NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
17 reportsClear category filterMileage unknown · Oct 7, 2024
Engine
The contact owns a 2009 Saturn Outlook. The contact stated that stated while driving at an undisclosed speed, the vehicle made an abnormal sound and stalled. The check engine warning light was illuminated. The contact was able to veer to the side of the road. The vehicle failed to restart and was towed to an independent mechanic…
Read full complaint
The contact owns a 2009 Saturn Outlook. The contact stated that stated while driving at an undisclosed speed, the vehicle made an abnormal sound and stalled. The check engine warning light was illuminated. The contact was able to veer to the side of the road. The vehicle failed to restart and was towed to an independent mechanic, where it was diagnosed and determined that the timing belt had failed and needed to be replaced. The dealer was notified of the failure and informed the contact that the vehicle was not covered under GM Campaign Number: 10287C since the campaign had expired. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was unknown.
NHTSA ODI #11618548
Mileage unknown · Dec 23, 2023
Engine
I was driving and my car started to lurch and went into reduced power mode. I quickly pulled over and turned off the engine. It was towed into the shop, and we found that the timing chain had broken. We had just had our engine mounts replaced and the oil changed. The vehicle has been well maintained. I have seen the issue with t…
Read full complaint
I was driving and my car started to lurch and went into reduced power mode. I quickly pulled over and turned off the engine. It was towed into the shop, and we found that the timing chain had broken. We had just had our engine mounts replaced and the oil changed. The vehicle has been well maintained. I have seen the issue with the timing chain failure is a common problem in Saturns/GM from internet research. It looks like there was a service bulletin to bring the car in if Service light comes on and you “think” it’s due to premature wear of timing chain. Now we are told the engine needs to be replaced because it was damaged by the timing chain failure and it seems like a known defect that should be covered because it exceeded the value of the car to have such a fix.
NHTSA ODI #11561602
Mileage unknown · Mar 6, 2023
Electrical SystemEngineVehicle Speed Control
UNKNOWN We have only had this vehicle for approximately 4 months and have had soon many issues but the electrical system has been a problem non stop
NHTSA ODI #11510488
Mileage unknown · Jul 30, 2022
EngineSteeringUnknown Or Other
I bought this 2009 Saturn Outlook yesterday from a used dealership they said there was nothing wrong with the car well I live over 100 miles away from where I bough it and about halfway home it’s it was dark outside I was driving on the highway going up a hill the motor was acting like it wanted to jump out f the car (I’m not su…
Read full complaint
I bought this 2009 Saturn Outlook yesterday from a used dealership they said there was nothing wrong with the car well I live over 100 miles away from where I bough it and about halfway home it’s it was dark outside I was driving on the highway going up a hill the motor was acting like it wanted to jump out f the car (I’m not sure exactly how to describe it) anyways it only did ur for just a second then stopped all went back to normal and today just died while driving and now it wont start wont even turn over
NHTSA ODI #11476684
185,000 miles · Apr 6, 2021
EnginePower TrainSuspension
I WAS DRIVING DOWN THE HIGHWAY AND ALL OF A SUDDEN MY CAR SLOWED DOWN REALLY SLOW I PULLED OVER AND TURNED IT OFF. WHEN I TRIED TO TURN IT BACK ON IT WOULDN'T CRANK.
NHTSA ODI #11406787
180,000 miles · Jan 1, 2021
Engine
THE TIMING CHAIN IS GETTING STRETCHED IS WHAT THE CODES SAY AND NEEDS TO BE REPAIRED FEELS LIKE IT'S LOOSING POWER
NHTSA ODI #11386008
134,000 miles · Feb 11, 2019
Electrical SystemEngineFuel/propulsion System
IN 2016, I PURCHASED A 2009 SATURN OUTLOOK FROM A DEALER, WITH 90,000 MILES ON IT. TWO MONTHS LATER, "TRANSMISSION OVERHEATING, LET ENGINE IDLE" INDICATOR CAME ON, AND THE SATURN SHUT ITSELF DOWN AS I DROVE DOWN I-35! MECHANIC SAID THEY COULDN'T FIND ANYTHING WRONG. THEY RESET MY CODES, AND ALL SEEMED OKAY. THIS HAPPENED A FEW…
Read full complaint
IN 2016, I PURCHASED A 2009 SATURN OUTLOOK FROM A DEALER, WITH 90,000 MILES ON IT. TWO MONTHS LATER, "TRANSMISSION OVERHEATING, LET ENGINE IDLE" INDICATOR CAME ON, AND THE SATURN SHUT ITSELF DOWN AS I DROVE DOWN I-35! MECHANIC SAID THEY COULDN'T FIND ANYTHING WRONG. THEY RESET MY CODES, AND ALL SEEMED OKAY. THIS HAPPENED A FEW MORE TIMES, BUT KNOW ONE COULD TELL ME WHAT WAS WRONG OTHER THAT BANK 1 LOW. FOR THE MOST PART IT DROVE WITHOUT PROBLEMS. REGULAR SERVICE MAINTENANCE, AND OIL CHANGES CONSISTENT WITH THE MANUAL. I RARELY DROVE IT AFTER THE SECOND YEAR OF OWNING IT. ON WAY HOME TO OREGON (PURCHASED OUTLOOK IN IOWA), I CONTINUOUSLY LOST POWER GOING UP THE PASSES. SEMI TRUCKS WERE PASSING ME, AS IF I WERE SITTING STILL. WITH NEW AIR-FILTER SYSTEM, MAF SENSOR, COILS, BOOTS, AND SPARK PLUGS INSTALLED I CONTINUED AT A SNAIL PACE ALL THE WAY TO OREGON. A TWO DAY TRIP TOOK ME SEVEN DAYS. NOBODY COULD TELL ME WHAT WAS WRONG OTHER THAN THE BANK 1 LOW, O2 SENSOR, WHICH I REPLACED THOSE AS WELL. I GET HOME AND SEVEN MONTHS LATER, I ALMOST GET HIT BY A SCHOOL BUS, BECAUSE MY SATURN STALLED IN THE MIDDLE OF THE INTERSECTION. THREE LIGHT CHANGES LATER, I MAKE IT ACROSS THE STREET TO THE COLLEGE. IT SHUDDERED ALL THE WAY, TILL I PARKED IT, WHERE I HAD TO WAIT TO BE TOWED THREE BLOCKS TO HOME. I PAID OVER $15,000 FOR A VEHICLE THAT LASTED ME UNDER 50,000 MILES. IT IS PAID IN FULL, AND IS NOW DEAD. STILL NO CLUE AS WHY. CODES SHOW BANK 1 AND 2 LOW ? BUT WHY WILL IT NOT START? WHY DID MY BATTERY DIE? I COULD NOT HAVE TAKEN BETTER CARE OF MY BABY, IF I TRIED! PLEASE, HELP ME FIX HER. THERE IS NO REASON FOR THIS VEHICLE TO BE OUT OF COMMISSION, YET IT IS AT 134,000 MILES. GM, PLEASE FIX THIS. THIS WAS FAULTY AT 90,500 MILES. I HAVE ALWAYS TAKEN GREAT CARE OF EVERY CAR I HAVE EVER OWNED. IT GOT WORSE AFTER I TOOK IT TO A CHEVY DEALER IN MISSOURI! CATALYTIC BANK 1 AND 2.
NHTSA ODI #11176129
121,190 miles · Oct 16, 2018
EnginePower Train
TAKATA RECALL I BOUGHT MY VEHICLE AT THE END OF MAY, 2018. MY ENGINE LIGHT CAME ON AT THE BEGINING OF OCTOBER, 2018. I HAD GOT IN MY VEHICLE AND STAYED THE ENGINE AMD IT CAME ON. I IMMEDIATELY TOOK IT TO ADVANCE AUTO TO GET THEM TO HOOK THE HAND HELD COMPUTER TO THE VEHICLE TO SEE WHAT WAS WRONG. IT CODED 2 CODES. ONE WAS FOR…
Read full complaint
TAKATA RECALL I BOUGHT MY VEHICLE AT THE END OF MAY, 2018. MY ENGINE LIGHT CAME ON AT THE BEGINING OF OCTOBER, 2018. I HAD GOT IN MY VEHICLE AND STAYED THE ENGINE AMD IT CAME ON. I IMMEDIATELY TOOK IT TO ADVANCE AUTO TO GET THEM TO HOOK THE HAND HELD COMPUTER TO THE VEHICLE TO SEE WHAT WAS WRONG. IT CODED 2 CODES. ONE WAS FOR THE TIMING CHAIN AND THE OTHER FOR THE CATALYST. THEY SAID I SHOULD TAKE IT TO A BIG CAR SHOP SO THEY COULD PUT IT OM THE BETTER COMPUTER. IT CODES THE SAME CODES. THE MECHANIC SAID THIS IS AN ISSUE WITH THESE GM ENGINS. HOWEVER, THEY ARE NOT ON RECALL. I STILL OWE AROUND 9,000 DOLLARS ON THIS VEHICLE. I AM NOT IN A SITUATION THAT I CAN SPEND OVER. $2,000 ON THIS VEHICLE. IN LISTENING TO THE MECHANIC AND DOING MY OWN RESEARCH, I HAVE FOUND THIS TO BE A REAL PROBLEM. I BELIEVE IT NEEDS TO BE FIXED AT THE COST OF THE MANUFACTURER.
NHTSA ODI #11140693
104,070 miles · Jul 24, 2018
Engine
WE ALWAYS CHANGE OUR OIL ON TIME. TOOK IT TO THE OIL CHANGE PLACE HE SAID THERE WAS BARELY ANY OIL IN IT , WE STILL HAD 200 MILE BEFORE RECOMMEND OIL CHANGE. THEN THE WHILE DRIVING THE ENGINE LIGHT WENT ON, WE TOOK IT AND MY MECHANIC SAID THAT'S THIS MOTOR IS BURNING OIL. AND CAN AFFECT ENGINE TIMING CHAIN.THE MECHANIC SAID …
Read full complaint
WE ALWAYS CHANGE OUR OIL ON TIME. TOOK IT TO THE OIL CHANGE PLACE HE SAID THERE WAS BARELY ANY OIL IN IT , WE STILL HAD 200 MILE BEFORE RECOMMEND OIL CHANGE. THEN THE WHILE DRIVING THE ENGINE LIGHT WENT ON, WE TOOK IT AND MY MECHANIC SAID THAT'S THIS MOTOR IS BURNING OIL. AND CAN AFFECT ENGINE TIMING CHAIN.THE MECHANIC SAID TO START PUTTING SYNTHETIC OIL IN PER GM. WE WE'RE NEVER NOTIFIED ABOUT OIL ISSUES OR CHANGING WHAT TYPE OF OIL TO USE. NOW WE ARE GOING TO NEED AN ENGINE TIMING CHAIN WHICH IS EXTREMELY COSTLY. WE HAVEN'T BEGUN THIS PROCESS YET. BUT FROM WHAT'S I UNDERSTAND GM USB HAVING TONS OF ISSUES WITH MOTOR. AND WE HAVEN'T NEVER BEEN NOTIFIED ABOUT ANY PREVENTIVE MAINTENANCE OR CARE.
NHTSA ODI #11113380
78,700 miles · Jun 20, 2016
Electrical SystemEnginePower Train
WHEN I WAS ENTERING MOVING TRAFFIC FROM A COMPLETELY STOPPED POSITION, A CAR WAS COMING FASTER THAN I REALIZED SO I FLOORED THE ACCELERATOR AND THIS IS WHAT HAPPENED: 1.ALL POWER TO MY CAR SHUT OFF AND THE CAR ROLLED FORWARD SLOWING DOWN. 2.ALL OF THE DASHBOARD LIGHTS AND SYMBOLS LIT UP. 3.MY CAR JOLTED STRONGLY ONCE…
Read full complaint
WHEN I WAS ENTERING MOVING TRAFFIC FROM A COMPLETELY STOPPED POSITION, A CAR WAS COMING FASTER THAN I REALIZED SO I FLOORED THE ACCELERATOR AND THIS IS WHAT HAPPENED: 1.ALL POWER TO MY CAR SHUT OFF AND THE CAR ROLLED FORWARD SLOWING DOWN. 2.ALL OF THE DASHBOARD LIGHTS AND SYMBOLS LIT UP. 3.MY CAR JOLTED STRONGLY ONCE, SPUTTERED (MANY TIMES), AND HICCUPPED (MANY TIMES). THE JOLT WAS SO STRONG THAT IT THREW ME FORWARD AND MADE MY SEATBELT CATCH ME. 4.AT THE SAME TIME AS # 3, THE GPS REBOOTED ITSELF 3 TIMES IN A ROW AND ALL OF THE CAR DOOR LOCKS UNLOCKED AND LOCKED THEMSELVES 3 TIMES IN A ROW. 5.I GENTLY PRESSED THE ACCELERATOR AND THE CAR ACCELERATED BUT THE CAR FELT WEAK AND I FELT UNCERTAIN. I WAS NOT SURE WHAT WOULD HAPPEN IF I TRIED TO ACCELERATE NORMALLY SO I PUT ON MY EMERGENCY BLINKERS AND SLOWLY DROVE HOME.
NHTSA ODI #10875449
Official recalls
7Jun 30, 2015
General Motors LLC (GM) is recalling certain model year 2008-2012 Buick Enclave vehicles manufactured January 3, 2007, to February 29, 2012, 2009-2012 Chevrolet Traverse vehicles manufactured July 6, 2008, to March 9, 2012, 2007-2012 GMC Acadia vehicles manufactured September 15, 2006, to February 29, 2012, and 2007-2010 Saturn Outlook vehicles manufactured August 17, 2006, to March 18, 2010. The affected vehicles, equipped with the power liftgate option, have gas struts that hold the power liftgate up when open. These struts may prematurely wear and the open liftgate may suddenly fall.
Consequence & remedy
Consequence: If the open liftgate unexpectedly falls, it may strike a person, increasing their risk of injury.
Remedy: GM will notify owners, and dealers will update the software for the power liftgate actuator motor control unit so that the motor will prevent the rapid closing of the lift gate, free of charge. The recall began on November 15, 2016. Owners may contact Buick customer service at 1-800-521-7300, Chevrolet customer service at 1-800-222-1020, GMC customer service at 1-800-462-8782, and Saturn customer service at 1-800-553-6000. GM's number for this recall is 15240.
May 20, 2014
General Motors is recalling certain model year 2009-2014 Buick Enclave vehicles manufactured April 14, 2008, through May 14, 2014, Chevrolet Traverse vehicles manufactured June 6, 2008, through May 14, 2014, and GMC Acadia vehicles manufactured April 9, 2008, through May 14, 2014, and 2009-2010 Saturn Outlook vehicles manufactured April 14, 2008, through March 18, 2010. In the affected vehicles, the flexible steel cable that connects the seatbelt to the front outboard seating positions may fatigue and separate over time.
Consequence & remedy
Consequence: If the steel cable becomes fatigued and separates, the seatbelt may not properly restrain the seat occupant increasing the risk of an injury in a crash.
Remedy: General Motors will notify owners, and dealers will inspect and, if necessary, repair and replace the lap pretensioner, free of charge. Parts are not currently available. An interim notice will be mailed to owners in July 2014. A second notice will be mailed to owners once parts become available. The recall for the 2009-2010 model years began on July 11, 2014. The interim letter for the 2011-2014 model years were distributed on July 11, 2014. Owners may contact General Motors at 1-800-222-1020 (Chevrolet), 1-800-521-7300 (Buick), 1-800-462-8782 (GMC), 1-800-553-6000 (Saturn). General Motors recall number for this campaign is 14187.
Mar 17, 2014
General Motors LLC (GM) is recalling certain model year 2008-2013 Buick Enclave and GMC Acadia and 2009-2013 Chevrolet Traverse and 2008-2010 Saturn Outlook vehicles. In the affected vehicles, increased resistance in the driver and passenger seat mounted side impact air bag (SIAB) wiring harnesses may result in the SIAB and seat belt pretensioners not deploying in the event of a crash.
Consequence & remedy
Consequence: Failure of the side impact air bags and seat belt pretensioners to deploy in a crash increase the risk of injury to the driver and front seat occupant.
Remedy: GM will notify owners, and dealers will replace the affected harness connections with soldered connections, free of charge. The recall began on June 16, 2014. Buick owners may contact the owner center at 1-800-521-7300, Chevrolet owners at 1-866-694-6546, Saturn at 1-800-553-6000, and GMC owners at 1-866-996-9463. GM's number for this recall is 14030. Note: Vehicles repaired as part of Customer Satisfaction Campaign 10085 and special coverage 10335 have already had the subject condition repaired and therefore are not included in the safety recall.
Aug 12, 2010
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2009-2010 CHEVROLET TRAVERSE, BUICK ENCLAVE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES. THE SECOND ROW SEAT SIDE TRIM SHIELD RESTRICTS THE UPWARD ROTATION OF THE SAFETY BELT BUCKLE WHEN THE SEAT BACK IS RETURNED TO A SEATING POSITION AFTER BEING FOLDED FLAT. IF THE BUCKLE CONTACTS THE SEAT FRAME, ADDITIONAL EFFORT IS REQUIRED TO RETURN THE SEAT TO A SEATING POSITION. IF SUFFICIENT FORCE IS APPLIED, THE BUCKLE COVER COULD BE PUSHED DOWN THE STRAP, EXPOSING AND PARTIALLY DEPRESSING THE RED RELEASE BUTTON.
Consequence & remedy
Consequence: THE SAFETY BELT MAY NOT RESTRAIN THE OCCUPANT AS INTENDED DURING A CRASH, INCREASING THE RISK OF INJURY TO THE SEAT OCCUPANT.
Remedy: DEALERS WILL MODIFY THE SECOND ROW SEAT SIDE TRIM SHIELDS. IF A SAFETY BELT BUCKLE IS DAMAGED, DEALERS WILL REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON AUGUST 18, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, BUICK AT 1-866-608-8080, GMC AT 1-866-996-9463, AND SATURN AT 1-800-972-8876, OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Jun 4, 2010
GM IS RECALLING CERTAIN MODEL YEAR 2006-2009 BUICK, LUCERNE; CADILLAC DTS; HUMMER H2; MODEL YEAR 2008-2009 BUICK ENCLAVE; CADILLAC CTS; MODEL YEAR 2007-2009 CADILLAC ESCALADE, ESCALADE ESV, ESCALADE EXT; CHEVROLET AVALANCHE, SILVERADO, SUBURBAN, TAHOE; GMC ACADIA, SIERRA, YUKON, YUKON XL; SATURN OUTLOOK; AND MODEL YEAR 2009 CHEVROLET TRAVERSE VEHICLES EQUIPPED WITH A HEATED WASHER FLUID SYSTEM (HWFS). A RECALL WAS IMPLEMENTED IN 2008 TO ADD A FUSE TO THE CONTROL CIRCUIT HARNESS TO ADDRESS THE POTENTIAL CONSEQUENCES OF A PRINTED CIRCUIT BOARD (PCB) ELECTRICAL SHORT. HOWEVER, THERE HAVE BEEN NEW REPORTS OF THERMAL INCIDENTS ON HWFS MODULES AFTER THIS IMPROVEMENT WAS INSTALLED. THESE INCIDENTS RESULTED FROM A NEW FAILURE MODE ATTRIBUTED TO THE DEVICE'S THERMAL PROTECTION FEATURE. THE SIGNIFICANCE VARIES FROM MINOR DISTORTION TO CONSIDERABLE MELTING OF THE PLASTIC AROUND THE HWFS FLUID CHAMBER.
Consequence & remedy
Consequence: IT IS POSSIBLE FOR THE HEATED WASHER MODULE TO IGNITE AND A FIRE MAY OCCUR.
Remedy: DEALERS WILL PERMANENTLY DISABLE AND REMOVE THE HEATED WASHER FLUID MODULE. AN UPDATED PAGE FOR THE OWNER MANUAL WILL BE PROVIDED AND INSERTED IN THE OWNER MANUAL TO DOCUMENT THAT THE FEATURE HAS BEEN PERMANENTLY DISABLED AND REMOVED FROM THE VEHICLE. THE SAFETY RECALL BEGAN ON JUNE 11, 2010. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CADILLAC AT 1-866-982-2339, CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876, GMC AT 1-866-996-9463 AND HUMMER AT 1-800-732-5493 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Mar 6, 2009
GENERAL MOTORS IS RECALLING 276,729 MY 2009 BUICK ENCLAVE, CHEVROLET COBALT, HHR, MALIBU, TRAVERSE, GMC ACADIA, PONTIAC G5, G6 AND SATURN AURA AND OUTLOOK PASSENGER VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLES SAFETY STANDARD 102, "TRANSMISSION SHIFT POSITION SEQUENCE, STARTER INTERLOCK, AND TRANSMISSION BRAKING EFFECT", AND FMVSS 114, "THEFT PROTECTION AND ROLLAWAY PREVENTION". ON SOME OF THESE VEHICLES, THE TRANSMISSION SHIFT CABLE ADJUSTMENT CLIP MAY NOT BE FULLY ENGAGED. IF THE CLIP IS NOT FULLY ENGAGED, THE SHIFT LEVER AND THE ACTUAL POSITION OF THE TRANSMISSION GEAR MAY NOT MATCH. WITH THIS CONDITION, THE DRIVE COULD MOVE THE SHIFTER TO "PARK" AND REMOVE THE IGNITION KEY, BUT THE TRANSMISSION GEAR MAY NOT BE IN "PARK".
Consequence & remedy
Consequence: THE DRIVER MAY NOT BE ABLE TO RESTART THE VEHICLE AND THE VEHICLE COULD ROLL AWAY AFTER THE DRIVER HAS EXITED THE VEHICLE, RESULTING IN A POSSIBLE CRASH WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSPECT AND ENSURE THAT THE SHIFT CABLE ADJUSTMENT CLIP IS FULLY ENGAGED. IN THE EVENT THAT THE CLIP DOES NOT ENGAGE, THE SHIFT CABLE WILL BE REPLACED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MARCH 24, 2009. OWNERS MAY CONTACT BUICK AT 1-866-608-8080, CHEVROLET AT 1-800-630-2438, GMC AT 1-866-996-9463, PONTIAC AT 1-800-620-7668 AND SATURN AT 1-800-972-8876 OR AT WWW.GMOWNERCENTER.COM.
Nov 24, 2008
GM IS RECALLING 16,667 MY 2009 BUICK ENCLAVE, CHEVROLET TRAVERSE, GMC ACADIA, AND SATURN OUTLOOK VEHICLES FOR FAILING TO CONFORM WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 209, 'SEAT BELT ASSEMBLIES.' THESE VEHICLES MAY HAVE BEEN BUILT WITH A SAFETY BELT BUCKLE IN THE SECOND OR THIRD ROW THAT IS MISSING A RIVET.
Consequence & remedy
Consequence: IN A VEHICLE CRASH, IF THE RIVET IS MISSING, THE BUCKLE MAY SEPARATE FROM THE MOUNTING STRAP, INCREASING THE RISK OF INJURY TO THE PASSENGER.
Remedy: DEALERS WILL INSPECT THE SAFETY BELT BUCKLES IN THE SECOND AND THIRD ROWS, AND REPLACE THEM IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 26, 2008. OWNERS MAY CONTACT BUICK AT 1-866-608-8080; CHEVROLET AT 1-800-630-2438; GMC AT 1-866-996-9463; SATURN AT 1-800-972-8876; OR THROUGH THEIR WEBSITE AT <A HREF=HTTP://WWW.GMOWNERCENTER.COM>HTTP://WWW.GMOWNERCENTER.COM</A> .
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3EA20002 · Outboard Front Seat Belt Anchor Cable Failure
Opened Aug 31, 2020 · Closed Aug 30, 2024
Status: closed (inferred from source dates) · Seat Belts; Seat Belts:front; Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Additional source detail variants (3)
Seat Belts:front:anchorage
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts:front
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
Seat Belts
On August 31, 2020, the Office of Defects Investigations (ODI) opened Engineering Analysis (EA) EA20002, as an upgrade of Recall Query (RQ) RQ19003. This investigation, related to recall 14V-266, was opened to investigate instances of detachment of the flexible steel seat belt anchor cable attached to the outboard side of the front seats in vehicles manufactured by General Motors (GM). The subject vehicles included model year (MY) 2009 through 2014 GMC Acadia, Buick Enclave, and Chevrolet Traverse SUVs as well as MY 2009 through 2010 Saturn Outlook SUVs. These vehicles were previously repaired for this defect under recall 14V-266. The subject vehicle population is approximately 1.3 million vehicles. Special Coverage N192219480, issued in June 2019, addressed the subject defect in vehicles that previously received the recall remedy repair for subject recall 14V-266. The Special Coverage allows for component replacement for 12 years or 180,000 miles from the initial sale date, whichever comes first. Special Coverage N192219480 instructed service technicians to inspect the driver’s seat belt anchor cable for any damage to the protective sleeve and if damage was observed, the cable was replaced with a new sleeve as well as a new closeout piece that relocated the cable to mitigate the subject condition. In view of the Special Coverage conducted by General Motors, the high detectability of the subject failure, and the low rate of occurrence, this Engineering Analysis is closed. The closing of this investigation does not constitute a finding by NHTSA that a safety-related defect does not exist. The Agency reserves the right to take additional action if warranted by future circumstances. To review the ODI reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov. Please see the attached document “EA20-002 Detailed Closing Summary” for more a detailed closing resume summary.
RQ19003 · Seat Belt Anchor Cable Failure
Opened May 28, 2019 · Closed Aug 31, 2020
Status: closed (inferred from source dates) · Seat Belts:front; Seat Belts:front:anchorage; Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Additional source detail variants (3)
Seat Belts:front:anchorage
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:front
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
Seat Belts:pretensioner
On May 19, 2014, General Motors LLC (GM) notified the Office of Defects Investigation (ODI) that it would conduct Safety Recall 14V266 to address fatigue and separation of the flexible steel cable that connects the front outboard seat belts to the seat-mounted belt pre-tensioner in 1.4 million model year (MY) 2009-2010 Saturn Outlook, 2009-2014 Buick Enclave, GMC Acadia and Chevrolet Traverse (Lambda Platform) vehicles.The remedy was to inspect for signs of damage and replace pre-tensioner anchor cables as needed. Re-work was conducted to relocate the pre-tensioner anchor cable out of the occupant entry path. ODI has subsequently received four (4) Vehicle Owners Questionnaires (VOQ) reporting anchor cable separations with no apparent warning in covered vehicles after the Recall 14V266 remedy had been applied.ODI opened RQ19-003 to assess the effectiveness of the actions GM took in Recall 14V266 and review the full warranty and complaint data related to seat belt anchor cable separations and replacements. ODI continues to receive occasional cable failure complaints both for the subject vehicles and other GM models and model years that have also been previously recalled addressing this condition.Although the cable separation complaint rate is very low, over the past three years ODI has received two (2) additional VOQ?s citing belt cable separations for Lambda platform vehicles outside the scope of recall 14V266, (11217092, 11118075) and complaints for other GM models covered in a number of similar Safety Recalls:* 15V269, 2011-12 Chevrolet Malibu (11181115, 11288168); * 16V209, 2014-15 Silverado 1500, Sierra 1500 (11254364, 10935183, 10953851, 11025376, 11282043, 11288701, 11309884); and * 16V518 2014-16 Caprice Police Pursuit, SS (10905644, 10990669, 11340893).ODI's review of GM's data confirms the low potential failure rate for the vehicles covered by recall 14V266. However, ODI believes that complainants may not recognize accumulating cable fatigue damage from the visual cues available in routine vehicle use.ODI is upgrading RQ19-003 to an Engineering Analysis to more closely assess seat belt conditions and strength levels in the field. This work will include the collection of seat belt samples from a wider range of recalled and peer vehicles for detailed analysis and testing.The ODI reports (VOQs) associated with this RQ19-003 can be viewed at NHTSA.gov under the following reference numbers: 11144704, 11076704, 11185619, 11151922, 11164011, 10967518, 11113486, 11115648
DP12003 · Loss Of Headlamp Illumination
Opened Jun 4, 2012 · Closed Jul 24, 2014
Status: closed (inferred from source dates) · Exterior Lighting:headlights
As of July 16, 2014, out of a population of 248,453 subject vehicles, NHTSA received 473 consumer complaints of inoperative head lamp. Many of these complaints indicated that the head lamp harness suffered damage from overheating. After reviewing the complaints, ODI found: -69% (328) alleged that a single head lamp was inoperative. -18% (86) alleged that both head lamps were inoperative but not at the same time. -9% (41) alleged that both head lamps were inoperative but the complaints did not indicate whether the failures had occurred at the same time. -4% (17) alleged that both head lamps were inoperative at the same time. -One additional complaint cited wire harness damage to both sides but did not specify an outage -No crashes or loss of vehicle control were reported. -Any alleged thermal damages were limited to melting of the head lamp harness and the head lamp housing. -A head lamp would intermittently fail to come on or flickers before becoming completely inoperative. For the seventeen complaints that alleged simultaneous failure of both head lamps while attempting to turn them on or while driving, the head lamp failures likely had occurred one at a time. The subject vehicle's head lamps are connected in a parallel circuit and each circuit is fused. Therefore, failure of one head lamp or its harness should not affect the other head lamp operation. Over the last 25 years, ODI has opened numerous defect investigations of the loss of headlamp illumination.Investigations that resulted in safety recalls involved simultaneous loss of illumination from both headlamps. NHTSA does not consider the loss of a single headlamp as presenting an unreasonable safety risk-such failures are readily detectable by the driver while allowing the vehicle to retain forward visibility and conspicuity from the remaining headlamp.There is typically enough time between the failure of the first headlamp and the second during which the vehicle operator can obtain the needed repairs. Based on the information currently available, NHTSA does not believe that the headlamp condition as alleged by the petitioner indicates the likelihood of a safety-related defect that would warrant a formal investigation.Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is denied.Further specifics can be found in the Federal Register Notice ODI complaint ID numbers are referenced on the next page.
Illustration