 YEAR OLD CAR. REPLACED UNDER WARRANTY. I WONDER WHAT WILL FAIL NEXT - ALL OF THESE COULD HAVE LED TO AN ACCIDENT.