IllustrationTL* THE CONTACT OWNS A 2003 SATURN L200. WHILE STARTING THE VEHICLE, THE CHECK ENGINE INDICATOR ILLUMINATED AND AN ABNORMAL NOISE WAS HEARD. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 148,000.
2003 Saturn L200
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Other model years Selected year
Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
220–25K
2025–50K
3150–75K
2375–100K
15100–150K
7150K+
118 reports with mileage · 20 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 50 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine And Engine Cooling. Review the 18 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Exterior Lighting. Review the 16 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
7 crash reports7 fire reports8 injury reports
Engine complaints
9 reportsI WAS STOPPING TO TURN RIGHT AT A RED LIGHT AND MY CARS BREAKS STOPPED WORKING. MY CAR RAN THROUGH THE INTERSECTION, STARTED VIOLENTLY SHAKING AND THEN STOPPED. THE CAR WAS STILL ON BUT IT WOULD NOT DRIVE. I TURNED THE CAR OFF AND TRIED TO START IT UP 6 TIMES AND IT WOULDN'T WORK. THEN FINALLY IT STARTED AND I DROVE HOME. I WENT…
Read full complaint
I WAS STOPPING TO TURN RIGHT AT A RED LIGHT AND MY CARS BREAKS STOPPED WORKING. MY CAR RAN THROUGH THE INTERSECTION, STARTED VIOLENTLY SHAKING AND THEN STOPPED. THE CAR WAS STILL ON BUT IT WOULD NOT DRIVE. I TURNED THE CAR OFF AND TRIED TO START IT UP 6 TIMES AND IT WOULDN'T WORK. THEN FINALLY IT STARTED AND I DROVE HOME. I WENT TO START MY CAR LATER THAT DAY AND NOW IT REFUSES TO START. THE BATTERY LIGHT COMES ON, THE CAR SHAKES, THERE'S A VERY LOUD TAPPING/RATTLING SOUND, THE ABS LIGHT FLASHES, THE 'SERVICE ENGINE SOON' LIGHT IS ON. IN THE VEHICLE INFORMATION SECTION OF THIS FORM, IT ASKING ME TO ENTER THE VEHICLES MAKE, MODEL AND YEAR. IT'S A SATURN L200 2002 BUT IT'S NOT GIVING ME AN OPTION FOR THE 2002. ONLY THE 2003.
BOTTOM ENGINE 2 CELLS GONE DEALERSHIP M676 ELECTRICAL SYSTEM INTERIOR AND EXTERIOR BLEW EENGINE
TL* THE CONTACT OWNS A 2003 SATURN L200. THE CONTACT STATED THAT THE AIR CONDITIONER FAILED TO BLOW COOL AIR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED A CONDENSER AND A CLUTCH WAS NEEDED IN ORDER TO REPAIR THE VEHICLE. THE MECHANIC ALSO STATED THAT IF THE VEHICLE WAS NOT PROPERLY REPAIRED THE BELT WOULD SEIZ…
Read full complaint
TL* THE CONTACT OWNS A 2003 SATURN L200. THE CONTACT STATED THAT THE AIR CONDITIONER FAILED TO BLOW COOL AIR. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED A CONDENSER AND A CLUTCH WAS NEEDED IN ORDER TO REPAIR THE VEHICLE. THE MECHANIC ALSO STATED THAT IF THE VEHICLE WAS NOT PROPERLY REPAIRED THE BELT WOULD SEIZE CAUSING AN ENGINE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 156,000.
THE CAR STARTED MAKING A FUNNY NOISE AS I WAS DRIVING HOME. THANKFULLY I MADE IT HOME BUT AFTER I SHUT THE CAR OFF IT WOULD NOT START AGAIN. ALSO MY REAR WHEELS WEAR ON THE INSIDE DUE TO THE POSITION OF THEM I AM GOING TO HAVE TO HAVE SHIMS PUT IN TO KEEP THE REAR WHEELS FROM ANGLING IN. *TR
FUEL IS LEAKING AT THE NIPPLE FROM FUEL PUMP. *TR
AS I WAS TURNING INTO THE GAS STATION THE TIMING CHAIN AND BOTH TENSIONERS BUSTED THE PISTON SMASHED ALL OF THE VALVES THE ENGINE WOULD NOT RESTART AND THE VEHICLE WAS ALMOST SIDESWIPED. *TR
I AM MORTIFIED BY ALL OF THE COMPLAINTS OF ENGINE FAILURE OF THE L200 SERIES DUE TO THE TIMING CHAIN AND AM EVEN MORE DEVASTATED THAT THERE IS NO RECALL INFORMATION ON IT. MY CAR HAD 78K MILES ON IT AND DID NOT START TODAY. IT WAS TOWED TO A SHOP AND THEY CALLED ME TO INFORM ME THAT IT WAS MY ENGINE DUE TO THE TIMING CHAIN. THE …
Read full complaint
I AM MORTIFIED BY ALL OF THE COMPLAINTS OF ENGINE FAILURE OF THE L200 SERIES DUE TO THE TIMING CHAIN AND AM EVEN MORE DEVASTATED THAT THERE IS NO RECALL INFORMATION ON IT. MY CAR HAD 78K MILES ON IT AND DID NOT START TODAY. IT WAS TOWED TO A SHOP AND THEY CALLED ME TO INFORM ME THAT IT WAS MY ENGINE DUE TO THE TIMING CHAIN. THE REPAIR SHOP ALSO SAID THAT IT WAS THE 4TH SATURN WITH THE SAME EXACT PROBLEM THAT THEY HAD SEEN THIS MONTH. I AM A COLLEGE STUDENT WITHOUT A CAR THAT IS STILL MAKING CAR PAYMENTS LIVING ON MY OWN. SATURN BETTER BE HAPPY THAT IT NO LONGER EXISTS, BUT GM BETTER HAVE SOME ANSWERS FOR ME. THERE ARE RECALLS FOR THE SAME PROBLEM FOR 2001 MODELS, THERE ARE EVEN MORE REPORTED ISSUES WITH LATER MODELS. HOW HAS GM GOTTEN AWAY WITH THIS? *TR
TL* THE CONTACT OWNS A 2003 SATURN L200. THE CONTACT STATED THAT THE BODY CONTROL MODULE SHUT OFF WHICH CAUSED THE GAUGES TO MALFUNCTIONED. THE CONTACT MENTIONED THAT THE VEHICLE TO STALL AND FAILED TO RESTART. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSE THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE FAILURE MILEAG…
Read full complaint
TL* THE CONTACT OWNS A 2003 SATURN L200. THE CONTACT STATED THAT THE BODY CONTROL MODULE SHUT OFF WHICH CAUSED THE GAUGES TO MALFUNCTIONED. THE CONTACT MENTIONED THAT THE VEHICLE TO STALL AND FAILED TO RESTART. THE VEHICLE WAS TAKEN TO THE DEALER WHO DIAGNOSE THAT THE BODY CONTROL MODULE NEEDED TO BE REPLACED. THE FAILURE MILEAGE WAS 50,000 AND THE CURRENT MILEAGE WAS 70,000.
Official recalls
405V245000 · Exterior Lighting:brake Lights
Jun 2, 2005
ON CERTAIN SEDANS AND WAGONS, THE PLASTIC HOUSING IN THE REAR TAIL LAMP ASSEMBLY CAN BECOME DISTORTED IF THE BRAKE LAMPS REMAIN ON FOR AN EXTENDED TIME.
Consequence & remedy
Consequence: THIS CAN CAUSE (1) AN INTERMITTENTLY INOPERATIVE BRAKE/TAIL LAMP BULB OR (2) A SHORT CIRCUIT THAT OPENS A FUSE CAUSING INOPERATIVE BRAKE LAMPS (INCLUDING THE CENTER HIGH-MOUNTED STOP LAMP) OR TAIL LAMPS. A FOLLOWING DRIVER MAY NOT KNOW WHEN THE BRAKES HAVE BEEN APPLIED, AND A REAR-END CRASH COULD OCCUR WITHOUT PRIOR WARNING.
Remedy: DEALERS WILL INSTALL TWO NEW TAIL LAMP REINFORCING SOCKET ADAPTERS AND SOCKETS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 17, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876.
05V158000 · Seat Belts
Apr 20, 2005
CERTAIN WAGONS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 210, "SEAT BELT ASSEMBLY ANCHORAGES." THE SEAT BELT ANCHOR MAY SEPARATE FROM THE FLOOR OF THE VEHICLE BEFORE HOLDING THE REQUIRED TEST LOAD FOR THE REQUIRED TIME.
Consequence & remedy
Consequence: IF A SEPARATION OCCURRED IN CRASH, THE RIGHT AND CENTER REAR SEAT OCCUPANTS MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF PERSONAL INJURY.
Remedy: DEALERS WILL INSTALL A REAR SEAT CENTER BELT ANCHOR REINFORCEMENT PLATE TO THE FLOOR PAN OF THE VEHICLE FREE OF CHARGE. THE RECALL BEGAN ON APRIL 25, 2005. OWNERS MAY CONTACT SATURN AT 1-800-972-8876.
03V231000 · Electrical System:ignition:module
Jun 23, 2003
ON CERTAIN PASSENGER VEHICLES EQUIPPED WITH 2.2L L4 (L61) ENGINES, A FAILURE OF THE IGNITION CONTROL MODULE MAY CAUSE DETERIORATION IN IDLE QUALITY, REDUCTION IN OVERALL ENGINE POWER, AND THE VEHICLE MAY BE HARD TO START. CONTINUED OPERATION OF THE VEHICLE AFTER SUCH AN IGNITION MODULE FAILURE WILL RESULT IN THE "SERVICE ENGINE SOON" LIGHT FLASHING, AND MAY LEAD TO SECONDARY FAILURES OF THE CATALYTIC CONVERTER, OXYGEN SENSOR, AND EXHAUST RESONATOR.
Consequence & remedy
Consequence: FAILURE OF THE RESONATOR WILL CAUSE INCREASED EXHAUST NOISE. PROLONGED OPERATION OF THE VEHICLE FOLLOWING A RESONATOR FAILURE MAY LEAD TO A FIRE.
Remedy: DEALERS WILL (1) REPLACE THE IGNITION CONTROL MODULE, (2) REPLACE THE IGNITION CONTROL MODULE AND SPARK PLUGS, OR (3) REPLACE THE IGNITION CONTROL MODULE, SPARK PLUGS, AND UPDATE THE POWERTRAIN CONTROL MODULE CALIBRATION. OWNER NOTIFICATION BEGAN ON AUGUST 4, 2003. OWNERS SHOULD CONTACT SATURN AT 1-800-553-6000, PROMPT 3.
02V283000 · Visibility:windshield Wiper/washer:motor
Oct 29, 2002
CERTAIN SPORT UTILITY AND PASSENGER VEHICLES EXHIBIT A CONDITION IN WHICH THE WINDSHIELD WIPER MOTOR COULD FAIL DURING USE BECAUSE OF IMPROPER MANUFACTURE.
Consequence & remedy
Consequence: IF THIS WERE TO OCCUR IN SEVERE WEATHER, DRIVER VISIBILITY COULD BE REDUCED, WHICH COULD RESULT IN A VEHICLE CRASH.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE WIPER MOTOR ASSEMBLY. OWNER NOTIFICATION BEGAN NOVEMBER 6, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SATURN AT 1-800-553-6000, PROMPT #3 OR HUMMER AT 1-866-486-6376.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE06006 · Timing Chain Failure
Opened Jan 24, 2006 · Closed Jun 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ON DECEMBER 12, 2005, ODI RECEIVED A DEFECT PETITION (DP05-008) REQUESTING THE INVESTIGATION OF TIMING CHAIN FAILURES THAT COULD CAUSE STALLING IN SATURN VEHICLES EQUIPPED WITH THE 2.2L (L61) ENGINE. ODI OPENED PE06-006 ON JANUARY 24, 2006, WITH 24 VEHICLE OWNER COMPLAINTS THAT ALLEGED A BROKEN TIMING CHAIN CAUSED THE VEHICLE TO STOP OPERATING.ON APRIL 12, 2006, ODI RECEIVED INFORMATION FROM GENERAL MOTORS (GM) CONCERNING TIMING CHAIN FAILURES IN APPROXIMATELY 412,000 MODEL YEAR (MY) 2000 THROUGH 2003 SATURN L-SERIES AND ION VEHICLES WITH 2.2L ENGINES. GM'S RESPONSE INCLUDED 1,020 OWNER COMPLAINTS AND FIELD REPORTS CONCERNING TIMING CHAIN FAILURE, INCLUDING 228 THAT ALLEGED THE FAILURE CAUSED THE VEHICLE TO STALL WHILE DRIVING.GM ALSO PROVIDED WARRANTY CLAIM DATA THAT SHOWED 1,902 SUBJECT VEHICLES RECEIVING TIMING CHAIN REPAIRS, INCLUDING 261 WHICH INDICATED THAT A STALL WHILE DRIVING RESULTED FROM THE FAILURE.THE GM COMPLAINTS, FIELD REPORTS AND WARRANTY CLAIMS THAT DID NOT CONTAIN SUFFICIENT INFORMATION TO DETERMINE THAT A STALL WHILE DRIVING OCCURRED WERE PROVIDED IN THE CATEGORY OTHER.GM STATED THAT THE MAJORITY OF THESE INCIDENTS PROBABLY OCCURRED WHILE THE VEHICLES WERE PARKED SINCE THE TIMING CHAIN IS MORE LIKELY TO BREAK DURING HIGH CHAIN LOAD SITUATIONS, SUCH AS ENGINE STARTUP.GM'S DATA SHOWED ELEVATED FAILURE RATES IN APPROXIMATELY 20,500 MY 2001 L-SERIES VEHICLES PRODUCED DURING A FOUR MONTH PERIOD FROM NOVEMBER 2000 THROUGH FEBRUARY 2001.OVER ONE-THIRD OF GM'S TOTAL COMPLAINTS AND FIELD REPORTS (34.3%) AND WARRANTY CLAIMS (38.2%) INVOLVED L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, WHICH ARE ONLY ABOUT 5% OF SUBJECT VEHICLE PRODUCTION.THE TIMING CHAIN FAILURE RATE IN THE VEHICLES BUILT DURING THIS RANGE IS OVER 10 TIMES GREATER THAN THE REMAINING SUBJECT VEHICLE POPULATION. FOR THE MY 2001 L-SERIES VEHICLES BUILT DURING THE 4-MONTH PERIOD, THE 36-MONTH FAILURE RATE FOR REPAIRS INVOLVING STALL WHILE DRIVING IS SLIGHTLY UNDER ONE PERCENT.HOWEVER, IF THE INCIDENTS CODED AS OTHER ARE ADDED, THE 36-MONTH FAILURE RATE RISES TO NEARLY FIVE PERCENT FOR THOSE VEHICLES.ODI AND GM ARE CONTINUING TO ASSESS THE NUMBER OF COMPLAINTS AND WARRANTY CLAIMS CODED BY GM AS OTHER THAT INVOLVE INCIDENTS OF STALL WHILE DRIVING.GM'S STATISTICAL MODELING OF THE FAILURE DATA INITIALLY CONCLUDED THAT THE FAILURE RATES WERE DECLINING WITH AGE AND MILEAGE FOR ANY SET OF WARRANTY DATA ANALYZED (E.G., STALL WHILE DRIVING, OTHER OR COMBINED).HOWEVER, SUBSEQUENT ANALYSIS SHOWED THAT THE FAILURE RATES ARE INCREASING. BASED ON THE HIGH COMPLAINT AND WARRANTY RATES FOR TIMING CHAIN FAILURE IN THE 4-MONTH PRODUCTION PERIOD FOR THE MY 2001 L-SERIES VEHICLES, THIS INVESTIGATION HAS BEEN UPGRADED TO AN ENGINEERING ANALYSIS TO FURTHER ASSESS THE FREQUENCY OF STALL INCIDENTS DUE TO TIMING CHAIN FAILURES IN THOSE VEHICLES (EA06-009).
DP05008 · Timing Chain Failure
Opened Dec 20, 2005 · Closed Feb 6, 2006
Status: closed (inferred from source dates) · Engine And Engine Cooling
ANALYSIS UNDERTAKEN IN RESPONSE TO THE PETITION IDENTIFIED 26 COMPLAINTS ALLEGING TIMING CHAIN FAILURES IN MY 2000-2003 SATURN L-SERIES VEHICLE EQUIPPED WITH THE 2.2L L4 ENGINE.MOST COMPLAINTS OF TIMING CHAIN FAILURE REPORTEDLY RESULTED IN A SUDDEN LOSS OF ENGINE POWER AND STALLING.ODI ALSO NOTED THAT CERTAIN MY 2002-2003 SATURN VUE AND MY 2003 SATURN ION MODEL VEHICLES WITH THE 2.2L ENGINE VEHICLESCOVERED BY A TECHNICAL SERVICE BULLETIN (03-06-01-017) THAT ADDRESSED TIMING CHAIN DESIGN AND SERVICE PROCEDURE CHANGES, EXHIBITED NO COMPLAINTS OF TIMING CHAIN FAILURE.ODI WILL GRANT THE PETITION AND OPEN A PRELIMINARY EVALUATION TO ASSESS THE FREQUENCY, TREND, SCOPE AND SAFETY CONSEQUENCES ASSOCIATED WITH THE ALLEGED DEFECT IN THE SUBJECT VEHICLES.REFER TO PE06-006.