IllustrationTRANSMISSION FAILED AND WOULD NOT ALLOW VEHICLE TO OPERATE. *TR
2009 Saturn Outlook
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Outlook years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
130–25K
5825–50K
3550–75K
1775–100K
29100–150K
6150K+
158 reports with mileage · 34 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Exterior Lighting. Review the 75 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 44 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 42 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports4 injury reports
Power Train complaints
19 reportsI WAS WAITING AT A STOPLIGHT AND HEARD AN UNUSUAL NOISE FROM THE ENGINE. WHEN I ACCELERATED ON THE GAS PEDDLE, I NOTICED THAT THE TRANSMISSION WOULD NOT SHIFT NORMALLY AND WOULD NOT EXCEED OVER 30 MPH. I MADE IT TO WORK BUT WHEN I TRIED TO REVERSE OUT OF THE PARKING LOT, THE CAR WOULD NOT MOVE AT ALL AND DISPLAYED "CHECK ENGINE …
Read full complaint
I WAS WAITING AT A STOPLIGHT AND HEARD AN UNUSUAL NOISE FROM THE ENGINE. WHEN I ACCELERATED ON THE GAS PEDDLE, I NOTICED THAT THE TRANSMISSION WOULD NOT SHIFT NORMALLY AND WOULD NOT EXCEED OVER 30 MPH. I MADE IT TO WORK BUT WHEN I TRIED TO REVERSE OUT OF THE PARKING LOT, THE CAR WOULD NOT MOVE AT ALL AND DISPLAYED "CHECK ENGINE LIGHT" ICON. I HAD TO PUSH IT OUT OF THE PARKING LOT THEN DRIVE FORWARD SLOWLY BACK HOME. I CALLED AROUND TOWN TO CHECK THE BEST SOLUTION FOR THE PROBLEM. I ALSO CHECKED ONLINE AND DISCOVERED THAT OTHER SATURN OUTLOOK OWNERS HAD THE SAME ISSUE AND THE SAME BROKEN PART WHEN IT WAS DIAGNOSED AND REPAIRED WHICH LEADS ME TO BELIEVE THAT GENERAL MOTORS IS AWARE OF THE PROBLEM AND FAILED TO RECALL MY VEHICLE AND ADD THE FAILED TRANSMISSION PROBLEM TO THE RECALL LIST. *TR
ON 10/24/2014, WHILE DRIVING MY 2009 SATURN OUTLOOK WITH MY CHILDREN IN THE CAR, I WAS ENTERING THE RAMP ONTO A MAJOR EXPRESSWAY, PUSHED DOWN ONTO THE GAS PEDAL TO SPEED UP TO ENTER THE HIGHWAY TRAFFIC WHEN A LOUD BANG WAS HEARD AND I FELT THE VEHICLE REV TO HIGHER RPM AND THEN THE CHECK ENGINE LIGHT CAME ON. I NOTICED IMMEDIATE…
Read full complaint
ON 10/24/2014, WHILE DRIVING MY 2009 SATURN OUTLOOK WITH MY CHILDREN IN THE CAR, I WAS ENTERING THE RAMP ONTO A MAJOR EXPRESSWAY, PUSHED DOWN ONTO THE GAS PEDAL TO SPEED UP TO ENTER THE HIGHWAY TRAFFIC WHEN A LOUD BANG WAS HEARD AND I FELT THE VEHICLE REV TO HIGHER RPM AND THEN THE CHECK ENGINE LIGHT CAME ON. I NOTICED IMMEDIATELY THAT THE VEHICLE RESPONDED LIKE IT WAS STUCK IN 3RD GEAR AND WOULD NOT SHIFT UP OR DOWN IN "D". I WAS ALMOST SMASHED BY A ODOT DUMP TRUCK BUT AVERTED THAT BY PULLING TO THE FAR RIGHT LANE. THE VEHICLE WOULD NOT ACCELERATE ANY FASTER THAN 50 MPH ON THE EXPRESSWAY. I WAS WITHIN 5 MILES OF MY DEALERSHIP AND BABIED THE VEHICLE TO THEIR LOCATION. I EXPLAINED MY VEHICLE ISSUE TO THE DEALER SERVICE REP AND HE SAID THEY COULD NOT GET IT IN THAT DAY TO CHECK IT BECAUSE IT WAS A FRIDAY AND THEY ARE NOT DOING SERVICE WORK OVER THE WEEKEND. RENTAL CAR RENTED AND LEFT MY CAR THERE OVER THE WEEKEND. I WAS CONTACTED THE FOLLOWING MONDAY WITH A REQUEST FOR AUTHORIZING A $500.00 CHARGE TO PULL THE TRANSMISSION TO CHECK INTERNALLY FOR THE PROBLEM. THE SERVICE REP SAID THEY HAVE SEEN A LOT OF PROBLEMS WITH THIS AND OTHER GM MADE VEHICLE RESULTING IN THE 35R CLUTCH WAVE PLATE BREAKING AND THE ONLY WAY IS TO PULL THE TRANSMISSION TO SEE. I GAVE HIM MY AUTHORIZATION BUT ASKED HIM FOR A ROUGH ESTIMATE FOR THE REPAIRS WHICH HE SAID ABOUT $3,500.00. I HAVE BEEN WITHOUT MY VEHICLE FOR ALMOST A WEEK AND THROUGH INTERNET SEARCH I HAVE COME ACROSS AS MANY AS UPWARD OF 17,000 ONLINE RESPONSE'S ABOUT THE CONTINUED PROBLEMS WITH THE 35R CLUTCH WAVE PLATE AS FAR BACK AS 2008 WITH THE GM ACADIA, CHEVROLET TRAVERSE AND SATURN OUTLOOK. I AM REQUESTING WITH NHTSA THAT SOMETHING BE SAID TO GM ABOUT THIS COMPLICATION WITH A "KNOWN" PROBLEM THAT NOTHING HAS BEEN RECALLED. I EVEN CAME ACROSS A POST THAT NOTED THE PROBLEM WITH NOTIFICATION TO REPS FROM JANUARY 12, 2010 FROM A FORUM. *TR
SEPTEMBER 16,2014 AROUND 8:30 PM WE WERE DRIVING ON I10 WESTBOUND AND ACCELERATED TO GET IN THE MAIN LANES. THE CAR MADE THE ACCELERATED NOISE BUT WAS STUCK IN GEAR AT 4400 RPMS AT 40 MILES PER HOUR. WE PULLED OVER IN A PARKING LOT TO TEST THE ACCELERATION AND IT WAS HARD TO TELL DRIVING IN A SHORT DISTANCE, BUT AS SOON AS WE P…
Read full complaint
SEPTEMBER 16,2014 AROUND 8:30 PM WE WERE DRIVING ON I10 WESTBOUND AND ACCELERATED TO GET IN THE MAIN LANES. THE CAR MADE THE ACCELERATED NOISE BUT WAS STUCK IN GEAR AT 4400 RPMS AT 40 MILES PER HOUR. WE PULLED OVER IN A PARKING LOT TO TEST THE ACCELERATION AND IT WAS HARD TO TELL DRIVING IN A SHORT DISTANCE, BUT AS SOON AS WE PULLED OFF AND ATTEMPTED TO ACCELERATE AGAIN THE SAME ISSUE OCCURRED. THE NEXT TIME THE CAR BEGAN TO LOSE POWER AS IF IT WOULD STOP SO WE PULLED INTO ANOTHER PARKING LOT AND CUT THE CAR OFF. WHEN WE TURNED IT BACK ON AND DROVE THE ISSUE WENT AWAY. *TR
IN APRIL 2013 THE TRANSMISSION WAVE PLATE WAS REPLACED. THIS IS AUGUST 1ST THE DEALERSHIP CALLS AND THE WAVE PLATE NEEDS TO BE REPLACE AGAIN. BY REVIEWING FORUMS IT SEEMS ALOT OF GM'S TRANSMISSIONS ARE NOT WHAT THEY ARE SUPPOSE TO BE. PLEASE CONSIDER REVIEWING THE TRANSMISSION PROBLEMS, THE VEHICLE ONLY HAS 63000 MILES. WE ARE P…
Read full complaint
IN APRIL 2013 THE TRANSMISSION WAVE PLATE WAS REPLACED. THIS IS AUGUST 1ST THE DEALERSHIP CALLS AND THE WAVE PLATE NEEDS TO BE REPLACE AGAIN. BY REVIEWING FORUMS IT SEEMS ALOT OF GM'S TRANSMISSIONS ARE NOT WHAT THEY ARE SUPPOSE TO BE. PLEASE CONSIDER REVIEWING THE TRANSMISSION PROBLEMS, THE VEHICLE ONLY HAS 63000 MILES. WE ARE PAYING THOUSANDS OF DOLLARS FOR THESE VEHICLES AND WE NOT GETTING ANYWHERE OUR MONIES WORTH. I PURCHASED IN MAY OF 2013...POWER TRAIN WARRANTY 5YEARS OR 100000 MILES,COME ON I WAS IN A NO WIN. FOR SURE THANKS IN ADVANCE FOR YOUR CONSIDERATION FOR REVIEW. *TR
TL* THE CONTACT OWNS A 2009 SATURN OUTLOOK. WHILE DRIVING 70 MPH, THE CONTACT FELT AN ABNORMAL MOVEMENT COMING FROM THE FRONT OF THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE, BUT WAS UNABLE TO LOCATE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WAVE PLATE AND THE SPEED SENSOR NEEDED TO B…
Read full complaint
TL* THE CONTACT OWNS A 2009 SATURN OUTLOOK. WHILE DRIVING 70 MPH, THE CONTACT FELT AN ABNORMAL MOVEMENT COMING FROM THE FRONT OF THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE, BUT WAS UNABLE TO LOCATE THE FAILURE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WAVE PLATE AND THE SPEED SENSOR NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED. THE VIN WAS UNAVAILABLE. THE APPROXIMATE FAILURE MILEAGE WAS 98,000.
2009 SATURN OUTLOOK. CONSUMER WRITES IN REGARDS TO TRANSMISSION AND CHECK ENGINE LIGHT ISSUES. *SMD THE CONSUMER STATED THE VEHICLE HAD TO BE TOWED TO A TRANSMISSION SHOP, AS HE COULD NO LONGER DRIVE IT. THE VEHICLE WAS IN THE SHOP FOR FIVE DAYS. UPON DRIVING HOME, THE ENGINE LIGHT ILLUMINATED AGAIN. THE CONSUMER RETURNED TO …
Read full complaint
2009 SATURN OUTLOOK. CONSUMER WRITES IN REGARDS TO TRANSMISSION AND CHECK ENGINE LIGHT ISSUES. *SMD THE CONSUMER STATED THE VEHICLE HAD TO BE TOWED TO A TRANSMISSION SHOP, AS HE COULD NO LONGER DRIVE IT. THE VEHICLE WAS IN THE SHOP FOR FIVE DAYS. UPON DRIVING HOME, THE ENGINE LIGHT ILLUMINATED AGAIN. THE CONSUMER RETURNED TO THE TRANSMISSION SHOP, WHERE HE WAS INFORMED THEY COULD NOT FIX, AND IN FACT, THEY HAD TAKEN A PART TO THE DEALER FOR RE-PROGRAMMING. THE REPAIR SHOP REPLACED THE TORQUE CONVERTER. *JB
VEHICLE STUTTERS AND HESITATES AT RANDOM TIMES. MORE AT HIGH SPEEDS AROUND 60-65 MPH. TROUBLE SHIFTING INTO GEARS AT TIMES. *TR
TRANSMISSION SLIPS AND CAR BUCKS,SHUTTERS, AND SKIPS AT A RPM AT AROUND 1400-1600 RPM'S. *TR
Official recalls
715V415000 · Structure:body:hatchback/liftgate
Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
14V266000 · Seat Belts
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
14V118000 · Air Bags:side/window
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
10V375000 · Seat Belts
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
10V240000 · Electrical System
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
09V073000 · Power Train:automatic Transmission:lever And Linkage:column Shift
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
08V615000 · Seat Belts: Rear/other:buckle Assembly
Nov 24, 2008
GM IS RECALLING 16,667 MY 2009 BUICK ENCLAVE, CHEVROLET TRAVERSE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES FOR FAILING TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, 'SEAT BELT ASSEMBLIES.' THESE VEHICLES MAY HAVE BEEN BUILT WITH A SAFETY BELT BUCKLE IN THE SECOND OR THIRD ROW THAT IS MISSING A RIVET.
Consequence & remedy
Consequence: IN A VEHICLE CRASH, IF THE RIVET IS MISSING, THE BUCKLE MAY SEPARATE FROM THE MOUNTING STRAP, INCREASING THE RISK OF INJURY TO THE PASSENGER.
Remedy: DEALERS WILL INSPECT THE SAFETY BELT BUCKLES IN THE SECOND AND THIRD ROWS, AND REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 26, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; SATURN AT 1-800-972-8876; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
DP12003 · Loss Of Headlamp Illumination
Opened Jun 4, 2012 · Closed Jul 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting:headlights
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.