NHTSA owner reports · September 18, 2026 snapshot.
Latches/locks/linkages complaints
12 reportsClear category filter72,500 miles · Oct 21, 2013
Latches/locks/linkagesStructure
I RECENTLY EXPERIENCED A MALFUNCTIONING DOOR LATCH ACTUATOR. ON TWO SEPARATE OCCASIONS, DRIVER WAS TRAPPED IN THE CAR BECAUSE NEITHER THE INTERIOR OR EXTERIOR DOOR HANDLE WOULD ACTUATE THE DOOR LATCH, OPENING THE DOOR. EXTERIOR, INTERIOR MANUAL, INTERIOR POWER AND REMOTE POWER LOCKS WERE REPEATEDLY ACTUATED TO NO AVAIL. EVENT…
Read full complaint
I RECENTLY EXPERIENCED A MALFUNCTIONING DOOR LATCH ACTUATOR. ON TWO SEPARATE OCCASIONS, DRIVER WAS TRAPPED IN THE CAR BECAUSE NEITHER THE INTERIOR OR EXTERIOR DOOR HANDLE WOULD ACTUATE THE DOOR LATCH, OPENING THE DOOR. EXTERIOR, INTERIOR MANUAL, INTERIOR POWER AND REMOTE POWER LOCKS WERE REPEATEDLY ACTUATED TO NO AVAIL. EVENTUALLY, THE DOOR FINALLY OPENED AFTER USING A HANGAR THROUGH THE WINDOW CAVITY TO BUMP ONE OF THE LINKAGE ARMS. IF THERE WERE AN ACCIDENT, THIS COULD POSE A SERIOUS THREAT TO A SUCCESSFUL EVACUATION. *TR
NHTSA ODI #10548673
71,935 miles · Aug 14, 2011
Electrical SystemLatches/locks/linkages
IGNITION STUCK IN "ON" POSITION, CAN'T REMOVE KEY. *TR
NHTSA ODI #10419385
86,755 miles · Jul 31, 2011
Latches/locks/linkages
2006 SATURN ION 2, THE KEY STUCK IN THE IGNITION SWITCH, IN THE RUN POSITION. I COULD NOT SHUT THE CAR OFF. I HAD TO DISENGAGE THE FUSE FROM THE IGNITION ASSEMBLY TO SHUT THE CAR OFF. THIS PROBLEM, AFTER MUCH ON-LINE RESEARCH, IS AN ISSUE WITH SATURNS FROM 2005-2007. MOST INDIVIDUALS WHO POSTED THIER ISSUES ONLINE NOTED THAT…
Read full complaint
2006 SATURN ION 2, THE KEY STUCK IN THE IGNITION SWITCH, IN THE RUN POSITION. I COULD NOT SHUT THE CAR OFF. I HAD TO DISENGAGE THE FUSE FROM THE IGNITION ASSEMBLY TO SHUT THE CAR OFF. THIS PROBLEM, AFTER MUCH ON-LINE RESEARCH, IS AN ISSUE WITH SATURNS FROM 2005-2007. MOST INDIVIDUALS WHO POSTED THIER ISSUES ONLINE NOTED THAT THE REPAIR, THROUGH THE DEALER, WAS IN EXCESS OF $500.00. IN ADDITION, MOST INDIVIDUALS NOTED THAT THEY EXPERIENCED THE SAME PROBLEM, SIX MONTHS OR MORE AFTER REPLACING THE THE IGNITION LOCK CYLINDER, THROUGH THIER DEALERSHIP. MECHANICS ARE NOTING THAT THE ASSEMBLY IS FAULTY, IN THAT EACH TIME THE KEY IS TURNED SMALL BITS OF METAL FROM THE KEY ARE FLAKING OFF INTO THE ASSEMBLY, CAUSING IT TO LOCK UP, TYPICALLY IN THE ON POSITION. THANKFULLY, FOR ME, THIS INCIDENT OCCURRED CLOSE TO HOME. THIS VEHICLE IS NOT UNDER WARRANTY AND THE REPAIR WILL TAKE REPLACEMENT OF THE IGNITION LOCK ASSEMBLY. THIS IS SOMETHING I WILL BE DOING MYSELF, AS I DO NOT HAVE THE FUNDS TO TAKE THE VEHICLE TO A DEALERSHIP FOR REPAIR. GIVEN THE NUMBER OF COMPLAINTS LISTED ON-LINE THROUGH EDMONDS AND OTHER CONSUMER COMPLAINT SITES, I FEEL THAT SATURN/GM SHOULD BE TAKING RESPONSIBILITY FOR THE FAULTY PARTS AND A RECALL SHOULD BE ISSUED. THIS POOR ENGINEERING SHOULD NOT BE AN OUT OF POCKET EXPENSE FOR ANY CONSUMER. *TR
NHTSA ODI #10416382
75,000 miles · Mar 14, 2011
Latches/locks/linkages
I HAVE A 2006 SATURN ION 3 THAT I PURCHASED FROM A SATURN DEALERSHIP IN 2009. TODAY THE CAR WOULD NOT TURN OFF. THERE WAS NOT A WARNING OR ANY SIGNS. THE CAR WAS WORKING 100% AS NORMAL, UNTIL IT WAS NOT. FOR THE THIRD TIME TODAY I TURNED THE CAR ON AND DROVE TO A DESTINATION. WHEN I ARRIVED AT MY DESTINATION I TURNED MY CAR OFF.…
Read full complaint
I HAVE A 2006 SATURN ION 3 THAT I PURCHASED FROM A SATURN DEALERSHIP IN 2009. TODAY THE CAR WOULD NOT TURN OFF. THERE WAS NOT A WARNING OR ANY SIGNS. THE CAR WAS WORKING 100% AS NORMAL, UNTIL IT WAS NOT. FOR THE THIRD TIME TODAY I TURNED THE CAR ON AND DROVE TO A DESTINATION. WHEN I ARRIVED AT MY DESTINATION I TURNED MY CAR OFF. I WENT IN TO THE STORE I WAS AT TO GET AN OIL CHANGE. THEY PULLED MY CAR INTO THE GARAGE AND THE IGNITION WOULD NOT TURN OFF. THE KEY WAS NOT ABLE TO BE REMOVED FROM THE IGNITION SWITCH (TUMBLER). THE CAR WOULD NOT TURN OFF. I CAN NOT GET THE CAR TO TURN OFF WITHOUT OPENING THE ENGINE COMPARTMENT AND THEN REMOVING THE #19 FUSE FROM THE ENGINE FUSE BOX. THEN IN ORDER TO KILL THE ELECTRICAL SYSTEM I HAVE TO DISCONNECT THE BATTERY TERMINALS. THIS IS A PROBLEM THAT OCCURS EVERY TIME I PLUG THE FUSE/BATTEY BACK UP. I DID SOME RESEARCH AND FOUND THAT WHILE THERE ARE 100'S OF ONLINE COMPLAINTS (THAT I READ) AND WHILE SOME SERVICE DEPARTMENTS ACKNOWLEDGE IT AS A KNOWN ISSUE, GM HAS NOT ISSUED A RECALL. I AM ABOUT TO DISH OUT $500 FOR REPAIRS THAT I BELIEVE SHOULD BE COVERED UNDER A RECALL. DO YOU HAVE ANY SUGGESTIONS FOR ME? *TR
NHTSA ODI #10390169
Mileage unknown · Nov 1, 2010
Electrical SystemEquipmentFuel System, Gasoline
YES A FEW MONTHS AFO I FINANCED A 2006 SATURN ION LEVEL 3 SINCE THE FIRST WEEK HAVING IT HAVE HAD NOTHING BUT PROBLEMS INCLUDING A MAJOR GAS LEAK AND SEVERE GAS FUMES INSIDE AND OUTSIDE THE CAB WHEN RUNNING AND NOT. THE DEALER HAD GIVIN ME NOTHING BUT LIES AND THE FUN AROUND AND ATTITUDE. HAD BEEN DOCUMENTED BY AN OUTSIDE MECHAN…
Read full complaint
YES A FEW MONTHS AFO I FINANCED A 2006 SATURN ION LEVEL 3 SINCE THE FIRST WEEK HAVING IT HAVE HAD NOTHING BUT PROBLEMS INCLUDING A MAJOR GAS LEAK AND SEVERE GAS FUMES INSIDE AND OUTSIDE THE CAB WHEN RUNNING AND NOT. THE DEALER HAD GIVIN ME NOTHING BUT LIES AND THE FUN AROUND AND ATTITUDE. HAD BEEN DOCUMENTED BY AN OUTSIDE MECHANIC THE CAR IN UNSAFE TO BE ON THE ROADS AND SHOULD NEVER HAVE PASSED INSPECTION WHICH THE DEALER DID. I REALLY NEED HELP. I KNOW IT'S A GOOD CHANCE IT'S A FLOOD CAR THEY SOLD ME. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10363599
59,838 miles · Oct 2, 2010
Electrical SystemLatches/locks/linkages
WE HAVE A SATURN ION 2006 WHICH IS NOW EXPERIENCING IGNITION ISSUES. FIRST THE CAR WOULD NOT STOP RUNNING (HAZARD!) IN MY DRIVEWAY. THIS WAS DUE TO THE KEY BEING STUCK IN THE ON POSITION IN THE IGNITION! WE HAD TO ALLOW IT TO RUN OUT OF GAS PRIOR TO FINDING THE EMERGENCY KEY RELEASE THAT SATURN HAS NOTED. NOW THE CAR WILL NOT…
Read full complaint
WE HAVE A SATURN ION 2006 WHICH IS NOW EXPERIENCING IGNITION ISSUES. FIRST THE CAR WOULD NOT STOP RUNNING (HAZARD!) IN MY DRIVEWAY. THIS WAS DUE TO THE KEY BEING STUCK IN THE ON POSITION IN THE IGNITION! WE HAD TO ALLOW IT TO RUN OUT OF GAS PRIOR TO FINDING THE EMERGENCY KEY RELEASE THAT SATURN HAS NOTED. NOW THE CAR WILL NOT EVEN START AND WHEN I CALLED THE CUSTOMER SERVICE LINE, THE RESPONSE WAS HARDLY COMFORTING. LOOKING ONLINE IT APPEARS THAT THERE ARE NUMEROUS COMPLAINTS LOGGING THIS ISSUE. IT APPEARS THAT THERE ARE QUITE A FEW PEOPLE THAT WOULD LIKE TO PURSUE A CLASS ACTION LAWSUIT AGAINST SATURN/GM AS THERE HAVE BEEN ABSOLUTELY NO INVESTIGATIONS, RECALLS, OR EVEN AN ACKNOWLEDGEMENT OF SAID ISSUE. THIS IS THE FIRST TIME THE IGNITION HAS CAUSED US ISSUES, BUT LOOKING AT THE ONLINE COMPLAINTS, IT WON'T BE THE LAST. WHEN WILL IT BE INVESTIGATED? WILL IT BE INVESTIGATED AFTER AN ACCIDENT HAPPENS PERHAPS WITH MY 2 CHILDREN IN THE CAR? WILL IT BE CLASSIFIED AS AN URGENT ISSUE THEN? SEE HOW MANY PEOPLE HAVE HAD THE ISSUE BELOW VIA THE LINK EMBEDDED. HTTP://WWW.CONSUMERAFFAIRS.COM/AUTOMOTIVE/SATURN.HTM. *TR
NHTSA ODI #10358839
50,000 miles · Sep 16, 2010
Electrical SystemLatches/locks/linkagesPower Train
VEHICLE WAS UNABLE TO BE SHUT OFF, KEY WAS STUCK IN THE IGNITION, I UNHOOKED THE BATTERY AND THE VEHICLE WAS STILL RUNNING. THIS SAME VEHICLE HAD A RECALL ON THE FUEL PUMP MODULE AND WAS LEAKING GAS, HAD THIS OCCURRED AT THE SAME TIME IT WOULD HAVE BEEN VERY UNSAFE FOR THE CAR TO HAVE BEEN RUNNING THE ENTIRE TIME WITH A GAS LEAK…
Read full complaint
VEHICLE WAS UNABLE TO BE SHUT OFF, KEY WAS STUCK IN THE IGNITION, I UNHOOKED THE BATTERY AND THE VEHICLE WAS STILL RUNNING. THIS SAME VEHICLE HAD A RECALL ON THE FUEL PUMP MODULE AND WAS LEAKING GAS, HAD THIS OCCURRED AT THE SAME TIME IT WOULD HAVE BEEN VERY UNSAFE FOR THE CAR TO HAVE BEEN RUNNING THE ENTIRE TIME WITH A GAS LEAK. FORTUNATELY I HAD JUST REPAIRED THE FUEL PUMP MODULE 1 WEEK PRIOR TO THIS ISSUE WITH THE IGNITION. *TR
NHTSA ODI #10355914
46,243 miles · Apr 14, 2010
Electrical SystemLatches/locks/linkages
COULD NOT TURN THE CAR OFF, THE KEY WAS STUCK IN THE ON POSITION WITH THE CAR STILL RUNNING, HAD TO PULL THE SPARK PLUGS OUT TO TURN OFF THE CAR AND DISCONNECT THE BATTERY TO KEEP FROM DRAINING DUE TO BEING IN THE ON POSITION. THE IGNITION LOCK CYLINDER WAS BOUND IN THE HOUSING. DEALER REPLACED THE IGNITION CYLINDER AND HOUSING,…
Read full complaint
COULD NOT TURN THE CAR OFF, THE KEY WAS STUCK IN THE ON POSITION WITH THE CAR STILL RUNNING, HAD TO PULL THE SPARK PLUGS OUT TO TURN OFF THE CAR AND DISCONNECT THE BATTERY TO KEEP FROM DRAINING DUE TO BEING IN THE ON POSITION. THE IGNITION LOCK CYLINDER WAS BOUND IN THE HOUSING. DEALER REPLACED THE IGNITION CYLINDER AND HOUSING, I DON'T KNOW IF THEY STILL HAVE THE OLD PART. *TR
NHTSA ODI #10325677
450 miles · Mar 23, 2010
Electrical SystemLatches/locks/linkages
SATURN ION 2006 BRAND NEW HAD THREE DAYS WHEN CRUISE CONTROL WOULD NOT ENGAGE.PHONED DEALER WAS TOLD TO STOP AND RESTART TO FIX PROBLEM.DID NOT CHANGE.STEERING WHEEL BEGAN TO LOB SIDE TO SIDE.TOOK TO DEALERSHIP WAS TOLD AFTER DIAGNOSIS IT WAS BODY MOUNT.POWER STEERING PROMPT APPEARED AFTER REPAIR WWHILE DRIVING EXPRESSWAY POWER …
Read full complaint
SATURN ION 2006 BRAND NEW HAD THREE DAYS WHEN CRUISE CONTROL WOULD NOT ENGAGE.PHONED DEALER WAS TOLD TO STOP AND RESTART TO FIX PROBLEM.DID NOT CHANGE.STEERING WHEEL BEGAN TO LOB SIDE TO SIDE.TOOK TO DEALERSHIP WAS TOLD AFTER DIAGNOSIS IT WAS BODY MOUNT.POWER STEERING PROMPT APPEARED AFTER REPAIR WWHILE DRIVING EXPRESSWAY POWER STEERING CEASED WORKING CAUSING ME TO ALMOST WRECK.WILL NOT START UNTIL 10 MINUTE DELAY.CANNOT DRIVE ANYWAY WITH MANUAL STEERING.THIS PROBLEM IS ELECTRICAL.DOOR LOCKS WILL NOT OPEN OR LOCK PROPERLY.CAR IS VERY DANGEROUS AND WILL NOT ALLOW ANYONE TO DRIVE IT.
NHTSA ODI #10321544
56,322 miles · Nov 25, 2008
Latches/locks/linkages
2ND OCCURRENCE - UNABLE TO MOVE KEY OF RUNNING VEHICLE FROM "RUN" TO OFF. HAD TO REMOVE FUSE AND DISCONNECT BATTERY TO STOP CAR. STILL UNABLE TO REMOVE KEY - DEALER HAS TO REPLACE LOCK CYLINDER PARTS. WOULD NOT HAVE BEEN ABLE TO STOP ENGINE IN THE EVENT OF AN EMERGENCY SITUATION. *TR
NHTSA ODI #10249840
Official recalls
4Apr 10, 2014
General Motors LLC (GM) is recalling certain model year 2005-2010 Chevrolet Cobalt, 2006-2011 Chevrolet HHR, 2007-2010 Pontiac G5, 2006-2010 Pontiac Solstice, 2003-2007 Saturn Ion, and 2007-2010 Saturn Sky vehicles. In the affected vehicles, the key can be removed from the ignition when the ignition is not in the "Off" position.
Consequence & remedy
Consequence: If the key can be removed from the ignition when the ignition is not in the "off" position, the vehicle could roll away: (a) for an automatic transmission, if the transmission is not in the "Park" position; or (b) for a manual transmission, if the parking brake is not engaged and the transmission is not in the "Reverse" position. This potential for rollaway increases the risk for a crash and occupant or pedestrian injuries.
Remedy: General Motors will notify owners, and for vehicles that were built with the defective ignition cylinder and have not previously had the ignition cylinder replaced with the redesigned part, dealers will replace the ignition cylinder and cut and, if necessary, re-learn two ignition/door keys for each vehicle. For vehicles that were built with the redesigned ignition cylinder or had the ignition cylinder replaced with the redesigned part, dealers will cut and, if necessary, re-learn two ignition/door keys for each vehicle. The recall began on April 18, 2014. Chevrolet owners may contact General Motors at 1-800-222-1020, Pontiac owners at 1-800-762-2737, and Saturn owners at 1-800-553-6000. General Motors' number for this recall is 14113 for the ignition lock cylinder and key replacement, and 14133 for only key replacements. Note: Until a vehicle has been remedied, owners and operators are advised that when exiting, to be sure that the vehicle is in "Park," or in the case of a manual transmission, that the vehicle is in the "Reverse" position and the parking brake is engaged.
Mar 31, 2014
General Motors LLC (GM) is recalling certain model year 2004-2006 and 2008-2009 Chevrolet Malibu, 2004-2006 Malibu Maxx, 2009-2010 HHR (non-turbo), 2010 Cobalt, 2008-2009 Saturn Aura and 2004-2007 Ion, and 2005-2009 Pontiac G6. In the affected vehicles, there may be a sudden loss of electric power steering (EPS) assist that could occur at any time while driving.
Consequence & remedy
Consequence: If power steering assist is lost, greater driver effort would be required to steer the vehicle at low speeds, increasing the risk of a crash.
Remedy: GM will notify owners, and dealers will perform one of four bulletins. Parts are not currently available. GM expects to send an interim notification around May 28, 2014. When parts are available, owners will be mailed a second letter to come in to have the applicable bulletin applied. Bulletin 14115 covers model year 2004-2007 Saturn Ion, 2009-2010 Chevrolet HHR and 2010 Chevrolet Cobalts. Dealers will replace the EPS motor. Bulletin 14116 covers model year 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from March 1, 2008, through June 27, 2008. Dealers will replace the torque sensor assembly. Bulletin 14117 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from February 1, 2008, through February 28, 2008. Dealers will replace the torque sensor assembly and EPS motor controller unit. Bulletin 14118 covers model year 2008 Chevrolet Malibu, Pontiac G6 and Saturn Aura built from October 1, 2007, through January 31, 2008. Dealers will replace the EPS motor controller unit. The recall began on July 17, 2014. Owners may contact Chevrolet at 1-800-630-2438, Saturn at 1-800-553-6000, and Pontiac at 1-800-620-7668. GM's number for this recall is N140115. Note: GM bulletin number 14119 will be implemented for model year 2006-2008 and early production of 2009 Chevrolet HHR (non-turbo) and model year 2003 Saturn ION to provide EPS Motor replacement for the life of the vehicle.
Feb 10, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence & remedy
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on February 10, 2014 that they are recalling 619,122 model year 2005-2007 Chevrolet Cobalt, and 2007 Pontiac G5 vehicles. On February 25, 2014, GM increased the recall to include an additional 748,024 model year 2006-2007 Chevrolet HHR and Pontiac Solstice vehicles and 2003-2007 Saturn Ion vehicles and 2007 Saturn Sky vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine. On March 27, 2014, GM notified the agency that the defective ignition switches may have been used as service replacement parts on other vehicles, and as a result GM will be recalling certain model year 2008-2010 Chevrolet Cobalt, Saturn Sky, and Pontiac G5 and Solstice, and 2008-2011 Chevrolet HHR vehicles. The part numbers for the service parts are 10392423 (a/k/a ACDelco D1461F), 10392737, 15857948, 15854953, 15896640, and 25846762. This expansion represents an additional 823,788 vehicles.
Consequence: If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.
Remedy: GM will notify owners, and dealers will replace the ignition switch, free of charge. An interim notification was issued to owners of 2007 and earlier models on March 10, 2014, informing them of the safety defect. Owners of 2008 and later vehicles will be mailed an interim letter on April 21, 2014. All affected owners will receive another letter once parts are available. The recall began on April 18, 2014. Owners may contact Chevrolet at 1-800-222-1020, Pontiac at 1-800-762-2737 or Saturn at 1-800-553-6000. GM's number for the initial recall is 13454 and 14063 for the expansion. GMs recall number for the vehicles that may have received the replacement parts is 14092. Note: Until the recall repairs have been performed, it is very important that customers remove all items from their key rings, leaving only the vehicle key. The key fob (if applicable), should also be removed from the key ring. Always wear your seatbelt.
Oct 29, 2009
GENERAL MOTORS IS RECALLING CERTAIN MODEL YEAR 2006 CHEVROLET COBALT AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA AND NEVADA; AND MODEL YEAR 2007 CHEVROLET COBALT, PONTIAC G5 AND SATURN ION VEHICLES ORIGINALLY SOLD IN OR CURRENTLY REGISTERED IN THE STATES OF ARIZONA, CALIFORNIA, FLORIDA, NEVADA AND TEXAS. THE PLASTIC SUPPLY OR RETURN PORT ON THE MODULAR RESERVOIR ASSEMBLY MAY CRACK. IF EITHER OF THESE PORTS DEVELOPS A CRACK, FUEL WILL LEAK FROM THE AREA. IF THE CRACK BECOMES LARGE ENOUGH, FUEL MAY BE OBSERVED DRIPPING ONTO THE GROUND AND VEHICLE PERFORMANCE MAY BE AFFECTED.
Consequence & remedy
Consequence: FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
Remedy: DEALERS WILL REPLACE THE FUEL PUMP MODULE FREE OF CHARGE. A SPECIAL COVERAGE WILL BE IMPLEMENTED IN THE SAME TIME FRAME FOR MODEL YEAR 2006 VEHICLES REGISTERED IN ALABAMA, ARKANSAS, CALIFORNIA, FLORIDA, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA, TENNESSEE AND TEXAS AND MODEL YEAR 2007 VEHICLES REGISTERED IN: ALABAMA, ARKANSAS, GEORGIA, HAWAII, LOUISIANA, MISSISSIPPI, NORTH CAROLINA, NEW MEXICO, OKLAHOMA, SOUTH CAROLINA AND TENNESSEE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 4, 2010. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, SATURN AT 1-800-972-8876 AND PONTIAC AT 1-800-620-7668 OR AT THE OWNER CENTER AT WWW.GMOWNERCENTER.COM.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2EA11014 · Electric Power Steering Failure
Opened Sep 29, 2011 · Closed Apr 15, 2014
Status: closed (inferred from source dates) · Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Additional source detail variants (2)
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
Steering:electric Power Assist System
On March 31, 2014, General Motors Company (GM) submitted a Defect Information Report (DIR) to NHTSA describing a safety defect that may result in a sudden loss of power steering assist in approximately 1,340,447 model year (MY) 2004 through 2010 vehicles equipped with electric power steering (EPS), including 334,728 MY 2004 through 2007 Saturn ION vehicles that are the subject of EA11-014.GM has assigned the recall number N140115.The NHTSA recall number is 14V-153.According to the DIR, if power steering assist is lost, a message is displayed on the Driver Information Center and a chime sounds to inform the driver.GM indicated that steering control can be maintained in manual (unassisted) steering mode, but would require greater driver effort at low vehicle speeds, which could increase the risk of a crash.Sudden loss of power steering assist can occur in the subject vehicles if the system loses electrical power or whenever the system detects a fault that requires it to enter fail-safe operation mode, removing power from the EPS motor.GM?s DIR identifies three basic conditions that may result in loss of power steering assist in the recalled vehicles:power steering motor faults, torque sensor assembly faults, and power steering motor controller unit faults.GM will issue four service bulletins providing different repair procedures for recalled vehicles.Bulletin 14115 will provide repair instructions for replacing the power steering motor in MY 2004-2007 Saturn ION, 2009-2010 Chevrolet HHR (non-turbo), 2010 Chevrolet Cobalt and vehicles repaired in recall 10V-073 that received repairs prior to May 31, 2010.Bulletin 14116 will provide repair instructions for replacing the torque sensor assembly in MY 2004-2006 Chevrolet Malibu and Malibu Maxx, 2005-2006 Pontiac G6 and 2008-2009 Malibu, Pontiac G6 and Saturn Aura vehicles built from March 1, 2008 through June 27, 2008.Bulletin 14117 will provide repair instructions for replacing the torque sensor assembly and power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from February 1, 2008 through February 28, 2008.Bulletin 14118 will provide repair instructions for replacing the power steering motor controller unit in MY 2008 Malibu, G6 and Aura vehicles built from October 1, 2007 through January 31, 2008.Analysis of information from all sources identified a total of 4,787 complaints and 30,560 warranty claims related to loss of power steering assist while driving in the MY 2004 through 2007 Saturn ION vehicles, resulting in a complaint rate of 14.3 incidents per thousand vehicles and a warranty claim rate of 9.1 percent.ODI?s analysis of alleged steering related crashes identified 12 with evidence indicating the incident was related to a loss of power steering assist. Two of the crash allegations involved low-speed curb impacts and are excluded from the resume crash count.Three incidents occurred in parking lots, six occurred while turning at street intersections, and one occurred on a highway exit ramp.The crashes in parking lots or intersections all occurred at speeds less than 30 mph.The crash on the highway exit ramp involved impact into a guard rail at approximately 35 mph.Two of the crashes resulted in injuries to the drivers.This investigation is closed.All ODI complaints associated with this closing resume are listed in the attachment pages.
RQ10004 · Electric Power Steering Failure
Opened Dec 15, 2010 · Closed Oct 5, 2011
Status: closed (inferred from source dates) · Steering; Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Additional source detail variants (2)
Steering:electric Power Assist System
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Steering
ODI has received 846 complaints and GM identified 3,489 reports alleging sudden loss of steering power assist in model year (MY) 2004 through 2007 Saturn Ion vehicles manufactured and sold by General Motors Corporation (GM).Sixteen of these complaints alleged that the EPS warning lamp had illuminated before or during the loss of steering assist and the increased steering effort contributed to a crash. Two of the GM crash claims indicated that the driver was injured in the crash. In a previous Preliminary Evaluation PE10-005, ODI investigated the sudden loss of power steering assist in MY 2005 through 2010 Chevrolet Cobalt vehicles. In May 2011, in response to an ODI information request letter for RQ10-004, GM provided ODI with complaint, warranty and EPS system information related to EPS loss of assist for the Saturn ION and Peer vehicles Pontiac G6 and Chevrolet Malibu. In that response, GM indicated that the EPS system used in the subject vehicles was the same as that used in the MY2005 to 2010 Chevrolet Cobalt and Pontiac G5. In March 2010, GM recalled approximately 1.05 million Chevrolet Cobalt and Pontiac G5 vehicles (NHTSA recall no. 10V-073) to correct a defect with the EPS assist motor. The defect identified was described as a buildup of brush debris mixed with oily material on the EPS electric motor armature which causes the motor to stop functioning; the same problem identified in the current subject vehicles.ODI has duplicated this failure in both a Chevrolet Cobalt and Saturn Ion previously tested at the Vehicle Research and Test Center (VRTC). In the defect notification letter for the previously recalled Cobalt and G5 vehicles, GM stated that the vehicles may experience a sudden loss of assist that could occur at any time while driving and that if power steering was lost the vehicle would revert to manual steering mode and would require increased steering effort from the driver.ODI believes that, depending on driving circumstances this increase in steering effort could result in some loss of control and a crash.This investigation has been upgraded to an engineering analysis (EA11-014) to further assess the frequency, scope and safety consequences of a sudden loss of steering assist in the subject vehicles.
Illustration