← New search

2006 Saturn Ion

Owner reports · Recalls · Investigations

Similar to other model years

Owner complaints for the 2006 Saturn Ion do not stand out strongly from the model-year median of 816.5.

About this comparison →

When problems were reported

Mileage at the reported incident

1,073 reports with mileage · 162 unknown

NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.

What to inspect

Issues worth paying extra attention to based on owner reports.

  • Steering. Review the 544 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Electrical System. Review the 392 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
  • Fuel System, Gasoline. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

44 crash reports7 fire reports23 injury reports

Vehicle Speed Control complaints

17 reports
Clear category filter
35,000 miles · Apr 20, 2014
Power TrainSteeringVehicle Speed Control

L WAS DRIVING MY 2006 SATURN ION WHICH L BOUGHT BRAND NEW IN 2006 GOING TO PICK UP MY GRANDDAUGHTER IN HOWELL MI I WAS ON INTERSTATE WITH MY CRUISE CONTROL ON AS L WENT ON EXIT INTERSTATE,L TURNED OFF CRUISE CONTROL WHEN L DID THAT IT SHUT MY CAR DOWN COMPLETELY ,L WAS MERGING ON ANOTHER INTERSTATE WITH NO ENGINE RUNNING NO POW…

Read full complaint

L WAS DRIVING MY 2006 SATURN ION WHICH L BOUGHT BRAND NEW IN 2006 GOING TO PICK UP MY GRANDDAUGHTER IN HOWELL MI I WAS ON INTERSTATE WITH MY CRUISE CONTROL ON AS L WENT ON EXIT INTERSTATE,L TURNED OFF CRUISE CONTROL WHEN L DID THAT IT SHUT MY CAR DOWN COMPLETELY ,L WAS MERGING ON ANOTHER INTERSTATE WITH NO ENGINE RUNNING NO POWER STEERING AND UNABLE TO RESTART ENGINE . THERE WAS NO WHERE TO PULL OVER OFF ROAD SAFELY , L WAS ALMOST KILLED CAR HAD TO COME TO A COMPLETE STOP TO RESTART . I HAVE HAD THIS HAPPEN TO ME 3 DIFFERENT TIMES , L HAVE TAKEN CAR TO CHEVY DEALERSHIP MANY TIME COMPLAINING ABOUT THIS MATTER, THEY SAID THEY COULD NOT FIND ANY PROBLEMS , L HAVE STOPPED USING MY CRUISE CONTROL . L REALLY HAVE A LEMON SUNROOF DOES NOT WORK SUN ROOF LEAKS , THE CAR STARTS WHEN IT WANTS TO , LAM RETIRED 65 YEARS OLD AND TAKE VERY GOOD CARE OF THE SATURN ION , L WOULD BE AFRAID TO SELL THIS 2006 SATURN ION TO THE PUBLIC , L DON'T WANT TO KILL ANYONE , THE CAR SITS ,NOT USING IT , WON'T SELL IT, WHAT CAN BE DONE? AND THERE IS NO RETAIL VALUE FOR THIS CAR .NOW THERE IS A RECALL ON IGNITION SWITCH I FEEL SO VERY SORRY FOR THE PEOPLE THAT LOST THEIR LIVES,L WAS LUCKY THAT L WAS NOT ONE THAT WAS KILLED ,AS L SAID EARLIER, THIS CAR WENT TO DEALERSHIP 3 DIFFERENT TIMES ON THIS MATTER , LAST TIME L TOOK THE CAR IN WAS LAST SUMMER 2013 , MECHANIC DROVE SATURN ION AND TOLD ME THERE IS NOTHING WRONG . THE CAR SITS. *TR

NHTSA ODI #10583782

30,000 miles · Mar 28, 2014
Vehicle Speed Control

OUR ION EXPERIENCED A LOSS OF POWER WHILE DRIVING FULL SPEED ON THE INTERSTATE MULTIPLE TIMES BETWEEN 2006 AND 2008. A CAR HAD BACKED INTO THE ION WHILE PARKED IN A LOT AT ONE POINT, SO WE THOUGHT IT MIGHT BE RELATED TO THAT, BUT OUR EXPERIENCE SEEMS TO BE IDENTICAL TO THOSE REPORTED UNDER THE RECALL. WE ATTEMPTED TO HAVE IT FIX…

Read full complaint

OUR ION EXPERIENCED A LOSS OF POWER WHILE DRIVING FULL SPEED ON THE INTERSTATE MULTIPLE TIMES BETWEEN 2006 AND 2008. A CAR HAD BACKED INTO THE ION WHILE PARKED IN A LOT AT ONE POINT, SO WE THOUGHT IT MIGHT BE RELATED TO THAT, BUT OUR EXPERIENCE SEEMS TO BE IDENTICAL TO THOSE REPORTED UNDER THE RECALL. WE ATTEMPTED TO HAVE IT FIXED SEVERAL TIMES AT GM DEALERSHIPS. THE LAST FIX INVOLVED REPLACING ALL THE MAIN WIRES IN THE MOTOR. AFTER THAT, THE IGNITION SEEMED TO BE TIGHTER, AND THE STALLING STOPPED, BUT THE CAR WOULD THEN NOT START, INTERMITTENTLY. IT WOULD RANDOMLY GO INTO LOCK DOWN MODE FOR 10 OR SO MINUTES. JUST THOUGHT WE WOULD ADD OUR EXPERIENCE TO THE STATISTICS. IT WAS VERY DANGEROUS, AND WE EASILY COULD HAVE DIED. WE DO STILL HAVE THE CAR- COULDN'T AFFORD ANOTHER. WE CURRENTLY HAVE A RENTAL CAR AND ARE AWAITING OUR FIX. *TR

NHTSA ODI #10575359

68,000 miles · Mar 25, 2014
Vehicle Speed Control

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE INDEPENDENTLY ACCELERATED. THE CONTACT HAD TO FULLY APPLY THE BRAKES WHILE MANEUVERING TO THE SIDE OF THE ROAD AND SHUT VEHICLE OFF TO BRING IT TO A FULL STOP. THERE WAS A RECALL UNDER NTHSA CAMPAIGN ID NUMBER 14V047000 (A…

Read full complaint

TL* THE CONTACT OWNS A 2006 SATURN ION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 35 MPH THE VEHICLE INDEPENDENTLY ACCELERATED. THE CONTACT HAD TO FULLY APPLY THE BRAKES WHILE MANEUVERING TO THE SIDE OF THE ROAD AND SHUT VEHICLE OFF TO BRING IT TO A FULL STOP. THERE WAS A RECALL UNDER NTHSA CAMPAIGN ID NUMBER 14V047000 (AIR BAGS, ELECTRICAL SYSTEM). THE VEHICLE WAS NOT TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 68,000.

NHTSA ODI #10574688

51,000 miles · Sep 24, 2008
Electrical SystemEngine And Engine CoolingSteering

TL*THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING 75 MPH, THE CRUISE CONTROL STOPPED WORKING. THE POWER STEERING, BATTERY, AND COOLANT WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ALSO NOTICED THAT THE VEHICLE WOULD NO LONGER ACCELERATE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CONTACT DID…

Read full complaint

TL*THE CONTACT OWNS A 2006 SATURN ION. WHILE DRIVING 75 MPH, THE CRUISE CONTROL STOPPED WORKING. THE POWER STEERING, BATTERY, AND COOLANT WARNING LIGHTS ILLUMINATED ON THE INSTRUMENT PANEL. THE CONTACT ALSO NOTICED THAT THE VEHICLE WOULD NO LONGER ACCELERATE. THE VEHICLE HAS NOT BEEN DIAGNOSED BY THE DEALER. THE CONTACT DID NOT NOTICE ANY DIFFERENCES BEFOREHAND. THE CURRENT AND FAILURE MILEAGES WERE 51,000. UPDATED 10/16/08 *BF THE CONSUMER ALSO STATED THE KEY BECAME STUCK IN THE IGNITION. UPDATED 10/21/08. *JB

NHTSA ODI #10243356

36,000 miles · Jan 21, 2008
Vehicle Speed Control

I WAS DRIVING IN THE MOUNTAINS OF VIRGINIA AND JUST GOT ON A MAJOR HIGHWAY CALLED 81 NORTH. I PUT MY CRUISE CONTROL ON AND SET IT AT AROUND 60. I DID THIS RIGHT BEFORE AN UPHILL CLIMB THEN I HELD ONTO THE ACCELERATE BUTTON TO SET IT AROUND 65 WHICH WAS THE SPEED LIMIT ON THAT HIGHWAY. IT ACCELERATED SLOWLY AND WHEN IT GOT TO T…

Read full complaint

I WAS DRIVING IN THE MOUNTAINS OF VIRGINIA AND JUST GOT ON A MAJOR HIGHWAY CALLED 81 NORTH. I PUT MY CRUISE CONTROL ON AND SET IT AT AROUND 60. I DID THIS RIGHT BEFORE AN UPHILL CLIMB THEN I HELD ONTO THE ACCELERATE BUTTON TO SET IT AROUND 65 WHICH WAS THE SPEED LIMIT ON THAT HIGHWAY. IT ACCELERATED SLOWLY AND WHEN IT GOT TO THE SPEED I WANTED I LET GO. I GOT TO THE TOP OF THE HILL AND IT KEEPS ACCELERATING. SO IM NOW GOING DOWNHILL AND ITS ACCELERATING PLUS THE HILL WAS STEEP AND I HIT MY BRAKE AND IT DOESN'T TURN OFF. I HIT THE CLUTCH SIMULTANEOUS TO WHEN I HIT THE BRAKE AND NEITHER SHUT OFF THE CRUISE CONTROL. I THEN TURN THE CRUISE CONTROL OFF AND ITS STILL GOING. I THEN HIT THE CLUTCH AND YANK THE SHIFTER INTO NEUTRAL (ITS A MANUAL) AND THE RPM'S ARE GOING CRAZY. I TURN THE CRUISE CONTROL BUTTON BACK ON AND THEN OFF AGAIN AND IT FINALLY STOPPED TRYING TO ACCELERATE (THE RPM'S STOPPED FREAKING OUT). NOT TO MENTION I GET PULLED BY A STATE TROOPER FOR SPEEDING. AFTER HE COMES BACK WITH MY TICKET (STILL SHOCKED THAT THE CRUISE CONTROL WOULDN'T LET UP) , I TELL HIM, "WELL WHAT HAPPENED WAS..." AND HE SAYS "I DON'T NEED TO KNOW, I JUST NEED YOU TO SIGN THIS PAPER RIGHT HERE." THIS JUST HAPPENED TODAY IN ROANOKE, VA AND I LIVE IN NORFOLK, VA SO I HAVE TO DRIVE ALL THE WAY BACK TO ROANOKE ON MARCH 13 TO CONTEST THIS TICKET. *TR

NHTSA ODI #10215596

14,000 miles · Feb 20, 2007
Vehicle Speed Control

TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2006 SATURN ION WITH 14000 FAILURE MILEAGE AT 30 MPH AND PASSING ANOTHER VEHICLE GOING UP HILL AND WITHOUT WARNING THE ACCELERATOR PEDAL GOT STUCK AND THE VEHICLE WAS CATAPULTED UP HILL 90 MPH. THE CONTACT STOMPED ON THE GAS PEDAL TO GET IT TO UNSTUCK, BUT THE SPEED DID NOT CHANG…

Read full complaint

TL*- THE CONTACT STATED THAT WHILE DRIVING THE 2006 SATURN ION WITH 14000 FAILURE MILEAGE AT 30 MPH AND PASSING ANOTHER VEHICLE GOING UP HILL AND WITHOUT WARNING THE ACCELERATOR PEDAL GOT STUCK AND THE VEHICLE WAS CATAPULTED UP HILL 90 MPH. THE CONTACT STOMPED ON THE GAS PEDAL TO GET IT TO UNSTUCK, BUT THE SPEED DID NOT CHANGE. THE CONTACT THEN APPLIED THE BRAKE WITH FORCE WITH NO CHANGE IN SPEED. WHILE DRIVING, AND STILL GOING UP HILL THE CONTACT PUT THE VEHICLE IN NEUTRAL, WAS PRESSING ON THE BRAKE AND PULLED UP THE EMERGENCY BRAKE ALL AT ONCE AND THE VEHICLE CAME TO A STOP SIDEWAYS JUST BEFORE THE GUARD RAIL. THE VEHICLE HAD TO BE TOWED AND HAD NOT BEEN REPAIRED. *AK RETURNED USPS, 2ND ATTEMPT MADE 06/16/07 FAILED. * LJ .

NHTSA ODI #10183016

113 miles · Jun 6, 2006
Vehicle Speed ControlCrash

ON TWO PRIOR OCCASIONS, THE VEHICLE'S MOTOR 'REVVED' OR RACED JUST BEFORE COMING TO A STOP. A COUPLE OF HOURS LATER, WHEN PULLING INTO A PARKING SPACE AND APPLYING THE BRAKE, THE CAR RAPIDLY ACCELERATED, JUMPED A CURB AND ENDED UP FINALLY COMING TO A STOP INSIDE A PARTY STORE. THERE WERE AT LEAST 10 FEET OF SKID MARKS PRESENT …

Read full complaint

ON TWO PRIOR OCCASIONS, THE VEHICLE'S MOTOR 'REVVED' OR RACED JUST BEFORE COMING TO A STOP. A COUPLE OF HOURS LATER, WHEN PULLING INTO A PARKING SPACE AND APPLYING THE BRAKE, THE CAR RAPIDLY ACCELERATED, JUMPED A CURB AND ENDED UP FINALLY COMING TO A STOP INSIDE A PARTY STORE. THERE WERE AT LEAST 10 FEET OF SKID MARKS PRESENT AND A WITNESS FROM BEHIND THAT SAW THE BRAKE LIGHTS ON. THERE WAS A LOT OF DAMAGE TO THE CAR AND STORE, ALL REPAIRED, HOWEVER THE PROBLEM THAT CAUSED THE ACCIDENT HAS NOT BEEN DUPLICATED AND HAS NOT BEEN RECTIFIED. *NM

NHTSA ODI #10159142

Official recalls

4

14V171000 · Electrical System:ignition

Apr 10, 2014

General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.

Consequence & remedy

Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.

Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.

14V153000 · Steering:electric Power Assist System

Mar 31, 2014

General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.

Consequence & remedy

Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.

Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.

14V047000 · Air Bags; Electrical System:ignition:switch

Feb 10, 2014

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence & remedy

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Additional source detail variants (2)

Air Bags

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

Electrical System:ignition:switch

This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.

Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GM’s recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.

09V419000 · Fuel System, Gasoline:delivery:fuel Pump

Oct 29, 2009

GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.

Consequence & remedy

Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.

Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

2

EA11014 · Electric Power Steering Failure

Opened Sep 29, 2011 · Closed Apr 15, 2014

Status: closed (inferred from source dates) · Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Additional source detail variants (2)

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

Steering:electric Power Assist System

On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.

RQ10004 · Electric Power Steering Failure

Opened Dec 15, 2010 · Closed Oct 5, 2011

Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Additional source detail variants (2)

Steering:electric Power Assist System

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.

Steering

ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.