Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 3 of 29 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Seat Belts. Review the 12 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seats. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Electrical System. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
2 crash reports1 fire reports3 injury reports
What owners actually said
29 reports
85,000 miles · Oct 9, 2005
Service Brakes, Hydraulic
THE BRAKE PEDAL IS ALWAYS LOW AND SOME TIMES BOTTOMS OUT WHEN YOU FIRST START DRIVING THE CAR. YOU CAN'T STOP. RECORD OF COMPLAINT IS ON FILE WITH SATURN, BUT THEY JUST BLEW ME OFF BECAUSE THEY CHECK OUT THE CAR, BUT SAID IT WAS OK. I SHOWED THEM THAT BY PUMPING THE BREAKS A FEW TIMES THAT THE PEDAL WOULD BOTTOM AND BREAKING…
Read full complaint
THE BRAKE PEDAL IS ALWAYS LOW AND SOME TIMES BOTTOMS OUT WHEN YOU FIRST START DRIVING THE CAR. YOU CAN'T STOP. RECORD OF COMPLAINT IS ON FILE WITH SATURN, BUT THEY JUST BLEW ME OFF BECAUSE THEY CHECK OUT THE CAR, BUT SAID IT WAS OK. I SHOWED THEM THAT BY PUMPING THE BREAKS A FEW TIMES THAT THE PEDAL WOULD BOTTOM AND BREAKING WAS LOST. THEY DUPLICATED IT BUT REFUSED TO ADMIT IT WAS A PROBLEM. NOW MY SONS ARE DRIVING AND I CAN'T LET THEM DRIVE THE CAR BECAUSE THEY ARE NOT EXPERIENCED ENOUGH DRIVERS AND IF THEY EVERY GET INTO A PANIC STOP SITUATION THEY NEED TO HAVE EXTRA ROOM FOR GLIDING AS THE WHEELS WON'T LOCK UP. I MADE SATURN REPLACE THE MASTER BREAK CYLINDER AND THE PROBLEM BECAME WORSE. I HAVE THE OLD MASTER BREAK CYLINDER. *NM
NHTSA ODI #10139160
85,000 miles · Oct 9, 2005
Service Brakes, Hydraulic
THE BRAKE PEDAL IS ALWAYS LOW AND SOME TIMES BOTTOMS OUT WHEN YOU FIRST START DRIVING THE CAR. YOU CAN'T STOP. RECORD OF COMPLAINT IS ON FILE WITH SATURN, BUT THEY JUST BLEW ME OFF BECAUSE THEY CHECK OUT THE CAR, BUT SAID IT WAS OK. I SHOWED THEM THAT BY PUMPING THE BREAKS A FEW TIMES THAT THE PEDAL WOULD BOTTOM AND BREAKING…
Read full complaint
THE BRAKE PEDAL IS ALWAYS LOW AND SOME TIMES BOTTOMS OUT WHEN YOU FIRST START DRIVING THE CAR. YOU CAN'T STOP. RECORD OF COMPLAINT IS ON FILE WITH SATURN, BUT THEY JUST BLEW ME OFF BECAUSE THEY CHECK OUT THE CAR, BUT SAID IT WAS OK. I SHOWED THEM THAT BY PUMPING THE BREAKS A FEW TIMES THAT THE PEDAL WOULD BOTTOM AND BREAKING WAS LOST. THEY DUPLICATED IT BUT REFUSED TO ADMIT IT WAS A PROBLEM. NOW MY SONS ARE DRIVING AND I CAN'T LET THEM DRIVE THE CAR BECAUSE THEY ARE NOT EXPERIENCED ENOUGH DRIVERS AND IF THEY EVERY GET INTO A PANIC STOP SITUATION THEY NEED TO HAVE EXTRA ROOM FOR GLIDING AS THE WHEELS WON'T LOCK UP. I MADE SATURN REPLACE THE MASTER BREAK CYLINDER AND THE PROBLEM BECAME WORSE. I HAVE THE OLD MASTER BREAK CYLINDER. *NM
NHTSA ODI #10139159
Mileage unknown · Jun 10, 2005
Suspension
DT: CONTACT STATES THE VEHICLE IS CONTINUOUSLY SHAKING, AFFECTING THE STEERING. THE SOLENOIDS HAVE BEEN REPLACED, 6 MONTHS LATER THE PROBLEM RECURRED. *AK
NHTSA ODI #10124940
Mileage unknown · May 28, 2004
Seat Belts
THE PASSENGER AND DRIVER PASSIVE RESTRAIN SEAT BELT LOCKS DOWN. THE VEHICLE WAS TAKEN TO THE DEALER FOR INSPECTION, AND THE MECHANIC INFORMED THE DRIVER THAT SEAT BELTS NEEDED TO BE REPLACED. *LA
NHTSA ODI #10074438
137,245 miles · Oct 3, 2003
Visibility
WHILE DRIVING AT APPROXIMATELY 60 MPH THE SUNROOF DETACHED FROM THE VEHICLE. UPON INSPECTION THE MOUNTS WERE COMPLETELY RUSTED THROUGH. AT NO TIME THE SUNROOF HAS BEEN IMMERSED AND THE VEHICLE HAS NEVER BEEN TO A ROLL OVER. I DO NOT BELIEVE THIS TO BE A RESULT OF NEGLECT ON MY PART, RATHER POOR QUALITY MATERIALS USED IN MANUFAC…
Read full complaint
WHILE DRIVING AT APPROXIMATELY 60 MPH THE SUNROOF DETACHED FROM THE VEHICLE. UPON INSPECTION THE MOUNTS WERE COMPLETELY RUSTED THROUGH. AT NO TIME THE SUNROOF HAS BEEN IMMERSED AND THE VEHICLE HAS NEVER BEEN TO A ROLL OVER. I DO NOT BELIEVE THIS TO BE A RESULT OF NEGLECT ON MY PART, RATHER POOR QUALITY MATERIALS USED IN MANUFACTURE. *LA
NHTSA ODI #10041200
Mileage unknown · Jun 26, 2001
Seat Belts
FRONT PASSENGER PASSIVE RESTRAINT BELT IS LOCKED IN FORWARD POSITION, LEAVING OCCUPANT UNRESTRAINED.*AK
NHTSA ODI #891237
Mileage unknown · Apr 8, 2001
Seat BeltsSeats
DRIVERS SEATBACK BROKEN AND MOTORIZED SHOULDER BELTS BIND IN TRACK AND BLOW FUSE. *AK
NHTSA ODI #743730
Mileage unknown · Nov 3, 2000
Seat BeltsCrashInjury
RESTRAINT SYSTEM ANALYSIS WAS PERFORMED BY CHP-CENTRAL DIVISION MAIT. THE ANALYSIS INDICATED THE RESTRAINT FAILED AT THE LATCH PLATE CONNECTION TO THE MOTORIZED GUIDE PLATE. THIS REPORT IS BEING FILED FOR THE VEHICLE OWNER BY THE CHP PER OUR DEPARTMENTAL POLICY. *AK
NHTSA ODI #735686
Mileage unknown · Aug 18, 2000
Power Train
MANUAL TRANSMISSION GEAR SHIFT ARM SUDDENLY WAS LOOSE. SATURN OF ASUTIN REPORTED SHIFTER CABLE BROKE AND REPLACED SAME. IF BREAK HAD OCCURRED WHILE MOVING IT LIKELY WOULD HAVE CAUSED ACCIDENT AND INJURY.
NHTSA ODI #728379
Mileage unknown · Apr 25, 2000
Engine And Engine Cooling
HAVE HAD CAR SERVICED NUMEROUS TIMES, ENGINE ALWAYS REMAINED ROUGH, CAR DIES ON US, HAS LOW UPTAKE SPEED, MECHANIC SAID ITS A SATURN ENGINE DEFECT, WILL EVENTUALLY DIE ALTOGETHER. *AK
THE GENERATOR ELECTRICAL WIRING IS NOT PROTECTED AGAINST EXCESSIVE CURRENT FLOW WHICH MAY BE CAUSED BY AN ELECTRICAL SHORT CIRCUIT IN THE GENERATOR.
Consequence & remedy
Consequence: SHOULD AN ELECTRICAL SHORT CIRCUIT OCCUR IN THEGENERATOR, THE GENERATOR WIRING HARNESS WOULD EXPERIENCE EXCESSIVE CURRENT FLOW.UNDER CERTAIN CONDITIONS, ENOUGH HEAT COULD BE GENERATED TO IGNITE SURROUNDINGMATERIALS. IF THIS OCCURS, AN UNDERHOOD FIRE COULD RESULT WITH OR WITHOUT THEENGINE RUNNING AND WITHOUT PRIOR WARNING.
Remedy: THE GENERATOR WIRING HARNESS WILL BE REPLACED WITH ONE THAT WILL OPEN AS A FUSE WOULD UNDER CERTAIN EXCESSIVE CURRENT FLOW CONDITIONS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA93016 · Fr Seatback Recliner Fails
Opened Jun 8, 1993 · Closed Jul 26, 1994
Status: closed (inferred from source dates) · Seats:front Assembly:recliner
There is no summary currently available
1991 Saturn Sl Problems, Complaints & Recalls | Skip That Year
Illustration