IllustrationTHE FUEL LINE IN THIS CAR IS EXPOSED AT THE BOTTOM OF THE CAR, AND TWICE NOW (ON 11/3/05 AND EARLIER IN 12/2003) THE FUEL LINE HAS RIPPED AND GASOLINE HAS SPILLED ONTO THE GROUND WHEN TRYING TO START THE CAR. THE GASOLINE SPILL OBVIOUSLY CREATES A SAFETY HAZARD. *NM
1996 Saturn Sl
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 1996 Saturn Sl do not stand out strongly from the model-year median of 171.5.
About this comparison →How this year compares
Owner complaints by model year
Compare all Sl years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 49 of 287 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 63 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 41 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 40 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
50 crash reports2 fire reports34 injury reports
Equipment complaints
7 reportsI OWN A 1996 SATURN SL1 THAT I PURCHASED USED IN DECEMBER OF 2000. I HAVE BEEN HAVING PROBLEMS WITH MY HORN SINCE I BOUGHT IT. I HAVE HAD TO HAVE IT SERVICED TWICE AND THE HORN IS BROKEN FOR A THIRD TIME. I REPLACED A FUSE IN SPRING 2001, BECAUSE IT WENT OUT. IN DECEMBER OF 2002 THE HORN WENT OUT AGAIN, SO IN MAY OF 2003 HAD…
Read full complaint
I OWN A 1996 SATURN SL1 THAT I PURCHASED USED IN DECEMBER OF 2000. I HAVE BEEN HAVING PROBLEMS WITH MY HORN SINCE I BOUGHT IT. I HAVE HAD TO HAVE IT SERVICED TWICE AND THE HORN IS BROKEN FOR A THIRD TIME. I REPLACED A FUSE IN SPRING 2001, BECAUSE IT WENT OUT. IN DECEMBER OF 2002 THE HORN WENT OUT AGAIN, SO IN MAY OF 2003 HAD THE DEALER REPLACE THE ENTIRE HORN ASSEMBLY. THIS LASTED UNTIL OCTOBER OF 2003 WHEN MY HORN STARTED GOING OFF WILDLY IN THE MIDDLE OF THE NIGHT, CAUSING THE LOCAL POLICE TO RESPOND AND GIVE ME A WARNING FOR A NOISE VIOLATION. IN THE STATE OF LOUISIANA I AM REQUIRED TO HAVE AN OPERATIONAL HORN TO GET MY VEHICLE INSPECTED, WHICH IS CURRENTLY COSTING ME AN $66/YEAR IN REPLACEMENT. THIS SHOULD NOT BE CONSIDERED REGULAR MAINTENANCE. I WAS LOOKING ON THE INTERNET FOR PARTS TO FIX MY HORN AGAIN, WHEN I CAME ACROSS A RECALL NHTSA: 98V-307, GM RECALL: 98C301. THIS APPLIES ONLY TO THE SW MODELS OF THE 1996 SATURN LINE. WHY DOES THIS ONLY APPLY TO THIS MODEL? THE EQUIPMENT AND THE CONFIGURATION ARE ALMOST IDENTICAL, AND YOU WOULD NOT BELIEVE HOW MANY PEOPLE HAVE HAD PROBLEMS WITH THIS SPECIFIC COMPLAINT. *JB
HEAD GASKET CRACKED.
ALARM FAILED.
IGNITION KEY STICKING.
RADIO INOPERATIVE.
BRAKE PADS REPLACED FOUR TIMES, BRAKE ROTORS FAILED.
Official recalls
197V138000 · Steering:gear Box (other Than Rack And Pinion)
Aug 29, 1997
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH MANUAL STEERING. THE PINION BEARING CAGE IN THE STEERING GEAR CAN SEPARATE UNDER HIGH STEERING SYSTEM LOAD CONDITIONS, SUCH AS PARKING LOT OR SIMILAR LOW SPEED MANEUVERS.
Consequence & remedy
Consequence: THIS COULD RESULT IN THE PINION GEAR DISENGAGING FROM THE RACK CAUSING A LOSS OF STEERING CONTROL.
Remedy: DEALERS WILL REPLACE THE MANUAL STEERING GEAR ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.